Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 22 of 352 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes, Hydraulic. Review the 178 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Structure. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 36 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
21 crash reports9 fire reports9 injury reports
What owners actually said
352 reports
Mileage unknown · Jun 1, 2005
Structure
DT: THE CONTACT OWNS A 1991 CHEVROLET LUMINA. HE STATES THAT THERE WAS RECALL 00V189000 CONCERNING ENGINE CRADLE BOLTS. THE SAME PROBLEM CONTACT ENCOUNTERED. THE RECALL STATED, THAT ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS. THE PROBLEM THE CONTACT HAD WAS THAT H…
Read full complaint
DT: THE CONTACT OWNS A 1991 CHEVROLET LUMINA. HE STATES THAT THERE WAS RECALL 00V189000 CONCERNING ENGINE CRADLE BOLTS. THE SAME PROBLEM CONTACT ENCOUNTERED. THE RECALL STATED, THAT ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS. THE PROBLEM THE CONTACT HAD WAS THAT HIS RETAINERS ACTUALLY FELL OUT OF THE BOTTOM OF THE VEHICLE. THIS ALMOST CAUSED A HEAD ON COLLISION BECAUSE HIS WIFE LOST CONTROL OF STEERING. THE CONTACT CALLED CHEVROLET, BUT WAS INFORMED THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
NHTSA ODI #10123847
199,000 miles · Apr 18, 2005
Electrical SystemFuel System, GasolineFire
VEHICLE CAUGHT ON FIRE 15 MINUTES AFTER BEING PARKED IN THE DRIVEWAY. THE LOCAL FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE. THE FIRE ALSO DAMAGED ANOTHER VEHICLE, THE RIGHT SIDE OF THE GARAGE, AND AN UPPER ROOM. THE CAUSE OF THE FIRE WAS DETERMINED TO HAVE BEEN CAUSED BY ONE OF TWO THINGS, EITHER FUEL LEAKAGE OR ELECTRICAL.…
Read full complaint
VEHICLE CAUGHT ON FIRE 15 MINUTES AFTER BEING PARKED IN THE DRIVEWAY. THE LOCAL FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE. THE FIRE ALSO DAMAGED ANOTHER VEHICLE, THE RIGHT SIDE OF THE GARAGE, AND AN UPPER ROOM. THE CAUSE OF THE FIRE WAS DETERMINED TO HAVE BEEN CAUSED BY ONE OF TWO THINGS, EITHER FUEL LEAKAGE OR ELECTRICAL. THE DEALER WAS NOT NOTIFIED.*AK VEHICLE HAS HAD FUEL INJECTION SYSTEM REPAIRED IN 2001 AND 2002. RIGHT SIGNAL REPAIRED IN JAN. 2004, HEADLIGHT DIMMER SWITCH REPAIRED IN APRIL FOR TEXAS INSPECTION. THEN VEHICLE CAUGHT ON FIRE IN MAY. *BF *NM
NHTSA ODI #10113642
Mileage unknown · Apr 6, 2005
Structure
CRADLE WHICH HOLD THE CRADLE. *JB LOOSE RETAINERS AND BOLTS AROUND THE ENGINE CRADLE. REAR CRADLE BOLTS/WASHERS/BUSHINGS WORN AND NEEDED TO BE REPLACED. DEALER CAUTIONED CUSTOMER NOT TO DRIVE THE CAR. *TT
NHTSA ODI #10089297
Mileage unknown · Feb 28, 2005
Structure
WHILE DRIVING THE CRADLE BOLT DISENGAGED, CAUSINGTHE ENGINE TO COM DROP OUT. RECALL NUMBER 97V058000/CRADLE WAS ISSUED. *AK
NHTSA ODI #10113131
147,000 miles · Oct 27, 2004
Structure
RECALL 00V18 000 CONCERNING CRADLE BOLTS. WHILE DRIVING CONSUMER HEARD A LOUD NOISE, AND THEN THE VEHICLE JERKED TO THE RIGHT WHILE DRIVING 60-70 MPH. VEHICLE WAS INSPECTED BY THE CONSUMER'S SON, WHO NOTICED THAT THE FRONT CRADLE BOLT BROKE. THE LOCALE DEALER AND THE MANUFACTURER WERE BOTH CONTACTED, AND BOTH CONFIRMED THAT T…
Read full complaint
RECALL 00V18 000 CONCERNING CRADLE BOLTS. WHILE DRIVING CONSUMER HEARD A LOUD NOISE, AND THEN THE VEHICLE JERKED TO THE RIGHT WHILE DRIVING 60-70 MPH. VEHICLE WAS INSPECTED BY THE CONSUMER'S SON, WHO NOTICED THAT THE FRONT CRADLE BOLT BROKE. THE LOCALE DEALER AND THE MANUFACTURER WERE BOTH CONTACTED, AND BOTH CONFIRMED THAT THIS VEHICLE WAS NOT COVERED UNDER THAT RECALL. *AK
NHTSA ODI #10097889
Mileage unknown · Sep 13, 2004
Visibility
INTERMITTENTLY WINDSHIELD WIPERS BECOME INOPERABLE, OBSTRUCTING DRIVER'S VIEW WHILE . DEALERSHIP HAS BEEN NOTIFIED. *AK
NHTSA ODI #10091871
256,000 miles · Aug 17, 2004
Steering
1. STEERING BECAME DIFFICULT. 2. LOUD THUD FROM FRONT OF VEHICLE AND TOTAL STEERING LOSS. 3. NOTHING. CAR WAS TOWED TO MY HOME. *JB
NHTSA ODI #10087029
89,000 miles · Jun 8, 2004
Structure
WHILE DRIVING BETWEEN 25 - 30 MPH ENTIRE FRAME AND THE MOTOR COLLAPSED ONTO THE ROAD. THIS OCCURRED BECAUSE THE FRAME BUSHING RUSTED. DEALERSHIP INDICATED THAT THIS WAS A COMMON PROBLEM WITH THESE MODEL VEHICLES.*AK
NHTSA ODI #10075829
110,000 miles · May 21, 2004
Service Brakes, Hydraulic
WHILE DRIVING 25 MPH FRONT DRIVER SIDE BRAKE CALIPER FAILED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10074043
Mileage unknown · Jan 23, 2004
Air BagsService Brakes, HydraulicCrashInjury
WHEN THE CONSUMER APPLIED THE BRAKES, THE PEDAL WENT TO THE FLOOR. THIS CAUSED THE DRIVER TO LOOSE CONTROL OF THE VEHICLE AND HIT A CONCRETE BARRIER. BOTH AIR BAGS DID NOT DEPLOY. THE DRIVER AND PASSENGER SUSTAINED NECK AND HEAD INJURIES AND WAS TRANSPORTED BY AMBULANCE TO THE HOSPITAL. THE VEHICLE WAS TOTALED. *JB
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, WHERE ROAD SALT USE IS HEAVY. A CONDITION WHERE ONE OR BOTH FRONT ENGINE CRADLE BOLTS CAN PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINERS.
Consequence & remedy
Consequence: IF BOTH BOLTS PULL THROUGH, THE FRONT OF THE CRADLE WOULD NO LONGER BE SUPPORTED AT THE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT COULD SEPARATE FROM THE STEERING GEAR.
Remedy: DEALERS WILL REPLACE THE FRONT AND REAR FRAME/CRADLE BOLTS AND RETAINERS.
VEHICLE DESCRIPTION: PASSENGER VEHICLES AND MINI VANS ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: CONNECTICUT, ILLINOIS, INDIANA, MAINE, MASSACHUSETTS, MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT AND WISCONSIN. THE REAR CRADLE BOLTS PULL THROUGH THE RETAINERS DUE TO CORROSION OF THE RETAINER. IF BOTH BOLTS PULL THROUGH, THE REAR CRADLE WOULD NOT LONGER BE SUPPORTED AT THESE MOUNTING LOCATIONS AND THE STEERING INTERMEDIATE SHAFT CAN SEPARATE FROM THE STEERING GEAR.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR WHILE THE VEHICLE WAS IN MOTION, A VEHICLE CRASH COULD RESULT.
Remedy: DEALERS WILL REPLACE THE REAR CRADLE BOLTS AND RETAINERS.
THE FRONT DOOR SHOULDER BELT GUIDE LOOPS MAY BE CRACKED AND ARE NOT IN COMPLIANCE WITH FMVSS 208.
Consequence & remedy
Consequence: THE SEAT OCCUPANT FACES INCREASED RISK OF INJURY IN THEEVENT OF A SUDDEN STOP OR ACCIDENT.
Remedy: INSTALL REINFORCING PLATES ON THE CRACKED SHOULDER BELT GUIDES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9
RP01001 · Structure
Opened Nov 28, 2001 · Closed Jun 13, 2002
Status: closed (inferred from source dates) · Structure
There is no summary currently available
EA00011 · Engine Cradle Separation
Opened Apr 10, 2000 · Closed Jan 12, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
THE ENGINE CRADLE FRONT BOLTS AND/OR RETAINERS MAY FAIL, ALLOWING THE FRONT OF THE ENGINE CRADLE TO FALL, POSSIBLY SEPARATING THE STEERING INTERMEDIATE SHAFT FROM THE STEERING GEAR, WITH COMPLETE LOSS OF STEERING CONTROL
RQ97017 · Cradle Bolt Failures
Opened Oct 2, 1997 · No close date supplied
Status: open (inferred from source dates) · Structure
There is no summary currently available
PE94063 · Corroded Rear Disk Brakes
Opened Aug 12, 1994 · Closed Dec 21, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE93085 · Wheel Failures
Opened Sep 29, 1993 · Closed Feb 28, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA92024 · Sticking Throttle
Opened Jun 26, 1992 · Closed Jan 31, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92052 · Apv Fuel Line Fires
Opened Jun 4, 1992 · Closed Oct 30, 1992
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
EA91049 · Jack Failure
Opened Nov 26, 1991 · Closed Oct 28, 1992
Status: closed (inferred from source dates) · Equipment
===
PE91072 · Steering Wheel Separation
Opened May 1, 1991 · Closed Jul 8, 1991
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1991 Chevrolet Lumina Problems, Complaints & Recalls | Skip That Year
Illustration