IllustrationIT STARTED SINCE 2013 AND NEW THINGS ARE JUST HAPPENED WHAT PART OF YOUR CAR WAS AFFECTED? ENGINE ELEC. STABILITY CONTROL SEAT BELTS UNKNOWN OR OTHER
2006 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2006 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
11925–50K
18850–75K
17475–100K
229100–150K
138150K+
913 reports with mileage · 202 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 810 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports6 fire reports17 injury reports
Electrical System complaints
142 reportsTL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 30 MPH, THE VEHICLE STALLED AND ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT CLUSTER. IN ADDITION, WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL SEIZED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE CONTACT WAS UNSU…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 30 MPH, THE VEHICLE STALLED AND ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT CLUSTER. IN ADDITION, WHILE DRIVING AT VARIOUS SPEEDS, THE STEERING WHEEL SEIZED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER, BUT THE CONTACT WAS UNSURE ABOUT WHAT PART NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING AT 30 MPH, THE SPEEDOMETER GAUGE ON THE INSTRUMENT PANEL FAILED TO INDICATE THE ACTUAL SPEED OF THE VEHICLE. THE CHECK ENGINE WARNING LIGHT ILLUMINATED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING AT 30 MPH, THE SPEEDOMETER GAUGE ON THE INSTRUMENT PANEL FAILED TO INDICATE THE ACTUAL SPEED OF THE VEHICLE. THE CHECK ENGINE WARNING LIGHT ILLUMINATED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
THE SOMETIMES WILL NOT START. IT'S LIKE IT'S NOT READING THE KEY. I HAD THE CAR FOR A MONTH AND BOUGHT 6 KEYS AND THAT DID NOT FIX THE PROBLEM.
I BOUGHT THIS VEHICLE USED FROM PAUL CONTE CHEVROLET IN FREEPORT, NY AND IT HAD 3 RECALLS THAT WERE NOT FIXED BEFORE SELLING IT TO ME. NOW MY POWER STEERING SYSTEM MALFUNCTIONED TO THE POINT WHERE THE STEERING WHEEL WOULD TWITCH UNCONTROLLABLY AND THEN BECOME STIFF, MAKING IT VERY DIFFICULT AND DANGEROUS TO STEER. I ENDED UP P…
Read full complaint
I BOUGHT THIS VEHICLE USED FROM PAUL CONTE CHEVROLET IN FREEPORT, NY AND IT HAD 3 RECALLS THAT WERE NOT FIXED BEFORE SELLING IT TO ME. NOW MY POWER STEERING SYSTEM MALFUNCTIONED TO THE POINT WHERE THE STEERING WHEEL WOULD TWITCH UNCONTROLLABLY AND THEN BECOME STIFF, MAKING IT VERY DIFFICULT AND DANGEROUS TO STEER. I ENDED UP PAYING FOR THE REPAIRS TO THE TUNE OF ALMOST $1700.00 TO REPLACE THE STEERING COLUMN AND STEERING MOTOR. AFTER DOING SOME RESEARCH, I FOUND THAT GM RECALLED MANY VEHICLES OF THE SAME YEAR, MAKE, AND MODEL AS MY CAR BUT FOR MY SPECIFIC VIN ONLY THE STEERING TORQUE SENSOR WAS RECALLED. I DID GET THE STEERING TORQUE SENSOR RECALL FIXED BUT MY STEERING WAS STILL MESSED UP. THIS RECALL DID NOT FIX MY VERY SERIOUS AND POTENTIALLY DANGEROUS ISSUE. IT WAS ONLY AFTER I AUTHORIZED THE STEERING COLUMN AND MOTOR REPAIRS THAT THE ISSUE WAS RESOLVED. GM CUSTOMER SERVICE IS SAYING THAT EVEN THOUGH I HAD THE SAME EXACT ISSUE AS THE GM RECALL FOR OTHER MALIBU'S, BECAUSE MY SPECIFIC VIN DID NOT FALL UNDER THE RECALL, I WILL NOT BE GETTING REIMBURSED. IT IS NOT RIGHT THAT GM BE ABLE TO GET AWAY WITH THIS. THIS SERIOUS STEERING ISSUE COULD HAVE CAUSED ME TO CRASH. I WOULD LIKE TO FILE A COMPLAINT AGAINST GM FOR FAILURE TO RECALL ALL VEHICLES THAT WERE AFFECTED BY THIS POWER STEERING ISSUE AND ALSO REQUEST THAT THEY REIMBURSE ME FOR FIXING AN ISSUE THAT SHOULD HAVE BEEN TAKEN CARE OF BEFORE I EVEN BOUGHT THE CAR. THE LINK BELOW WILL TAKE YOU TO THE OFFICIAL GM STATEMENT ON THIS POWER STEERING ISSUE. HTTP://MEDIA.GM.COM/MEDIA/US/EN/GM/VEHICLES.DETAIL.HTML/CONTENT/PAGES/NEWS/US/EN/2014/MAR/0331-POWER-STEERING.HTML
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE IDLING, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, WHEN THE IGNITION KEY WAS TURNED TO THE ON POSITION, THE VEHICLE STARTED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN STATED THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFA…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE IDLING, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, WHEN THE IGNITION KEY WAS TURNED TO THE ON POSITION, THE VEHICLE STARTED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN STATED THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000. THE VIN WAS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 10 MPH AROUND A CURVE, THE BRAKES DID NOT RESPOND AND THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED. THE TRACTION CONTROL LIGHT BECAME ILLUMINATED AND THE VEHICLE ACCELERATED AND CRASHED INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED AN INJ…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. WHILE DRIVING 10 MPH AROUND A CURVE, THE BRAKES DID NOT RESPOND AND THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED. THE TRACTION CONTROL LIGHT BECAME ILLUMINATED AND THE VEHICLE ACCELERATED AND CRASHED INTO A DITCH. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED AN INJURY TO THE RIGHT ARM THAT DID NOT REQUIRE MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 161,000.
IF YOU THINK GM HAD A BIG PROBLEM WITH THE IGNITION SWITCHES HERE IS A BIGGER ONE. I HAVE OWNED GM SINCE 1972 AND HAVE ALWAYS FOUND THAT THE DELCO BATTERIES ARE THE BEST. YOU COULD GO 8 TO 8 1/2 YEARS BEFORE YOU NEEDED TO REPLACE THE BATTERY BECAUSE AN INTERNAL PLATE WOULD SEPARATE FROM THE BANK OF PLATES. BUT SOMETHING CHANG…
Read full complaint
IF YOU THINK GM HAD A BIG PROBLEM WITH THE IGNITION SWITCHES HERE IS A BIGGER ONE. I HAVE OWNED GM SINCE 1972 AND HAVE ALWAYS FOUND THAT THE DELCO BATTERIES ARE THE BEST. YOU COULD GO 8 TO 8 1/2 YEARS BEFORE YOU NEEDED TO REPLACE THE BATTERY BECAUSE AN INTERNAL PLATE WOULD SEPARATE FROM THE BANK OF PLATES. BUT SOMETHING CHANGED IN THE 1990S.I HAVE HAD TWO DELCO BATTERIES DO THIS AND I READ ABOUT A MAN IN FLORIDA THAT DIED IN HIS CAR BECAUSE IT HAPPENED TO HIM. YOUR GET IN YOUR VEHICLE, START THE ENGINE, PUT THE CAR IN GEAR, THE DOOR LOCKS ACTIVATE, AND THE ENGINE QUITS. YOU PUT THE CAR BACK IN PARK, AND TRY STARTING THE VEHICLE AGAIN, NOTHING !! ALL ELECTRICAL CIRCUITS ARE DEAD. THE POSITIVE BATTERY CABLE AND POST HAVE SEPERATED FROM THE BATTERY. TO GET OUT OF THE CAR YOU HAVE TO TRIP THE MANUAL DOOR LOCKS. IF SOMEONE HOLDS THE POST BACK INTO THE BATTERY YOU WILL HAVE POWER BUT AS SOON AS THEY LET GO, ALL ELECTRICAL CIRCUITS DIE. THINK OF IT THIS WAY. YOU ARE HEADING HOME AFTER A HOLIDAY, ON AN EXPRESSWAY IN THE COUNTRY, DOING 70 MPH, IN THE DARK. BUMPER TO BUMPER. THE POSITIVE BATTERY POST BREAKS LOOSE. YOU NOW HAVE NO HEAD LIGHTS, NO HORN, NO TURN SIGNALS, NO BRAKE LIGHTS, NO BODY LIGHTS,NO POWER STEERING, NO POWER BRAKES, ALL ELECTRICAL CIRCUITS HAVE DIED. YOU ARE THE CAPTAIN OF A GHOST SHIP AND THAT DRIVER THAT YOU KNOW WAS BEHIND YOU WILL ONLY HAVE A SECOND TO REACT WHEN HIS HEADLIGHTS PICK YOU UP. GM NEEDS TO INVESTIGATE AND CORRECT.
IN SEPT 2014, I HAD MY 2006 MALIBU REPAIRED UNDER GM RECALL 13036. AT THE END OF JUNE 2015, I NOTICED THAT MY BRAKE LIGHTS WERE MALFUNCTIONING. I TOOK MY CAR TO A LOCAL MECHANIC FOR REPAIR, WHICH WAS THE SAME WORK THAT WAS DONE FOR THE RECALL. AT THE END OF JULY 2015, THE MALFUNCTION RETURN AGAIN. I CONTACTED CHEVY VIA EMAIL AND…
Read full complaint
IN SEPT 2014, I HAD MY 2006 MALIBU REPAIRED UNDER GM RECALL 13036. AT THE END OF JUNE 2015, I NOTICED THAT MY BRAKE LIGHTS WERE MALFUNCTIONING. I TOOK MY CAR TO A LOCAL MECHANIC FOR REPAIR, WHICH WAS THE SAME WORK THAT WAS DONE FOR THE RECALL. AT THE END OF JULY 2015, THE MALFUNCTION RETURN AGAIN. I CONTACTED CHEVY VIA EMAIL AND PHONE, AND WAS FIRST TOLD THAT THERE WASN'T A RECALL FOR THIS PROBLEM. I CALLED AGAIN AND EXPLAIN THAT I WAS HAVING THE PROBLEM DESCRIBED IN RECALL 13036 (" THESE FLUCTUATIONS CAN CAUSE ONE OR MORE OF THESE CONDITIONS: THE BRAKE LIGHTS TO ILLUMINATE WITHOUT THE BRAKE PEDAL BEING PUSHED; THE BRAKE LIGHTS TO NOT ILLUMINATE WHEN THE PEDAL IS PUSHED"). I WAS THEN TOLD THAT THERE WAS A RECALL, BUT THAT MINE WAS "CLOSED" SINCE I HAD ALREADY HAD IT DONE ONCE. I AM CONCERNED THAT I WILL BE REAR-ENDED BECAUSE OF THE MALFUNCTIONING BRAKE LIGHTS, WHICH IS A PROBLEM THAT CHEVY/GM IS AWARE OF, HAVING ALREADY ISSUED A RECALL.
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY FAILED TO TURN IN THE IGNITION. THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. TH…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT THE KEY FAILED TO TURN IN THE IGNITION. THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 212,610.
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V486000 · Equipment:other:labels
Oct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence & remedy
Consequence: A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Remedy: OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.