IllustrationTHE FIRST IS THE STEERING SOUNDS LIKE FRONT END IS GOING TO FALL APART WHEN DRIVING AND WHEN I TURN CORNERS. THE SECOND IS THE FUEL THE CAR CONSTANTLY SHUTS OFF FOR NO REASON. AND THE THIRD IS THE AIR CONDITONER BLOWS FROM COLD TO HOT. *TR
2006 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2006 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
650–25K
11925–50K
18850–75K
17475–100K
229100–150K
138150K+
913 reports with mileage · 202 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 810 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
41 crash reports6 fire reports17 injury reports
Electrical System complaints
142 reportsFUEL LEVEL SENSOR FAILURE. FUEL READS EMPTY EVEN THOUGH THE GAS TANK IS FILLED. IT TOOK 3 HOURS AND 322 DOLLARS TO FIX.. UNREASONABLE IS ALL I CAN SAY... *TR
CAR SHUTS OFF WHILE DRIVING AN STEERING IS HARD. *TR
I HAVE TAKEN MY CAR TO SIERRA CHEVROLET IN SOUTHFIELD, MI WHERE IT WAS PURCHASED IN 10/13, SINCE PURCHASING ON 3 DIFFERENT OCCASIONS IN 5 MONTHS FOR LOSS OF POWER STEERING AND ALL SYSTEMS ON DASHBOARD DROP TO ZERO (0), GAS, SPEEDOMETER AND RPM'S. I WAS FIRST CHARGED $125 (DEALER CLAIMED THEY WOULD SPLIT COST) WHICH DIDN'T FIX PR…
Read full complaint
I HAVE TAKEN MY CAR TO SIERRA CHEVROLET IN SOUTHFIELD, MI WHERE IT WAS PURCHASED IN 10/13, SINCE PURCHASING ON 3 DIFFERENT OCCASIONS IN 5 MONTHS FOR LOSS OF POWER STEERING AND ALL SYSTEMS ON DASHBOARD DROP TO ZERO (0), GAS, SPEEDOMETER AND RPM'S. I WAS FIRST CHARGED $125 (DEALER CLAIMED THEY WOULD SPLIT COST) WHICH DIDN'T FIX PROBLEM. NOW THEY ARE TRYING TO CHARGE ME $430 TO REPLACE A MODULE WITH NO GUARANTEE THIS WILL FIX PROBLEM. I AM BEING REPEATEDLY TOLD MY CAR DOES NOT FALL UNDER THE RECALL. I HAVE A COPY OF LETTER FROM NHTSA TO GENERAL MOTORS DATED 3/31/14 IDENTIFYING SAFETY RECALL OF POWER STEERING AS WELL GM'S LETTER TO DEALERSHIPS DATED 3/31/14 REFERRED TO AS BULLETIN # 14116 WHICH STATES DEALERS ARE TO REPLACE TORQUE SYSTEM IN MODELS 2004-2006 MALIBU. *TR
MY VEHICLE PERIODICALLY STALLS DURING OPERATION. I HAVE NOTICED THIS OCCURRENCE FOR THE LAST YEAR OR SO. I HAVE NOT EXPERIENCED ANY INJURIES OR ACCIDENTS AS A RESULT OF THIS. HOWEVER, I AM READING THAT THERE MAY BE ISSUES WITH IGNITION SWITCHES OF THIS PARTICULAR MAKE AND MODEL. *TR
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE POWER STEERING ASSIST FAILED AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION COIL NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FA…
Read full complaint
TL* THE CONTACT OWNS A 2006 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE POWER STEERING ASSIST FAILED AS THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE IGNITION COIL NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED ON TWO OCCASIONS BUT THE FAILURE RECURRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 160,000. ..UPDATED 04-23-14 *BF UPDATED 05/28/14*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED AND THE OWNER IS IN POSSESSION OF THE FAILED PARTS. UPDATED 06/2014 *JS
I HAVE BEEN REPETITIVELY TURNED AWAY BY VARIOUS GM DEALERSHIPS TO ADDRESS SERIOUS ISSUES WITH MY VEHICLE & POTENTIAL RECALLS. MY ISSUES INCLUDE - STEERING MALFUNCTIONS MAKING THE VEHICLE DIFFICULT TO CONTROL, FAULTY FUEL PUMP SENDING UNIT CAUSING CHECK ENGINE LIGHT TO ILLUMINATE & VEHICLE TO STALL, UNCONTROLLABLE VIBRATIONS WHEN…
Read full complaint
I HAVE BEEN REPETITIVELY TURNED AWAY BY VARIOUS GM DEALERSHIPS TO ADDRESS SERIOUS ISSUES WITH MY VEHICLE & POTENTIAL RECALLS. MY ISSUES INCLUDE - STEERING MALFUNCTIONS MAKING THE VEHICLE DIFFICULT TO CONTROL, FAULTY FUEL PUMP SENDING UNIT CAUSING CHECK ENGINE LIGHT TO ILLUMINATE & VEHICLE TO STALL, UNCONTROLLABLE VIBRATIONS WHEN BREAKING AT HIGH SPEEDS NEARLY CAUSING ME TO WRECK, POPPING SOUNDS IN THE SUSPENSION SYSTEM, AND FINALLY UNEXPLAINED ELECTRICAL MALFUNCTIONS SUCH AS RADIO SWITCHING CHANNELS ON ITS OWN, FAILURE OF KEYLESS ENTRY SYSTEM, FAILURE OF REMOTE ENTRY SYSTEM, BUZZING OF LIGHTS WHEN DIMMING, AND FLICKERING OF HEADLIGHTS. I HAVE BEEN TOLD BY DEALERSHIPS THAT BECAUSE MY VEHICLE IS A "FLEET CAR" THAT IT DOES NOT QUALIFY FOR ANY RECALLS. PROBLEMS BEGAN WHILE UNDER WARRANTY. STEERING WIRING HARNESS WAS REPLACED WHILE UNDER WARRANTY. AT AROUND 65,000 MILES, SYSTEMS BEGAN TO FAIL DESPITE MY REGULAR CARE OF THE VEHICLE WHICH I HAVE DOCUMENTED. AFTER WARRANTY EXPIRED, I WAS ROUTINELY TURNED DOWN FOR RECALL INSPECTIONS. A RECENT EMISSIONS INSPECTION CAUSED CONCERN BY THE MECHANIC OVER THE STEERING OF THE VEHICLE AND I WAS ENCOURAGED TO ADDRESS THESE PROBLEMS AGAIN. I CANNOT AFFORD A NEW CAR. *TR
I WAS DRIVING ABOUT 30 MILES PER HOURS, BUT THE SPEEDOMETER WAS 85 MILES PER HOURS. *TR
I GOT IN MY CAR LAST NIGHT, COMING FROM OUT THE GROCERY STORE, AND IT WOULDN'T START!....ANTI THEFT SYSTEM LIGHT KEPT BLINKING. I LIVE IN MICHIGAN AND ITS JANUARY, I WAS FREEZING, CRYING AND DIDN'T KNOW WHAT TO DO. THANK GOODNESS I DIDNT HAVE MY DAUGHTER WITH ME....I GOOGLED ABOUT WHAT HAPPENED AND IT SEEMS A LOT OF PEOPLE ARE H…
Read full complaint
I GOT IN MY CAR LAST NIGHT, COMING FROM OUT THE GROCERY STORE, AND IT WOULDN'T START!....ANTI THEFT SYSTEM LIGHT KEPT BLINKING. I LIVE IN MICHIGAN AND ITS JANUARY, I WAS FREEZING, CRYING AND DIDN'T KNOW WHAT TO DO. THANK GOODNESS I DIDNT HAVE MY DAUGHTER WITH ME....I GOOGLED ABOUT WHAT HAPPENED AND IT SEEMS A LOT OF PEOPLE ARE HAVING THIS PROBLEM. WHY HASN'T THIS BEEN RECALLED????!!!!!...I TRIED THE 10 MINUTE FIX BUT WHILE DOING IT, IT DRAINED MY BATTERY. EVERY GM CAR I HAD, HAS GIVEN ME PROBLEMS. THEY DON'T WANT US TO BUY FOREIGN BUT I THINK NEXT TIME I GET A CAR THATS WHERE IM HEADING!...GM YOU ARE RIDICULOUS AND EVERY SITE I GET TO COMPLAIN ON ABOUT YOU, I WILL!!!!....GET THIS FIXED ASAP!! *TR
AS I WAS PULLING OUT OF A PARKING LOT A MESSAGE CAME ACROSS MY RADIO/TEMP SCREEN AND SAID POWER STEERING. ALL OF A SUDDEN MY POWER STEERING WENT OUT. I DROVE IT A FEW BLOCKS TO MAKE IT HOME WITH ABSOLUTELY NO POWER STEERING. IT WAS TOUGH, BUT I MADE IT HOME. I TURNED THE CAR OFF AND DID A LITTLE RESEARCH ON THE INTERNET CONCERNI…
Read full complaint
AS I WAS PULLING OUT OF A PARKING LOT A MESSAGE CAME ACROSS MY RADIO/TEMP SCREEN AND SAID POWER STEERING. ALL OF A SUDDEN MY POWER STEERING WENT OUT. I DROVE IT A FEW BLOCKS TO MAKE IT HOME WITH ABSOLUTELY NO POWER STEERING. IT WAS TOUGH, BUT I MADE IT HOME. I TURNED THE CAR OFF AND DID A LITTLE RESEARCH ON THE INTERNET CONCERNING MY POWER STEERING. I SEEN A LOT OF PEOPLE SAID ONCE THEY STARTED THEIR CARS AGAIN THE POWER STEERING WORKED, BUT ALSO WENT OUT AGAIN INTERMITTENTLY. SO I WENT OUTSIDE AND STARTED MY CAR AND SURE ENOUGH MY POWER STEERING IS WORKING....FOR NOW. I AM SCARED TO DRIVE IT AGAIN FEARING IT WILL GO OUT AND I WON'T BE ABLE TO CONTROL IT AND CAUSE A HORRIBLE ACCIDENT. GM NEEDS TO RECALL THESE CARS BECAUSE THIS IS A HUGE SAFETY PROBLEM! *TR
Official recalls
615V064000 · Steering:electric Power Assist System
Feb 4, 2015
General Motors LLC (GM) is recalling certain model year 2006-2007 Chevrolet Malibu and Malibu Maxx vehicles manufactured April 1, 2006, to June 30, 2006, and 2006-2007 Pontiac G6 vehicles manufactured April 18, 2006, to June 30, 2006. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the torque sensor assembly, free of charge. The recall began February 24, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or Pontiac customer service at 1-800-762-2737. GM's number for this recall is 14772. Note: This is an expansion of recall 14V-153 to cover additional vehicles built between April 1, 2006 and June 30, 2006.
14V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
06V417000 · Air Bags:frontal
Oct 31, 2006
CERTAIN VEHICLES ORIGINALLY BUILT WITH CLOTH SEATS THAT WERE EQUIPPED WITH AN AUTOMATIC AIR BAG PASSENGER SENSING SYSTEM AND LATER REUPHOLSTERED WITH AFTERMARKET LEATHER SEAT COVER KITS ARE INVOLVED. TESTING HAS INDICATED THAT THE AFTERMARKET LEATHER SEAT COVERS CAN CAUSE THE PASSENGER SENSING SYSTEM TO MALFUNCTION.
Consequence & remedy
Consequence: IF THE PASSENGER SENSING SYSTEM MALFUNCTIONS, THE FRONT AIR BAG ON THE PASSENGER SIDE MAY BE DISABLED WHEN IT SHOULD BE ENABLED, OR ENABLED WHEN IT SHOULD BE DISABLED. IN EITHER CASE, IN THE EVENT OF A CRASH THAT REQUIRES AIR BAG DEPLOYMENT, A FRONT PASSENGER'S LEVEL OF INJURY MAY BE INCREASED.
Remedy: BECAUSE A REPLACEMENT LEATHER SEAT COVER THAT IS COMPATIBLE WITH THE PASSENGER SENSING SYSTEM IS NOT AVAILABLE, GENERAL MOTORS (GM) WILL REPURCHASE THESE VEHICLES IN ACCORDANCE WITH THE TERMS STATED IN GM'S LETTER TO OWNERS. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS SHOULD CONTACT GM AT 1-877-477-1022 TO BEGIN THE PROCESS OF REPURCHASING THEIR VEHICLE.
05V486000 · Equipment:other:labels
Oct 19, 2005
CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE LABEL TABLE SPECIFIED THE 15 INCH SPARE FOR THE FRONT DISC/REAR DRUM BRAKE SYSTEM AND IT SHOULD SPECIFY A 16 INCH SPARE TIRE SIZE.
Consequence & remedy
Consequence: A 15" DIAMETER REPLACEMENT SPARE TIRE CAN NOT BE INSTALLED ON THE FRONT AXLE DUE TO A FIT INTERFERENCE WITH THE BRAKE CALIPER.
Remedy: OWNERS WILL BE MAILED A CORRECTED LABEL WITH INSTALLATION INSTRUCTIONS OR THE CUSTOMERS COULD HAVE THEIR DEALERS TO INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON NOVEMBER 29, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.