IllustrationDT*: THE CONTACT STATED WHILE ATTEMPTING TO START THE VEHICLE IT FAILED TO START AND THE THEFT SYSTEM LIGHT ILLUMINATED. ONCE THE VEHICLE STARTED IT WAS TAKEN TO THE DEALERSHIP AND THEY REPLACED THE PASS LOCK SENSOR, WHICH REMEDIED THE PROBLEM. THE MANUFACTURER WAS ALERTED. UPDATED 06/16/06. *JB
1997 Chevrolet Malibu
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1997 Chevrolet Malibu do not stand out strongly from the model-year median of 310.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Malibu years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 98 of 443 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 100 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 87 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 80 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
22 crash reports0 fire reports13 injury reports
What owners actually said
443 reportsDT*: THE CONTACT STATED THERE WAS ANTIFREEZE ON THE GROUND UNDER THE ENGINE. AN INDEPENDENT REPAIR SHOP DETERMINED THE INTAKE GASKET NEEDED TO BE REPLACED.
I OWN A CHEVROLET MALIBU,1997 MODEL AND EVERY TIME I GO OUT TO START IT, I VEHICLE WILL START AND THEN DIE. I WILL HAVE TO CONTINUE TO START IT AT LEAST 6 TIMES BEFORE IT WILL START AND STAY RUNNING. I HAVE TAKEN MY VEHICLE TO MECHANICS AND THEY DON'T SEEM TO KNOW WHAT IS THE PROBLEM. THE LAST MECHANIC I TOOK IT TO CALLED A …
Read full complaint
I OWN A CHEVROLET MALIBU,1997 MODEL AND EVERY TIME I GO OUT TO START IT, I VEHICLE WILL START AND THEN DIE. I WILL HAVE TO CONTINUE TO START IT AT LEAST 6 TIMES BEFORE IT WILL START AND STAY RUNNING. I HAVE TAKEN MY VEHICLE TO MECHANICS AND THEY DON'T SEEM TO KNOW WHAT IS THE PROBLEM. THE LAST MECHANIC I TOOK IT TO CALLED A GM GARAGE AND THEY SAID THAT IT WAS THE THEFT LOCK SYSTEM. I KINDLY SUGGEST THAT THIS PART BE RECALLED, BECAUSE IN TALKING WITH THE GM GARAGE THEY MENTIONED THAT THEY WERE SEEING A LOT OF THE SAME PROBLEM.*AK
WE BOUGHT THIS 1997 MALIBU FROM MY DAD LESS THAN A YEAR AGO FOR MY SON TO DRIVE TO COLLEGE. MY DAD IS METICULOUS IN CARING FOR HIS VEHICLES SO ALL THE SCHEDULED AND ROUTINE MAINTENANCE WORK HAS BEEN DONE AND IT STILL ONLY HAS 70XXX MILES ON IT. MY COMPLAINT IS THIS : LAST NIGHT MY SON WAS PARKING THE CAR WHEN IT SUDDENLY BECA…
Read full complaint
WE BOUGHT THIS 1997 MALIBU FROM MY DAD LESS THAN A YEAR AGO FOR MY SON TO DRIVE TO COLLEGE. MY DAD IS METICULOUS IN CARING FOR HIS VEHICLES SO ALL THE SCHEDULED AND ROUTINE MAINTENANCE WORK HAS BEEN DONE AND IT STILL ONLY HAS 70XXX MILES ON IT. MY COMPLAINT IS THIS : LAST NIGHT MY SON WAS PARKING THE CAR WHEN IT SUDDENLY BECAME VERY HARD TO TURN THE STEERING WHEEL. HE FINISHED PARKING, BUT A SHORT TIME LATER AS HE STARTED TO DRIVE HOME, HE REALIZED THAT THE POWER STEERING WAS COMPLETELY GONE. THERE HAVE BEEN SO MANY INCIDENTS LIKE THIS ONE THAT THERE WAS FINALLY A SAFETY RECALL ISSUED IN 2004. THE PAPERWORK I HAVE STATES THAT THE DEALER "REPLACED STEERING GEAR PINION BEARING AND RESET TOEIN". OBVIOUSLY,THAT REMEDY FAILED SINCE THE POWER STEERING WENT OUT ANYWAY. I'M SO THANKFUL THAT NO ONE WAS HURT, THAT IT DIDN'T HAPPEN WHILE HE WAS DRIVING TO OR FROM SCHOOL, AND THAT HE WAS HOME FOR CHRISTMAS BREAK WHEN IT HAPPENED. WE'LL BE TAKING THE CAR IN TO THE DEALER ON TUESDAY AND, BECAUSE THERE HAVE BEEN SO MANY OF THESE INCIDENTS IN THE '97 MALIBU (AND OTHER '97 GM MODELS) THAT THEY HAD TO ISSUE THE RECALL, I EXPECT THEM TO FIX IT FREE OF CHARGE. *NM
DT: ON 07/19/2005 THE CONTACT'S VEHICLE WAS HIT FROM BEHIND WHICH CAUSED IT TO NOSE DIVE INTO A DITCH. UPON IMPACT THE AIR BAGS DID NOT DEPLOY. THERE WERE NO LIGHTS ILLUMINATED ON THE DASH PRIOR TO THE ACCIDENT. THE CONTACT DID NOT KNOW HOW FAST THE OTHER VEHICLE WAS TRAVELING AT THE TIME OF IMPACT. THE IMPACT OF THE CRASH …
Read full complaint
DT: ON 07/19/2005 THE CONTACT'S VEHICLE WAS HIT FROM BEHIND WHICH CAUSED IT TO NOSE DIVE INTO A DITCH. UPON IMPACT THE AIR BAGS DID NOT DEPLOY. THERE WERE NO LIGHTS ILLUMINATED ON THE DASH PRIOR TO THE ACCIDENT. THE CONTACT DID NOT KNOW HOW FAST THE OTHER VEHICLE WAS TRAVELING AT THE TIME OF IMPACT. THE IMPACT OF THE CRASH BENT THE VEHICLE'S DOORS AND BUSTED HE WINDSHIELD. *AK *NM
THEFT LIGHT COMES ON WHILE DRIVING, THEN NEXT TIME I TRY TO START CAR IT FLASHES AND I CAN START CAR FROM 10 MINS LIKE OWNERS MANUAL SAYS TO TRY AFTER 10 MINS AFTER LIGHT STOPS FLASHING. I DO THIS AND THE LIGHT STARTS FLASHING. THIS IS VERY UNSAFE NOT BEING ABLE TO START A CAR LEAVING A MOTORIST STRANDED WHERE EVER THEY TURN THE…
Read full complaint
THEFT LIGHT COMES ON WHILE DRIVING, THEN NEXT TIME I TRY TO START CAR IT FLASHES AND I CAN START CAR FROM 10 MINS LIKE OWNERS MANUAL SAYS TO TRY AFTER 10 MINS AFTER LIGHT STOPS FLASHING. I DO THIS AND THE LIGHT STARTS FLASHING. THIS IS VERY UNSAFE NOT BEING ABLE TO START A CAR LEAVING A MOTORIST STRANDED WHERE EVER THEY TURN THERE CAR OFF FOR HOURS AND IN MY CASE 1 1\2 DAYS WITH NO CELL SERVICE TO CALL FOR REPAIR I HAD TO SLEEP IN MY CAR UNTIL ANOTHER MOTORIST PASSED THE FOLLOWING DAY. I UNDERSTAND THAT NORMAL EQUIPMENT FAILURE IS AN ISSUE OF ITS OWN THE DEALERSHIP SAYS THERE NO FIX FOR THE PROBLEM BUT TO HAVE THE CAR TOWED EVERTIME TO THE SHOP TO BE REPROGRAMMED WHICH HAPPENS EVERY 2-3 MONTHS. *JB
THIS IS A FOLLOW-UP TO MY REPORT OF THE FAILURE OF THE FLASHING OF THE TURN SIGNALS AND HAZARD WARNING LIGHTS (OID#10121781). I REPLACED THE HAZARD WARNING SWITCH IN THE DASH ON JUNE 4, 2005, AND THIS FIXED THE PROBLEM. THIS IS THE SAME PART THAT IS UNDER A RECALL FOR THE 2000 AND 2001 MODELS OF THIS SAME CAR (NHTSA CAMPAIGN ID …
Read full complaint
THIS IS A FOLLOW-UP TO MY REPORT OF THE FAILURE OF THE FLASHING OF THE TURN SIGNALS AND HAZARD WARNING LIGHTS (OID#10121781). I REPLACED THE HAZARD WARNING SWITCH IN THE DASH ON JUNE 4, 2005, AND THIS FIXED THE PROBLEM. THIS IS THE SAME PART THAT IS UNDER A RECALL FOR THE 2000 AND 2001 MODELS OF THIS SAME CAR (NHTSA CAMPAIGN ID NUMBER 03V327000). AS SUGGESTED PREVIOUSLY, I THINK IT WOULD BE APPROPRIATE TO EXTEND THE RECALL TO THE 1997 MODELS, SINCE IT IS THE SAME DEFECTIVE PART.
THE TURN SIGNALS AND HAZARD SIGNALS SUDDENLY STOPPED FLASHING. INTERMITTENTLY, THEY FLASH RAPIDLY WHEN ACTIVATED, BUT THEY TYPICALLY JUST STAY ON CONTINUOUSLY. THIS APPEARS TO BE THE SAME PROBLEM WHICH LED TO A RECALL ON THE 2000 AND 2001 MODELS OF THIS SAME CAR (NHTSA CAMPAIGN ID NUMBER 03V327000): "EXTERIOR LIGHTING:HAZARD FLA…
Read full complaint
THE TURN SIGNALS AND HAZARD SIGNALS SUDDENLY STOPPED FLASHING. INTERMITTENTLY, THEY FLASH RAPIDLY WHEN ACTIVATED, BUT THEY TYPICALLY JUST STAY ON CONTINUOUSLY. THIS APPEARS TO BE THE SAME PROBLEM WHICH LED TO A RECALL ON THE 2000 AND 2001 MODELS OF THIS SAME CAR (NHTSA CAMPAIGN ID NUMBER 03V327000): "EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH". I THINK IT WOULD BE APPROPRIATE TO EXTEND THE RECALL TO THE 1997 MALIBU MODELS.
STEERING WHEEL MADE AN IRRITATING SOUND WHEN TURNED. THE DEALERSHIP WAS NOTIFIED. UPON INSPECTION THEY INDICATED THAT THE STEERING GEAR HAD AN INTERNAL FAULT, AND REPLACED IT. CAUSE OF THE INTERNAL FAULT WAS NOT DISCLOSED TO THE CONSUMER. *AK RECALL CAMPAIGN# 03V527000. THE STEERING WAS REPAIRED. A YEAR LATER THE ENTIRE…
Read full complaint
STEERING WHEEL MADE AN IRRITATING SOUND WHEN TURNED. THE DEALERSHIP WAS NOTIFIED. UPON INSPECTION THEY INDICATED THAT THE STEERING GEAR HAD AN INTERNAL FAULT, AND REPLACED IT. CAUSE OF THE INTERNAL FAULT WAS NOT DISCLOSED TO THE CONSUMER. *AK RECALL CAMPAIGN# 03V527000. THE STEERING WAS REPAIRED. A YEAR LATER THE ENTIRE STEERING ASSEMBLY HAD TO BE REPLACED AGAIN. THE CHECK EMISSIONS LIGHT WOULD COME ON INTERMITTENTLY. THERE WERE NOISES WHEN THE VEHICLE WAS TURNED LEFT DUE TO THE STEERING GEARS INTERNAL FAULT AND THE GEAR WAS REPLACED, THE LEFT FRONT TIRE HAD A STEEL BELT SHOWING ON THE INSIDE. *SC *JB
DT: THERE WAS A RECALL REGARDING RACK AND PINION STEERING. THIS HAS BEEN REPAIRED AND REPLACED TWICE. THE VEHICLE STILL HAS PROBLEMS WITH THE STEERING SYSTEM. CONTACT TOOK THE VEHICLE TO A SERVICE DEALER, AND THEY CONCLUDED THAT IT WAS A POWER STEERING PUMP PULLEY. THE CONTACT HAS NOT HAD THIS REPAIRED, THE VEHICLE IS AT TH…
Read full complaint
DT: THERE WAS A RECALL REGARDING RACK AND PINION STEERING. THIS HAS BEEN REPAIRED AND REPLACED TWICE. THE VEHICLE STILL HAS PROBLEMS WITH THE STEERING SYSTEM. CONTACT TOOK THE VEHICLE TO A SERVICE DEALER, AND THEY CONCLUDED THAT IT WAS A POWER STEERING PUMP PULLEY. THE CONTACT HAS NOT HAD THIS REPAIRED, THE VEHICLE IS AT THE DEALERSHIP AT THIS DATE.*AK
Official recalls
414V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
03V527000 · Steering:rack And Pinion
Dec 11, 2003
CERTAIN PASSENGER VEHICLES HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE RETAINERS COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN ON FEBRUARY 5, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR PONTIAC AT 1-800-620-7668.
01V068000 · Visibility:windshield Wiper/washer:linkages
Mar 8, 2001
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE "SALT BELT" STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, UTAH, VERMONT, WEST VIRGINIA, WISCONSIN, AND WYOMING. IF A BUILDUP OF SNOW OR ICE RESTRICTS THE MOVEMENT OF THE PASSENGER SIDE WINDSHIELD WIPER ARM, THE PIVOT HOUSING CAN CRACK AND THE WIPERS WILL NOT OPERATE.
Consequence & remedy
Consequence: REDUCED VISIBILITY IN INCLEMENT WEATHER COULD LEAD TO A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE PASSENGER SIDE WINDSHIELD WIPER PIVOT HOUSING. OWNER NOTIFICATION BEGAN AUGUST 14, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR OLDSMOBILE AT 1-800-442-6537.
97V107000 · Air Bags:frontal
Jun 28, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FASTENERS THAT SECURE THE PASSENGER AIR BAG MODULE TO THE INSTRUMENT PANEL TIE BAR WERE OMITTED.
Consequence & remedy
Consequence: IF THE AIR BAG DEPLOYS, THE MODULE COULD SEPARATE FROM THE INSTRUMENT PANEL STRIKING AND INJURING AN OCCUPANT.
Remedy: DEALERS WILL INSPECT THE AIR BAG MODULE FOR THE PRESENCE OF THE FASTENERS AND, IF NECESSARY, INSTALL ANY FASTENERS THAT MAY HAVE BEEN OMITTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ04006 · Windshield Wiper Failure
Opened Jul 7, 2004 · Closed Jan 13, 2005
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer; Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Visibility:windshield Wiper/washer
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
Visibility:windshield Wiper/washer:linkages
IN MARCH 2001, GM NOTIFIED NHTSA THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA NUMBER 01V068) ON CERTAIN MODEL YEAR (MY) 1997-1998 CHEVROLET MALIBU AND OLDSMOBILE CUTLASS VEHICLES TO REPLACE DEFECTIVE WINDSHIELD WIPER PIVOT HOUSINGS.GM REPORTED THE WIPER FAILURE WAS TRIGGERED BY LOADS PLACED ON THE WIPERS WHEN OPERATED UNDER CONDITIONS OF MODERATE TO HEAVY SNOWFALL.GM CONDUCTED THE RECALL IN 28 STATES AND THE DISTRICT OF COLUMBIA (RECALL STATES) THAT RECEIVE MODERATE TO HEAVY SNOWFALL.THE RECALL COVERED THE SUBJECT VEHICLES BUILT THROUGH JANUARY 1998.ODI OPENED THIS RQ IN RESPONSE TO COMPLAINTS FROM CONSUMERS THAT EXPERIENCED WIPER FAILURE AND WERE DENIED THE RECALL REMEDY.GM IS SENDING LETTERS TO OWNERS NOT LOCATED IN THE RECALL STATES GIVING THEM A FREE REMEDY UPON REQUEST IF THEY ANTICIPATE DRIVING THE VEHICLE IN AREAS THAT MAY HAVE MODERATE TO HEAVY SNOWFALL.IN ADDITION, GM IS NOTIFYING ALL OWNERS WHO HAVE CHANGED THEIR RESIDENCE FROM A NON-RECALL STATE TO A RECALL STATE SINCE THE DATE OF THE ORIGINAL OWNER NOTIFICATION LETTER (MARCH 2001).THE ACTIONS TAKEN BY THE MANUFACTURER ARE SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
EA00019 · Windshield Wiper
Opened Jul 12, 2000 · Closed Mar 6, 2001
Status: closed (inferred from source dates) · Visibility
ON FEBRUARY 22, 2000, THE OFFICE OF DEFECTS INVESTIGATION (ODI) INITIATED PE00-009 BASED ON SEVEN REPORTS OF WINDSHIELD WIPER FAILURE IN CERTAIN MODEL YEAR (MY) 1997 & 1998 CHEVROLET MALIBU & OLDSMOBILE CUTLASS VEHICLES.THE INVESTIGATION WAS UPGRADED TO EA00-019 ON JULY 12, 2000.DURING THE COURSE OF THE INVESTIGATION, IT WAS FOUND THAT THE FAILURES WERE THE RESULT OF FRACTURE OF THE PASSENGER-SIDE WINDSHIELD WIPER PIVOT HOUSING (SUBJECT COMPONENT).SUCH A FRACTURE LED TO AN IMMEDIATE AND IRRECOVERABLE LOSS OF WINDSHIELD WIPER FUNCTION.GMREPORTED THAT THE MATERIAL COMPOSITION (50% GLASS-REINFORCED ACETAL) OF THE SUBJECT COMPONENT WAS INSUFFICIENT TO WITHSTAND STRESSES IMPOSED BY CERTAIN FROZEN PRECIPITIATION ACCUMULATIONS.THE SUBJECT COMPONENT MATERIAL WAS CHANGED TO THE STRONGER 50% GLASS-REINFORCEDNYLON-6, EFFECTIVE JANUARY 98.OBSOLETE SERVICE PART WERE DISCARDED.GM WILL REPLACE THE SUBJECT COMPONENTS IN 129,427 SUBJECT VEHICLES FOUND IN 28 STATES (AK, CO, CT, DE, ID, IL, IN, IA ME, MD, MA, MI, MN, MT, NE, NH, NJ, NY, ND, OH, PA, RI, SD, UT, VT, WV, WI, WY), THE DISTRICT OF COLUMBIA, AND ALL CANADIAN PROVINCES.THESE STATES ACCOUNTED FOR 91% OF THE CONSUMER COMPLAINTS IDENTIFIED ABOVE.ODI WILL MONITOR THIS COMPAIGN FOR ADEQUATE EFFCTIVENESS AND, IF NECESSARY, TAKE FURTHER ACTION IN THE FUTURE.FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS MATTER IS UNJUSTIFIED AT THIS TIME.THE ENGINEERING ANALYSIS IS CLOSED.
EA00010 · Stop Lamp Assembly Overheat
Opened Mar 27, 2000 · Closed Aug 9, 2001
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE00009 · Windshield Wiper
Opened Feb 22, 2000 · Closed Jul 12, 2000
Status: closed (inferred from source dates) · Visibility
There is no summary currently available