Steering. Review the 667 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 113 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

37 crash reports2 fire reports25 injury reports

Fuel System, Gasoline complaints

47 reports

Clear category filter

Mileage unknown · Nov 16, 2011

Fuel System, Gasoline

Read full complaint

MY CAR FOR THE LAST YEAR OR SO HAS SAID THAT MY FUEL TANK IS EMPTY, EVEN RIGHT AFTER I FILL IT UP. I'VE BEEN TOLD BY AUTO ZONE THAT IT'S MY FUEL SENSOR IN THE FUEL TANK THAT IS BROKEN, THAT'S WHY MY CHECK ENGINE LIGHT IS ON AND MY GAUGE IS ALWAYS ON EMPTY. THEY TOLD ME THAT THERE IS NO RECALL FOR MY CAR AND THAT IT WOULD BE AT LEAST 400 TO FIX NOT INCLUDING LABOR. I'VE LOOKED AT ALL THE COMPLAINTS AND THE MAJORITY OF THEM ARE DEALING WITH THE SAME PROBLEM THAT I HAVE. I'M NOT MADE OUT OF MONEY AND I'M WORRIED THAT ONE DAY I MIGHT RUN OUT OF GAS OR SOMETHING COULD HAPPEN. I USUALLY ALWAYS HAVE MY TODDLER IN THE CAR WITH ME AND IF I HAD THE MONEY FOR A NEW CAR, THIS WOULDN'T BE A PROBLEM. I'M GUESSING SINCE THIS IS AN EXPENSIVE FIX, NOBODY WANTS TO RECALL THESE CARS AND OWN UP TO THEIR MISTAKES. WHAT HAPPENS IF THERE IS A CRASH ONE DAY BECAUSE OF THIS. I'D LIKE TO KNOW WHY THERE'S NO RECALL BUT A TON OF COMPLAINTS ABOUT THE SAME THING. *TR

NHTSA ODI #10436071

93,000 miles · Nov 10, 2011

Fuel System, Gasoline

Read full complaint

I FILLED MY CAR UP FOR THE FIRST TIME SINCE PURCHASE TO FIND THE GAUGE GOES FROM FULL TO EMPTY AT ANY TIME. IN A 10 MINUTE DRIVE, IT WENT UP AND DOWN 6 TIMES. THE FUEL LIGHT COMES ON AND THE CHECK ENGINE LIGHT TURNS ON. AS I RESEARCHED THE PROBLEM ONLINE, I SEE MANY COMPLAINTS ABOUT THIS HAPPENING. IT'S AN EXPENSIVE FIX, WHICH IS WHY I BELIEVE NOTHING IS BEING DONE ABOUT IT. THIS IS MORE THAN A NUISANCE, AS MOST HAVE STATED. HOW AM I TO KNOW WHEN THERE IS A REAL PROBLEM WITH MY ENGINE IF THE LIGHT IS ON ALWAYS? HOW AM I TO TRAVEL ANY DISTANCE NOT KNOWING IF MY TANK IS FULL OR ALMOST EMPTY? WHAT IF I RUN OUT OF GAS IN THE MIDDLE OF NO WHERE? *TR

NHTSA ODI #10435236

Mileage unknown · Nov 10, 2011

Fuel System, Gasoline

Read full complaint

MY CAR FOR THE LAST COUPLE OF MONTHS HAVE BEEN HAVING PROBLEMS WITH THE FUEL GAUGE GOING UP AND DOWN AS I DRIVE THE DIAGNOSIS SAYS THAT IT IS THE FUEL SENSOR AND WAS TRYING TO FIND OUT IF THERE IS A RECALL APPARENTLY I AM NOT THE ONLY ONE WITH A 2007 MALIBU THAT I HAVING PROBLEMS WITH THIS CHECK ENGINE LIGHT GOING ON AND THE GAS GAUGE GOES UP AND DOWN AS I DRIVE. IT I FRUSTRATING BECAUSE IT STARTED OF WHEN I GO TO A QUARTER OF A TANK THE GAUGE WOULD DROP AND THE ENGINE LIGHT WOULD GO ON. TEN IT WOULD PROGRESSIVELY GET WORST, STARTEDAT A HALF A TANK AND TEN TO TREE QUARTERS OF A TANK AND NOW WHEN I FILL UP IT STILL FLUCTUATES AS I DRIVE AND THE CHECK ENGINE LIGHT STAYS ON. I BELIEVE THAT THIS IS UNSAFE FOR MY SMALL CHILDREN TO BE DRIVING AROUND IN BECAUSE I CA BE STUCK SOMETHING COULD HAPPEN WIT A FUEL LINE AND A FIRE CAN BE CAUSED I WOULD REALLY LIKE A NOTICE ON THE RECALL SO I CAN BE REIMBURSED FOR MY TROUBLES AND MONEY TO HAVE THIS REPLACED. THANKYOU FOR LISTENING AND I HOP THAT THERE IS SOMETHING GOING TO BE DONE OR I WILL HELP SPREAD THE WORD NOT TO BUY THIS CAR EVEN THOUGH I LOVE IT IS HAS BEEN CAUSING ME PROBLEMS WITH THIS I AM A SINGLE MOM OF 2 LITTLE GIRLS AND I CANT BE THROWING AWAY MONEY FOR A MANUFACTURERS PROBLEM. *TR

NHTSA ODI #10435169

Mileage unknown · Oct 25, 2011

Air BagsEngine And Engine CoolingFuel System, Gasoline

Read full complaint

HAVE HAD PROBLEMS WITH THE FUEL SENSOR, THOUGHT IT WAS FUEL LEVEL SENSOR BUT APPARENTLY FROM ALL OTHERS REPORTS THESE ARE SEVERAL PROBLEMS WITH THE FUEL SYSTEM. THIS CAUSES THE CHECK ENGINE LIGHT TO COME ON AND WILL NOT ALLOW THE REMOTE START TO WORK. ALSO HAVE PROBLEMS WITH SENSOR IN PASSENGER SEAT. JUST WORKS RANDOMLY. VERY CONCERNED THIS WILL INTERFERE WITH AIR BAG DEPLOYMENT. ALL OF THESE THINGS WERE FIXED WHILE STILL UNDER WARRANTY BUT STARTED DOING IT AGAIN AFTER IT EXPIRED AND TOO COSTLY TO FIX ON MY OWN. *TT

NHTSA ODI #10432766

117,000 miles · Sep 16, 2011

Fuel System, GasolineUnknown Or Other

THE FUEL GAUGE WILL RANDOMLY GO TO EMPTY TURNING ON THE LOW FUEL LIGHT THIS ALSO CAUSED THE CHECK ENGINE LIGHT TO COME ON IT WILL GO UP AND DOWN ALL THE TIME EVERY FEW MINUTES WHEN DRIVING NO MATTER WHAT THE SPEED OR TYPE OF DRIVING CONDITIONS IT IS BELIEVED TO BE A FUEL SENSOR AND INTERFERENCE WITH A VENT TUBE. *TT

NHTSA ODI #10425733

40,000 miles · Sep 9, 2011

Fuel System, Gasoline

Read full complaint

TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, THE FUEL GAUGE WOULD NOT PROVIDE AN ACCURATE FUEL LEVEL READING. THE CHECK ENGINE LIGHT WAS CONSTANTLY ILLUMINATED. THE VEHICLE WAS TAKEN TO A MECHANIC AND AFTER INSPECTION THE CONTACT WAS ADVISED THAT THE VEHICLE NEEDED A FUEL SENSOR. THE MANUFACTURER WAS NOT NOTIFIED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 89,455. THE VIN WAS NOT AVAILABLE.

NHTSA ODI #10424411

40,100 miles · Aug 24, 2011

Fuel System, Gasoline

Read full complaint

FOR MORE THAN TWO MONTHS NOW, SINCE JUNE 10, 2011, MY GAS GAUGE KEEPS JUMPING UP AND DOWN, AND CAN REMAIN TO THE "EMPTY" OR "0" SIGN FOR MORE THAN A HUNDRED MILES. THEN I RECEIVE MESSAGES THAT MY GAS TANK IS EMPTY EVEN WHEN IT IS FULL. THIS OCCURS AT THE MOMENT WHEN I ADD GASOLINE IN THE TANK OR FILL OUT THE TANK. THEN, SINCE JUNE 17, THE EMPTY SIGN HAS BEEN ACCOMPANIED BY THE ALERT ENGINE SIGN. UNTIL THE END OF JULY, THE TWO ALERTS WOULD ROUTINELY DISAPPEAR AFTER I HAVE DRIVEN FOR ABOUT 100 MILES OR AFTER A DAY OR TWO DAYS. BUT FOR MORE THAN THREE WEEKS NOW, THE TWO ALERTS CAN STAY FOR A WEEK AND BEYOND 100 MILES. BUT THEY WOULD EVENTUALLY DISAPPEAR AND WOULD REAPPEAR ONCE I PUT NEW GASOLINE IN THE CAR OR FILL OUT THE TANK. ON AUGUST 18, 2011, I BROUGHT THE CAR TO A MECHANIC AND THE DIAGNOSIS WAS THAT IS WAS THE FAILURE OF THE GAS TANK SENSOR. SAYING THAT THE GAS TANK WILL NEED TO BE TAKEN OUT TO INSTALL A NEW SENSOR. WHEN I WENT TO GOOGLE FOR GET ADDITIONAL INFORMATION FOR THIS SPECIFIC ISSUE FOR MALIBU 2007, I FOUND OUT THAT OTHER PEOPLE WERE COMPLAINING ABOUT THE SAME PROBLEM WITH THEIR 2007 MALIBU. I CALLED CHEVROLET ASKING IF MALIBU 2007 HAS BEEN RECALLED FOR THIS PARTICULAR PROBLEM, I WAS INFORMED THAT THE RECALL CAN ONLY BE ISSUED BY THE NHTSA. THAT'S WHY I AM FILING THIS COMPLAINT.

NHTSA ODI #10422257

Mileage unknown · Jul 13, 2011

Electrical SystemFuel System, GasolineFuel System, Other

Read full complaint

2007 CHEVROLET MALIBU. CONSUMER STATES PROBLEMS WITH GAS GAUGE *TGW THE CONSUMER STATED WHEN SHE RE-FUELED THE VEHICLE, THE GAS GAUGE REACHED APPROXIMATELY 3/4 FULL, THE FUEL GAUGE NEEDLE DROPPED TO EMPTY AND THE CHECK ENGINE LIGHT ILLUMINATED. THE GAS GAUGE CONTINUED TO READ EMPTY AND THE ENGINE LIGHT STAYED ON UNTIL THREE TO FOUR GALLONS OF GAS WAS USED. THE GAUGE WOULD THEN BEGIN TO READ THE CORRECT AMOUNT OF GAS IN THE TANK AND WOULD CONTINUE TO DO SO UNTIL THE TANK WAS FILLED AGAIN. THE CHECK ENGINE LIGHT WOULD REMAIN ON FOR SEVERAL DAYS UNTIL GAS WAS PUT IN THE TANK ABOVE 3/4 FULL. THE CONSUMER BELIEVED THE FUEL GAUGE LEVER SENSOR WAS POORLY DESIGNED. *JB UPDATED 06/19/12 *JB

NHTSA ODI #10412691

90,000 miles · May 16, 2011

Fuel System, Gasoline

WHEN ATTEMPTING TO REFUEL THE VEHICLE, THE GAS GAUGE WOULD DECREASE TO ZERO AND THE CHECK ENGINE WARNING LIGHT WOULD ILLUMINATE. NORMAL OPERATION WOULD RESUME AFTER THE TANK WAS HALF EMPTY. IN ORDER TO CORRECT THIS PROBLEM THE DEALER STATED THAT HIS WOULD REQUIRE A COMPLETE REPLACEMENT OF THE SENDING UNIT ALL SENSORS AS THE COM…

Read full complaint

NHTSA ODI #10401161

68,000 miles · May 10, 2011

Fuel System, Gasoline

Read full complaint

TL* THE CONTACT OWNS A 2007 CHEVROLET MALIBU. THE CONTACT STATED THAT THE FUEL GAUGE WAS FAULTY AND WHEN ATTEMPTING TO REFUEL THE VEHICLE, THE GAS GAUGE WOULD GO TO ZERO AND THE CHECK ENGINE WARNING LIGHT WOULD ILLUMINATE. THE CONTACT STATED THAT NORMAL OPERATION WOULD RESUME AFTER THE TANK WAS HALF EMPTY. THE DEALER ADVISED THE CONTACT THAT THERE WERE NO RELATED RECALLS TO THE FAILURE AND OFFERED NO FURTHER ASSISTANCE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND CONFIRMED THAT THERE WERE NO RECALLS FOR THE VEHICLE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS APPROXIMATELY 80,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 68,000. UPDATED 05/26/11 *BF

NHTSA ODI #10399864

Official recalls

15V064000 · Steering:electric Power Assist System

Feb 4, 2015

General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.

14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control

May 14, 2014

General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.

Consequence & remedy

Consequence: Any of the above failure conditions increases the risk of a crash.

Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.

Additional source detail variants (5)

Electronic Stability Control (esc)