IllustrationMY FUEL PUMP DOES NOT WORK PROPERLY IT READS EMPTY. ALSO I WAS DRIVING AND MY POWER STEERING STOPPED WORKING AS I WAS TURNING. I WAS VERY SCARED OF CRASHING MY CAR. I HAD TO STOP MY CAR AND TURN IT OFF THEN TURN IT BACK ON AND MY POWER STEERING WAS WORKING AGAIN. THIS HAS HAPPENED 3 TIMES IN THE LAST 2 DAYS.
2006 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2006 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
11925–50K
18850–75K
17475–100K
229100–150K
138150K+
913 reports with mileage · 202 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 810 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports6 fire reports17 injury reports
Steering complaints
810 reportsTL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE TRAVELING AT VARIOUS SPEEDS, THE POWER STEERING HAD FAILED WITHOUT WARNING INTERMITTENTLY. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING) WHICH THE CONTACT FELT IT WAS RELATED TO THE FAILURE EXPERIENCED. THE CONTAC…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE TRAVELING AT VARIOUS SPEEDS, THE POWER STEERING HAD FAILED WITHOUT WARNING INTERMITTENTLY. UPON INVESTIGATION, THE CONTACT DISCOVERED NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING) WHICH THE CONTACT FELT IT WAS RELATED TO THE FAILURE EXPERIENCED. THE CONTACT CALLED OURISMAN CHEVROLET OF BALTIMORE LOCATED AT 6633 SECURITY BLVD, BALTIMORE, MD 21207 WHERE IT WAS CONFIRMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE AND THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 190,000.
POWER STEERING STOPS WORKING. 1ST TIME WAS ON THE INTERSTATE ON THE WAYTO WORK. SHUT CAR OFF AND RESTARTED IT AND IT WORKED THE LAST 2 MILES. LEAVING WORK IT WENT OUT AGAIN ON THE HIGHWAY.
MY 2006 CHEVY MALIBU'S POWER STEERING IS MALFUNCTIONING. AT TIMES IT DOESN'T WORK WHEN I START THE CAR. OTHER TIMES IT QUITS WORKING WHILE DRIVING. I NOTICED WHERE THERE WAS A RECALL FOR POWER STEERING ISSUES FROM GM. I CONTACTED MY DEALER AND WAS TOLD AFTER GIVING MY VIN THAT IT WASN'T COVERED BECAUSE OF MILEAGE. I TOOK THE CAR…
Read full complaint
MY 2006 CHEVY MALIBU'S POWER STEERING IS MALFUNCTIONING. AT TIMES IT DOESN'T WORK WHEN I START THE CAR. OTHER TIMES IT QUITS WORKING WHILE DRIVING. I NOTICED WHERE THERE WAS A RECALL FOR POWER STEERING ISSUES FROM GM. I CONTACTED MY DEALER AND WAS TOLD AFTER GIVING MY VIN THAT IT WASN'T COVERED BECAUSE OF MILEAGE. I TOOK THE CAR TO MY LOCAL REPAIR SHOP AND TOLD BY THEM TO CONTACT GM BECAUSE OF THE RECALL. I CONTACTED GM THROUGH THEIR CUSTOMER SERVICE NUMBER BUT WAS TOLD SINCE I WASN'T THE ORIGINAL OWNER THAT IT'S NOT COVERED. THE CURRENT MILEAGE IS 241239.
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 25 MPH, THE POWER STEERING SEIZED AND THE POWER ASSIST WARNING INDICATOR ILLUMINATED. THE CONTACT CALLED REGENCY CHEVROLET BUICK GMC (825 E MAIN ST, UVALDE, TX 78801) AND WAS PROVIDED A REPAIR ESTIMATE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS N…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 25 MPH, THE POWER STEERING SEIZED AND THE POWER ASSIST WARNING INDICATOR ILLUMINATED. THE CONTACT CALLED REGENCY CHEVROLET BUICK GMC (825 E MAIN ST, UVALDE, TX 78801) AND WAS PROVIDED A REPAIR ESTIMATE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.
MY DAUGHTER'S 2006 CHEVY MALIBUE HAS A STEERING PROBLEM. SHE HEARD THE INDICATOR BELL FROM THE DASH AND THEN HER STEERING INDICATOR LIGHT CAME ON THE DASH. THIS TELLS US THERE IS A PROBLEM IN HER STEERING SYSTEM. SHE HAS EXPERIENCED A SLIGHT LOSS OF POWER STEERING AND FOUND IT THE BE A LITTLE HARDER TO STEER. . YOUR WEB SITE HAS…
Read full complaint
MY DAUGHTER'S 2006 CHEVY MALIBUE HAS A STEERING PROBLEM. SHE HEARD THE INDICATOR BELL FROM THE DASH AND THEN HER STEERING INDICATOR LIGHT CAME ON THE DASH. THIS TELLS US THERE IS A PROBLEM IN HER STEERING SYSTEM. SHE HAS EXPERIENCED A SLIGHT LOSS OF POWER STEERING AND FOUND IT THE BE A LITTLE HARDER TO STEER. . YOUR WEB SITE HAS INDICATED THAT THERE IS A RECALL FOR THE 2006 AND 2007 CHEVY MALIBUE MANUFACTURERD CERTAIN MONTHS. WE CALLED OUR LOCAL DEALERSHIP TO FINE IF MY DAUGHTER'S CAR WAS ONE OF THE DEFECTIVE CARS WITH A POWER STEERING ELECTRICAL MODULES. THEY STATED NO. I LIKE TO KNOW WHAT THE DIFFERENCE BETWEEN A CAR MANUFACTURED IN FEBRUARY AND ONE IN APRIL. THERE BUILT ON THE SAME ASSEMBLY LINE USING THE SAME PARTS. MY COMPLAINT IS THAT SOMEONE ELSE WITH THE SAME YEAR AND MODEL GET THERE CAR FIXED AND SHE DOES NOT. SHE HAS A LOW PAYING JOB AND CANNOT REALLY AFFORD THE REPAIR BILL. GM NEEDS TO FIX ALL 2006 CHEVY MALIBU S.
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE, THE 'POWER STEERING FAILURE' MESSAGE DISPLAYED AND THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN IN EITHER DIRECTION. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING SENSOR WAS FAULTY AND NEEDED TO BE REPLACED.…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE OPERATING THE VEHICLE, THE 'POWER STEERING FAILURE' MESSAGE DISPLAYED AND THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN IN EITHER DIRECTION. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING SENSOR WAS FAULTY AND NEEDED TO BE REPLACED. THE CONTACT NOTIFIED THE MANUFACTURER OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 15V064000 (STEERING) IN MARCH OF 2015. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 119,500.
THE ELECTRONIC STEERING STOPS WORKING INTERMITTENTLY. THIS CAUSES THE CAR TO STEER VERY HARD AND IS DEFINITELY A SAFETY ISSUE. I'VE DONE SOME RESEARCH AND FOUND THAT THERE HAS BEEN RECALLS FOR THIS EXACT ISSUE. WHEN I ENTER MY VIN NUMBER OF COARSE IT ISN'T INCLUDED. THE PAST RECALLS NEED TO BE EXTENDED AS I SEE THERE ARE MANY OT…
Read full complaint
THE ELECTRONIC STEERING STOPS WORKING INTERMITTENTLY. THIS CAUSES THE CAR TO STEER VERY HARD AND IS DEFINITELY A SAFETY ISSUE. I'VE DONE SOME RESEARCH AND FOUND THAT THERE HAS BEEN RECALLS FOR THIS EXACT ISSUE. WHEN I ENTER MY VIN NUMBER OF COARSE IT ISN'T INCLUDED. THE PAST RECALLS NEED TO BE EXTENDED AS I SEE THERE ARE MANY OTHERS WITH THE SAME ISSUE AND FALL IN THE SAME CATEGORY. IT SHOULD NOT TAKE A FATALITY BEFORE THIS HAPPENS. GM KNOWS THEY HAVE A VERY BAD SAFETY ISSUE HERE AND SHOULD HELD ACCOUNTABLE FOR ALL THE VEHICLES EFFECTED, NOT JUST A PORTION. THIS PROBLEM OCCURS WHEN THE VEHICLE IS JUST STARTED AND WHILE TRAVELING DOWN THE HIGHWAY. THE CAR THEN HAS TO BE STOPPED, SHUT OFF AND RESTARTED FOR THE ISSUE TO CLEAR.
WAS DRIVING ON CITY STREET APPROACHING AN INTERSECTION WHEN THE VEHICLE LOSS POWER, STEERING, AND ABS BRAKES
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 30 MPH AND MAKING A LEFT TURN, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PARK ON THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED DIMMITT CHEVROLET (LOCATE…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 30 MPH AND MAKING A LEFT TURN, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT WAS ABLE TO PARK ON THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED DIMMITT CHEVROLET (LOCATED AT 25485 US HWY 19 N, CLEARWATER, FL 33763, (727) 608-1248) AND WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 160,000.
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V486000 · Equipment:other:labels
Oct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence & remedy
Consequence: A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Remedy: OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.