IllustrationLETTER FROM SENATOR WARNER ON BEHALF OF CONSTITUENT RE 2005 MALIBU RECALLS (ATTN: SHANE CLEM). *SMD THE CONSUMER STATED EACH TIME HE CALLED THE DEALER, TO INQUIRE ABOUT GETTING THE RECALL ISSUES RECTIFIED, HE WAS INFORMED THE PARTS WERE NOT AVAILABLE. ALSO, THE EMISSION CONTROL VALVE HAD TO BE REPLACED. *JB
2005 Chevrolet Malibu
Owner reports · Recalls · Investigations
More warning signs than most Malibu years
Owner complaints for the 2005 Chevrolet Malibu are substantially higher than the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
740–25K
9125–50K
13050–75K
13975–100K
199100–150K
130150K+
763 reports with mileage · 212 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 506 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 180 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 153 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
46 crash reports34 fire reports36 injury reports
Engine And Engine Cooling complaints
17 reportsTHERE WAS A CODE FOR SMALL LARGE EVAP LEAK ON THE COMPUTER. WE HAVE REPLACED THE SENSOR AND PART OF THE EXHAUST SYSTEM AND THE CODE IS STILL THERE. *TR
THE CAR DIED ON THE HIGHWAY WHEN IT GOES OVER 55 THE FUEL CUTS OUT. THE CAR DIES AND WILL NOT RESTART. *TR
CAR LOST POWER, STEERING INTACT & I STEERED IT TO THE SHOULDER OF THE INTERSTATE HIGHWAY. ANTI-THEFT LIGHT WAS FLASHING. ON JUN 4TH, ALL ATTEMPTS TO RESET THE THE SYSTEM FAILED (I WAS WAITING TEN MINUTES WITH KEY IN ON POSITION). THE CAR BEGAN TO FLASH ALL LIGHTS & A BUZZING ALARM SOUNDED. BY JULY, THE ANTI THEFT DEVICE WAS P…
Read full complaint
CAR LOST POWER, STEERING INTACT & I STEERED IT TO THE SHOULDER OF THE INTERSTATE HIGHWAY. ANTI-THEFT LIGHT WAS FLASHING. ON JUN 4TH, ALL ATTEMPTS TO RESET THE THE SYSTEM FAILED (I WAS WAITING TEN MINUTES WITH KEY IN ON POSITION). THE CAR BEGAN TO FLASH ALL LIGHTS & A BUZZING ALARM SOUNDED. BY JULY, THE ANTI THEFT DEVICE WAS PREVENTING STARTING OR CAUSING THE ENGINE TO STOP ON A DAILY BASIS. A CODE INDICATED A PROBLEM WITH THE FUEL SUPPLY TO THE INJECTORS & POSSIBLY THE FUEL PUMP. (THE ANTI THEFT DEVICE WORKS BY CUTTING OFF THE FUEL TO THE INJECTORS). REPLACED 2 FUEL PUMPS (ALL WORKING), HAD ELECTRICAL SYSTEM CHECKED, REPLACED A DEFECTIVE FUSE BOX,BENT PLUG. THE PROBLEM OCCURRED INTERMITTENTLY, & WAS DOCUMENTED BY THE SHOP. TODAY CAR WAS DISABLED BY THE ANTI THEFT DEVICE AS I TURNED ONTO THE STATE HIGHWAY.. WHEN I PICKED MY HUSBAND UP FROM WORK AT NIGHT THE CAR DISPLAYED THE ANTI THEFT LIGHT AND BUZZED & QUIT IN THE MIDDLE OF A FOUR LANE ROAD. WE MANAGED TO GET ALMOST HOME, & TURNED INTO OUR DRIVEWAY WHEN THE LIGHT BEGAN FLASHING & THE BUZZER AGAIN WENT OFF. A CAR ALMOST HIT US, BUT THE GUY PULLED OVER & HELPED PUSH OUR CAR. THE LOCAL CHEVROLET DEALER OFFERED TO DO A DIAGNOSTIC FOR $98, BUT SAYS THERE ARE NO BULLETINS OR RECALLS IT APPEARS THAT A GREAT MANY INCIDENTS OF THIS SORT HAVE OCCURRED WITHOUT ANY RESPONSE BY THE NHTSA TO INITIATE A RECALL OR HAVE CHEVROLET FIX OR DISABLE THE DEVICE ON AFFECTED VEHICLES, EVEN THOUGH THERE IS A SPAN OF OVER SEVEN YEARS OR MORE DURING WHICH CHEVY CONTINUED TO MANUFACTURE VEHICLES WITH FULL KNOWLEDGE THAT THE PART WAS DEFECTIVE & CAUSING LIFE THREATENING EVENTS. PLEASE DIRECT CHEVROLET TO NOTIFY OWNERS & AMELIORATE THE DANGER CREATED BY THEIR DEFECTIVE PRODUCT AT THEIR EXPENSE. *KB
CHECK ENGINE/POWER STEERING LIGHT CAME ON WHEN STARTING DOWN THE ROAD. RPMS SHOT UP TO 4 AND 5, CAR WON'T SHIFT (AUTOMATIC CAR), MPH STOPPED READING, ALL THE INFO I GET THROUGH MY RADIO SCREEN WENT BLANK, THERE IS ONLY AN ERROR SIGN WHERE MY MILEAGE IS. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT TURNED THE VEHICLE BACK ON AND IT PERFORMED NORMALLY. THE CONTACT CALLED THE DEALER WHO ADVISED HER TO TAKE THE VEHICLE IN FOR DIAGNOSIS. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRRENT AND FAILURE…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT TURNED THE VEHICLE BACK ON AND IT PERFORMED NORMALLY. THE CONTACT CALLED THE DEALER WHO ADVISED HER TO TAKE THE VEHICLE IN FOR DIAGNOSIS. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRRENT AND FAILURE MILEAGES WERE APPROXIMATELY 58,000.
MY FRIEND, MRS. X., A WIDOW AND MOTHER OF TWO CHILDREN ATTENDING COLLEGE, HAS BEEN PLAGUED BY A RECURRING PROBLEM WITH REPAIRS PERFORMED BY JOHNNY LONDOFF CHEVROLET. HER CAR, A 2005 CHEVY MALIBU WITH 68,000 MILES, HAS BEEN IN FOR REPAIRS FOUR TIMES. . . LONDOFF HAS EXTRACTED OVER $1400.00 FROM THIS WIDOW WOMAN, CONTINUING TO RE…
Read full complaint
MY FRIEND, MRS. X., A WIDOW AND MOTHER OF TWO CHILDREN ATTENDING COLLEGE, HAS BEEN PLAGUED BY A RECURRING PROBLEM WITH REPAIRS PERFORMED BY JOHNNY LONDOFF CHEVROLET. HER CAR, A 2005 CHEVY MALIBU WITH 68,000 MILES, HAS BEEN IN FOR REPAIRS FOUR TIMES. . . LONDOFF HAS EXTRACTED OVER $1400.00 FROM THIS WIDOW WOMAN, CONTINUING TO REPLACE PART AFTER PART WHICH HAS DONE NOTHING TO ALLEVIATE THE COMPLAINT. THEY DO NOT KNOW WHAT THE PROBLEM IS !!!! THE INTERNET REVEALS THOUSANDS OF IDENTICAL COMPLAINTS! ESSENTIALLY, MS. X'S CHEVY STOPS RUNNING, OR SLOWS TO 15 MPH WHILE IN THE FAST LANE OF THE INTERSTATE HIGHWAY WHERE THE SPEED LIMIT IS 60 MPH WITH NO WARNING! THE LAST TIME THE CAR WAS TAKEN INTO LONDOFF, THE SERVICE MANAGER, MR. B W. ADVISED THAT AFTER TAKING $1400.00 FROM MY FRIEND FOR "REPAIRS" THAT DID NOT EFFECT A REPAIR, THAT LONDOFF WAS GOING TO REPLACE THE "POWERTRAIN CONTROL MODULE" UNDER FACTORY WARRANTY, TO COMPLETE THE REPAIRS WHICH THE PREVIOUS REPAIRS DID NOT FIX. TO MAKE THE STORY SHORT, LONDOFF REPLACED THE PCM AND THROTTLE BODY / PEDAL FOR MRS. X, AND NOW 30 DAYS LATER, THE CAR ONCE AGAIN STALLS IN THE FAST LANE - IN THE RAIN, AS HUGE TRACTOR TRAILERS CAME BARRELING DOWN ON HER AT HIGH SPEED AT NIGHT. I FEAR FOR BOTH MY FRIENDS LIFE AND HER SAFETY IN THIS ' 05 MALIBU. WE TOOK THE CAR IN AGAIN TODAY FOR THE 4TH REPAIR OPPORTUNITY FOR LONDOFF, AND "MR. W" REFUSED TO GUARANTEE TO MAKE GOOD ON THE 12 MONTH, 12000 REPAIR WARRANTY, AND REFUSED TO PROVIDE EITHER A LOANER OR A RENTAL AT GM'S COST SO MRS. X COULD MAKE IT TO WORK NEXT WEEK. ESSENTIALLY, THESE MEN CONTINUE TO "JACK UP" THIS POOR WIDOW WOMAN, TAKING MORE AND MORE OF HER MEAGER SUSTENANCE WITHOUT EFFECTING REPAIRS!!!! MRS.X'S LIFE, HER JOB, HER HOME, HER CREDIT, HER CHILDREN'S COLLEGE EDUCATION IS THREATENED BY GM / LONDOFF'S FAILURE TO PROPERLY REPAIR THIS VEHICLE. IN ADDITION, TIME AFTER TIME THIS CAR HAS BROKEN DOWN IN THE FAST LANE IN HEAVY TRAFFIC DURING A THUNDERSTORM. OBVIOUS RECALL !!! UPDATED IVOQ 12/01/10 *TR
I OWN A 05 PRE-OWNED CHEVY MALIBU THAT WAS IN PRESTINE CONDITION WHEN BUYING. AFTER HAVING FOR ABOUT 6 MONTHS THE FUEL GAUGE STARTED ACTING ERRATICALLY AND THE CHECK ENGINE LIGHT STAYS ON AS A CAUSE OF THIS ISSUE. I WAS TOLD IT WILL COST ME $800 TO FIX THE ISSUE. ALSO THE AIR CONDITIONING UNIT HAS GONE OUT DUE TO A FAULTY PAR…
Read full complaint
I OWN A 05 PRE-OWNED CHEVY MALIBU THAT WAS IN PRESTINE CONDITION WHEN BUYING. AFTER HAVING FOR ABOUT 6 MONTHS THE FUEL GAUGE STARTED ACTING ERRATICALLY AND THE CHECK ENGINE LIGHT STAYS ON AS A CAUSE OF THIS ISSUE. I WAS TOLD IT WILL COST ME $800 TO FIX THE ISSUE. ALSO THE AIR CONDITIONING UNIT HAS GONE OUT DUE TO A FAULTY PART (TOLD BY A MECHANIC). I GOOGLED THIS ISSUE AND SO MANY OTHER PURCHASERS OF THE SAME VEHICLE ARE HAVING THE SAME ISSUES WITH THE AIR CONDITIONING AND THE FUEL GAUGE. THIS IS NOT RIGHT AND GM HAS TO KNOW THAT THESE PARTS ARE FAULTY. I AM A WORKING MOTHER OF 3 WHO CANNOT AFFORD TO HAVE THIS FIXED AND BECAUSE OF THIS I CANNOT RENEW BY TAGS ON MY CAR DUE TO THE CHECK ENGINE LIGHT BEING ON. *TR
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. SINCE PURCHASING THE VEHICLE, THE ANTI THEFT DEVICE HAS FAILED REPEATEDLY, THE ENGINE MAKES A TICKING SOUND, THE STEERING WHEEL IS SLIPPING OR LOOSE, AND OIL LEAKS FROM THE ENGINE. WHILE DRIVING 45 MPH, THE DASHBOARD . VIBRATES. THE CONTACT HEARS A NOISE IN THE RADIO WHEN THE VEHIC…
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. SINCE PURCHASING THE VEHICLE, THE ANTI THEFT DEVICE HAS FAILED REPEATEDLY, THE ENGINE MAKES A TICKING SOUND, THE STEERING WHEEL IS SLIPPING OR LOOSE, AND OIL LEAKS FROM THE ENGINE. WHILE DRIVING 45 MPH, THE DASHBOARD . VIBRATES. THE CONTACT HEARS A NOISE IN THE RADIO WHEN THE VEHICLE IS TURNED ON, THE ENGINE SERVICE LIGHT IS ILLUMINATED ON THE INSTRUMENT PANEL, THE INTERIOR LIGHTS FAILED, THE REMOTE START WOULD NOT START THE VEHICLE, AND THE ENGINE SHAKES ROUGHLY. THE CURRENT MILEAGE WAS 12,030 AND FAILURE MILEAGE WAS 100. UPDATED 09/24/08. *LJ THE CONSUMER STATED THERE WAS A PROBLEM WITH THE ENTIRE SUSPENSION. THE SHOCKS AND BEARINGS MADE A NOISY. THE HAZARD LIGHTS FAILED. UPDATED 09/30/08.*JB
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHEN TURNING THE STEERING WHEEL, THE CONTACT HEARD A POPPING SOUND. THE FAILURE BEGAN SIX MONTHS AGO AND NOW IT IS CAUSING THE POWER STEERING TO FAIL. THE FAILURE WAS VERY SUBTLE AT FIRST, BUT NOW THE POWER STEERING FAILS FOR DAYS AT A TIME. THE AIR CONDITIONING WOULD ACTIVATE ON …
Read full complaint
TL*THE CONTACT OWNS A 2005 CHEVROLET MALIBU. WHEN TURNING THE STEERING WHEEL, THE CONTACT HEARD A POPPING SOUND. THE FAILURE BEGAN SIX MONTHS AGO AND NOW IT IS CAUSING THE POWER STEERING TO FAIL. THE FAILURE WAS VERY SUBTLE AT FIRST, BUT NOW THE POWER STEERING FAILS FOR DAYS AT A TIME. THE AIR CONDITIONING WOULD ACTIVATE ON AND OFF, BUT NOW IT DOES NOT WORK AT ALL. THE DEALER STATED THAT THE POWER STEERING MODULE AND AIR CONDITIONING RESISTOR NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE CONTROL PANEL IS WARM TO THE TOUCH AFTER DRIVING FOR SOME TIME. THE VEHICLE IS CURRENTLY WITH THE DEALER AND THE REPAIR WILL COST OVER $900. THE CURRENT MILEAGE WAS 70,000 AND FAILURE MILEAGE WAS 50,000. UPDATED 09/10/08. *LJ THE CONSUMER STATED THE SHOCKS WENT BAD, THE TIE ROD ENDS HAD TO BE REPLACED, THE CD BECAME STUCK IN THE CD PLAYER. THE REAR CALIPERS HAD TO BE REPLACED AND THE STARTER WORKED INTERMITTENTLY. UPDATED 09/12/08. *JB
Official recalls
314V252000 · Electrical System:wiring; Electronic Stability Control (esc); Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Vehicle Speed Control:cruise Control
May 14, 2014
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence & remedy
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Additional source detail variants (5)
Electronic Stability Control (esc)
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Vehicle Speed Control:cruise Control
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights:switch
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
Electrical System:wiring
General Motors LLC (GM) is recalling certain model year 2004-2012 Chevrolet Malibu vehicles manufactured May 16, 2003, through October 11, 2012, 2004-2007 Malibu Maxx vehicles manufactured June 25, 2003, through April 5, 2007, 2005-2010 Pontiac G6 vehicles manufactured May 26, 2004, through January 4, 2010, and 2007-2010 Saturn Aura vehicles manufactured April 24, 2006, through May 26, 2009. In the affected vehicles, increased resistance in the Body Control Module (BCM) connection may result in voltage fluctuations in the Brake Apply Sensor (BAS) circuit. These fluctuations can cause one or more of these conditions: the brake lights to illuminate without the brake pedal being pushed; the brake lights to not illuminate when the pedal is pushed; difficulty disengaging the cruise control; moving the gear shifter out of the 'PARK' position without pushing the brake; and disablement of crash avoidance features such as traction control, electronic stability control, and panic braking assist features.
Consequence: Any of the above failure conditions increases the risk of a crash.
Remedy: GM will notify owners, and dealers will attach the wiring harness to the BCM with a spacer, apply dielectric lubricant to both the BCM and harness connector and the BAS and harness connector, and will relearn the brake pedal home position, free of charge. The manufacturer distributed an Interim letter to customers on July 14, 2014. The recall began on August 18, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), 1-800-762-2737 (Pontiac), 1-800-553-6000 (Saturn). GM's number for this recall is 13036.
14V224000 · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
Apr 30, 2014
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence & remedy
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Additional source detail variants (2)
Power Train:automatic Transmission:lever And Linkage:floor Shift
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
Power Train:automatic Transmission
General Motors LLC (GM) notified the agency on April 29, 2014, that they are recalling 56,214 model year 2007 and 2008 Saturn Aura vehicles. On May 22, 2014, GM increased the recall to include an additional 1,074,899 model year 2004-2008 Chevrolet Malibu vehicles manufactured from May 16, 2003, through October 5, 2007, model year 2004-2007 Malibu Maxx vehicles manufactured from June 25, 2003, through April 5, 2007, and model year 2005-2008 Pontiac G6 vehicles manufactured from May 26, 2004, through September 28, 2007, and equipped with 4-speed transmissions. The total number vehicles being recalled is now 1,131,113.
Consequence: If the transmission shift cable fractures while the vehicle is being driven, the transmission gear selection may not match the indicated gear and the vehicle may move in an unintended or unexpected direction, increasing the risk of a crash. Furthermore, when the driver goes to stop and park the vehicle, despite selecting the PARK position, the transmission may not be in PARK. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: GM will notify owners, and GM dealers will replace the shift cable assembly and mounting bracket, free of charge. The manufacturer has not yet provided a notification schedule. Owners may contact General Motors at 1-800-553-6000. GM's number for this recall is 14152.
14V153000 · Steering:electric Power Assist System
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA09004 · Turn Signal Lamps
Opened Mar 20, 2009 · Closed Aug 12, 2010
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:headlights; Exterior Lighting:tail Lights; Exterior Lighting:turn Signal
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Additional source detail variants (4)
Exterior Lighting:brake Lights
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Exterior Lighting:headlights
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Exterior Lighting:tail Lights
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.
Exterior Lighting:turn Signal
GM designed the MY 2004 and 2005 Chevrolet Malibu and Malibu Maxx vehicles with a daytime running lamp (DRL) system that uses the same filament (the high power filament of a dual filament bulb) as the front turn signals.The high power filament operates at full battery voltage when functioning as a DRL.The DRL is illuminated whenever the headlamps are off, increasing the duty cycle of the front turn signal bulb.The MY 2003 and earlier Malibu vehicles (Malibu Maxx was not manufactured for sale in the U.S. prior to MY 2004) used a headlamp based design, operated at a reduced voltage, for the DRL function; GM reverted back to this design on the MY 2006 and later Malibu and Malibu Maxx vehicles. Filament based bulbs have a finite life (hours of illumination) for any given operating voltage.As a result, increasing the duty cycle of a bulb typically decreases the life span of the bulb.GM identified and addressed two front turn signal/DRL and rear turn signal bulb quality issues early in MY 2004 production, however vehicle warranty claims for failed bulbs continued to occur.To address the high warranty levels of bulb failures (90% of the warranty claims submitted to ODI by GM were bulb failures and 10% were socket failures), GM issued a technical service bulletin in March 2006 advising dealers to use a new specification of bulb when addressing service failures, and to also inspect the electrical sockets for thermal damage and replace if necessary.In June 2006 (after subject vehicle production ended) GM changed the turn signal bulb specification to that of the TSB bulb in vehicle production also.To date, ODI has not identified any allegations of crash, injury, or fire related to the alleged defect even though the subject vehicles have experienced 5 - 6 years of field exposure.ODI's analysis of consumer complaints, both VOQ and manufacturer, shows a declining trend.The warranty rate for turn signal bulb replacement is high however statistical analysis of the warranty data suggests that the majority of the original equipment bulbs have already been replaced.GM conducted a safety recall (06V-263) for MY 2004-2005 Cadillac XLR to replace the front turn signal/DRL bulbs and the electrical sockets.However GM advised that the turn signal/DRL bulbs/sockets on the subject vehicles differ from those on the recalled XLRs in several respects, including using bulb sockets with four electrical terminals as opposed to three, which improves the electrical connection, allows the bulb to operate at a lower temperature, and adds stability to the bulb in the socket; operating at a lower voltage, which increases vehicle bulb life; using vented headlamps, which allows bulbs to run cooler than those installed in a non-vented XLR headlamp; and using a clear bulb, which runs cooler than the amber bulbs installed on the XLR.Additionally, the warranty claim level related to subject vehicle sockets is unremarkable compared to other defect investigations into defective socket assemblies.A safety-related defect trend has not been identified at this time.Further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will take further action if warranted by the circumstances.See attached report for further information.