Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
6625–50K
9150–75K
8175–100K
121100–150K
87150K+
513 reports with mileage · 181 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 264 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports32 fire reports23 injury reports
What owners actually said
694 reports
Mileage unknown · May 3, 2005
Service Brakes, Hydraulic
THIS IS NOT IN REPECT TO A ACCIDENT OR PART FAILURE. BUT I READ TODAY IN THE CHICAGO TRIBUNE ABOUT AN INVESTIGATION INTO GM TRUCKS IN THE SALT-BELT THAT HAD IMPROPER CORROSION ON THE BRAKE ROTORS, CAUSING THE BRAKES TO FAIL. I JUST BROUGHT MY 2003 CHEVY IMPALA FOR A TIRE ROTATION AT MY CALIFORNIA MECHANIC. THE MECHANIC NOTI…
Read full complaint
THIS IS NOT IN REPECT TO A ACCIDENT OR PART FAILURE. BUT I READ TODAY IN THE CHICAGO TRIBUNE ABOUT AN INVESTIGATION INTO GM TRUCKS IN THE SALT-BELT THAT HAD IMPROPER CORROSION ON THE BRAKE ROTORS, CAUSING THE BRAKES TO FAIL. I JUST BROUGHT MY 2003 CHEVY IMPALA FOR A TIRE ROTATION AT MY CALIFORNIA MECHANIC. THE MECHANIC NOTIFIED MY THAT THE REAR BRAKE ROTORS WERE SHOWING AN UNUSUAL CORROSION. HE SAID THAT ROAD SALT IN ILLINOIS, WHERE THE CAR IS USED 50% OF THE YEAR, MAY HAVE BEEN A REASON, BUT IT DIDN'T LOOK LIKE THE USUAL CORROSION HE IS USED TO SEEING ON SALT BELT CARS. THE BRAKES HAVE BEEN PULSING RATHER STRANGELY AND MY BRAKING DISTANCE SEEMS INCREASED SINCE THE LAST TIME I LEFT ILLINOIS. I WAS WONDERING IF THERE WERE OTHER NON-TRUCK COMPLAINTS OF THIS NATURE, GIVEN THE SIMILARITIES BETWEEN MY EXPERIANCE AND THE TRUCK INVESTIGATION?
NHTSA ODI #10119502
34 miles · Apr 12, 2005
Latches/locks/linkages
BOUGHT IMPALA 2003 THE TRUNK WOULD NOT OPEN PROPERLY, RETURNED TO HAVE FIXED, SAID IT WAS WORKING. IT WAS NOT WORKING PROPERLY. DURING WARMER MONTHS THE BACK DOORS WOULD NOT OPEN, HAD TO OPEN FROM FRONT DOOR REACHING AROUND TO BACK. THEY NOTED NOTHING WRONG WITH THEM.. MY WARRENTY RAN OUT, TWO MONTHS LATER PASSANGER SIDE BACK DO…
Read full complaint
BOUGHT IMPALA 2003 THE TRUNK WOULD NOT OPEN PROPERLY, RETURNED TO HAVE FIXED, SAID IT WAS WORKING. IT WAS NOT WORKING PROPERLY. DURING WARMER MONTHS THE BACK DOORS WOULD NOT OPEN, HAD TO OPEN FROM FRONT DOOR REACHING AROUND TO BACK. THEY NOTED NOTHING WRONG WITH THEM.. MY WARRENTY RAN OUT, TWO MONTHS LATER PASSANGER SIDE BACK DOOR HANDLE BROKE OFF IN MY HAND. 6 MONTHS AFTER THE OTHER DRIVERS SIDE BACK DOOR HANDLE BROKE OFF IN MY HAND. THIS SEEMS TO BE A BIG PROBLEM, VERY VERY CHEAPLY MADE. THE FRONT DOOR HANDLES AT TIMES STICK AND ARE ALSO HARD TO OPEN. THIS ISNT A ISOLATED INCIDENT, ALL THE HANDLES SEEM TO HAVE THE SAME PROBLEM I AM WAITING FOR THE DAY I CANNOT OPEN ANY OF THEM. CHEVROLET HAS IGNORED MY COMPLAINTS. THE GEARS INSIDE THE FRONT DOOR PANEL WAS NEVER OILED. OVERLOOKED, TOO QUICK TO MAKE AND MASS PRODUCE. I AM VERY VERY UNHAPPY!*AK
NHTSA ODI #10116776
Mileage unknown · Mar 30, 2005
Exterior Lighting
DURING NIGHT DRIVING, THE HEADLIGHTS ARE VERY DIM, EVEN WHEN USING THE HIGH BEAMS. THE CONSUMER CONTACTED THE DEALER. THE SERVICE DEALER TOLD THE CONSUMER WHAT DID SHE EXPECT SINCE SHE BOUGHT A CHEAP CAR. THE CONSUMER CONTACTED THE MANUFACTURER SEVERAL TIMES REGARDING THE PROBLEM WITH THE HEADLIGHTS. *AK THE CONSUMER COUL…
Read full complaint
DURING NIGHT DRIVING, THE HEADLIGHTS ARE VERY DIM, EVEN WHEN USING THE HIGH BEAMS. THE CONSUMER CONTACTED THE DEALER. THE SERVICE DEALER TOLD THE CONSUMER WHAT DID SHE EXPECT SINCE SHE BOUGHT A CHEAP CAR. THE CONSUMER CONTACTED THE MANUFACTURER SEVERAL TIMES REGARDING THE PROBLEM WITH THE HEADLIGHTS. *AK THE CONSUMER COULD ONLY SEE APPROXIMATELY 2-2 1/2 CAR LENGTHS IN FRONT, WITH DIM LIGHTS. *SC *JB
NHTSA ODI #10115096
Mileage unknown · Mar 29, 2005
Engine And Engine CoolingUnknown Or Other
MY 2003 CHEVROLET IMPALA MAKES A ROARING SOUND WHEN THE ROAD IS WET AFTER A RAIN. I TOOK IT BACK TO THE DEALER, THEY SAID IT WAS CAUSED BY WATER BEING SPLASHED UP ON THE CONVERTER,AND IT COULD NOT BE FIXED
NHTSA ODI #10115995
77,000 miles · Mar 25, 2005
Equipment
2003 CHEVROLET IMPALA HAS PROBLEMS WITH RADIO EQUIPMENT.*MR THE CD WOULD NOT EJECT. THE CONSUMER WAS TOLD THE RADIO WAS LINKED TO OTHER SAFETY FEATURES ON THE VEHICLE AND IF A REPAIR ATTEMPT WAS MADE BY ANYONE OTHER THAN GM IT MAY PERMANENTLY DISABLE THE FEATURES. *JB
NHTSA ODI #10117506
Mileage unknown · Mar 22, 2005
Engine And Engine Cooling
TOOK CAR TO HAVE A SIMPLE OIL CHANGE, I GET A PHONE CALL INFORMING THAT I NEED MAJOR WORK DONE. I PURCHASED MY CHEVROLET IMPALA IN 2003, AND NOW I'M BEING TOLD I HAVE ALMOST A THOUSAND DOLLARS OF WORK THAT NEEDS TO BE DONE. I RECENTLY FOUND OUT THAT A CLOSE RELATIVE AND A NEIGHBOR WHO ALSO HAVE 2003, CHEVROLET VEHICLES (CARS) NE…
Read full complaint
TOOK CAR TO HAVE A SIMPLE OIL CHANGE, I GET A PHONE CALL INFORMING THAT I NEED MAJOR WORK DONE. I PURCHASED MY CHEVROLET IMPALA IN 2003, AND NOW I'M BEING TOLD I HAVE ALMOST A THOUSAND DOLLARS OF WORK THAT NEEDS TO BE DONE. I RECENTLY FOUND OUT THAT A CLOSE RELATIVE AND A NEIGHBOR WHO ALSO HAVE 2003, CHEVROLET VEHICLES (CARS) NEEDED THE SAME WORK DONE TO THEIR CAR. THE CARS COOLANT IS SOMEHOW MIXING WITH THE OIL, BECOMING A SLUDE LIKE SUBSTANCE CAUSING THE OIL TO DIRTY. THIS IS CAUSING ALL KINDS OF PROBLEMS, THE CAR IS RUNNING HOT, AND THE TEMPERATURE GUAGE IS JUMPING FRANTICALLY. THREE DIFFERENT CARS, ALL THE SAME YEAR/MAKE, AND EGINE SETUP; I THINK THERE IS DEFINITELY A DEFECT IN HERE SOMEWHERE.*AK
NHTSA ODI #10114488
Mileage unknown · Mar 2, 2005
Exterior Lighting
AT TIMES WHILE DRIVING HEADLIGHTS INADVERTENTLY CUT OFF. THE CAUSE WAS UNDETERMINED.*AK
NHTSA ODI #10113291
16,000 miles · Feb 23, 2005
Service Brakes, Hydraulic
I OWN A 2003 IMPALA. AT 16000 MILES I HAD TO REPLACE ALL FOUR ROTORS AND BRAKE PADS.*AK
NHTSA ODI #10112061
3,700 miles · Feb 14, 2005
SteeringSuspension
WHILE TURNING AT ANY SPEED, CONSUMER HEARD A KNOCKING NOISE COMING FROM THE FRONT END. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK.....ALSO, REPLACED INTERMEDIATE STEERING SHAFT. *AK
NHTSA ODI #10111451
75,000 miles · Feb 14, 2005
Air BagsCrash
WHILE MAKING A LEFT TURN CONSUMER WAS STRUCK BY ANOTHER VEHICLE AT APPROXIMATELY 50 MPH., WHEREBY THE AIR BAGS DID NOT DEPLOY.*AK
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2003 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration