NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
199 reportsClear category filter126,000 miles · Jul 17, 2011
Electrical System
2000 CHEVY MALIBU. ANTI-THEFT SYSTEM RANDOMLY ENGAGES AND WILL NOT ALLOW THE CAR TO BE STARTED. WE HAVE TO KEY LOCK AND UNLOCK THE DOORS, HAVE HAD TO UNHOOK THE BATTERY(WHICH WE JUST REPLACED IN HOPES THAT WAS PART OF THE PROBLEM) , AND LET THE CAR SIT FOR TEN MINUTES IN HOPES THAT IT WILL RESET ITSELF. AT 2:30 IN THE MORNING,…
Read full complaint
2000 CHEVY MALIBU. ANTI-THEFT SYSTEM RANDOMLY ENGAGES AND WILL NOT ALLOW THE CAR TO BE STARTED. WE HAVE TO KEY LOCK AND UNLOCK THE DOORS, HAVE HAD TO UNHOOK THE BATTERY(WHICH WE JUST REPLACED IN HOPES THAT WAS PART OF THE PROBLEM) , AND LET THE CAR SIT FOR TEN MINUTES IN HOPES THAT IT WILL RESET ITSELF. AT 2:30 IN THE MORNING, AND THE NEIGHBORHOOD I WORK IN, THIS IS UNSAFE. *TR
NHTSA ODI #10413198
133,000 miles · May 3, 2011
Electrical System
2000 CHEVROLET MALIBU , BOUGHT THE CAR IN 2005. THE ANTI-THEFT LIGHT COMES ON AND CAR WON'T CRANK, OR A FEW MINUTES DOWN THE ROAD IF IT DOES CRANK IT STALLS LOOSES ALL POWER ,AND THEN WON'T CRANK FOR ABOUT 30 MINUTES LATER IF NOT I MIGHT HAVE TO BEAT WITH MY HAND ON THE DASH JUST UNDER THE IGNITION SWITCH FOR ALL POWER TO REGAIN…
Read full complaint
2000 CHEVROLET MALIBU , BOUGHT THE CAR IN 2005. THE ANTI-THEFT LIGHT COMES ON AND CAR WON'T CRANK, OR A FEW MINUTES DOWN THE ROAD IF IT DOES CRANK IT STALLS LOOSES ALL POWER ,AND THEN WON'T CRANK FOR ABOUT 30 MINUTES LATER IF NOT I MIGHT HAVE TO BEAT WITH MY HAND ON THE DASH JUST UNDER THE IGNITION SWITCH FOR ALL POWER TO REGAIN ITS SELF. THIS PROBLEM STARTED BACK IN 2008, BUT MY HUSBAND GOT IT DOING RIGHT AGAIN AFTER ABOUT A MONTH OF TAPPING THE COMPUTER PART OF THE SWITCH FROM THE INSIDE OF THE DASH WITH A SCREW DRIVER HANDLE EVERY TIME HE WENT TO CRANK IT. IT DID FINE UP UNTIL RECENTLY , ABOUT SOMEWHERE IN FEBRUARY OF 2011, IT STARTED DOING IT AGAIN, DEALERSHIP CAN SEEM TO TELL ME NOTHING, THEY HAVE NO IDEA EVEN AFTER RUNNING IT ON A COMPUTER OVER NIGHT, ALL BECAUSE THE COMPUTER THEY SAID CAN'T FIND ANYTHING, HOW DUMB. I AM POOR, CAN'T AFFORD ANOTHER CAR. I LOVE MY MALIBU APART FROM WHAT IT IS DOING TO ME, I HAVE 2 KIDS, SMALL KIDS, THEY ARE WITH ME 24/7 AND THE CAR WILL JUST DIE ON ME LEAVING ME TO USE ALL ,Y STRENGTH AND POWER TO STEER AND STOP THE CAR ON TO THE SIDE OF THE ROAD. TO TOP IT OFF MY AIR ISN'T WORKING ANYMORE, AND BEING STUCK LIKE THAT IN THE HEAT FROM THIS STATE OF ALABAMA, IS NOT FUN OR HEALTHY FOR MY 2 KIDS OR ME. I JUST WANT IT TO WORK LIKE IT IS SUPPOSED TO . I CAN'T AFFORD TO PAY OVER 300 DOLLARS FOR A SWITCH AND I DON'T EVEN KNOW IF THAT IS THE PROBLEM, MY CAR SURGES, AND NO ONE CAN SEEM TO TELL ME A STRAIGHT ANSWER , BUT WHAT I DO KNOW IS I AM NOT THE ONLY ONE WITH THIS PROBLEM. AND SOMEONE NEEDS TO FIX IT NOW.BEFORE SOMETHING BAD HAPPENS, WHAT IF IT DIES ON ME LIKE THAT AND IT WILL AT HIGH SPEEDS ,AND SOMEONE NOT PAYING ATTENTION RUNS ME AND MY 2 KIDS OVER. PLEASE I AM BEGGING YOU, I DON'T WANT A NEW CAR, I JUST WANT MY PROBLEM THAT SEEMS TO BE VERY COMMON FIXED. *TR
NHTSA ODI #10398721
100,000 miles · Apr 4, 2011
Electrical System
THE ANTI-THEFT IGNITION LOCK DEVICE MALFUNCTIONS EVERY DAY, 3 OR MORE TIMES IN MOST CASES, YOU HAVE TO WAIT 10 MINUTES TO ATTEMPT TO START THE CAR AGAIN AND EVEN THEN IT MAY NOT START AND YOU HAVE TO WAIT 10 MORE MINUTES, NOW ITS NOT A "CRASH YOUR CAR THROUGH A BUILDING AND KILL PEOPLE" TYPE OF PROBLEM BUT IT IS A "SIT IN YOUR C…
Read full complaint
THE ANTI-THEFT IGNITION LOCK DEVICE MALFUNCTIONS EVERY DAY, 3 OR MORE TIMES IN MOST CASES, YOU HAVE TO WAIT 10 MINUTES TO ATTEMPT TO START THE CAR AGAIN AND EVEN THEN IT MAY NOT START AND YOU HAVE TO WAIT 10 MORE MINUTES, NOW ITS NOT A "CRASH YOUR CAR THROUGH A BUILDING AND KILL PEOPLE" TYPE OF PROBLEM BUT IT IS A "SIT IN YOUR CAR IN A TERRIBLE NEIGHBORHOOD AND PRAY YOU DONT GET RAPED, MURDERED, ROBBED, ETC" PROBLEM. I RECENTLY WAS WORKING IN INNER CITY BALTIMORE AND WAS REQUIRED TO PARK MY CAR ON GREENMOUNT AVENUE, WHICH IS THE WORST OF THE WORST AND SOMETIMES IT WOULD TAKE ME AN HOUR TO START MY CAR!!!!!!!!! THIS IS UTTERLY RIDICULOUS AND THIS IS THE REASON NOBODY WANTS TO BUY AMERICAN MADE CARS ANYMORE!!!!!! TAKE RESPONSIBILITY GM!!!!!!!!!! I SHOULDNT HAVE TO PAY $300+ TO GET THIS ISSUE FIXED. GM SHOULD PAY FOR IT AND ALSO REMOVE THIS DEVICE FROM ALL OF THIER VEHICLES. IT WAS OBVIOUSLY NOT A WELL THOUGHT OUT THEFT DETERRENT. AND FURTHER MORE THERE ARE SEVERAL OTHER ISSUES ON MY VEHICLE THAT I HAVE BEEN TOLD ARE "NOTORIOUS" ON THESE CARS. THE WHOLE ENTIRE BRAND SHOULD FALL UNDER THE LEMON LAW. I WANT SOME SATISFACTION, THEY NEED TO DO A RECALL FOR THIS. IT IS THE IGNITION LOCK CYLINDER AND HOUSING ASSEMBLY AND I CURRENTLY DONT HAVE THE MONEY TO GET IT FIXED, AND I MAY NEVER HAVE THE MONEY SEEING AS HOW IT CONSTANTLY MAKES ME LATE FOR WORK AND I MAY LOSE MY JOB BECAUSE OF IT! WAY TO GO CHEVY-THUMBS UP! *TR
NHTSA ODI #10394164
Mileage unknown · Mar 25, 2011
Electrical System
I HAVE A 2000 CHEVY MALIBU LS IN WHICH THE ANTI THEFT SYSTEM DOES NOT ALLOW ME TO OPERATE MY CAR PROPERLY. I WILL TRY TO START MY CAR AND GO SOMEWHERE AND IT WONT START FOR TEN TO FIFTEEN MINUTES. I LIVE INWI WHERE IT CAN GET VERY HOT AND EXTREMELY COLD. I ALSO HAVE A CHILD UNDER THE AGE OF TWO WHO IS WITH ME IN MY VEHICLE ON A …
Read full complaint
I HAVE A 2000 CHEVY MALIBU LS IN WHICH THE ANTI THEFT SYSTEM DOES NOT ALLOW ME TO OPERATE MY CAR PROPERLY. I WILL TRY TO START MY CAR AND GO SOMEWHERE AND IT WONT START FOR TEN TO FIFTEEN MINUTES. I LIVE INWI WHERE IT CAN GET VERY HOT AND EXTREMELY COLD. I ALSO HAVE A CHILD UNDER THE AGE OF TWO WHO IS WITH ME IN MY VEHICLE ON A REGULAR BASIS. I HAVE CALLED GM AND COMPLAINED ABOUT THIS ISSUE AND I AM TOLD THAT THEY CANT DO ANYTHING BECAUSE THIS IS NOT A SAFETY ISSUE. THIS IS A SAFETY ISSUE. IF IT IS BELOW FREEZING OUT SIDE AND I HAVE MY BABY IN THE CAR WITH ME AND HAVE TO WAIT FOR TEN OF FIFTEEN MINS FOR IT TO HOPEFULLY START MY CHILD OR I COULD GET VERY SICK. NOT TO MENTION SITTING IN A HOT CAR FOR THAT TIME WAITING FOR THE FAKE LIGHT TO GO OFF SO THAT I CAN START IT WITH THEY KEY THAT IS SUPPOSED TO GO WITH THE CAR BUT YET THE CAR THINKS IM TRYING TO STEAL IT. AND ANOTHER ONE IF IM TRAVELING AND STOP TO GET GAS AT NIGHT AND I HAVE TO PAY AT THE PUMP AND TURN THE CAR OFF, CUZ THAT'S WHAT YOUR SUPPOSED TO DO WHILE FUELING, THEN IT DOESN'T WANT TO START AGAIN IM STRANDED AT AN UNOPENED GAS STATION WHO KNOWS WHERE WITH MY YOUNG CHILD AND MYSELF AT NIGHT IN THE FREEZING COLD OR VERY HOT TEMPS. WHY AGAIN IS THIS NOT A SAFETY ISSUE? THIS PROBLEM NEEDS TO BE FIXED. AND WE SHOULD NOT HAVE TO PAY FOR IT TO BE DONE EITHER. 400 TO 800 TO TRY TO FIX A PROBLEM THAT GM SHOULD RECALL. AND IT ISN'T EVEN GUARANTEED TO NOT HAPPEN AGAIN. WHY IS IT THAT GM WONT RECALL THIS ISSUE THAT I HAVE SEEN TONS AND TONS OF COMPLAINTS ABOUT? IS IT BECAUSE GM DOESN'T KNOW A SOLUTION TO THIS PROBLEM? WELL GM U BETTER FIGURE ONE OUT OR U WILL MOST LIKELY BE LOOSING A LOT OF CUSTOMERS. I CERTAINLY WONT BUY ANOTHER GM CAR IF THEY WONT TAKE RESPONSIBILITY FOR THE ISSUES THAT THEY ARE HAVING WITH THESE CARS NOW. GM SHOULD STAND BY THEIR PRODUCT AND FIX THE ISSUES THAT CONSUMERS ARE HAVING WITH THEIR CARS. THIS IS DEFINITELY A SAFETY ISSUE WHO ARE YOU KIDDING? FIX THIS PROBLEM!!!! *TR
NHTSA ODI #10392838
147,257 miles · Dec 23, 2010
Electrical SystemFuel System, Gasoline
I HAVE A 2000 CHEVY MALIBU. IT HAS SOMETHING CALLED THE PASSLOCK SYSTEM OR THEFT SYSTEM AND IT PREVENTS THE CAR FROM STARTING. IT PREVENTS THE CAR FROM STARTING ALL THE TIME. THIS ISN'T THE FIRST TIME YOU HAVE RECEIVED THIS COMPLAINT I BET. I HAVE PUT AN EXTRA $2000 INTO THE CAR AFTER I BROUGHT IT HOPING IT WOULD FIX IT BUT …
Read full complaint
I HAVE A 2000 CHEVY MALIBU. IT HAS SOMETHING CALLED THE PASSLOCK SYSTEM OR THEFT SYSTEM AND IT PREVENTS THE CAR FROM STARTING. IT PREVENTS THE CAR FROM STARTING ALL THE TIME. THIS ISN'T THE FIRST TIME YOU HAVE RECEIVED THIS COMPLAINT I BET. I HAVE PUT AN EXTRA $2000 INTO THE CAR AFTER I BROUGHT IT HOPING IT WOULD FIX IT BUT I STILL HAVE THE PROBLEM. I HAVE READ ON-LINE AND EVERYONE WHO OWNS A 96 AND UP GM CAR HAS THIS PROBLEM. EVERYONE SAYS GM DOESN'T CARE ABOUT THIS PROBLEM AND THEY WON'T FIX IT. THEY SAY THIS IS THE ONLY WAY TO GET THEM TO FIX IT. IF WE COMPLAIN ON HERE. PLEASE MAKE THEM FIX THIS PROBLEM WITH THEIR CARS BECAUSE YOU WOULD SAVE OVER 1,000,000 PEOPLE TIME AND FRUSTRATION. NO JOKE, LITERALLY 1,000,000 PEOPLE HAVE THIS PROBLEM. THIS IS WHY THEY WENT BANKRUPT. GM SUCKS. THIS IS WHY AMERICA SUCKS AS A NATION. WE HAVE TO COMPLAIN ON HERE TO FIX OUR PROBLEMS. NO OFFENSE TO YOU. I DON'T HAVE ENOUGH MONEY TO BY ANOTHER CAR, AS MOST PEOPLE WITH THIS PROBLEM. PLEASE DO THE RIGHT THING AND MAKE GM FIX IT. I KNOW IT IS NOT THE AMERICAN WAY TO GIVE THE PEOPLE WHAT THEY WANT BUT MAYBE THIS TIME WE CAN MAKE AN EXCEPTION. PLEASE HELP ALL OF US WHO WOULD LOVE TO BUY A DIFFERENT CAR BUT DON'T HAVE THE MONEY. THANK YOU. *LN
NHTSA ODI #10372293
138,618 miles · Oct 25, 2010
Electrical System
TL- THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THE IGNITION SWITCH WORKS INTERMITTINGLY. THE CONTACT WAS TOLD TO TURN THE KEY AND LET IT SIT FOR 15 MINUTES AND THEN TRY TO START THE VEHICLE. THIS HAS WORKED, BUT THE CONTACT FEELS THIS IS A SAFETY ISSUE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMP…
Read full complaint
TL- THE CONTACT OWNS A 2000 CHEVROLET MALIBU. THE CONTACT STATED THE IGNITION SWITCH WORKS INTERMITTINGLY. THE CONTACT WAS TOLD TO TURN THE KEY AND LET IT SIT FOR 15 MINUTES AND THEN TRY TO START THE VEHICLE. THIS HAS WORKED, BUT THE CONTACT FEELS THIS IS A SAFETY ISSUE. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE FAILURE MILEAGE AND CURRENT MILEAGES WAS 136818
NHTSA ODI #10362291
141,501 miles · Oct 23, 2010
Electrical SystemExterior Lighting
AFTER DRIVING FOR A FEW MINUTES, SUDDENLY WITHOUT WARNING, THE TURN SIGNALS STOPPED WORKING, SO I STUCK MY ARM OUT THE WINDOW TO TRY TO COMPENSATE FOR THE LACK, I TRIED TO USE EMERGENCY FLASHERS AND THEY DID NOT WORK EITHER. EVERY DAY THAT I DRIVE, THE TURN SIGNALS WORK FOR ABOUT 15 MINUTES THEN STOP (EVEN THE EMERGENCY FLASHERS…
Read full complaint
AFTER DRIVING FOR A FEW MINUTES, SUDDENLY WITHOUT WARNING, THE TURN SIGNALS STOPPED WORKING, SO I STUCK MY ARM OUT THE WINDOW TO TRY TO COMPENSATE FOR THE LACK, I TRIED TO USE EMERGENCY FLASHERS AND THEY DID NOT WORK EITHER. EVERY DAY THAT I DRIVE, THE TURN SIGNALS WORK FOR ABOUT 15 MINUTES THEN STOP (EVEN THE EMERGENCY FLASHERS STOP WORKING). I CONTACTED THE CHEVY RECALL # 800-630-2438 AND SPOKE TO DANIEL WHO TOLD ME THAT THE RECALLS ARE VIN SPECIFIC AND THAT MY CAR WAS NOT INCLUDED IN THOSE VIN #'S AND THAT I HAVE TO PAY TO HAVE IT FIXED. *TR
NHTSA ODI #10361871
141,600 miles · Oct 22, 2010
Electrical SystemExterior Lighting
DRIVING FROM QUEENS TO BROOKLYN, NY AND SUDDENLY WITHOUT WARNING, THE TURN SIGNALS STOPPED WORKING, SO I STUCK MY ARM OUT THE WINDOW TO TRY TO COMPENSATE FOR THE LACK. EVERY DAY THAT I DRIVE, THE TURN SIGNALS WORK FOR ABOUT 15 MINUTES THEN STOP (EVEN THE EMERGENCY FLASHERS STOP WORKING). I'VE TAKEN THE CAR TO MECHANICS WHO ARE …
Read full complaint
DRIVING FROM QUEENS TO BROOKLYN, NY AND SUDDENLY WITHOUT WARNING, THE TURN SIGNALS STOPPED WORKING, SO I STUCK MY ARM OUT THE WINDOW TO TRY TO COMPENSATE FOR THE LACK. EVERY DAY THAT I DRIVE, THE TURN SIGNALS WORK FOR ABOUT 15 MINUTES THEN STOP (EVEN THE EMERGENCY FLASHERS STOP WORKING). I'VE TAKEN THE CAR TO MECHANICS WHO ARE AS STUMPED AS I WAS (UNTIL TODAY) WHEN I SAW THE NHTSA.DOT RECALL AND INVESTIGATION LIST WHICH INCLUDED MY CAR 2000 CHEVY IMPALA. *TR
NHTSA ODI #10361788
171,504 miles · Sep 23, 2010
Electrical SystemExterior Lighting
TURN SIGNALS INOPERABLE. FLASHER INOPERABLE. THIS MAKES IT IMPOSSIBLE TO ALERT OTHER DRIVERS OF INTENT TO TURN OR CHANGE LANES CAUSING A DANGEROUS SITUATION. I WAS TOLD THERE HAS ALREADY BEEN A RECALL BY THE CHEVROLET REPRESENTATIVE. THE RECALL WAS FOR THE TURN SIGNALS AND HAZARD SWITCH AND BOTH HAVE BEEN REPLACED BY A PREVIOUS …
Read full complaint
TURN SIGNALS INOPERABLE. FLASHER INOPERABLE. THIS MAKES IT IMPOSSIBLE TO ALERT OTHER DRIVERS OF INTENT TO TURN OR CHANGE LANES CAUSING A DANGEROUS SITUATION. I WAS TOLD THERE HAS ALREADY BEEN A RECALL BY THE CHEVROLET REPRESENTATIVE. THE RECALL WAS FOR THE TURN SIGNALS AND HAZARD SWITCH AND BOTH HAVE BEEN REPLACED BY A PREVIOUS OWNER AT 70000 MI. UNDER THE PREVIOUS RECALL. I AM NOW HAVING THE SAME PROBLEM AT 172000 MI. AND WAS TOLD IT IS NOW NOT THEIR RESPONSIBILITY. *TR
NHTSA ODI #10357136
84,500 miles · Sep 9, 2010
Electrical SystemExterior Lighting
TURN SIGNALS HAVE NOT BEEN WORKING UPON DEMAND. AS OF 9/82010 MY TURN SIGNALS HAVE STOPPED WORKING ALL TOGETHER. GM SAID MY VIN DID NOT FALL IN THE RECALL CATEGORY OF THE SAME VEHICLES WITH THE SAME PROBLEM. *TR
NHTSA ODI #10354632
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Aug 28, 2003
CERTAIN PASSENGER VEHICLES HAVE HAZARD WARNING SWITCHES THAT MAY EXPERIENCE SOLDER JOINT CRACKING CAUSED BY RAPID TEMPERATURE TRANSITIONS AND THE SOLDERING PROCESS. IF SOLDER JOINT CRACKING OCCURS AND RESULTS IN AN OPEN CIRCUIT, THE TURN SIGNALS/HAZARD LAMPS BECOME INTERMITTENT OR INOPERATIVE.
Consequence & remedy
Consequence: WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN THAT COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD WARNING SWITCH. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Oct 29, 1999
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILL FITTING IS NOT PROPERLY SECURED TO THE FUEL TANK. IN THAT CONDITION, FUEL LEAKAGE WOULD EXCEED THE PERMISSIBLE AMOUNT IN AN FMVSS TEST. FUEL LEAKS MAY OCCUR, PARTICULARLY AFTER REFUELING OR WHEN THE TANK IS MORE THAN HALF FULL.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WERE PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSPECT THE FUEL TANK AND REPLACE IT IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02037 · Turn Signal Failures
Opened Dec 23, 2002 · Closed Sep 5, 2003
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED AUGUST 27, 2003, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY SAFETY RECALL (NHTSA RECALL NO. 03V327) INVOLVING CERTAIN MODEL YEAR (MY) 2000-2001 CHEVROLET MALIBU, OLDSMOBILE ALERO, AND PONTIAC GRAND AM.GM'S RECALL COVERS 670,740 VEHICLES MANUFACTURED BEGINNING FEBRUARY 1, 2000 THROUGH MAY 1, 2001 (ALERO AND GRAND AM) AND FEBRUARY 1, 2000 THROUGH MAY 31, 2001 (MALIBU).GM REPORTS THAT TURN SIGNAL FAILURE IS DUE TO SOLDER JOINT CRACKING IN THE HAZARD SWITCH, AND HAS IDENTIFIED RAPID TEMPERATURE TRANSITIONS OF THE HAZARD SWITCH AND THE SOLDERING PROCESS AS THE CAUSE OF CRACKING.ELECTRICAL CURRENT TO THE TURN SIGNALS FLOWS THROUGH THE HAZARD SWITCH AND AN OPEN CIRCUIT IN THE HAZARD SWITCH WILL CAUSE THE EXTERIOR TURN/HAZARD LAMPS TO BECOME INTERMITTENT OR INOPERATIVE.GM WILL REPLACE THE HAZARD SWITCH ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA02028 · Erratic Fuel Gauge
Opened Sep 30, 2002 · Closed Dec 30, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Gasoline
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Other:storage:fuel Gauge System
ODI OPENED EA 02-028 TO REVIEW COMPLAINTS OF CONSUMERS REPORTING THAT THEIR FUEL GAUGE WAS INCORRECTLY DISPLAYING THE AMOUNT OF FUEL IN THE GAS TANK.THE FUEL GAUGE RECEIVES AN ELECTRICAL SIGNAL FROM A FUEL TANK SENDING SENSOR CIRCUIT CARD.A FLOAT ARM IN THE TANK MOVES ELECTRICAL CONTACTS THAT RUB AGAINST THE CARD AS THE LEVEL OF FUEL RISES AND FALLS.DISRUPTION OF THE ELECTRICAL SIGNAL (SUCH AS CAUSED BY CORROSION OF THE CIRCUIT CARD) WILL CAUSE INCORRECT READINGS TO REGISTER ON THE FUEL GAUGE.GM REPORTED IN THEIR RESPONSE TO ODI DATED JANUARY 13, 2003 THAT THE PRIMARY CAUSE OF ERRATIC FUEL GAUGE OPERATION IS EXCESS ELEMENTAL SULFUR IN FUEL.GM REPORTED THAT ABNORMAL LEVELS OF SULFUR SPORADICALLY OCCURRED IN CERTAIN PARTS OF CANADA AND THE U.S. RESULTING IN REPORTS OF FUEL GAUGE MALFUNCTION.GM MODIFIED THE SENDING SENSOR FOR VEHICLES BUILT AFTER OCTOBER 2000.IT MADE A SECOND SENSOR MODIFICATION FOR VEHICLES BUILT AFTER JANUARY 2003.GM ALSO ISSUED A CUSTOMER SATISFACTION CAMPAIGN (GM NUMBER 00101) IN DECEMBER 2000 FOR U.S. CUSTOMERS IN THE STATE OF MAINE AND ISSUED SEVERAL SERVICE BULLETINS INFORMING DEALERS OF THE AVAILABILITY OF SENSORS WITH IMPROVED CORROSION RESISTANCE.THE COMPLAINT TREND INDICATES THAT COMPLAINTS PEAKED IN LATE 2000 TO EARLY 2001.WARRANTY CLAIMS DECLINED SINCE PEAKING IN APRIL 2002.BASED ON THE NUMBER OF COMPLAINTS AND THE INDICATION OF A DECLINING TREND, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE02066 · Engine Stall Due To Fuel Starvation
Opened Sep 6, 2002 · Closed Nov 3, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Other; Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Additional source detail variants (4)
Fuel System, Gasoline:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Gasoline
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other:delivery:fuel Pump
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
Fuel System, Other
ODI OPENED PE02-066 TO EVALUATE THE SCOPE AND CONSEQUENCE OF ENGINE POWER-LOSS DUE TO FUEL STARVATION INDUCED BY IN-TANK MODULAR FUEL PUMP STRAINER RESTRICTION.THE SUBJECT PUMPS USE AN EXTERNAL ?SOCK? STRAINER TO FILTER FUEL FLOWING TO THE PUMP INLET.THIS FILTER CAN SOMETIMES BECOME CLOGGED, RESULTING IN A REDUCED FLOW OF FUEL TO THE ENGINE.GM HAS SUBSEQUENTLY MODIFIED THE STRAINERS TO REDUCE THIS RESTRICTION.ANALYSIS OF THE ODI COMPLAINT DATABASE SHOWS THAT DESPITE THESE RESTRICTIONS, THE SUBJECT VEHICLES STALL AT A RATE THAT IS COMPARABLE TO THOSE OF MANY PEER VEHICLES.ADDITIONALLY, NONE OF THE RELEVANT WARRANTY REPAIR RATES EXCEED 1% AT 36 MONTHS OF EXPOSURE.ONE RELATED CRASH INVOLVES A STALLED VEHICLE THAT WAS REAR-ENDED ON THE ROADWAY, WHILE THE REMAINDER INVOLVED MINOR COLLISIONS OR SCRAPES.THE SOLE INJURY CONSISTED OF BRUISING FROM A LOW SPEED FRONTAL CRASH. GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
PE02064 · Turn Signal Failure
Opened Aug 22, 2002 · Closed Dec 23, 2002
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:hazard Flashing Warning Lights:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
Exterior Lighting:turn Signal:switch
ODI OPENED THE INVESTIGATION BASED ON 9 COMPLAINTS OF TURN SIGNALS OPERATING SPORADICALLY ON THE 2000-2001 CHEVROLET MALIBU.THE TURN SIGNALS QUIT WORKING WITHOUT WARNING AND MAY OCCUR WHILE THE VEHICLE IS IN MOTION OR STANDING STILL.GM IDENTIFIED THE HAZARD SWITCH AS THE ROOT CAUSE OF THIS PROBLEM.ELECTRICAL CURRENT TO THE TURN SIGNAL PASSES THROUGH THE HAZARD SWITCH.FAILURE OF THE HAZARD SWITCHRESULTS IN LOSS OF TURN SIGNALS AND HAZARD LIGHTS.GM REPORTS 318, 184 AND 201 CONSUMER COMPLAINTS FOR THE MALIBU, ALERO AND GRAND AM RESPECTIVELY.GM ALSO REPORTS THE FOLLOWING MODELS HAVE THE SAME DESIGN TURN SIGNAL/HAZARD SWITCH AS THE CHEVROLET MALIBU: CHEVROLET CORVETTE, MONTE CARLO, AND IMPALA; OLDSMOBILE INTRIGUE AND ALERO; AND THE PONTIAC GRAND AM.THE COMPLAINT AND WARRANTY DATA SHOW THE HIGHEST OCCURANCE OF THE PROBLEM IN THE MY 2000-2001 MALIBU, ALERO, AND GRAND AM.
SQ01002 · Erratic Fuel Gauge
Opened Jan 26, 2001 · Closed Sep 30, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
SQ00004 · Accelerator Cable Detaches From Throttle
Opened Feb 2, 2000 · Closed Jan 19, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration