IllustrationI HAVE A 2006 CHEVY MALIBU LS . POWER STEERING KEEPS COMING ON. THE WHEEL TURNS SLIGHTLY IN IDLE. WELL NOW POWER STEERING IS LOST WHILE DERIVING MAKING IT HARD TO MOVE AT HIGH SPEEDS. DANGEROUS. AFTER CAR IS TURNED OFF THE PROBLEM SEEMS TO GO AWAY UNTIL MINUTES LATER YOU HEAR CHIMES AND IT LOCKS AGAIN. *TR
2006 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2006 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
11925–50K
18850–75K
17475–100K
229100–150K
138150K+
913 reports with mileage · 202 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 810 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports6 fire reports17 injury reports
Steering complaints
810 reportsTL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 25 MPH THE STEERING COLUMN MADE A POPPING AND SNAPPING NOISE. THE CONTACT WAS CONCERNED THAT THE NOISE WOULD CAUSE THE STEERING WHEEL TO LOCK. THE FAILURE MILEAGE WAS 96,000. UPDATED 04/05/10 *BF UPDATED 05/05/10.*JB
WHEN STARTING MY CAR IT IS VERY HARD TO TURN THE WHEEL UNTIL I GAIN A LITTLE SPEED. *TR
POWER STEERING FAILS WHILE DRIVING. WHEEL TURNS SUDDENLY TO THE LEFT AND THEN THERE IS NO POWER STEERING. I LOOKED ONLINE AND SAW THAT SEVERAL PEOPLE HAVE HAD THE SAME PROBLEM. *TR
POWER STEERING INDICATOR KEEPS COMING ON WHILE DRIVING. TYPICALLY HAPPENS EVERYTIME I GET IN THE CAR TO DRIVE IT. *TR
I HAVE A 2006 CHEVROLET MALIBU THAT I HAVE BEEN HAVING PROBLEMS WITH THE POWER STEERING FOR ALMOST A YEAR NOW. I WAS HOPEFUL THAT THE RECALL THAT WAS ISSUED RECENTLY INCLUDES MY CAR, BUT IT DOES NOT...WHICH REALLY DISAPPOINTS ME SINCE I JUST PRINTED OFF AROUND 15 PAGES OF SIMILAR COMPLAINTS FROM OTHER PEOPLE WITH THE SAME PROBL…
Read full complaint
I HAVE A 2006 CHEVROLET MALIBU THAT I HAVE BEEN HAVING PROBLEMS WITH THE POWER STEERING FOR ALMOST A YEAR NOW. I WAS HOPEFUL THAT THE RECALL THAT WAS ISSUED RECENTLY INCLUDES MY CAR, BUT IT DOES NOT...WHICH REALLY DISAPPOINTS ME SINCE I JUST PRINTED OFF AROUND 15 PAGES OF SIMILAR COMPLAINTS FROM OTHER PEOPLE WITH THE SAME PROBLEMS TO TAKE TO MY DEALER. THE FAILURE ON MY CAR STARTED LAST SPRING-SUMMER AND HAVE HAD IT LOOKED AT SEVERAL TIMES. I WAS DRIVING WHEN ALL OF A SUDDEN MY STEERING WHEEL STARTED TO FEEL LIKE IT WAS FREEZING AND THEN WOULDN'T ALLOW ME TO DRIVE STRAIGHT, IT WOULD EITHER GO FAR RIGHT OR FAR LEFT. I THOUGHT I NEEDED AN ALIGNMENT (WHICH I HAD DONE), BUT THAT DIDN'T HELP AT ALL. THIS TERRIFIED ME. IT HAPPENS AT LEAST 2-3 TIMES A DAY ALL WEEK LONG. WE HAVE REPLACED THE STEERING COLUMN (ON OUR OWN-RECALL ON 2005 MALIBU'S WON'T COVER MY 2006 EVEN THOUGH THE REP AT GM WE TALKED TO CONFIRMED MY CAR CAME OFF THE LINE IN 2005) AND IT STARTED DOING THE SAME THING THE NEXT DAY. HERE IS A DESCRIPTION OF EVERYTHING MY CAR DOES. IT HAS ALWAYS MADE A CLUNKING NOISE WHEN I TURN THE WHEEL IN EITHER DIRECTION. THE STEERING WHEEL WILL FREEZE UP AND BECOMES REALLY TIGHT MAKING IT HARD TO CONTROL. WHEN IT'S FROZEN, AND I TRY TO DRIVE STRAIGHT BY SLIGHTLY TURNING THE WHEEL, IT WILL ONLY TURN DRASTICALLY TO THE LEFT OR THE RIGHT MAKING MY WHOLE CAR JERK TO EITHER SIDE OF THE ROAD. ALSO WHEN IT'S DOING THIS, IT MAKE A LOUD VIBRATION NOISE AND THE WHEEL MOVES ON IT OWN IF I'M STOPPED AT A LIGHT OR IN PARK..EVEN OCCASIONALLY WHEN THE CAR IS TURNED OFF. WHEN IT'S MAKING THIS LOUD SOUND I CAN ALSO FEEL THE VIBRATION IN THE BRAKE PAD. POWER STEERING WILL DISPLAY ON THE DIC SCREEN ON THE DASH. FROM WHAT I'VE READ,I KNOW HUNDRED OF OTHER PEOPLE ARE HAVING THIS PROBLEM AND DON'T KNOW WHAT TO DO. WE SHOULD NOT HAVE TO KEEP THROWING MONEY INTO PROBLEMS THAT WERE CREATED EVEN BEFORE WE BOUGHT THESE CARS. SOMETHING NEEDS TO BE DONE BEFORE SOMEONE DIES. *TR
CAR WAS IN THIS CONDITION WHEN WE BOUGHT. THE DEALERSHIP IT WAS PURCHASED FROM SENT IT OFF TO BE REPAIRED. THE DEALERSHIP THAT IT WAS REPAIRED AT REPLACED STEERING COLUMN. WHEN WE GOT THE CAR BACK IT HAD THE SAME PROBLEM. DEALER WOULD NOT SEND THE CAR BACK TO BE REPAIR UNTIL 2 MONTHS LATER WHEN I COULDN'T TURN THE STEERING WHEE…
Read full complaint
CAR WAS IN THIS CONDITION WHEN WE BOUGHT. THE DEALERSHIP IT WAS PURCHASED FROM SENT IT OFF TO BE REPAIRED. THE DEALERSHIP THAT IT WAS REPAIRED AT REPLACED STEERING COLUMN. WHEN WE GOT THE CAR BACK IT HAD THE SAME PROBLEM. DEALER WOULD NOT SEND THE CAR BACK TO BE REPAIR UNTIL 2 MONTHS LATER WHEN I COULDN'T TURN THE STEERING WHEEL IT COMPLETELY LOCK UP. THE DEALER SENT IT BACK TO THE CHEVY DEALERSHIP AND THE REPLACED THE POWER STEERING MOTOR. 2 MONTHS LATER WE BEGAN TO HAVE THE SAME STEERING PROBLEMS. I HAVE ALMOST GOTTEN IN 3 ACCIDENTS BECAUSE OF THIS PROBLEM. *TR
STEERING. *TR
TL*THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHEN THE CONTACT DROVE THE VEHICLE AT VARIOUS SPEEDS AND IN ANY GEAR THE VEHICLE WOULD SUDDENLY LOOSE ALL POWER STEERING. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 92000.
MY GIRLFRIEND OWNS A 2006 MALIBU LS AND SHE HAS BEEN EXPERIENCING SERIOUS STEERING ISSUES OVER THE PAST MONTH. HER POWER STEERING GOES OUT WHILE DRIVING WITHOUT ANY NOTICE. I THOUGHT SHE WAS JUST KIDDING ABOUT IT UNTIL I FINALLY DROVE IT AND WHILE TURNING A CORNER THE STEERING WENT OUT ON ME AND I NEARLY WAS IN AN ACCIDENT. A…
Read full complaint
MY GIRLFRIEND OWNS A 2006 MALIBU LS AND SHE HAS BEEN EXPERIENCING SERIOUS STEERING ISSUES OVER THE PAST MONTH. HER POWER STEERING GOES OUT WHILE DRIVING WITHOUT ANY NOTICE. I THOUGHT SHE WAS JUST KIDDING ABOUT IT UNTIL I FINALLY DROVE IT AND WHILE TURNING A CORNER THE STEERING WENT OUT ON ME AND I NEARLY WAS IN AN ACCIDENT. AFTER DOING SOME RESEARCH ON THE INTERNET I HAVE FOUND THAT HER MALIBU IS NOT THE ONLY ONE EXPERIENCING THIS PHENOMENON, I FOUND MORE POSTS ABOUT THIS THAN I COULD COUNT. NOW I SEE THAT GM JUST ISSUED A RECALL FOR TWO VEHICLES MANUFACTURED AT THE SAME TIME AS HERS FOR THIS EXACT PROBLEM, MY QUESTION IS; WHY AREN'T THE MALIBUS' INCLUDED IN THIS RECALL WHEN THEY OBVIOUSLY HAVE THE SAME STEERING ISSUES AS THE TWO RECALLED VEHICLES? *TR
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V486000 · Equipment:other:labels
Oct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence & remedy
Consequence: A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Remedy: OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.