IllustrationMy car sometimes cuts off while driving. Was on highway 301 running about 60 mph in the middle lane and just lost power no warning. No code no nothing. Sacred me, I truly feel that's a safety issue, for me and the cars behind me. It's bad not knowing when or where this will happen again.
2003 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
6625–50K
9150–75K
8175–100K
121100–150K
87150K+
513 reports with mileage · 181 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 264 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports32 fire reports23 injury reports
What owners actually said
694 reportsAfter I go back and forth between my bright headlights and regular All of a sudden my headlights shut off it happens after so many times going between them
Ignition lock issue. I’m guessing security light came on hard to start vehicle when switch doesn’t work. Almost left me stranded. Apparently this is common. I have kids and if I get stranded with them what am I supposed to do? Something needs to be done
I have a 2003 Chevrolet Impala! Look it up on the internet, and you will see that the failure rate of the GM passlock system is huge, and massively expensive to repair! In fact from a inside relative, says GM makes more money in parts, and repairs than on selling a new vehicle! This is without doubt a premeditated flow to rip o…
Read full complaint
I have a 2003 Chevrolet Impala! Look it up on the internet, and you will see that the failure rate of the GM passlock system is huge, and massively expensive to repair! In fact from a inside relative, says GM makes more money in parts, and repairs than on selling a new vehicle! This is without doubt a premeditated flow to rip off the public! This is in fact insensitive for GM to engineer a constant, and ongoing failure of the of its vehicles! This passlock defect can not be fixed by accessing the cars computer! It should be that easy but it is not a option. Being stranded by this defect is life threatening. The problem is the Passlock system that has failed for me, and hundreds of thousands owners of GM vehicles, and tens of millions of dollars in repairs that GM should be forced to repair, at no costs, past, and present to the owners, and including towing, and a rental car! The passlock defect, and failure completely locks up the cars entire electrical system, so the owner can not start, or even open the trunk of their car in a emergency! After it happens you can’t even access the car radio to reset back to the original factory functions! Even if you disconnect the battery, to get this accomplished, it will be a short while before it happens again! It is crazy expensive just to diagnose this problem! Please note that this is not just a Impala problem! This passlock defect falling involves dozens of Models of all types, old, and new. These vehicles number in the many hundreds of thousands over decades! Many tens of millions of dollars in repairs, and hundreds of thousands waiting to happen! This needs to be addressed at a government level! We won’t to see some consumer protection, and Justice! Thank you for your time, and consideration! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
225/60/r16 Tire bead is warped/slanted (defective) with inability to install the tires
Accelator keeps getting stuck at traffic lights and while driving
Fuel line leaking gas under engine.
Hey my name is [XXX] I recently took my Chevy impala for repairs they told me I need more repairs done I’m like cool my bottom of my car is rusted n my struts are bad n my oil pump n other stuff is not working as well I’m when I gave Chevy a call ball they took my they manager not to bring the car back I’m kinda upset bout this …
Read full complaint
Hey my name is [XXX] I recently took my Chevy impala for repairs they told me I need more repairs done I’m like cool my bottom of my car is rusted n my struts are bad n my oil pump n other stuff is not working as well I’m when I gave Chevy a call ball they took my they manager not to bring the car back I’m kinda upset bout this whole thing idk cause they had to fix my head gasket for free but I need help getting these thing fixes. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Traveling at 58 mph in Cruise Control for 10 minutes I increased speed with 4-6 rapid pushes of the Accelerate button in less than 1.5 seconds, Each push is 1 mph. I have never pushed it that rapidly.The engine acted as if I floored the accelerator & the transmission went from 4th to 3rd gear, speed went to 70+ and rapidly incre…
Read full complaint
Traveling at 58 mph in Cruise Control for 10 minutes I increased speed with 4-6 rapid pushes of the Accelerate button in less than 1.5 seconds, Each push is 1 mph. I have never pushed it that rapidly.The engine acted as if I floored the accelerator & the transmission went from 4th to 3rd gear, speed went to 70+ and rapidly increasing. I stepped on the break pedal several times to disable CC but no help, I switched the CC button to the off position several times, no help. Now at 85+ and accelerating hard in wide open throttle (WOT). I shift to Neutral and turned the ignition to the ACC position to retain steering ability as the engine was RPM'ing out to destruction. I coasted off the highway and set ignition to off. After a few minutes I turned engine on and it rev'd out of control, still WOT. Ignition off did not reset the problem. I opened the hood to disconnected the battery & I observe that neither the CC or accelerator cables are not holding the throttle body (TB) in "WOT", it was closed in an idle position. It is not mechanical. I disconnected the battery for several minutes and then the system operated normally. I have used CC a million times but never have pushed that accel button that fast. I served 7 years as a Reactor Operation onboard US navy Fast attack Submarines, have torn apart and assemble mechanical and electrical reactor systems. I have been a Hardware Engineer for 40+ yrs and have 10 US patents in fault tolerant server design. I've been a car guy since 5 yrs old. This is a problem with the cars computer or its code. The rapid pushing of the CC accel button is key here as well as memory retaining this CC state after Key OFF. Its a good thing I experienced with many hard casualty life and death situations while serving, because my car was accelerating out of control, my experience and training in the US Military taught me to keep cool and think.You really should investigate this. I can tell you more specifics but I'm character limited.
ON 3/21/2021 I WAS DRIVING ON THE FREEWAY FOR ABOUT 25 MILES, WHEN MY 2003 CHEVY IMPALA STARTED MAKING A WHINING NOISE AND IT CONTINUED TO GET WORSE WITH EACH TURN. MY HUSBAND SOON REALIZED IT HAD TO BE THE POWER STEERING FLUID. SO HE PUT A BOTTLE OF POWER STEERING FLUID IN AND AFTER STARTING AND DRIVING FOR A FEW MINUTES THE CA…
Read full complaint
ON 3/21/2021 I WAS DRIVING ON THE FREEWAY FOR ABOUT 25 MILES, WHEN MY 2003 CHEVY IMPALA STARTED MAKING A WHINING NOISE AND IT CONTINUED TO GET WORSE WITH EACH TURN. MY HUSBAND SOON REALIZED IT HAD TO BE THE POWER STEERING FLUID. SO HE PUT A BOTTLE OF POWER STEERING FLUID IN AND AFTER STARTING AND DRIVING FOR A FEW MINUTES THE CAR WAS BACK TO NORMAL! SO I PROCEEDED TO GET BACK ON THE FREEWAY TO HEAD HOME. AS SOON AS WE GOT TO OUR EXIT ABOUT 23 MILES FROM WHERE WE HAD JUST PUT THE FLUID IN. IT STARTED MAKING THE SAME WHINING NOISE. SO BACK TO THE STORE FOR MORE POWER STEERING FLUID. HE FILLS IT UP. THE NEXT MORNING SAME PROBLEMS. WE KNOW NOW THERE IS A LEAK IN OUR POWER STEERING BUT NOT SURE WHERE EXACTLY. MY CAR NOW SITS AS WE CAN'T AFFORD TO BE ADDING BOTTLE AFTER BOTTLE OF POWER STEERING FLUID TO MY CAR EVERYTIME WE NEED TO GO SOMEWHERE. MY HUSBAND BELIEVES WE HAVE RUN INTO THE SAME ISSUES THAT HAVE RECENTLY BEEN REPORTED BY NHTSA ID# 11316116 BEING POWER STEERING RETURN HOSE RUBS AGAINST SOME PART OF THE MOTOR AND RUBBER HOLE IN POWER STEERING RETURN HOSE.
Official recalls
515V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
03V051000 · Air Bags:frontal:driver Side:inflator Module
Feb 14, 2003
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.