The contact owns a 2016 Chevrolet Malibu. The contact stated that while her husband was driving at an undisclosed speed, the brakes were inoperable. The contact stated that the vehicle eventually stopped as needed. The vehicle was driven to the residence. The vehicle was taken to two independent mechanics; however, the failure c…
Read full complaint
The contact owns a 2016 Chevrolet Malibu. The contact stated that while her husband was driving at an undisclosed speed, the brakes were inoperable. The contact stated that the vehicle eventually stopped as needed. The vehicle was driven to the residence. The vehicle was taken to two independent mechanics; however, the failure could not be duplicated. The vehicle was taken to the dealer where it was diagnosed with a failed brake master cylinder. The contact was informed that the brake master cylinder needed to be replaced. The vehicle was not repaired. The contact was advised that the parts to repair the vehicle were no longer in production. The manufacturer was not made aware of the failure. The failure mileage was approximately 75,000.
General Motors LLC (GM) is recalling certain model year 2016 Malibu Hybrid vehicles manufactured October 27, 2015, to June 3, 2016. The affected vehicles have a shut-off switch for the high voltage battery for use when servicing the vehicle. This manual service disconnect switch (MSD) may not be properly installed and thus may not lock into position, unexpectedly disconnecting the high-voltage power while driving, effectively stalling the vehicle.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: GM will notify owners, and dealers will inspect the MSD and correct the installation, as necessary, free of charge. The recall began on August 10, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 51230.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2016 Chevrolet Malibu Hybrid Problems, Complaints & Recalls | Skip That Year
Illustration