IllustrationTHE PAINT JOB IS HORRIBLE. THE PAINT IS COMPLETELY PEELING OFF OF MY LUMINA. *JB
1996 Chevrolet Lumina
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 Chevrolet Lumina do not stand out strongly from the model-year median of 126.
About this comparison →How this year compares
Owner complaints by model year
Compare all Lumina years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 36 of 245 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
24 crash reports2 fire reports24 injury reports
What owners actually said
245 reportsDT*: THE CONTACT STATED THE ENGINE'S INTAKE MANIFOLD WAS LEAKING ANTIFREEZE. THE NON SERVICE DEALER DETERMINED THE TOP OF THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A SERVICE DEALER.
I TURNED ON MY CAR AND PUT IT IN REVERSE TO BACK OUT OF A PARKING SPACE. I HAD FOUR FRIENDS IN THE CAR. I WAITED FOR MY FRIENDS TO GET SITUATED IN THE CAR AND TOOK MY FOOT OFF THE BRAKE. THE CAR DID NOT ROLL BACK AS IT NORMALLY DID WHEN IN GEAR. SUDDENLY, THE CAR LURCHED BACKWARD AND STARTING ACCELERATING TOWARD A CONCRETE WAL…
Read full complaint
I TURNED ON MY CAR AND PUT IT IN REVERSE TO BACK OUT OF A PARKING SPACE. I HAD FOUR FRIENDS IN THE CAR. I WAITED FOR MY FRIENDS TO GET SITUATED IN THE CAR AND TOOK MY FOOT OFF THE BRAKE. THE CAR DID NOT ROLL BACK AS IT NORMALLY DID WHEN IN GEAR. SUDDENLY, THE CAR LURCHED BACKWARD AND STARTING ACCELERATING TOWARD A CONCRETE WALL THAT WAS ABOUT 45 FEET BEHIND US. I DID NOT HAVE MY FOOT ON THE ACCELERATOR. I QUICKLY PUT MY FOOT ON THE BRAKE TO TRIED TO SLOW THE CAR DOWN. NOTHING HAPPENED, SO I QUICKLY TOOK MY FOOT OFF THE BRAKE, JUST IN CASE I HAD ACCIDENTALLY HIT THE ACCELERATOR. THE CAR CONTINUED TO ACCELERATE TOWARDS THE WALL. I REMEMBER PICKING UP BOTH MY FEET JUST TO MAKE SURE I WAS NOT TOUCHING THE PEDALS. WE HIT THE WALL GOING ABOUT 25-30 MPH. FOUR OF US WERE FINE, BUT MY FRIEND IN THE REAR PASSENGER SIDE SEAT BROKE HER CHEEKBONE. THE CAR WAS TOTALED. I WAS NOT ABLE TO FIND ANYONE WILLING TO INSPECT THE CAR TO DETERMINE THE CAUSE OF FAILURE. THE CAR WAS SALVAGED FOR PARTS. *JB
1996 CHEVROLET LUMINA, BRAKE LIGHTS NOT WORKING EXCEPT FOR IN THE REAR WINDOW. IF THAT BULB WERE TO BURN OUT, I WOULD HAVE NO BRAKE LIGHTS AT ALL. I HAVE DISCOVERED, AND I AM SURE, THAT YOU ARE AWARE THAT THIS IS A VERY COMMON PROBLEM. WHY HAS THIS NOT BEEN CORRECTED? *JB
THE ENGINE STARTED KNOCKING AROUND 100K MILES AND GETTING WORSE EVER SINCE. THE PISTON PIN IS GOING BAD. I FOUND OUT THAT GM KNOWS ABOUT THIS PROBLEM BY A CERTIFIED GM TECHNICIAN. HE TOLD ME THAT ALL 3.1L ENGINES HAVE THIS PROBLEM AND GM WONT FIX IT. I FEEL SHAFTED AND WILL NEVER BY A GM PRODUCT AGAIN. *NM
THE CHEVROLET LUMINA, 1996; POOR PAINT JOB. THE PAINT LASTS APPROXIMATELY FOUR (4) YEARS AND THEN IT STARTS TO CHIP AND PEEL OFF. *NM
WHILE DRIVING TO WORK ONE MORNING ON A HIGHWAY, THE INTAKE MANIFOLD HEAD GASKET BLEW, MIXING THE OIL WITH THE WATER, CAUSING THE MOTOR TO NEED REPLACING. I HAD THE MOTOR REPLACED AT A COST OF $2680.07. WE HAD AN EXTENDED WARRANTY OF 6 YEARS 50 THOUSAND MILES, THE MOTOR BLEW AT 6.5 YEARS AND 52,091 MILES. NOTHING WAS DONE TO HELP…
Read full complaint
WHILE DRIVING TO WORK ONE MORNING ON A HIGHWAY, THE INTAKE MANIFOLD HEAD GASKET BLEW, MIXING THE OIL WITH THE WATER, CAUSING THE MOTOR TO NEED REPLACING. I HAD THE MOTOR REPLACED AT A COST OF $2680.07. WE HAD AN EXTENDED WARRANTY OF 6 YEARS 50 THOUSAND MILES, THE MOTOR BLEW AT 6.5 YEARS AND 52,091 MILES. NOTHING WAS DONE TO HELP ME THE CONSUMER. I CALLED THE DEALER( BURTNESS CHEVY,303 E.BELOIT ST. ORFORDVILLE,WI.53576), AND THEY SAID IT WAS MY FAULT FOR NOT TRADING IN THE CAR BEFORE THE WARRANTY WAS UP. THEN I CALLED GM(CENTRAL OFFICE P.O.BOX 33170, DETROIT, MI.48232-5170)AND THEY SAID A WARRANTY IS A WARRANTY. I JUST NOW CAME ACROSS YOUR WEB SIGHT, AND I FEEL I NEED TO LET YOU KNOW ABOUT THIS PROBLEM. HOPE THEY CAN COME UP WITH A BETTER REASON IN THE FUTURE FOR OTHER CONSUMERS. THANKS YOU, CHERYL PHILLIPS. *JB
DT: THE CONTACT STATED WHILE DRIVING THE FRAME CAME OUT AROUND THE BOLTS. THIS CAUSED THE ENGINE TO FALL ONTO THE GROUND AND THE STEERING TO PULL OUT OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALERSHIP, BUT THEY HAVE NOT INSPECTED THE VEHICLE. THE MANUFACTURER WAS SUPPOSE TO SEND OUT A REPRESENTATIVE TO INSPECT THE VEHI…
Read full complaint
DT: THE CONTACT STATED WHILE DRIVING THE FRAME CAME OUT AROUND THE BOLTS. THIS CAUSED THE ENGINE TO FALL ONTO THE GROUND AND THE STEERING TO PULL OUT OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALERSHIP, BUT THEY HAVE NOT INSPECTED THE VEHICLE. THE MANUFACTURER WAS SUPPOSE TO SEND OUT A REPRESENTATIVE TO INSPECT THE VEHICLE.*AK UPDATED 2/7/2006 - *NM
1996 CHEVROLET LUMINA TIRE BLEW OUT. *TS THE PASSENGER SIDE FRONT TIRE BLEWOUT DAMAGING THE RIGHT FRONT FENDER AND DOOR (OHIO TRAFFIC CRASH REPORT). *NM
TURN SIGNAL SWITCH IN CHEVROLET LUMINA CAUSING BRAKE LIGHTS TO NOT WORK. (EXCEPT 3RD BRAKE LIGHT) FROM MY RESEARCH, THIS IS A WELL KNOWN ISSUE. FOR WHATEVER REASON THE MAIN BRAKE LIGHTS GO THROUGH THAT SWITCH. THE DEFECTIVE SWITCH IS CAUSING THEM NOT TO WORK. THE 3RD BRAKE LIGHT IS NOT AFFECTED BECAUSE IT'S NOT WIRED THRO…
Read full complaint
TURN SIGNAL SWITCH IN CHEVROLET LUMINA CAUSING BRAKE LIGHTS TO NOT WORK. (EXCEPT 3RD BRAKE LIGHT) FROM MY RESEARCH, THIS IS A WELL KNOWN ISSUE. FOR WHATEVER REASON THE MAIN BRAKE LIGHTS GO THROUGH THAT SWITCH. THE DEFECTIVE SWITCH IS CAUSING THEM NOT TO WORK. THE 3RD BRAKE LIGHT IS NOT AFFECTED BECAUSE IT'S NOT WIRED THROUGH THAT SWITCH. I KNOW SWITCHES GO BAD, BUT THIS SWITCH HAS WENT BAD ON A LOT OF VEHICLES CAUSING NO MAIN BRAKE LIGHTS AND SHOULD BE RECALLED. *NM
Official recalls
296V122000 · Service Brakes, Hydraulic:power Assist:vacuum
Jul 1, 1996
THESE VEHICLES WERE ASSEMBLED WITH ONE OF THE FOUR BRAKE BOOSTER TABS NOT PROPERLY LOCATED IN THE FRONT OF DASH REINFORCEMENT ASSEMBLY.
Consequence & remedy
Consequence: IF THIS CONDITION WERE PRESENT IN A SITUATION WHERE STOPPING DISTANCES WERE SMALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL INSPECT FOR PROPER BOOSTER INSTALLATION. BOOSTERS FOUND TO BE IMPROPERLY LOCATED WILL BE REMOVED AND REINSTALLED PROPERLY.
96V069000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Apr 19, 1996
THE LEFT FRONT BRAKE LINE CAN CONTACT THE TRANSAXLE MOUNTING BRACKET OR ATTACHMENT BOLT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE BRAKE LINE TO WEAR THROUGH, RESULTING IN LOSS OF BRAKE FLUID AND EVENTUAL LOSS OF ONE-HALF OF THE VEHICLE'S BRAKE SYSTEM, INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE VEHICLE FOR PROPER BRAKE LINE CLEARANCE AND REPOSITION THOSE BRAKE LINES FOUND TO HAVE LESS THAN MINIMAL CLEARANCE. ADDITIONALLY, THOSE BRAKE LINES FOUND TO HAVE AN INDENTATION CAUSED BY THE CONTACT WILL BE REPLACED AND PROPERLY ROUTED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA03019 · Power Rack And Pinion Steering Failure
Opened Sep 15, 2003 · Closed Dec 18, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Additional source detail variants (2)
Steering
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
Steering:rack And Pinion
GM'S LETTER TO NHTSA DATED DECEMBER 11, 2003, EXPANDS ITS ORIGINAL RECALL (NHTSA 02V286) TO INCLUDE CERTAIN W-BODY VEHICLES: 96-97 OLDS CUTLASS SUPREME; 98 OLDS INTRIGUE; 97-98 OLDS CUTLASS; 97-98 CHEVY LUMINA, MONTE CARLO AND MALIBU; 96 PONTIAC GRAND PRIX; AND 96-98 BUICK REGAL.THE NUMBER OF VEHICLES RECALLED IS 750,283.GM DETERMINED THAT FAILURE OF THE RACK AND PINION IS RELATED TO DAMAGE OF THE LOWER PINION BEARING AND THE LEVEL OF THE PINION BEARING PRE-LOAD SPRING FORCE.GM STATES, HIGHER RACK PRE-LOAD SPRING FORCE (133 LB.) IS THE DESIGN CHARACTERISTIC MOST CLOSELY ASSOCIATED WITH HIGHER BEARING DAMAGE RATES IN MOST OF THE VEHICLE APPLICATIONS THAT USED THE GENERAL BEARING COMPANY (GBC) BEARING.ALL OF THE VEHICLES COVERED IN THE EXPANDED RECALL HAVE THE 133 LB SPRING FORCE.THE 96 LUMINA/MONTE CARLO AND 97-98 CENTURY W-BODY VEHICLES INCLUDED IN THIS INVESTIGATION UTILIZE A LOWER SPRING FORCE AND ARE NOT INCLUDED IN THE RECALL.
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
EA96023 · Inappropriate Air Bag Deployment
Opened Sep 27, 1996 · Closed Feb 13, 1998
Status: closed (inferred from source dates) · Air Bags
THE FAILURE RATE (1.25/100K) ON THIS ISSUE IS LOW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITURE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO CLOSELY MONITOR THIS ISSUE.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED IN THE PUBLIC FILE.
PE96031 · Inappropriate Air Bag Deployment
Opened Apr 18, 1996 · Closed Sep 27, 1996
Status: closed (inferred from source dates) · Air Bags
There is no summary currently available