NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
634 reports139,428 miles · Apr 17, 2023
Visibility
The contact owns a 2014 Chevrolet Impala. The contact stated that after she started the vehicle, she smelled a burning odor and then heard a popping sound. The contact then stated that she turned the vehicle off and waited then restarted the vehicle and proceeded to drive. The contact then stated that she noticed what appeared t…
Read full complaint
The contact owns a 2014 Chevrolet Impala. The contact stated that after she started the vehicle, she smelled a burning odor and then heard a popping sound. The contact then stated that she turned the vehicle off and waited then restarted the vehicle and proceeded to drive. The contact then stated that she noticed what appeared to be snow on the rear windshield; however, the windshield then caved in. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 139,428.
NHTSA ODI #11517492
Mileage unknown · Apr 9, 2023
Seats
The Automatic Occupant Sensing (AOS) system fails to suppress the front passenger air bag with no passenger in the seat. The airbag on light stays on. There is no code triggered in the system. This also causes the unbuckled passenger seatbelt warning to chime with no passenger in the seat.
NHTSA ODI #11516150
Mileage unknown · Apr 5, 2023
Electrical SystemLane DepartureUnknown Or Other
My car has had a the side detection modules fail every 1 to 2 years since I've owned the car new in 2014. The dealership has repaired it for free every time now for at least 5 times. Now that the car is not under warranty they refuse to fix it for free. This is a problem with the design and engineering of the car and it is ve…
Read full complaint
My car has had a the side detection modules fail every 1 to 2 years since I've owned the car new in 2014. The dealership has repaired it for free every time now for at least 5 times. Now that the car is not under warranty they refuse to fix it for free. This is a problem with the design and engineering of the car and it is very costly to fix. The problem will continue to occur since the manufacturer refuses to find a permanent solution to the issue. It is related to the placement of the unit and it is affected by the environment and corrodes.
NHTSA ODI #11515681
Mileage unknown · Apr 5, 2023
Electrical System
Electrical wiring problems. Parking light wouldn't go off and clicking noise under dash in front seat
NHTSA ODI #11515555
Mileage unknown · Apr 5, 2023
Electrical SystemService BrakesStructure
The right turn signal bulb keeps blowing. Break lights were stuck on. I got pulled over because the blinker wasn't working and parking light wouldn't go off. The officer was nice because I had just got the car and didn't give me a ticket, just a warning. Blinker on passenger side won't work with lights on and fuses for that sid…
Read full complaint
The right turn signal bulb keeps blowing. Break lights were stuck on. I got pulled over because the blinker wasn't working and parking light wouldn't go off. The officer was nice because I had just got the car and didn't give me a ticket, just a warning. Blinker on passenger side won't work with lights on and fuses for that side keeps blowing
NHTSA ODI #11515549
Mileage unknown · Mar 29, 2023
Air BagsCrashInjury
Air bags did not deploy in an automotive collision.
NHTSA ODI #11514351
Mileage unknown · Mar 5, 2023
Lane DepartureUnknown Or Other
Side detection system failures. Repaired side detection systems 2 times ( 2017/2018 and again in 2020) both times GM reimbursed for repairs under technical bulletin. Repairs were supposed to be using “redesigned” parts to prevent issue from reoccurring. Side detection system requires service again in February 2023. That is 3 …
Read full complaint
Side detection system failures. Repaired side detection systems 2 times ( 2017/2018 and again in 2020) both times GM reimbursed for repairs under technical bulletin. Repairs were supposed to be using “redesigned” parts to prevent issue from reoccurring. Side detection system requires service again in February 2023. That is 3 times this failure has occurred in 8 years of owning this car. I have been told not too drive this vehicle with this issue as more serious issues can happen - dashboard failure, engine issues, etc. which can cause serious issues while driving. Even though GM extended the warranty for this, it doesn’t seem fair that I have to continue to pay repairs for a defective system ….. especially when I cannot drive for safety reasons. If this were just cosmetic, not that bad an issue. But this is a safety concern.
NHTSA ODI #11510252
40,000 miles · Feb 27, 2023
Electrical SystemLatches/locks/linkages
The contact owns a 2014 Chevrolet Impala. The contact stated that while operating the vehicle, the side mirror blind spot detection system malfunctioned, and the warning light blinked constantly and blinked while no oncoming vehicle was present. The contact stated that the failure occurred on both the driver’s side and passenger…
Read full complaint
The contact owns a 2014 Chevrolet Impala. The contact stated that while operating the vehicle, the side mirror blind spot detection system malfunctioned, and the warning light blinked constantly and blinked while no oncoming vehicle was present. The contact stated that the failure occurred on both the driver’s side and passenger’s side mirrors. The contact stated that while the failure occurred the electronic cluster also malfunctioned, and the doors and trunk lid would not always open, and the vehicle would not always start immediately. The vehicle was taken to the local dealer who replaced an unknown module kit. The contact stated that the vehicle had been repaired for the same failure on three previous occasions. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 40,000.
NHTSA ODI #11509323
Mileage unknown · Feb 16, 2023
Engine
Had a new catalyst converter installed new up steam down steam 02 sensor and it say Catalytic converter system is below threshold bank one had numerous parts put on and the engine light won’t stay off I don’t have a lot of money to keep fixing it the light goe out for a couple days come back on
NHTSA ODI #11507665
Mileage unknown · Jan 28, 2023
Air BagsElectrical SystemExterior Lighting
Multiple electric concerns...airbag light, park assist, inop camera, and losing communication with BCM(?) Found multiple communication codes for a variety of different modules. Found main source to be from the "side detection modules". Found fuse 62 blown underhood. Inspected side detection modules and found "a lot of corrosion"…
Read full complaint
Multiple electric concerns...airbag light, park assist, inop camera, and losing communication with BCM(?) Found multiple communication codes for a variety of different modules. Found main source to be from the "side detection modules". Found fuse 62 blown underhood. Inspected side detection modules and found "a lot of corrosion" on both modules and connectors. Needs side detection kit. I purchased the used impala on 12/19/2020 with 63,897 miles. The first time this issue was a concern was on 07/02/2022 at Merit chevrolet (MN). Mileage was at 83144 at that time. Diagnosis ... recommend both rear side detection modules and harness? According to Special coverage adjustment #N172097060 it is known to be subject to "water intrusion"? This problem affects the whole electrical system which includes airbag function. Why does this safety concern have a limited coverage time? According to the "Special Coverage" document, there was an 80000 mile timeline? This appears to be an ongoing issue with this year, make, and model and my feeling is that a "special coverage" is denying the safety problem and putting it on the consumer?
NHTSA ODI #11504191
Official recalls
12Jul 24, 2015
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Impala vehicles manufactured April 15, 2013, to June 19, 2015, equipped with front vented-heated passenger seats. Accordingly, the Automatic Occupant Sensing (AOS) system may fail to suppress the front passenger air bag if a child seat is in the front passenger seat. These vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: If the front passenger air bag deploys with a child seat in the front passenger seat, it increases the risk of injury to the child.
Remedy: GM will notify owners, and dealers will correct the calibration-learning error by preconditioning the empty seat, and also resetting the ECU to a seat zero-value, free of charge. The recall began on August 25, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15400.
Apr 6, 2015
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured March 22, 2013, to May 22, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Systems (FMVSS) No. 135 "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.
Remedy: GM has notified owners, and dealers will reprogram the electronic parking brake control module with new software, free of charge. The recall began on May 6, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 15259. Note: The vehicles covered by this campaign were previously remedied incorrectly under campaigns 14V541 or 15V085.
Feb 11, 2015
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured November 15, 2012, to May 30, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Systems (FMVSS) No. 135 "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.
Remedy: GM will notify owners, and dealers will reprogram the electronic parking brake control module with new software, free of charge. The recall began March 5, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 (Chevrolet). GM's number for this recall is 15100. Note: This recall covers a limited population of vehicles that were remedied incorrectly under recall 14V-541.
Oct 1, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac CTS, Escalade, Escalade ESV, Chevrolet Suburban, Tahoe, GMC Yukon, and Yukon XL, and 2014 Buick Enclave, Chevrolet Express, Impala, Silverado HD, Traverse, GMC Acadia, Savana, and Sierra HD vehicles. In the affected vehicles, the chassis electronic module may be internally contaminated, resulting in an electrical short.
Consequence & remedy
Consequence: If the module experiences an electrical short, the vehicle could stall, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will replace the chassis electronic module, free of charge. The recall began on December 26, 2014. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-006 (Cadillac), 1-800-222-1020 (Chevrolet), and 1-800-462-8782 (GMC). GMs number for this recall is 14515.
Sep 9, 2014
General Motors LLC (GM) is recalling certain model year 2013-2015 Cadillac XTS vehicles manufactured February 14, 2012, to August 22, 2014, and 2014-2015 Chevrolet Impala vehicles manufactured November 5, 2012, to September 2, 2014. In the affected vehicles, the electronic parking brake piston actuation arm may not fully retract causing the brake pads to stay partially engaged.
Consequence & remedy
Consequence: Brake pads that remain partially engaged with the rotors may cause excessive brake heat that may result in a fire.
Remedy: GM will notify owners, and dealers will update the electronic parking brake software, free of charge. The recall began on October 28, 2014. Owners may contact Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is 14471.
Aug 28, 2014
General Motors LLC (GM) is recalling certain model year 2013-2014 Cadillac XTS vehicles manufactured April 11, 2013, to June 27, 2013, and 2014 Chevrolet Impala vehicles manufactured May 13, 2013, to November 5, 2013. The affected vehicles may have left the factory with the sensing and diagnostic module (SDM) set to "manufacturing mode."
Consequence & remedy
Consequence: In manufacturing mode, the vehicle's air bags will not deploy in the event of a crash, increasing the risk of occupant injury.
Remedy: GM will notify owners, and dealers are to reprogram the SDM to the correct mode, free of charge. The recall is expected to begin in September 2014. Owners may contact Cadillac customer service at 1-800-458-8006 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14532.
Aug 8, 2014
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Impala vehicles manufactured May 7, 2014, to July 28, 2014. In the event of an accident, the center storage console may not stay latched. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 201, "Occupant Protection In Interior Impact."
Consequence & remedy
Consequence: The storage compartment door may not remain closed in the event of a crash, increasing the risk of occupant injury.
Remedy: Parts to remedy this condition are not currently available. GM will send owners an interim notification in early October 2014, and will send a second letter when parts are available. At that time dealers will inspect, and if necessary, replace the console storage compartment door inertia latch, free of charge. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14476.
Jul 23, 2014
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Impala vehicles manufactured November 5, 2012, to December 20, 2013. Due to a poor electrical ground connection to the Power Steering Control Module (PSCM), the affected vehicles may have a loss of power steering assist during start up or while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will clean paint from behind the ground stud nut and update the PSCM software, free of charge. Owners may contact Chevrolet customer service at 1-800-222-1020. The recall began on August 21, 2014. GM's number for this recall is 14330.
Jul 2, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, Cadillac XTS, Chevrolet Camaro and Chevrolet Impala vehicles. Improperly torqued fasteners may cause the steering intermediate shaft and the steering gear and/or the lower control arm and the lower ball joint to separate.
Consequence & remedy
Consequence: If any of the components separate, the vehicle may have a loss of steering, increasing the risk of a crash.
Remedy: GM began to notify owners on June 27, 2014, and dealers will inspect the fasteners for correct torque, correcting them as necessary, free of charge. Owners may contact GM customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac) or 1-800-222-1020 (Chevrolet). GM's number for this recall is 14378.
Jun 23, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) is recalling certain model year 2005-2009 Buick LaCrosse, 2006-2011 Buick Lucerne, 2000-2005 Cadillac DeVille, 2006-2011 Cadillac DTS, 2006-2014 Chevrolet Impala, and 2006-2007 Chevrolet Monte Carlo vehicles. In the affected vehicles, the weight on the key ring and road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury. Additionally, a key knocked out of the run position will cause loss of engine power, power steering, and power braking, increasing the risk of a vehicle crash.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 23, 2014. Owners may contact General Motors customer service at 1-800-521-7300 (Buick), 1-800-458-8006 (Cadillac), and 1-800-222-1020 (Chevrolet). GM's number for this recall is 14299.
Feb 21, 2014
General Motors LLC (GM) is recalling certain model year 2014 Buick Regal, LaCrosse, Verano, and Enclave, and Chevrolet Impala, Malibu, Cruze, and Traverse, and GMC Acadia vehicles equipped with automatic transmissions. In the affected vehicles, the transmission shift cable adjuster may disengage from the transmission shift lever. As such, these vehicles do not conform to Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence, Starter Interlock, and Transmission Braking Effect." They also fail to conform to FMVSS number 114, "Theft Protection and Rollaway Prevention."
Consequence & remedy
Consequence: If a vehicle's shift cable disengages from the transmission shift lever, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the driver may be able to shift the lever to the "PARK" position, but the vehicle transmission may not be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Remedy: General Motors will notify owners, and dealers will inspect and replace any affected transmission shift cable adjusters, free of charge. The recall began on April 10, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Buick owners at 1-800-521-7300, and GMC owners at 1-800-462-8782. General Motors' number associated with this recall is 14048.
May 24, 2013
General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."
Consequence & remedy
Consequence: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.
Additional source detail variants (2)
Exterior Lighting:brake Lights
General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."
Consequence: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.
Electrical System
General Motors LLC (GM) is recalling certain model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; model year 2014 Chevrolet Impala; and 2013 Chevrolet Sonic vehicles. Originally, in May 2013, GM recalled 1,627 model year 2013 Cadillac ATS and model year 2013 Cadillac XTS; and model year 2014 Chevrolet Impala vehicles. In October 2013, GM informed the agency that it was adding model year 2013 Chevrolet Sonic vehicles to this campaign , representing an additional 8,050 units. The total number of vehicles being recalled is now 9,677. On the affected vehicles, the brake lamps may intermittently flash without the brakes being applied and the cruise control may disengage. Thus, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, reflective devices, and associated equipment."
Consequence: If the brake lamps flash when the vehicle is not slowing, a following driver may not adjust vehicle speed when the vehicle is in fact braking, and the brake lamps are illuminating as intended, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will reprogram the body control module. The recall began on June 13, 2013. Owner's may contact Chevrolet at 1-800-630-2438 or Cadillac at 1-866-982-2339. GM's recall number is 13158.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2AQ17002 · Bical Chevrolet/loss Of Power Steering
Opened Mar 16, 2017 · Closed May 14, 2020
Status: closed (inferred from source dates) · Steering:electric Power Assist System
NHTSA opened AQ17-002 to determine whether BiCal Chevrolet of Valley Stream, New York (BiCal) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ?30120(i)).NHTSA issued an information request (IR) letter to BiCal on March 15, 2017. BiCal responded to this request on November 8, 2017. On March 16, 2017, an IR letter was issued to General Motors LLC (GM) and a response was received from GM on April 28, 2017. In NHTSA?s view, it had difficulties in obtaining responses to IR letters from BiCal throughout the AQ investigation, including not receiving a response to the first IR until more than three months after the original deadline. Additionally, in NHTSA's view, BiCal failed to provide a full response to the second IR. BiCal does not contest NHTSA's conclusion that it violated the Safety Act by initially failing to provide full and complete responses to the IRs from NHTSA by their deadlines. NHTSA's investigation also indicated that BiCal sold and delivered at least 54 recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.BiCal did not contest NHTSA?s conclusion that it violated the Safety Act by selling and delivering certain new motor vehicles that were subject to a recall before the vehicles were remedied.Under a Settlement Agreement dated March 11, 2019, BiCal agreed to pay compromised civil penalties in the amount of $40,000. This Audit Query is closed.
PE14010 · Active Safety System Malfunction
Opened Apr 15, 2014 · Closed Nov 21, 2014
Status: closed (inferred from source dates) · Forward Collision Avoidance; Forward Collision Avoidance: Adaptive Cruise Control; Forward Collision Avoidance: Crash Imminent Braking; Parking Brake; Parking Brake:indicator Light
On April 15, 2014, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE14-010 based on two complaints alleging incidents of sudden/severe uncommanded braking resulting in rear impact collisions in model year (MY) 2014 Chevrolet Impala vehicles.ODI analyzed all complaints related to allegations of unwanted brake activations while driving that were provided by GM or submitted to ODI from consumers and has not identified any additional incidents involving sudden, extended (greater than 1 second) autonomous braking.The two crash complaints that were the basis of PE14-010 involved rental vehicles equipped with an Electric Park Brake (EPB) system.Neither vehicle was equipped with Full Speed Range Adaptive Cruise Control (FSRACC) or Forward Collision Alert (FCA) systems. According to GM, brake lights will be illuminated if the service brakes are applied or the EPB system is activated while the vehicle is moving (dynamic EPB brake apply).In a dynamic EPB brake apply, the Electric Brake Control Module (EBCM) initiates a controlled deceleration while activating a chime and a telltale light.If the service brake is applied at any time during dynamic EPB brake apply, the system provides a substantially greater deceleration.Witness statements and analysis of crash data from the two incidents are consistent with inadvertent dynamic EPB brake applications.Both reports alleged beeping noise immediately before the accidents and one pre-crash data report shows a moderate initial vehicle deceleration followed by in increase in deceleration to approximately 0.6g just prior to the vehicle stopping and being struck from the rear.During this investigation, General Motors LLC (GM) inspected the two crash incident vehicles and examined each of the EPB switches to assess potential mechanical and electrical fault conditions.The testing and part examination did not find any evidence of mechanical or electrical failure of the EPB switches and GM did not identify any faults in the subject components or systems that could have caused or contributed to autonomous brake applications in the incident vehicles.According to GM, the evidence indicates the events were caused by inadvertent driver actuation of the EPB switch. Additionally, during this investigation, GM identified a defect condition in the EPB software in approximately 132,921 model year (MY) 2014 through 2015 Chevrolet Impala and MY 2013 through 2015 Cadillac XTS vehicles (Recall No. 14V-541) that could result in failure of the EPB to release after vehicle start-up.In this condition, the electronic parking brake piston actuation arm may not fully retract when the driver disengages the EPB, which may cause the brake pads to stay partially engaged with the rotor.According to GM, the parking brake indicator may not illuminate when the EPB is engaged and the driver may experience poor vehicle acceleration, undesired deceleration during idle coast-down, excessive brake heat, and premature wear to some brake components. If the vehicle is operated for an extended period of time in this condition, there is a potential for the rear brakes to generate significant heat, smoke, and sparks.GM and its supplier, Mando Pyeongtaek, upgraded the EPB software to address brake drag conditions and issued a recall bulletin on September 4, 2014 instructing dealers to reprogram the electronic parking brake control module on all affected vehicles. This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, see Attachment A to this c
Additional source detail variants (5)
Forward Collision Avoidance: Adaptive Cruise Control
On April 15, 2014, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE14-010 based on two complaints alleging incidents of sudden/severe uncommanded braking resulting in rear impact collisions in model year (MY) 2014 Chevrolet Impala vehicles.ODI analyzed all complaints related to allegations of unwanted brake activations while driving that were provided by GM or submitted to ODI from consumers and has not identified any additional incidents involving sudden, extended (greater than 1 second) autonomous braking.The two crash complaints that were the basis of PE14-010 involved rental vehicles equipped with an Electric Park Brake (EPB) system.Neither vehicle was equipped with Full Speed Range Adaptive Cruise Control (FSRACC) or Forward Collision Alert (FCA) systems. According to GM, brake lights will be illuminated if the service brakes are applied or the EPB system is activated while the vehicle is moving (dynamic EPB brake apply).In a dynamic EPB brake apply, the Electric Brake Control Module (EBCM) initiates a controlled deceleration while activating a chime and a telltale light.If the service brake is applied at any time during dynamic EPB brake apply, the system provides a substantially greater deceleration.Witness statements and analysis of crash data from the two incidents are consistent with inadvertent dynamic EPB brake applications.Both reports alleged beeping noise immediately before the accidents and one pre-crash data report shows a moderate initial vehicle deceleration followed by in increase in deceleration to approximately 0.6g just prior to the vehicle stopping and being struck from the rear.During this investigation, General Motors LLC (GM) inspected the two crash incident vehicles and examined each of the EPB switches to assess potential mechanical and electrical fault conditions.The testing and part examination did not find any evidence of mechanical or electrical failure of the EPB switches and GM did not identify any faults in the subject components or systems that could have caused or contributed to autonomous brake applications in the incident vehicles.According to GM, the evidence indicates the events were caused by inadvertent driver actuation of the EPB switch. Additionally, during this investigation, GM identified a defect condition in the EPB software in approximately 132,921 model year (MY) 2014 through 2015 Chevrolet Impala and MY 2013 through 2015 Cadillac XTS vehicles (Recall No. 14V-541) that could result in failure of the EPB to release after vehicle start-up.In this condition, the electronic parking brake piston actuation arm may not fully retract when the driver disengages the EPB, which may cause the brake pads to stay partially engaged with the rotor.According to GM, the parking brake indicator may not illuminate when the EPB is engaged and the driver may experience poor vehicle acceleration, undesired deceleration during idle coast-down, excessive brake heat, and premature wear to some brake components. If the vehicle is operated for an extended period of time in this condition, there is a potential for the rear brakes to generate significant heat, smoke, and sparks.GM and its supplier, Mando Pyeongtaek, upgraded the EPB software to address brake drag conditions and issued a recall bulletin on September 4, 2014 instructing dealers to reprogram the electronic parking brake control module on all affected vehicles. This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, see Attachment A to this c
Forward Collision Avoidance: Crash Imminent Braking
On April 15, 2014, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE14-010 based on two complaints alleging incidents of sudden/severe uncommanded braking resulting in rear impact collisions in model year (MY) 2014 Chevrolet Impala vehicles.ODI analyzed all complaints related to allegations of unwanted brake activations while driving that were provided by GM or submitted to ODI from consumers and has not identified any additional incidents involving sudden, extended (greater than 1 second) autonomous braking.The two crash complaints that were the basis of PE14-010 involved rental vehicles equipped with an Electric Park Brake (EPB) system.Neither vehicle was equipped with Full Speed Range Adaptive Cruise Control (FSRACC) or Forward Collision Alert (FCA) systems. According to GM, brake lights will be illuminated if the service brakes are applied or the EPB system is activated while the vehicle is moving (dynamic EPB brake apply).In a dynamic EPB brake apply, the Electric Brake Control Module (EBCM) initiates a controlled deceleration while activating a chime and a telltale light.If the service brake is applied at any time during dynamic EPB brake apply, the system provides a substantially greater deceleration.Witness statements and analysis of crash data from the two incidents are consistent with inadvertent dynamic EPB brake applications.Both reports alleged beeping noise immediately before the accidents and one pre-crash data report shows a moderate initial vehicle deceleration followed by in increase in deceleration to approximately 0.6g just prior to the vehicle stopping and being struck from the rear.During this investigation, General Motors LLC (GM) inspected the two crash incident vehicles and examined each of the EPB switches to assess potential mechanical and electrical fault conditions.The testing and part examination did not find any evidence of mechanical or electrical failure of the EPB switches and GM did not identify any faults in the subject components or systems that could have caused or contributed to autonomous brake applications in the incident vehicles.According to GM, the evidence indicates the events were caused by inadvertent driver actuation of the EPB switch. Additionally, during this investigation, GM identified a defect condition in the EPB software in approximately 132,921 model year (MY) 2014 through 2015 Chevrolet Impala and MY 2013 through 2015 Cadillac XTS vehicles (Recall No. 14V-541) that could result in failure of the EPB to release after vehicle start-up.In this condition, the electronic parking brake piston actuation arm may not fully retract when the driver disengages the EPB, which may cause the brake pads to stay partially engaged with the rotor.According to GM, the parking brake indicator may not illuminate when the EPB is engaged and the driver may experience poor vehicle acceleration, undesired deceleration during idle coast-down, excessive brake heat, and premature wear to some brake components. If the vehicle is operated for an extended period of time in this condition, there is a potential for the rear brakes to generate significant heat, smoke, and sparks.GM and its supplier, Mando Pyeongtaek, upgraded the EPB software to address brake drag conditions and issued a recall bulletin on September 4, 2014 instructing dealers to reprogram the electronic parking brake control module on all affected vehicles. This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, see Attachment A to this c
Forward Collision Avoidance
On April 15, 2014, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE14-010 based on two complaints alleging incidents of sudden/severe uncommanded braking resulting in rear impact collisions in model year (MY) 2014 Chevrolet Impala vehicles.ODI analyzed all complaints related to allegations of unwanted brake activations while driving that were provided by GM or submitted to ODI from consumers and has not identified any additional incidents involving sudden, extended (greater than 1 second) autonomous braking.The two crash complaints that were the basis of PE14-010 involved rental vehicles equipped with an Electric Park Brake (EPB) system.Neither vehicle was equipped with Full Speed Range Adaptive Cruise Control (FSRACC) or Forward Collision Alert (FCA) systems. According to GM, brake lights will be illuminated if the service brakes are applied or the EPB system is activated while the vehicle is moving (dynamic EPB brake apply).In a dynamic EPB brake apply, the Electric Brake Control Module (EBCM) initiates a controlled deceleration while activating a chime and a telltale light.If the service brake is applied at any time during dynamic EPB brake apply, the system provides a substantially greater deceleration.Witness statements and analysis of crash data from the two incidents are consistent with inadvertent dynamic EPB brake applications.Both reports alleged beeping noise immediately before the accidents and one pre-crash data report shows a moderate initial vehicle deceleration followed by in increase in deceleration to approximately 0.6g just prior to the vehicle stopping and being struck from the rear.During this investigation, General Motors LLC (GM) inspected the two crash incident vehicles and examined each of the EPB switches to assess potential mechanical and electrical fault conditions.The testing and part examination did not find any evidence of mechanical or electrical failure of the EPB switches and GM did not identify any faults in the subject components or systems that could have caused or contributed to autonomous brake applications in the incident vehicles.According to GM, the evidence indicates the events were caused by inadvertent driver actuation of the EPB switch. Additionally, during this investigation, GM identified a defect condition in the EPB software in approximately 132,921 model year (MY) 2014 through 2015 Chevrolet Impala and MY 2013 through 2015 Cadillac XTS vehicles (Recall No. 14V-541) that could result in failure of the EPB to release after vehicle start-up.In this condition, the electronic parking brake piston actuation arm may not fully retract when the driver disengages the EPB, which may cause the brake pads to stay partially engaged with the rotor.According to GM, the parking brake indicator may not illuminate when the EPB is engaged and the driver may experience poor vehicle acceleration, undesired deceleration during idle coast-down, excessive brake heat, and premature wear to some brake components. If the vehicle is operated for an extended period of time in this condition, there is a potential for the rear brakes to generate significant heat, smoke, and sparks.GM and its supplier, Mando Pyeongtaek, upgraded the EPB software to address brake drag conditions and issued a recall bulletin on September 4, 2014 instructing dealers to reprogram the electronic parking brake control module on all affected vehicles. This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, see Attachment A to this c
Parking Brake
On April 15, 2014, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE14-010 based on two complaints alleging incidents of sudden/severe uncommanded braking resulting in rear impact collisions in model year (MY) 2014 Chevrolet Impala vehicles.ODI analyzed all complaints related to allegations of unwanted brake activations while driving that were provided by GM or submitted to ODI from consumers and has not identified any additional incidents involving sudden, extended (greater than 1 second) autonomous braking.The two crash complaints that were the basis of PE14-010 involved rental vehicles equipped with an Electric Park Brake (EPB) system.Neither vehicle was equipped with Full Speed Range Adaptive Cruise Control (FSRACC) or Forward Collision Alert (FCA) systems. According to GM, brake lights will be illuminated if the service brakes are applied or the EPB system is activated while the vehicle is moving (dynamic EPB brake apply).In a dynamic EPB brake apply, the Electric Brake Control Module (EBCM) initiates a controlled deceleration while activating a chime and a telltale light.If the service brake is applied at any time during dynamic EPB brake apply, the system provides a substantially greater deceleration.Witness statements and analysis of crash data from the two incidents are consistent with inadvertent dynamic EPB brake applications.Both reports alleged beeping noise immediately before the accidents and one pre-crash data report shows a moderate initial vehicle deceleration followed by in increase in deceleration to approximately 0.6g just prior to the vehicle stopping and being struck from the rear.During this investigation, General Motors LLC (GM) inspected the two crash incident vehicles and examined each of the EPB switches to assess potential mechanical and electrical fault conditions.The testing and part examination did not find any evidence of mechanical or electrical failure of the EPB switches and GM did not identify any faults in the subject components or systems that could have caused or contributed to autonomous brake applications in the incident vehicles.According to GM, the evidence indicates the events were caused by inadvertent driver actuation of the EPB switch. Additionally, during this investigation, GM identified a defect condition in the EPB software in approximately 132,921 model year (MY) 2014 through 2015 Chevrolet Impala and MY 2013 through 2015 Cadillac XTS vehicles (Recall No. 14V-541) that could result in failure of the EPB to release after vehicle start-up.In this condition, the electronic parking brake piston actuation arm may not fully retract when the driver disengages the EPB, which may cause the brake pads to stay partially engaged with the rotor.According to GM, the parking brake indicator may not illuminate when the EPB is engaged and the driver may experience poor vehicle acceleration, undesired deceleration during idle coast-down, excessive brake heat, and premature wear to some brake components. If the vehicle is operated for an extended period of time in this condition, there is a potential for the rear brakes to generate significant heat, smoke, and sparks.GM and its supplier, Mando Pyeongtaek, upgraded the EPB software to address brake drag conditions and issued a recall bulletin on September 4, 2014 instructing dealers to reprogram the electronic parking brake control module on all affected vehicles. This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, see Attachment A to this c
Parking Brake:indicator Light
On April 15, 2014, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE14-010 based on two complaints alleging incidents of sudden/severe uncommanded braking resulting in rear impact collisions in model year (MY) 2014 Chevrolet Impala vehicles.ODI analyzed all complaints related to allegations of unwanted brake activations while driving that were provided by GM or submitted to ODI from consumers and has not identified any additional incidents involving sudden, extended (greater than 1 second) autonomous braking.The two crash complaints that were the basis of PE14-010 involved rental vehicles equipped with an Electric Park Brake (EPB) system.Neither vehicle was equipped with Full Speed Range Adaptive Cruise Control (FSRACC) or Forward Collision Alert (FCA) systems. According to GM, brake lights will be illuminated if the service brakes are applied or the EPB system is activated while the vehicle is moving (dynamic EPB brake apply).In a dynamic EPB brake apply, the Electric Brake Control Module (EBCM) initiates a controlled deceleration while activating a chime and a telltale light.If the service brake is applied at any time during dynamic EPB brake apply, the system provides a substantially greater deceleration.Witness statements and analysis of crash data from the two incidents are consistent with inadvertent dynamic EPB brake applications.Both reports alleged beeping noise immediately before the accidents and one pre-crash data report shows a moderate initial vehicle deceleration followed by in increase in deceleration to approximately 0.6g just prior to the vehicle stopping and being struck from the rear.During this investigation, General Motors LLC (GM) inspected the two crash incident vehicles and examined each of the EPB switches to assess potential mechanical and electrical fault conditions.The testing and part examination did not find any evidence of mechanical or electrical failure of the EPB switches and GM did not identify any faults in the subject components or systems that could have caused or contributed to autonomous brake applications in the incident vehicles.According to GM, the evidence indicates the events were caused by inadvertent driver actuation of the EPB switch. Additionally, during this investigation, GM identified a defect condition in the EPB software in approximately 132,921 model year (MY) 2014 through 2015 Chevrolet Impala and MY 2013 through 2015 Cadillac XTS vehicles (Recall No. 14V-541) that could result in failure of the EPB to release after vehicle start-up.In this condition, the electronic parking brake piston actuation arm may not fully retract when the driver disengages the EPB, which may cause the brake pads to stay partially engaged with the rotor.According to GM, the parking brake indicator may not illuminate when the EPB is engaged and the driver may experience poor vehicle acceleration, undesired deceleration during idle coast-down, excessive brake heat, and premature wear to some brake components. If the vehicle is operated for an extended period of time in this condition, there is a potential for the rear brakes to generate significant heat, smoke, and sparks.GM and its supplier, Mando Pyeongtaek, upgraded the EPB software to address brake drag conditions and issued a recall bulletin on September 4, 2014 instructing dealers to reprogram the electronic parking brake control module on all affected vehicles. This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, see Attachment A to this c
Illustration