TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE STEERING WHEEL INDEPENDENTLY TURNED TO THE LEFT WITHOUT WARNING. THE VEHICLE WAS TURNED OFF AND BACK ON BUT FAILED TO FIX THE ISSUE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTAC…
Read full complaint
TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU CLASSIC. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE STEERING WHEEL INDEPENDENTLY TURNED TO THE LEFT WITHOUT WARNING. THE VEHICLE WAS TURNED OFF AND BACK ON BUT FAILED TO FIX THE ISSUE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE RACK AND PINION DETACHED FROM THE SUBFRAME AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT ONLY THE BUSHING WAS REPLACED AND NOT THE RACK AND PINION. IN ADDITION, THE CONTACT STATED ON ANOTHER OCCASION THE VEHICLE FAILED TO SHIFT TO REVERSE OR GO INTO FORWARD GEAR WHILE IN THE MIDDLE OF THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE SHIFT CABLE WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 157,000.
NHTSA ODI #11311038
100,103 miles · May 10, 2017
Power Train
I TURN MY CAR ON DRIVE GO TO GET OUT THE KEY WON'T COME OUT SOMETIMES IT DOES AND MOST TIME IS DOESN'T. I TRY TURN THE CAR BACK ON PUTTING THE CAR IN DRIVE THEN PARK AND TURNING THE KEY TO OFF POSITION AND THE CAR STILL DOESN'T GO INTO THE PARK POSITION SO THE KEY DOESN'T GO INTO OFF POSITION TO TAKE KEY OUT. THE CAR STAYS ON …
Read full complaint
I TURN MY CAR ON DRIVE GO TO GET OUT THE KEY WON'T COME OUT SOMETIMES IT DOES AND MOST TIME IS DOESN'T. I TRY TURN THE CAR BACK ON PUTTING THE CAR IN DRIVE THEN PARK AND TURNING THE KEY TO OFF POSITION AND THE CAR STILL DOESN'T GO INTO THE PARK POSITION SO THE KEY DOESN'T GO INTO OFF POSITION TO TAKE KEY OUT. THE CAR STAYS ON WITHOUT THE IGNITION BEING ON. THE CAR IS STATIONARY BUT THE CAR WON'T GO INTO PARK TO TURN THE CAR COMPLETELY OFF. SPOKE TO GM PROBLEM WITH TRANSMISSION SHIFT CABLE BUT THEY WON'T HELP ME. THE KEEP SAYING THERE IS NO RECALL FOR MY CAR. THERE WAS A RECALL FOR THIS GM'S RECALL 14152. PLEASE HELP. THANK YOU!
NHTSA ODI #10984738
207,000 miles · Apr 5, 2015
Power Train
VEHICLE IS UNABLE TO SMOOTHLY SHIFT INTO PARK POSITION TO ALLOW THE KEY TO BE TURNED OFF. CERTIFIED MECHANIC STATED THE SHIFTER CABLE IS MOST LIKELY THE DEFECT. MANY MODELS HAVE ALREADY BEEN RECALLED. THE CAR IN NOT ABLE TO SHIFT INTO PARK TO ALLOW TURNING OF THE KEY IGNITION SWITCH TO THE OFF POSITION SO THAT THE CAR BATTERY …
Read full complaint
VEHICLE IS UNABLE TO SMOOTHLY SHIFT INTO PARK POSITION TO ALLOW THE KEY TO BE TURNED OFF. CERTIFIED MECHANIC STATED THE SHIFTER CABLE IS MOST LIKELY THE DEFECT. MANY MODELS HAVE ALREADY BEEN RECALLED. THE CAR IN NOT ABLE TO SHIFT INTO PARK TO ALLOW TURNING OF THE KEY IGNITION SWITCH TO THE OFF POSITION SO THAT THE CAR BATTERY TURNS OFF. SIFTER CABLE COULD POSSIBLY MALFUNCTION DURING NORMAL DRIVING/OPERATION, STARTING/STOPPING. *TR
NHTSA ODI #10703790
120,000 miles · May 22, 2014
Power Train
WHEN IN REVERSE, BUT NOT MOVING, THE WHOLE FRONT OF THE CAR SHIMMIES AND MAKES NOISES. THE AFFECTED PART WAS JUST REPLACED (SUPPOSEDLY) IN FEB. 2012. NOW THEY SAY THAT THE PARTS AGAIN MUST BE REPLACED BECAUSE THEY ARE JUST FINDING IT NOW, A COUPLE OF MONTHS AFTER THE WARRANTY HAS EXPIRED. *TR
NHTSA ODI #10593519
65,000 miles · Feb 19, 2013
Power TrainService BrakesSteering
I WAS DRIVING ALONG THE ROAD, AND THE YELLOW WRENCH POPPED UP,THE WHEEL WAS DIFFICULT TO CONTROL. ALSO, WHILE TURNING THE CAR THE WHEEL WAS DIFFICULT TO TURN. THIS PROBLEM OCCURS AT LEAST 3-4 TIMES A YEAR. MY BRAKE PEDDLE ACTS UP IN THE SNOWY MONTHS. WHEN I PRESS THE BRAKE PEDDLE-THE PEDDLE JUMPS PUSHES UP AND DOWN INTO MY FEET.…
Read full complaint
I WAS DRIVING ALONG THE ROAD, AND THE YELLOW WRENCH POPPED UP,THE WHEEL WAS DIFFICULT TO CONTROL. ALSO, WHILE TURNING THE CAR THE WHEEL WAS DIFFICULT TO TURN. THIS PROBLEM OCCURS AT LEAST 3-4 TIMES A YEAR. MY BRAKE PEDDLE ACTS UP IN THE SNOWY MONTHS. WHEN I PRESS THE BRAKE PEDDLE-THE PEDDLE JUMPS PUSHES UP AND DOWN INTO MY FEET. WHEN IT SNOWS, I WORRY ABOUT RUNNING INTO A CAR. *TR
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA04018 · Loss Of Electric Power Steering
Opened Jul 1, 2004 · Closed May 10, 2005
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
Additional source detail variants (2)
Steering:electric Power Assist System
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
Steering
IN PERFORMING THIS ENGINEERING ANALYSIS, ODI DETERMINED THAT THE ELECTRIC POWER STEERING SYSTEM IN THE SUBJECT VEHICLES CAN MALFUNCTION OR FAIL, CAUSING THE DRIVER TO LOSE POWER STEERING ASSISTANCE; HOWEVER, DUE TO THE FOLLOWING REASONS, ODI HAS DECIDED THAT FURTHER EXPENDITURE OF AGENCY RESOURCES ON THIS INVESTIGATION IS NOT WARRANTED AT THIS TIME: - GM ISSUED CUSTOMER SATISFACTION CAMPAIGN (CSC) 04050A INDECEMBER 2004 TO ADDRESS THE ALLEGED DEFECT IN APPROXIMATELY58,700 SUBJECT VEHICLES, ENCOMPASSING AT LEAST 97 PERCENT OF THECOMPLAINT AND WARRANTY CLAIMS POPULATION.VEHICLES OUTSIDE THECSC 04050A POPULATION CONTAIN A NEWLY DESIGNED TORQUE ANDPOSITION SENSOR AND HAVE EXPERIENCED A RELATIVELY LOW COMPLAINTRATE.THIS CUSTOMER SATISFACTION CAMPAIGN PRESENTLY HAS ACOMPLETION RATE OF 52%. - THE IMPACT ON THE DRIVER?S ABILITY TO CONTROL THESE RELATIVELYSMALL AND LIGHT VEHICLES WAS LIMITED.VRTC TEST ENGINEERS WEREUNABLE TO INDUCE A FAILURE MODE THAT WOULD CAUSE THE EPS TOSUBSTANTIALLY LIMIT THE DRIVER?S ABILITY TO TURN THE VEHICLE IN APARTICULAR DIRECTION OR TO PROVIDE THE DRIVER WITH UNINTENDEDPOWER ASSISTANCE.- THERE IS NO RISK OF FIRE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED BY THE CIRCUMSTANCES.(FOR FURTHER DETAILS SEE ATTACHED ENGINEERING ANALYSIS (EA04-018)CLOSING REPORT.)
2004 Chevrolet Malibu Classic Problems, Complaints & Recalls | Skip That Year
Illustration