IllustrationTHE SOMETIMES WILL NOT START. IT'S LIKE IT'S NOT READING THE KEY. I HAD THE CAR FOR A MONTH AND BOUGHT 6 KEYS AND THAT DID NOT FIX THE PROBLEM.
2006 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2006 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
11925–50K
18850–75K
17475–100K
229100–150K
138150K+
913 reports with mileage · 202 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 810 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports6 fire reports17 injury reports
Unknown Or Other complaints
24 reportsI BOUGHT THIS VEHICLE USED FROM PAUL CONTE CHEVROLET IN FREEPORT, NY AND IT HAD 3 RECALLS THAT WERE NOT FIXED BEFORE SELLING IT TO ME. NOW MY POWER STEERING SYSTEM MALFUNCTIONED TO THE POINT WHERE THE STEERING WHEEL WOULD TWITCH UNCONTROLLABLY AND THEN BECOME STIFF, MAKING IT VERY DIFFICULT AND DANGEROUS TO STEER. I ENDED UP P…
Read full complaint
I BOUGHT THIS VEHICLE USED FROM PAUL CONTE CHEVROLET IN FREEPORT, NY AND IT HAD 3 RECALLS THAT WERE NOT FIXED BEFORE SELLING IT TO ME. NOW MY POWER STEERING SYSTEM MALFUNCTIONED TO THE POINT WHERE THE STEERING WHEEL WOULD TWITCH UNCONTROLLABLY AND THEN BECOME STIFF, MAKING IT VERY DIFFICULT AND DANGEROUS TO STEER. I ENDED UP PAYING FOR THE REPAIRS TO THE TUNE OF ALMOST $1700.00 TO REPLACE THE STEERING COLUMN AND STEERING MOTOR. AFTER DOING SOME RESEARCH, I FOUND THAT GM RECALLED MANY VEHICLES OF THE SAME YEAR, MAKE, AND MODEL AS MY CAR BUT FOR MY SPECIFIC VIN ONLY THE STEERING TORQUE SENSOR WAS RECALLED. I DID GET THE STEERING TORQUE SENSOR RECALL FIXED BUT MY STEERING WAS STILL MESSED UP. THIS RECALL DID NOT FIX MY VERY SERIOUS AND POTENTIALLY DANGEROUS ISSUE. IT WAS ONLY AFTER I AUTHORIZED THE STEERING COLUMN AND MOTOR REPAIRS THAT THE ISSUE WAS RESOLVED. GM CUSTOMER SERVICE IS SAYING THAT EVEN THOUGH I HAD THE SAME EXACT ISSUE AS THE GM RECALL FOR OTHER MALIBU'S, BECAUSE MY SPECIFIC VIN DID NOT FALL UNDER THE RECALL, I WILL NOT BE GETTING REIMBURSED. IT IS NOT RIGHT THAT GM BE ABLE TO GET AWAY WITH THIS. THIS SERIOUS STEERING ISSUE COULD HAVE CAUSED ME TO CRASH. I WOULD LIKE TO FILE A COMPLAINT AGAINST GM FOR FAILURE TO RECALL ALL VEHICLES THAT WERE AFFECTED BY THIS POWER STEERING ISSUE AND ALSO REQUEST THAT THEY REIMBURSE ME FOR FIXING AN ISSUE THAT SHOULD HAVE BEEN TAKEN CARE OF BEFORE I EVEN BOUGHT THE CAR. THE LINK BELOW WILL TAKE YOU TO THE OFFICIAL GM STATEMENT ON THIS POWER STEERING ISSUE. HTTP://MEDIA.GM.COM/MEDIA/US/EN/GM/VEHICLES.DETAIL.HTML/CONTENT/PAGES/NEWS/US/EN/2014/MAR/0331-POWER-STEERING.HTML
MY 2006 MALIBU SHUT OFF WHILLE DRIVING DOWN THE HIGHWAY. THE KEY WAS BUMPED AND SHUT OFF THE CAR. MY WIFE WAS DRIVING THE CAR AT THE TIME. THE IGNITION SWITCH IS VERY LOOSE. I AM NOT SURE WHY THERE IS NOT A RECALL ON THE 2006 MALIBU?
INNER AND OUTER TIE ROD ENDS HAVE BEEN REPLACED 2 TIMES AND NEEDS WORK A THIRD TIME
MY 2006 CHEVROLET MALIBU'S AIRBAGS DID NOT FUNCTION IN TWO SEPARATE HARD-HITTING CRASHES. THE CAR'S ENGINE LIGHT OFTEN COMES ON AND STAYS ON UNTIL I DRIVE OVER A LARGE BUMP IN THE ROAD OR SLAM ON MY BRAKES TO GIVE IT A JOLT. I ALSO SMELL FUEL PERIODICALLY. THE HORN HAS NOT WORKED FOR MANY YEARS. I TOOK MY CAR TO A DEALER ONC…
Read full complaint
MY 2006 CHEVROLET MALIBU'S AIRBAGS DID NOT FUNCTION IN TWO SEPARATE HARD-HITTING CRASHES. THE CAR'S ENGINE LIGHT OFTEN COMES ON AND STAYS ON UNTIL I DRIVE OVER A LARGE BUMP IN THE ROAD OR SLAM ON MY BRAKES TO GIVE IT A JOLT. I ALSO SMELL FUEL PERIODICALLY. THE HORN HAS NOT WORKED FOR MANY YEARS. I TOOK MY CAR TO A DEALER ONCE WITH THE REQUEST TO REPLACE MY IGNITION SWITCH BECAUSE IT GETS STUCK INTERMITTENTLY, AND THEY STRANGELY REFUSED TO REPLACE IT BECAUSE "IT ISN'T MALFUNCTIONING FOR US." THIS WAS BEFORE THE RECALLS BECAME PUBLIC. THEY DID REPAIR THE "HIGH TONE" HORN BUT IT STOPPED WORKING WITHIN A FEW MONTHS. I BELIEVE I HAVE A DANGEROUS VEHICLE.
RECIVED CALKBACK GM ACCKNOLAGED PROBLEM WITH STEERING REFUSED TO WORK ON CAR BECAUSE IT WAS LOOK AT FROM ANOTHER DEALER.
WE HAVE RECEIVED A RECALL FOR THIS VEHICLE THREE TIMES BUT EVERY TIME WE CONTACT THE DEALER WE ARE TOLD THAT IT WILL BE SEVERAL MONTHS BEFORE THEY CAN REPAIR THIS ISSUE. THEY ALSO STATE THAT THIS IS NOT A DANGEROUS ISSUE AND THAT WE CAN DRIVE THE CAR WITHOUT CONCERN. WE DO NOT FEEL SAFE DRIVING THIS CAR. WHAT IS OUR RECOURSE A…
Read full complaint
WE HAVE RECEIVED A RECALL FOR THIS VEHICLE THREE TIMES BUT EVERY TIME WE CONTACT THE DEALER WE ARE TOLD THAT IT WILL BE SEVERAL MONTHS BEFORE THEY CAN REPAIR THIS ISSUE. THEY ALSO STATE THAT THIS IS NOT A DANGEROUS ISSUE AND THAT WE CAN DRIVE THE CAR WITHOUT CONCERN. WE DO NOT FEEL SAFE DRIVING THIS CAR. WHAT IS OUR RECOURSE AT THIS TIME? THIS IS FOR RECALL 13036. *TR
STARTED THE CAR AND ALARM BELL RANG. GAS GAGE WAS DEAD AND POWER STEERING WAS GONE. HAD TO STOP THE CAR AND RE START IT AND EVERYTHING WAS BACK. THEN WE GOT OUT ON THE HIGHWAY GOING 70 MPH AND ALL THE GAGES WENT DEAD, WHICH HAS HAPPENED MANY MANY TIMES BEFORE AND HAVE THE ROUTINE DOWN NOW. I PULL OVER AND SHUT THE CAR DOWN, WHIC…
Read full complaint
STARTED THE CAR AND ALARM BELL RANG. GAS GAGE WAS DEAD AND POWER STEERING WAS GONE. HAD TO STOP THE CAR AND RE START IT AND EVERYTHING WAS BACK. THEN WE GOT OUT ON THE HIGHWAY GOING 70 MPH AND ALL THE GAGES WENT DEAD, WHICH HAS HAPPENED MANY MANY TIMES BEFORE AND HAVE THE ROUTINE DOWN NOW. I PULL OVER AND SHUT THE CAR DOWN, WHICH WON'T START BACK UP UNTIL I DO SEVERAL THINGS. I SIT IN THE DRIVERS SEAT, TAKE THE KEYS OUT OF THE IGNITION, OPEN THE DOOR AND LOCK IT LIKE I AM LEAVING THE CAR. THEN I SIT THERE UNTIL THE DOME LIGHT AND THE ALARM LIGHT GOES OUT, ONCE THAT HAPPENS I MANUALLY UNLOCK THE DOOR, OPEN IT AND WHEN THE ALARM GOES OFF I PUT IN THE KEY AND START IT. ALSO BEEN HAVING ISSUES WITH THE BREAK LIGHTS STAYING ON WHEN I'M NOT EVEN HITTING THE BREAKS.
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO RECALL INFORMATION FOR VEHICLE. *SMD UPDATED 06/09/14 *BF
GETTING CLOSE OF STEERING WHILE DRIVING ALMOST LOST CONTROL ACCELERATING TO GET ONTO HIGHWAY.NOTIFIED GM TOLD ME CAR NOT COVER UNDER WARRANTY. BRAKE LIGHT BULBS HAVE ALSO BEEN REPLACED AT LEAST 30 TIMES ON RIGHT SIDE.WHILE TURNING WHEEL VEHICLE GETTING CLUNKING SOUND FRONT END OF VEHICLE INSPECTED SEVERAL TIMES NO LOSE COMPONENT…
Read full complaint
GETTING CLOSE OF STEERING WHILE DRIVING ALMOST LOST CONTROL ACCELERATING TO GET ONTO HIGHWAY.NOTIFIED GM TOLD ME CAR NOT COVER UNDER WARRANTY. BRAKE LIGHT BULBS HAVE ALSO BEEN REPLACED AT LEAST 30 TIMES ON RIGHT SIDE.WHILE TURNING WHEEL VEHICLE GETTING CLUNKING SOUND FRONT END OF VEHICLE INSPECTED SEVERAL TIMES NO LOSE COMPONENTS FOUND.
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V486000 · Equipment:other:labels
Oct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence & remedy
Consequence: A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Remedy: OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.