IllustrationMY STEERING WHEEL SHAKES EXTREMELY BAD ILIT ALSO LOCKS UP TO THE POINT THE WHEEL WON'T TURN.
2006 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2006 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
11925–50K
18850–75K
17475–100K
229100–150K
138150K+
913 reports with mileage · 202 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 810 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports6 fire reports17 injury reports
What owners actually said
1,115 reportsTL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING ABILITY SEIZED COMPLETELY. ALSO, THE CHECK ENGINE AND POWER STEERING WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED THREE YEARS AGO BY RELIABLE CHEVROLET (3655 S CAMPBELL AVE, SPRINGFIELD, MO 65807) PER NHTSA CAMP…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE STEERING ABILITY SEIZED COMPLETELY. ALSO, THE CHECK ENGINE AND POWER STEERING WARNING INDICATORS ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED THREE YEARS AGO BY RELIABLE CHEVROLET (3655 S CAMPBELL AVE, SPRINGFIELD, MO 65807) PER NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING), BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT REPAIRED AGAIN. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 138,000.
POWER STEERING RANDOMLY FAILS TO ENGAGE WHEN CAR IS STARTED. WHEN THE CAR WAS PURCHASED TWO YEARS AGO, THERE WAS A GM RECALL ON THE STEERING SHAFT TORQUE SENSOR. THAT RECALLED PART WAS REPLACED IN 2016; HOWEVER, THE POWER STEERING CONTINUES TO FAIL. TO DATE, THE POWER STEERING HAS ONLY FAILED WHEN THE CAR IS STARTED. THE …
Read full complaint
POWER STEERING RANDOMLY FAILS TO ENGAGE WHEN CAR IS STARTED. WHEN THE CAR WAS PURCHASED TWO YEARS AGO, THERE WAS A GM RECALL ON THE STEERING SHAFT TORQUE SENSOR. THAT RECALLED PART WAS REPLACED IN 2016; HOWEVER, THE POWER STEERING CONTINUES TO FAIL. TO DATE, THE POWER STEERING HAS ONLY FAILED WHEN THE CAR IS STARTED. THE PROBLEM IS INTERMITTENT. OUR LOCAL CHEVY DEALER ATTEMPTED TO DIAGNOSE THE ISSUE. CHEVY DEALER IS UNSURE OF PROBLEM BUT SUGGESTS REPLACING THE ELECTRONIC POWER STEERING MODULE AND MOTOR ASSEMBLY. POWER STEERING FAILURE IS AN ONGOING PROBLEM THAT IS INCREDIBLY DANGEROUS FOR THIS MAKE AND MODEL OF VEHICLE. CLEARLY, CHEVY'S ORIGINAL RECALL AND REPLACEMENT PART DID NOT WORK TO FIX THE PROBLEM. THEY SHOULD BE HELD ACCOUNTABLE TO ENSURE THAT EVERY 2006 CHEVY MALIBU IS CORRECTLY FIXED - IMMEDIATELY.
THE ELECTRIC POWER STEERING FAILED. TURNED THE CAR OFF THEN ON AGAIN AND POWER STEERING WORKED AGAIN
MY POWER STEERING WENT OUT WHILE I WAS ON THE FREEWAY AND I ALMOST WRECKED. SO I HAD NO POWER STEERING, AND STILL DON'T. IT WILL COME BACK FOR A MINUTE AND THEN GO OUT AGAIN. I CHECKED ONLINE AND SAW THAT GM HAD RECALLED MY MODEL YEAR MALIBUS, AND OTHERS, FOR A PROBLEM WITH THE POWER STEERING. SO I CALLED GM AND THEY SAID TH…
Read full complaint
MY POWER STEERING WENT OUT WHILE I WAS ON THE FREEWAY AND I ALMOST WRECKED. SO I HAD NO POWER STEERING, AND STILL DON'T. IT WILL COME BACK FOR A MINUTE AND THEN GO OUT AGAIN. I CHECKED ONLINE AND SAW THAT GM HAD RECALLED MY MODEL YEAR MALIBUS, AND OTHERS, FOR A PROBLEM WITH THE POWER STEERING. SO I CALLED GM AND THEY SAID THAT MY CAR WAS NOT A SUBJECT OF THE RECALL. IF THE PROBLEM IS THE SAME PROBLEM, I DO NOT UNDERSTAND WHY THEY REFUSE TO FIX IT. SO I AM FILING THIS COMPLAINT BECAUSE TO ME IT IS OBVIOUS THAT THIS SHOULD BE FIXED BY GM, REGARDLESS OF WHAT THEY SAID, WHICH I GUESS IS JUST A COINCIDENCE THAT MY CAR HAS THE SAME PROBLEM! I: HOPE YOU CAN HELP.
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE, THE STEERING WHEEL BECAME DIFFICULT TO TURN IN EITHER DIRECTION. ALSO, WHILE THE VEHICLE WAS IDLING, THE STEERING WHEEL SHOOK AND VIBRATED. THE FAILURES WERE NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER (HENNA CHEVROLET, 8805 INTERSTATE 35…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE, THE STEERING WHEEL BECAME DIFFICULT TO TURN IN EITHER DIRECTION. ALSO, WHILE THE VEHICLE WAS IDLING, THE STEERING WHEEL SHOOK AND VIBRATED. THE FAILURES WERE NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER (HENNA CHEVROLET, 8805 INTERSTATE 35, AUSTIN, TX) WERE NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 200,000. *TT*JB
2006 CHEVROLET MALIBU: POWER STEERING LOCKS UP! LOCKS UP TO THE POINT IT TAKE TWO PEOPLE TO TURN THE WHEEL, THIS HAPPENS WHILE DRIVING! HEADLIGHTS AND BRAKE LIGHTS GO OUT AND WHEN BULB IS REPLACED THEY BURN INSTANTLY. T/C NEVER TURNS OFF! RECENT COMPLAINTS FROM PEOPLE IN OTHER STATES HAVE BEEN MADE THERE ARE ALSO EVIDENT RECALLS…
Read full complaint
2006 CHEVROLET MALIBU: POWER STEERING LOCKS UP! LOCKS UP TO THE POINT IT TAKE TWO PEOPLE TO TURN THE WHEEL, THIS HAPPENS WHILE DRIVING! HEADLIGHTS AND BRAKE LIGHTS GO OUT AND WHEN BULB IS REPLACED THEY BURN INSTANTLY. T/C NEVER TURNS OFF! RECENT COMPLAINTS FROM PEOPLE IN OTHER STATES HAVE BEEN MADE THERE ARE ALSO EVIDENT RECALLS BUT CHEVROLET FAILS TO HONOR THE RECALL AND REFUSE TO FIX BECAUSE THE CARS ARE 2006 AND THE UEAR NOW IS 2018. THIS IS NOT FAIR! WHAT ARE WE SUPPOSED TO DO? THIS IS A SAFTEY ISSUE! IT IS MORALLY UNETHICAL AND ILLEGAL FOR CHEVROLET NOT TO ACKNOWLEDGE AND HONOR THIS RECALL REGARDLESS IF THE CAR WE HAVE IS USED. IF THE RECALL WAS MADE AND WAS NOT FIXED THEY MUST ACKNOWLEDGE THAT THE REPAIR WAS NOT MADE AND FIX THE PROBLEM FOR THE CAR OWNER! I AM SURE CHEVROLET HAS A DATABASE AND IS AWARE AT WHAT AND HOW MANY VEHICLES HAVE BEEN REPAIRED DUE TO THIS RECALL. WHAT ARE THEY WAITING FOR A LAWSUIT? I DEMAND THAT THIS RECALL BE HONORED AND THIS PROBLEM FIXED ASAP. IF I OR MY FAMILY ARE HARMED DUE TO THIS I WILL SUE SO HELP ME GOD! I AM SURE THERE ARE MANY PEOPLE OUT THERE WHO AGREE THAT WHAT CHEVROLET IS DOING IS WRONG! THE ISSUE HAPPENED SEVERAL TIME THIS YEAR AND HAPPENED AGAIN TODAY!
MY 06 MALIBU HAS INTERMIT POWER STEERING LOSS. I HAVE ALMOST HAD TWO ACCIDENTS WHEN THE POWER STEERING LOST OCCURRED. I HAVE RESEARCHED THAT GM HAS RECALLED CERTAIN VEHICLES FOR THIS CONDITION, BUT MINE HAS YET TO RECEIVE THIS RECALL. WHEN WILL GM FIX THE ISSUE WITH ALL VEHICLES EFFECTED BY THIS CONDITION. LOSS OF STEERING WHILE…
Read full complaint
MY 06 MALIBU HAS INTERMIT POWER STEERING LOSS. I HAVE ALMOST HAD TWO ACCIDENTS WHEN THE POWER STEERING LOST OCCURRED. I HAVE RESEARCHED THAT GM HAS RECALLED CERTAIN VEHICLES FOR THIS CONDITION, BUT MINE HAS YET TO RECEIVE THIS RECALL. WHEN WILL GM FIX THE ISSUE WITH ALL VEHICLES EFFECTED BY THIS CONDITION. LOSS OF STEERING WHILE DRIVING IS NOT CONDUCIVE TO A SAFE CONDITION.
THE POWER STEERING RANDOMLY GOES OUT WHEN DRIVING AND WON'T WORK AGAIN UNTIL I CUT THE CAR OFF . THE DEALERSHIP WANT TO CHARGE ME $130 TO LOOK AT IT AND WAS SUPPOSEDLY FIX DURING THE RECALL IN 2015. THIS ISN'T FAIR CHEVY IS SCAMMING US AND POTENTIALY CAUSING INJURIES.
THE POWER STEERING GOES OUT COMPLETELY AT RANDOM TIMES WHILE DRIVING. I CALLED CHEVROLET ABOUT THE RECALL ON IT AND WAS TOLD THAT THEY CLOSED THE RECALL AND ARE NO LONGER FIXING THE ISSUE. THE BRAKE LIGHTS ALSO STOP WORKING RANDOMLY. THE REAR BLINKERS HAVE STOPPED WORKING COMPLETELY.
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V486000 · Equipment:other:labels
Oct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence & remedy
Consequence: A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Remedy: OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.