IllustrationAT TIMES IT'S VERY HARD TO STEER, TURNING THE KEY TO START THE CAR AND THE ENGINE JUST CRANKS AND WHEN YOU LET THE KEY OFF THE ENGINE CONTINUES TO CRANK.
2006 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2006 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
11925–50K
18850–75K
17475–100K
229100–150K
138150K+
913 reports with mileage · 202 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 810 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports6 fire reports17 injury reports
Electronic Stability Control (esc) complaints
29 reportsWHEN I ACCELERATE QUICKLY TO ENTER TRAFFIC, MERGE WITH TRAFFIC OR PASS A CAR (GOING 25 - 50 MPH), I HEAR DING, DING, DING WARMING BELL AND THE STEERING WHEEL PULLS TO THE RIGHT AND MOMENTARILY BECOMES LOCKED. I GRAB IT WITH BOTH HANDS AND LET OFF THE GAS AND IT RECOVERS. IT IS TOTALLY UNMANAGEABLE FOR THOSE MOMENTS AND VERY ALAR…
Read full complaint
WHEN I ACCELERATE QUICKLY TO ENTER TRAFFIC, MERGE WITH TRAFFIC OR PASS A CAR (GOING 25 - 50 MPH), I HEAR DING, DING, DING WARMING BELL AND THE STEERING WHEEL PULLS TO THE RIGHT AND MOMENTARILY BECOMES LOCKED. I GRAB IT WITH BOTH HANDS AND LET OFF THE GAS AND IT RECOVERS. IT IS TOTALLY UNMANAGEABLE FOR THOSE MOMENTS AND VERY ALARMING. I HAVE HAD MY CAR IN FOUR DIFFERENT TIMES SINCE NOV, 2011 FOR POWER STEERING PROBLEMS/RECALLS. THIS CURRENT PROBLEM IS A SAFETY FACTOR!!!! UPDATED 09/15/15*LJ.....UPDATED 10/01/15*BF THE CONSUMER STATED THE STEERING COLUMN AND COLUMN SENSOR WERE REPLACED TWICE. UPDATED 10/13/15. *JB *CN
THE POWER STEERING LIGHT CAME ON THE DISPLAY. I COULD NOT STEER OR TURN THE CAR. I TURN THE CAR OFF FOR ABOUT THIRTY MINUTES. I STARTED THE CAR BACK UP CALLED GM DEALER ON 38TH STREET EXPLAINED THE PROBLEM & WENT IN. THE SERVICE DEPARTMENT SAID THAT IT WAS POWER STEERING COLUMN & THAT IT WOULD BE 1200 DOLLARS TO FIX. I DID NOT…
Read full complaint
THE POWER STEERING LIGHT CAME ON THE DISPLAY. I COULD NOT STEER OR TURN THE CAR. I TURN THE CAR OFF FOR ABOUT THIRTY MINUTES. I STARTED THE CAR BACK UP CALLED GM DEALER ON 38TH STREET EXPLAINED THE PROBLEM & WENT IN. THE SERVICE DEPARTMENT SAID THAT IT WAS POWER STEERING COLUMN & THAT IT WOULD BE 1200 DOLLARS TO FIX. I DID NOT HAVE THE MONEY TO FIX IT. ON SEVERAL OCCASIONS THIS HAS HAPPENED TO ME. AS RECENTLY AS FEBRUARY 25, 2015 I TOOK MY CAR TO A PRIVATE MECHANIC & PAID 817.00 FOR SUSPENSION WORK, BUSHINGS ETC & 253.00 FOR TWO TIRES. THE MECHANIC INFORMED ME THAT THE INTERMEDIATE MID SHAFT NEEDS TO BE REPLACE & THAT THERE WAS STILL CLUCKING NOISE & RATTLING IN THE STEERING WHEEL. I TEST DROVE THE CAR WITH THE MECHANIC & AS I WAS TURNING OUT OF THE PARKING LOT THE POWER STEERING LOCKED UP AGAIN. IT WAS VERY DIFFICULT FOR ME TO TURN THE STEERING WHEEL AS I WAS TURNING ON A BUSY INTERSECTION. THE POWER STEERING LIGHT CAME ON DISPLAY. I CUT MY HAZARD LIGHTS ON & CUT THE CAR OFF & STARTED THE CAR UP....I DO NOT FEEL SAFE IN THIS CAR. I GOT ON LINE ON FEBRUARY 27, 2015 GOOGLED 2006 RECALLS ON CHEVROLET MALIBU'S & SEEN THAT THERE WAS A RECALL. I CONTACTED DORMAN PRODUCTS & LEFT A MESSAGE IN REGARDS TO MY ISSUE. I ALSO CONTACTED GM 18006302438, SPOKE WITH A REPRESENTATIVE ABOUT THE ISSUE (POWER STEERING) & SHE ASKED FOR MY VIN NUMBER. SHE ALSO ASKED ME IF I WAS THE FIRST OWNER OF THE CAR, I EXPLAINED THAT I PURCHASED THE CAR FROM THE ANDY MOHR DEALERSHIP & THAT THERE WAS A PREVIOUS OWNER. THE REPRESENTATIVE INFORMED ME THAT THE RECALL LETTER TO THE PREVIOUS OWNER ON FEBRUARY 5, 2015. I UPDATED MY INFORMATION & RECEIVED A LETTER THE NEXT DAY FOR THE RECALL. I AM SCHEDULED TO GO IN FOR ELECTRIC POWER STEERING ASSIST (RECALL # 14772) ON TUESDAY MARCH 3, 2015. I HOPE THAT THIS DANGEROUS ISSUE IS TAKEN CARE OF. CONCERNED CHEVROLET MALIBU OWNER. *TR
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO RECALL NOTICES. *TGW THE CONSUMER STATED TWO DAYS AFTER THE FIRST RECALL REPAIR, BECAUSE THE REPAIR WAS NOT FULLY COMPLETED, DUE TO LACK OF PARTS, SHE EXPERIENCED TWO EPISODES WHICH SHE DEEMED UNSAFE. WHILE SITTING WITH HER FOOT ON THE BRAKE, AND THE VEHICLE IN DRIVE, SHE SU…
Read full complaint
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO RECALL NOTICES. *TGW THE CONSUMER STATED TWO DAYS AFTER THE FIRST RECALL REPAIR, BECAUSE THE REPAIR WAS NOT FULLY COMPLETED, DUE TO LACK OF PARTS, SHE EXPERIENCED TWO EPISODES WHICH SHE DEEMED UNSAFE. WHILE SITTING WITH HER FOOT ON THE BRAKE, AND THE VEHICLE IN DRIVE, SHE SUDDENLY FELT A SLIGHT SHIFT, AS IF THE VEHICLE WAS TRYING TO MOVE FORWARD, WHICH IT DID, WITHOUT ANY WARNING. THE VEHICLE BUMPED A CAR IN FRONT OF HER. THE CONSUMER REFERENCED RECALL # 14V252000. *JB
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL REPAIR AN…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL). THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR THE RECALL REPAIR AND WAS LATER INFORMED THAT THE PART WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 11/20/14*LJ UPDATED 8/12/2015 *JS
2006 CHEVROLET MALIBU. CONSUMER WRITES IN REGARDS TO TORQUE SENSOR ASSEMBLY; WIRING HARNESS TO THE BCM OR MAG BEAM AND TRANSMISSION SHIFT CABLE THAT MAY FRACTURE AT ANY TIME. *TGW THE CONSUMER WAS INFORMED, THE PARTS WERE NOT AVAILABLE. *JB
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), 14V153000 (STEERING), AND 14V224000 (POWER TRAIN). THE PARTS NEEDED TO PERFORM THE R…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED RECALL NOTIFICATIONS FOR NHTSA CAMPAIGN NUMBERS: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL), 14V153000 (STEERING), AND 14V224000 (POWER TRAIN). THE PARTS NEEDED TO PERFORM THE RECALL REPAIRS WERE UNAVAILABLE. THE DEALER WAS UNCERTAIN WHEN THE PARTS WOULD BECOME AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE CONTACT STATED…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM, ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL); HOWEVER, THE PARTS NEEDED TO REPAIR THE VEHICLE WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE LIGHTS WOULD WORK INTERMITTENTLY. THE CONTACT REPLACED THE BRAKE LIGHTS ON NUMEROUS OCCASIONS. THE INDEPENDENT MECHANIC REPAIRED THE WIRING HARNESS BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAG…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE LIGHTS WOULD WORK INTERMITTENTLY. THE CONTACT REPLACED THE BRAKE LIGHTS ON NUMEROUS OCCASIONS. THE INDEPENDENT MECHANIC REPAIRED THE WIRING HARNESS BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE BCM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED UNDER CAMPAIGN NUMBER: 14V252000 (ELECTRICAL SYSTEM , ELECTRONIC STABILITY CONTROL, EXTERIOR LIGHTING , SERVICE BRAKES, HYDRAULIC, VEHICLE SPEED CONTROL) THE REMEDY FAILED TO RECTIFY THE FAILURE. ADDITIONALLY, THE CONTACT ALSO STATED THAT THE HEATED SEAT FUNCTION FAILED AND THE POWER STEERING SEIZED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING). THE APPROXIMATE FAILURE MILEAGE WAS 60,000...UPDATED 10/01/14 *BF THE CONSUMER STATED THE FUEL TANK WOULD SHOW 1/8 OF A TANK, BUT IN ACTUALITY THE TANK WAS EMPTY.
NO PHYSICAL INCIDENTS HAVE TAKEN PLACE AS OF YET, HOWEVER WHEN ASKING ABOUT PART BEING REPLACE FOR MY TWO RECALLS I GET NOTHING BUT ATTITUDE AND "I DON'T KNOW" ANSWERS. MY RECALLS ARE ON THE TRANSMISSION SHIFT CABLE, BODY CONTROL MODULE, BRAKE APPLY SENSOR AND ELECTRONIC STABILITY CONTROL. I STILL MAKE CAR PAYMENTS, SINGLE MOTHE…
Read full complaint
NO PHYSICAL INCIDENTS HAVE TAKEN PLACE AS OF YET, HOWEVER WHEN ASKING ABOUT PART BEING REPLACE FOR MY TWO RECALLS I GET NOTHING BUT ATTITUDE AND "I DON'T KNOW" ANSWERS. MY RECALLS ARE ON THE TRANSMISSION SHIFT CABLE, BODY CONTROL MODULE, BRAKE APPLY SENSOR AND ELECTRONIC STABILITY CONTROL. I STILL MAKE CAR PAYMENTS, SINGLE MOTHER WITH A TODDLER IN THE VEHICLE AND ALL I GET IS AN " I DON'T KNOW" WHEN OUR SAFETY IS IN QUESTION. IF I COULD AFFORD A RENTAL I WOULD GET ONE AND KEEP THE CAR PARKED, HOWEVER A RENTAL IS LIKE ANOTHER CAR PAYMENT....WHERE DO I GO FROM HERE? *TR
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V486000 · Equipment:other:labels
Oct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence & remedy
Consequence: A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Remedy: OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.