NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
789 reports90,100 miles · Jun 29, 2007
Suspension
FAILURE OF FRONT STRUT SPRINGS. NO NOTIFICATION EITHER TIME THEY BROKE / PASSENGER'S SIDE FRONT SPRING BROKE ABOUT 6 MONTHS AGO. I DID NOT THINK TOO MUCH OF IT BECAUSE DEALER STATED THEY HAVE SEEN THIS HAPPEN BEFORE. 6-27-07 MY DRIVER'S SIDE STRUT SPRING BROKE. I WAS NOW TOLD THAT THIS COULD HAVE CAUSED AN ACCIDENT BY THE WAY …
Read full complaint
FAILURE OF FRONT STRUT SPRINGS. NO NOTIFICATION EITHER TIME THEY BROKE / PASSENGER'S SIDE FRONT SPRING BROKE ABOUT 6 MONTHS AGO. I DID NOT THINK TOO MUCH OF IT BECAUSE DEALER STATED THEY HAVE SEEN THIS HAPPEN BEFORE. 6-27-07 MY DRIVER'S SIDE STRUT SPRING BROKE. I WAS NOW TOLD THAT THIS COULD HAVE CAUSED AN ACCIDENT BY THE WAY THIS HAD BROKE. I CONTACTED ANOTHER DEALER PER RECALL OR ANY NOTIFICATION OUT THERE REGARDING THIS SAFETY ISSUE. I WAS TOLD BY DEALER THAT THEY REPLACED THEM OFTEN ENOUGH THAT THEY EVEN STOCKED THEM. I FELT THAT IN THIS YEAR THE PRODUCTION DEFECT REQUIRED INTERVENTION BY YOU. I AGAIN HAD NO INDICATION UNTIL I HEARD A CLUNG. WHICH AT THAT TIME I WAS NOT DRIVING VERY FAST. I WORK IN A REPAIR SHOP, AND HAVE NEVER SEEN A SPRING BREAK ON ANY VEHICLE. THE SHOP I WORK FOR DEALS WITH VEHICLE WITH LOTS OF MILES ON THEM. MY 99 MALIBU ONLY HAS 85,000-90,000 MILES ON IT AND BOTH MY SPRINGS BROKE WITHIN 6 MONTHS OF EACH OTHER. THANKS FOR TAKING THE TIME TO READ MY CONCERN. PLEASE LET ME KNOW IF YOU HAVE HEARD OF ANYMORE ISSUES THAT MAY RELATE TO MY CONCERN.*AK
NHTSA ODI #10194951
123,810 miles · May 29, 2007
Suspension
REAR SUSPENSION - BOLT HOLDING LOWER CONTROL ARM FOR REAR TIRE. EITHER UNSCREWED ITSELF OR BROKE. VEHICLE BEGAN TO SHAKE VIOLENTLY AND WAS DIFFICULT TO CONTROL. ANY OTHER DRIVER MAY HAVE NOT BEEN ABLE TO HANDLE VEHICLE CAUSING A SERIOUS ACCIDENT WITH INJURIES OR EVEN DEATH. *TR
NHTSA ODI #10191951
92,000 miles · May 8, 2007
Exterior Lighting
TL*THE CONTACT OWNS A 1999 CHEVROLET MALIBU. THE CONTACT STATED THAT THE VEHICLE'S TURN SIGNALS AND HAZARD LIGHTS HAVE WORKED SPORADICALLY SINCE OCTOBER OF 2006. BEGINNING IN MAY OF 2007, THE LIGHTS DO NOT ILLUMINATE AT ALL. THE CURRENT MILEAGE IS 100,100 AND FAILURE MILEAGE WAS 92,000.
NHTSA ODI #10190119
258,000 miles · May 7, 2007
Electrical System
I BOUGHT THE CAR IN 2003, 3 MONTHS LATER THE ANTI-THEFT LIGHT BEGAN COMING ON KEEPING THE CAR FROM STARTING FOR AT LEAST 10 MINUTES. APRIL 24, 2007 THE CAR WOULD NOT START AT ALL. I CONTACTED CHEVROLET SEVERAL TIMES, AND NO DEFINITE ANSWER FOR THE PROBLEM COULD BE GIVEN. I COULD NOT AFFORD TO LET THEM TRY TO FIGURE THE PROBLEM…
Read full complaint
I BOUGHT THE CAR IN 2003, 3 MONTHS LATER THE ANTI-THEFT LIGHT BEGAN COMING ON KEEPING THE CAR FROM STARTING FOR AT LEAST 10 MINUTES. APRIL 24, 2007 THE CAR WOULD NOT START AT ALL. I CONTACTED CHEVROLET SEVERAL TIMES, AND NO DEFINITE ANSWER FOR THE PROBLEM COULD BE GIVEN. I COULD NOT AFFORD TO LET THEM TRY TO FIGURE THE PROBLEM OUT. I WORK IN A NOT SO SAFE PART OF TOWN AND THE CAR STALLED IN AN EMPTY PARKING LOT AT NIGHT AND I COULD HAVE BEEN ROBBED OR WORSE. THIS WAS VERY UNSAFE FOR PEOPLE. IF A PERSON NEEDING MEDICAL ATTENTION WAS DRIVING ONE OF THESE DEFECTIVE MALIBUS IT COULD HAVE RESULTED IN VERY SERIOUS PROBLEMS IF NOT EVEN DEATH TO THE OWNER. *AK
NHTSA ODI #10190026
54,300 miles · Apr 26, 2007
Engine And Engine Cooling
TL*THE CONTACT OWNS A 1999 CHEVROLET MALIBU. WHILE DRIVING 30 MPH THE ENGINE COOLANT INDICATOR LIGHT ILLUMINATED ON THE DASHBOARD. THE CONTACT TOOK THE VEHICLE TO A MECHANIC, WHO STATED THAT THE INTAKE MANIFOLD GASKET FAILED, ALLOWING THE COOLANT TO FLOW INTO THE ENGINE. THE CURRENT AND FAILURE MILEAGES WERE 54,300. *AK
NHTSA ODI #10189049
110,000 miles · Apr 9, 2007
Exterior Lighting
TL*- THE CONTACT OWNS A 1999 CHEVEROLET MALIBU WITH FAILURE MILEAGE 110,000. THE CONTACT STATED WHILE DRIVING AT 45 MPH SHE NOTICED THAT THE HAZARD LIGHTS AND SIGNAL LIGHTS WORKED ON OCCASION OR NOT AT ALL. ALSO, THE CONTACT STATED THAT SOMETIMES THEY WILL STOP WORKING AT ANY GIVEN TIME FOR A PERIOD OF TIME. SHE CONTACTED THE …
Read full complaint
TL*- THE CONTACT OWNS A 1999 CHEVEROLET MALIBU WITH FAILURE MILEAGE 110,000. THE CONTACT STATED WHILE DRIVING AT 45 MPH SHE NOTICED THAT THE HAZARD LIGHTS AND SIGNAL LIGHTS WORKED ON OCCASION OR NOT AT ALL. ALSO, THE CONTACT STATED THAT SOMETIMES THEY WILL STOP WORKING AT ANY GIVEN TIME FOR A PERIOD OF TIME. SHE CONTACTED THE MANUFACTURER, AND THEY DID NOT DO ANYTHING OTHER THAN TELL THE CONTACT THAT THE ABOVE MENTIONED PARTS THAT WERE AFFECTED DID NOT COME FROM THE SAME PLACE AS THOSE PARTS OF THE 2000 CHEVROLET MALIBU. THE CONTACT MENTIONED NHTSA NOTIFICATION RQ040005 AS A REFERENCE. THE CURRENT MILEAGE WAS 117,000.*AK UPDATE 4/30/07*TR
NHTSA ODI #10187357
Mileage unknown · Mar 22, 2007
Air BagsElectrical SystemEngine And Engine Cooling
MY 1999 CHEVY MAILBU HAS HAD MANY PROBLEMS. I WILL START WITH THE 2 FUEL INJECTERS REPLACED 2 MONTHS AFTER PURCHASING. THE CAR BEGIN TO RUN ROUGH THEN WOULD HAVE PROBLEMS STARTING. THEN THERE WAS THE ALTANATOR, THE THERMOSTAT, THE HEAD AND INTAKE GASKETS AND THE NUMUROUS ELECTICAL PROBLEMS. THE ELECTRICAL PROBLEMS STILL CANNOT B…
Read full complaint
MY 1999 CHEVY MAILBU HAS HAD MANY PROBLEMS. I WILL START WITH THE 2 FUEL INJECTERS REPLACED 2 MONTHS AFTER PURCHASING. THE CAR BEGIN TO RUN ROUGH THEN WOULD HAVE PROBLEMS STARTING. THEN THERE WAS THE ALTANATOR, THE THERMOSTAT, THE HEAD AND INTAKE GASKETS AND THE NUMUROUS ELECTICAL PROBLEMS. THE ELECTRICAL PROBLEMS STILL CANNOT BE SOLVED AFTER NUMROUS TRIPSTO THE REPAIR SHOP. MOST OF THE PROBLEMS HAVE BEEN CORRECTED ON MORE THAN ONE OCCASION. AS A CONSUMER I HOPE YOU WILL HELP US MALIBU OWNERS WHO ARE IN DESTRESS. I KNOW THE AUTO COMPANIES ARE IN FINANCIAL TROUBLE BUT THAT STILL DOES NOT EXCUSE MAKING AN UNSAFE AUTO. I AM AFRAID ENOUGH NOT TO DRIVE MY CAR. I FEEL I PUT MY FAMILY AND MYSELF IN DANGER TAKING THSI CAR ON THE ROAD. I HOPE YOU WILL HELP CORRECT THIS PROBLEM. I FEEL MY ONLY NEXT OPTION IS TO CONTACT A LAWYER OVER MY LEGAL RIGHTS.
NHTSA ODI #10185956
90,000 miles · Jan 19, 2007
SuspensionCrash
RIGHT FRONT COIL SPRING BROKE DAMAGING STRUT AND DAMAGING TIRE. BREAK WAS DUE TO RUST. VEHICLE WAS MAKING A TURN WHEN BREAK OCCURRED CAUSING WHEEL TO BE "STUCK" IN THE TURN POSITION DUE TO PARTS RUBBING ON TIRE. MECHANIC SAYS MANY OF GM PRODUCTS ARE AND HAVE EXPERIENCED SAID PROBLEM. *JB
NHTSA ODI #10179181
Mileage unknown · Jan 15, 2007
Structure
I HAVE A 1999 CHEVY MALIBU. I NOTICED LAST YEAR ABOUT AUGUST AROUND MY GAS TANK THE PAINT WAS STARTING TO BUBBLE, SO I TOOK IT IN TO A CHEVY DEALER IN LIVONIA TO SEE IF THERE WAS A WARRANTY ON THE BUBBLING PAINT, THEY HAD TOLD ME THE WARRANT WAS UP ON THAT, THEY HAD ALSO SAID THAT THEY HAD BEEN GETTING A LOT OF COMPLAINTS ABOUT…
Read full complaint
I HAVE A 1999 CHEVY MALIBU. I NOTICED LAST YEAR ABOUT AUGUST AROUND MY GAS TANK THE PAINT WAS STARTING TO BUBBLE, SO I TOOK IT IN TO A CHEVY DEALER IN LIVONIA TO SEE IF THERE WAS A WARRANTY ON THE BUBBLING PAINT, THEY HAD TOLD ME THE WARRANT WAS UP ON THAT, THEY HAD ALSO SAID THAT THEY HAD BEEN GETTING A LOT OF COMPLAINTS ABOUT THE SAME ISSUE FROM OTHER OWNERS OF A 1999 CHEVY MALIBU. I WANTED TO KNOW IF GENERAL MOTORS IS GOING TO HAVE A RECALL ON THAT, OR DO I JUST HAVE THE PROBLEM FIXED BY A BODY SHOP? *NM
NHTSA ODI #10178715
Mileage unknown · Dec 29, 2006
Engine And Engine CoolingService Brakes, AirVisibility
AFTER REPLACING MY INTAKE GASKET 8 MONTHS AGO, MY CAR STILL OVERHEATS. ONE OF MY COOLING FANS IS NOT WORKING. MY AC LEVEL CONTROLS 1 & 2 DOESN'T WORK, ONLY 3,4, AND 5. AC SHUTS OFF ON ITS OWN. MY ENGINE BELT WENT FROM SQEAKING TO MAKING A NOISE I NEVER HEARD BEFORE. NOW MY CAR IS NON OPERATIONAL DUE TO A KNOCKING SOUND COMING FR…
Read full complaint
AFTER REPLACING MY INTAKE GASKET 8 MONTHS AGO, MY CAR STILL OVERHEATS. ONE OF MY COOLING FANS IS NOT WORKING. MY AC LEVEL CONTROLS 1 & 2 DOESN'T WORK, ONLY 3,4, AND 5. AC SHUTS OFF ON ITS OWN. MY ENGINE BELT WENT FROM SQEAKING TO MAKING A NOISE I NEVER HEARD BEFORE. NOW MY CAR IS NON OPERATIONAL DUE TO A KNOCKING SOUND COMING FROM THE ENGINE. SO FAR IN THE PAST 8 MONTHS, I REPLACED MY INTAKE GASKET $600, REPLACED MY ENGINE BELT COST $120, REPLACED MY BRAKE PADS AND CALIPER TWICE IN THE PAST 2 YEARS $250 EACH TIME. NOW I'M LOOKING AT ANOTHER MAJOR REPAIR JOB. HELP ME PLEASE
NHTSA ODI #10177289
NHTSA investigations
5RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
DP02008 · Engine Coolant Boils Over
Opened Sep 3, 2002 · Closed Sep 24, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
Illustration