IllustrationWHEN I PUT GAS IN MY 2006 CHEVY MALIBU THE GAS GAUGE IS SAYING FULL THAN I DRIVE IT SAYS EMPTY. I DON'T KNOW WHEN I NEED GAS.. AS I DRIVE AROUND THE GAUGE GOES WHERE EVER. IS THERE A RECALL ON THIS SENSOR ISSUE BECAUSE I KNOW 4 OTHER PEOPLE WHO HAVE MALIBU WITH SAME ISSUE. *TR
2006 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2006 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
11925–50K
18850–75K
17475–100K
229100–150K
138150K+
913 reports with mileage · 202 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 810 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports6 fire reports17 injury reports
What owners actually said
1,115 reportsI PULLED IN GAS STATION SHUT CAR OFF, ATTENDANT FILLED TANK, WHEN HE WAS DONE I PAID AND STARTED CAR, CAR DINGED A LOT AND GAS GAUGE REGISTERED EMPTY, AND MESSAGE ON SCREEN SAID LOW FUEL, AND CHECK ENGINE LIGHT WAS ON. LONG STORY SHORT IF YOU BOUNCE CAR GAUGE COMES BACK UP TO FULL, THEN DROPS BACK DOWN UNTIL YOU DO THIS A COUPLE…
Read full complaint
I PULLED IN GAS STATION SHUT CAR OFF, ATTENDANT FILLED TANK, WHEN HE WAS DONE I PAID AND STARTED CAR, CAR DINGED A LOT AND GAS GAUGE REGISTERED EMPTY, AND MESSAGE ON SCREEN SAID LOW FUEL, AND CHECK ENGINE LIGHT WAS ON. LONG STORY SHORT IF YOU BOUNCE CAR GAUGE COMES BACK UP TO FULL, THEN DROPS BACK DOWN UNTIL YOU DO THIS A COUPLE TIMES, THEN RUNS OK. THIS HAPPENED AGAIN YESTERDAY 03/31/2013, SEEM TO ONLY HAPPEN WHEN I FILL THE TANK. I NOTICED THERE ARE OTHER COMPLAINTS ON THIS, IS THERE A RECALL ON THIS? *TR
BRAKE LIGHTS WOULD NOT COME ON, OR WOULD STAY ON. SPEED CONTROL COULD BE ACTIVATED, BUT WOULD KICK OFF BY ITSELF. WOULD NOT PASS INSPECTION BECAUSE AGENT SAID BRAKE LIGHTS WOULD NOT WORK. TOOK CAR TO DEALER BUT THEIR REPAIRS DID NOT FIX CAR. *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE POWER STEERING WARNING LAMP ILLUMINATED AND THE ELECTRONIC STEERING LOCKED UP, AS THE CONSUMERS WIFE WAS MAKING A LEFT TURN. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECH…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE POWER STEERING WARNING LAMP ILLUMINATED AND THE ELECTRONIC STEERING LOCKED UP, AS THE CONSUMERS WIFE WAS MAKING A LEFT TURN. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE STEERING COLUMN HAD AN INTERNAL SHORT IN ONE OF THE SENSORS. AS A RESULT, THE STEERING COLUMN NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 40,708. *TR UPDATED 04/30/13*LJ
I WAS PULLING INTO A PARKING LOT AND THE CAR GAVE ME THE 'DING' THAT TELLS ME SOMETHING IS WRONG. I LOOKED AT THE DASH AND IT FLASHED POWER STEERING. THE WHEEL BECAME VERY HARD TO TURN AND I WAS ABLE TO PULL INTO A PARKING STALL. WHEN I STARTED THE CAR BACK UP THE STEERING WAS NORMAL AGAIN. I WENT ONLINE AND NOTICED THAT THE…
Read full complaint
I WAS PULLING INTO A PARKING LOT AND THE CAR GAVE ME THE 'DING' THAT TELLS ME SOMETHING IS WRONG. I LOOKED AT THE DASH AND IT FLASHED POWER STEERING. THE WHEEL BECAME VERY HARD TO TURN AND I WAS ABLE TO PULL INTO A PARKING STALL. WHEN I STARTED THE CAR BACK UP THE STEERING WAS NORMAL AGAIN. I WENT ONLINE AND NOTICED THAT THERE ARE A NUMBER OF COMPLAINTS SIMILAR TO WHAT I EXPERIENCED. I AM REALLY CONCERNED ABOUT THIS. THE 2006 MALIBU HAS HAD A RECALL ON THE STEERING COLUMN IN CANADA BUT NOT IN THE US. I THINK THAT GM SHOULD FIX THE PROBLEM. THIS COULD CAUSE AN ACCIDENT IF IT IS NOT FIXED. *TR
LATCH ATTACHMENT ON ONE SIDE OF THE SEAT DOES NOT STAY TIGHT. JUST A SLIGHT TUG AND THE ATTACHMENT PULLS ALL THE WAY OUT. SINCE THE SEAT ISN'T LISTED IN THE DROP DOWN ON THE NEXT PAGE, IT IS THE GRACO AFFIX BOOSTER. MODEL 1852665. (RELATED VEHICLE INFORMATION: MODEL YEAR=2006, MAKE=MALIBU, MODEL=CHEVY). *TR
THE VEHICLE WAS BEING DRIVEN ON 2 LANE HIGHWAY AT 45 MPH SUDDENLY POWER STEERING WARNING MESSAGE APPEARED IN DISPLAY, WARNING NOISE CAME ON (DING) AND THERE WAS NO POWER STEERING. THE VEHICLE WAS PULLED OVER ANF THE IGNITION WAS TURNED OFF AND THE VEHICLE WAS RE-STARTED AND THE WARNING MESSAGE WAS GONE AND THE POWERSTEERING STAR…
Read full complaint
THE VEHICLE WAS BEING DRIVEN ON 2 LANE HIGHWAY AT 45 MPH SUDDENLY POWER STEERING WARNING MESSAGE APPEARED IN DISPLAY, WARNING NOISE CAME ON (DING) AND THERE WAS NO POWER STEERING. THE VEHICLE WAS PULLED OVER ANF THE IGNITION WAS TURNED OFF AND THE VEHICLE WAS RE-STARTED AND THE WARNING MESSAGE WAS GONE AND THE POWERSTEERING STARTED WORKING AGAIN. I CHECKED FOR, (DIAGNOSTIC TROUBLE CODES), DTC'S WITH A SCANTOOL AND THERE WERE NO CODES LISTED. I LOOKED FOR SERVICE BULLETINS FOR THIS AND FOUND THE FOLLOWING. SPECIAL COVERAGE ADJUSTMENT - POWER STEERING ASSIST2012/05/2310183A THIS BULLETIN COVERS MY VEHICLE AND WILL REPLACE THE STEERING COLUMN IN THE VEHICLE. *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE POWER STEERING SYSTEM MALFUNCTIONED. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR DIAGNOSTICS WHO STATED THAT THE STEERING A SHAFT NEEDED TO BE REPLACED. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE FAILURE MILEAGE W…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE POWER STEERING SYSTEM MALFUNCTIONED. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR DIAGNOSTICS WHO STATED THAT THE STEERING A SHAFT NEEDED TO BE REPLACED. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE FAILURE MILEAGE WAS 30,280. UPDATED 03/15/13*LJ THE CONSUMER STATED HIS WIFE EXPERIENCED TWO FAILURES AT 25 MPH AND ONE AT 5 MPH. UPDATED 03/27/13
I WAS DRIVING ON THE HIGHWAY WITH 60 MPH. I SUDDENLY RECOGNIZED THAT IT WAS VERY HARD TO STEER. IT WAS VERY HARD FOR ME TO PULL IT OVER . AS I KNEW THIS ISSUE WITH 2006 MALIBU CARS (READ MANY COMPLAINTS ABOUT IT ON THE INTERNET BEFORE), I DID NOT PANIC, AND ACHIEVED IT TO PULL OVER WITHOUT ANY ACCIDENT. (BY THE WAY, I AM A MAL…
Read full complaint
I WAS DRIVING ON THE HIGHWAY WITH 60 MPH. I SUDDENLY RECOGNIZED THAT IT WAS VERY HARD TO STEER. IT WAS VERY HARD FOR ME TO PULL IT OVER . AS I KNEW THIS ISSUE WITH 2006 MALIBU CARS (READ MANY COMPLAINTS ABOUT IT ON THE INTERNET BEFORE), I DID NOT PANIC, AND ACHIEVED IT TO PULL OVER WITHOUT ANY ACCIDENT. (BY THE WAY, I AM A MALE DRIVER AND I DO NOT THINK ANY FEMALE DRIVER WITHOUT ANY KNOWLEDGE OF SUCH PROBLEM IN ADVANCE COULD PULL THE CAR OVER) I HAVE SEEN THE "POWER STEERING" FLASH ON THE SCREEN DURING THE INCIDENT. AFTER TURNING OFF AND ON THE IGNITION, EVERYTHING WAS NORMAL. I DO NOT KNOW WHETHER IT WILL REPEAT AGAIN IN THE FUTURE. I SEARCHED FOR ANY RECALLS ABOUT THE POWER STEERING, AND FOUND THAT 2005/2006/2008 MALIBU CARS WERE RECALLED ON OCTOBER 2012 IN CANADA. (PLEASE SEE THE LINK FOR MORE INFORMATION HTTP://WWWAPPS.TC.GC.CA/SAF-SEC-SUR/7/VRDB-BDRV/SEARCH/RECALLDETAIL.ASPX?LANG=ENG&RN=2012331 ) HOWEVER, THERE IS NO SUCH ACTION IN THE USA. IT IS A VERY CRUCIAL SAFETY PROBLEM AND THESE CARS ARE TO BE RECALLED IMMEDIATELY IN THE USA AS WELL. GM SHOULD DEFINITELY TAKE AN ACTION BEFORE ANY DEADLY ACCIDENT HAPPENS. *TR
TRAVELING DOWN THE HIGHWAY AND SUDDENLY THE VEHICLE IS VERY HARD TO STEER GOT THE VEHICLE PULLED OVER TO THE SIDE OF THE ROAD AFTER HAVING TO MUSCLE THE WHEEL THEN HAD THE CAR TOWED TO THE DEALER.WAS TOLD IT WAS A ELECTRIC POWER STEERING ASSIST MOTOR THAT HAD WENT OUT CAUSING THE PROBLEM AND AFTER QUESTIONING ABOUT A RECALL WAS …
Read full complaint
TRAVELING DOWN THE HIGHWAY AND SUDDENLY THE VEHICLE IS VERY HARD TO STEER GOT THE VEHICLE PULLED OVER TO THE SIDE OF THE ROAD AFTER HAVING TO MUSCLE THE WHEEL THEN HAD THE CAR TOWED TO THE DEALER.WAS TOLD IT WAS A ELECTRIC POWER STEERING ASSIST MOTOR THAT HAD WENT OUT CAUSING THE PROBLEM AND AFTER QUESTIONING ABOUT A RECALL WAS TOLD THEY WERE RECALLED IN CANADA BUT NOT THE US THIS IS A VERY CONCERNING MATTER THAT GM NEEDS TO CORRECT. *TR
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V486000 · Equipment:other:labels
Oct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence & remedy
Consequence: A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Remedy: OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.