(3) PROBLEMS THAT ARE, AND HAVE BEEN, OCCURING. 1) SECURITY ISSUE: CAR WILL NOT START WHEN KEY IS TURN TO START. HAPPENS RANDOMLY. HAVE TO LET SECURITY RESET ITSELF AFTER 10 MINUTES AND CAR WILL START AGAIN. 2) ABS LIGHT ON: RANDOM. BRAKES WILL GRIND AT CERTAIN TIMES WHEN BRAKING. HARNESS AND/OR SENSOR PROBLEM. 3) TRACTION C…
Read full complaint
(3) PROBLEMS THAT ARE, AND HAVE BEEN, OCCURING. 1) SECURITY ISSUE: CAR WILL NOT START WHEN KEY IS TURN TO START. HAPPENS RANDOMLY. HAVE TO LET SECURITY RESET ITSELF AFTER 10 MINUTES AND CAR WILL START AGAIN. 2) ABS LIGHT ON: RANDOM. BRAKES WILL GRIND AT CERTAIN TIMES WHEN BRAKING. HARNESS AND/OR SENSOR PROBLEM. 3) TRACTION CONTROL LIGHT ON: TRACTION KCIKS IN WHEN DRIVING FOR NO APPARENT REASON. HAVE TO TURN TRACTOIN OFF FOR IT TO STOP. *TR
NHTSA ODI #10609950
100,000 miles · Dec 27, 2013
Electronic Stability Control (esc)Service BrakesSteering
THE SERVICE TRACTION CONTROL LIGHT IS ON THE DASH PANEL AND MY CAR STARTED TO SHAKE AND PULL TO ONE SIDE WHEN THE BRAKES WERE APPLIED. THE PROBLEM QUICKLY GREW INTO THE CAT CONSTANTLY PULLS TO ONE SIDE AND THE STEERING FEELS SLOPPY AND LOOSE IF THAT MAKES SENSE. THE TRACTION CONTROL DOESN'T WORK BUT WILL RANDOMLY KICK IN WHILE D…
Read full complaint
THE SERVICE TRACTION CONTROL LIGHT IS ON THE DASH PANEL AND MY CAR STARTED TO SHAKE AND PULL TO ONE SIDE WHEN THE BRAKES WERE APPLIED. THE PROBLEM QUICKLY GREW INTO THE CAT CONSTANTLY PULLS TO ONE SIDE AND THE STEERING FEELS SLOPPY AND LOOSE IF THAT MAKES SENSE. THE TRACTION CONTROL DOESN'T WORK BUT WILL RANDOMLY KICK IN WHILE DRIVING AND THE CAR INSTANTLY FEELS AS IF THE BRAKES ARE BEING APPLIED AND GRINDER BUT THE WORSE PART IS HOW THE PULLING TO ONE SIDE BECOMES A QUICK GRAB AND JERK TO ONE SIDE AND HAS NEARLY CAUSED ME SEVERAL ACCIDENTS AND I CANNOT RELAX AND DRIVE. I AM ALWAYS TENSE AND READY TO FIGHT TO KEEP MY CAR GOING STRAIGHT AND NOW WITH THE BAD MICHIGAN WINTER ITS IMPOSSIBLE TO DRIVE ON SOME DAYS. I'VE BEEN TOLD THAT I NEED A NEW TRACTION CONTROL PUMP WHICH IS GOING TO COST AROUND $2500 AND UP DEPENDING ON WHAT THEY FIND BUT WILL AUTOMATICALLY START AT $2500. THAT COST IS RIDICULOUS AND I HAVE TALKED TO PROB APPROX A HUNDRED PEOPLE WHO EITHER HAD THE SAME PROBLEM OR KNEW OF SOMEONE WHO DOES, OVER THE PAST FEW YEARS. MY CAR IS NOW PARKED AND I HAVE TO BEG FOR RIDES TO WORK BECAUSE ITS WINTER AND I CANNOT PUT MYSELF AND OTHERS IN DANGER WITH THIS ISSUE. I HAVE TO WORK AND TRANSPORT KIDS TO DIFFERENT EVENTS AND FEEL THAT THIS PART HAS TO BE DEFECTIVE FROM THE START IF THERE'S THAT MANY PEOPLE WITH THIS SAME ISSUE. AND ALL OF THE SAME EXACT COMPLAINTS FOUND ONLINE. PLEASE I'M BEGGING YOU TO CHECK INTO THIS ISSUE TO SEE IF A RECALL IS NECESSARY. THANK YOU SO MUCH. *TR
NHTSA ODI #10557383
102,500 miles · Oct 30, 2013
Service Brakes
DRIVING SAID VEHICLE THANKFULLY AT LOW SPEED WHEN ALL OF THE SUDDEN THE BRAKES WENT TO THE FLOOR . PULLED OVER AT SAW BRAKE FLUID . LOOKED UNDER VEHICLE SAW ROTTED OUT BRAKE LINES WITH A BIG HOLE IN ONE OF THEM AND THE OTHER IS JUST AS RUSTED . I CONSIDER THIS A GREAT SAFETY ISSUE . DUE TO IT HAPPENS SUDDENLY. NOTE: I SAW ON ABC…
Read full complaint
DRIVING SAID VEHICLE THANKFULLY AT LOW SPEED WHEN ALL OF THE SUDDEN THE BRAKES WENT TO THE FLOOR . PULLED OVER AT SAW BRAKE FLUID . LOOKED UNDER VEHICLE SAW ROTTED OUT BRAKE LINES WITH A BIG HOLE IN ONE OF THEM AND THE OTHER IS JUST AS RUSTED . I CONSIDER THIS A GREAT SAFETY ISSUE . DUE TO IT HAPPENS SUDDENLY. NOTE: I SAW ON ABC NEW AND ON THE INTERNET THERE IS AN ISSUE WITH GM TRUCKS AS WELL. IT NOW SEEMS ITS NOT JUST TRUCKS. I KEEP MY CAR IN GREAT SHAPE AND HAVE IT SERVICED AT THE DEALER AND NEVER WAS INFORMED OF A PROBLEM WITH MY BRAKE LINES. THANK-YOU FOR YOUR TIME. *TR
NHTSA ODI #10550091
58,000 miles · Aug 6, 2013
Service Brakes
AT ANY TIME WHETHER TURNING OR PROCEEDING FORWARD AT VARIOUS SPEEDS TRACTION ACTIVATES AND STAYS ON. I HAVE JUST LEARNED OF THIS RECALL WEBSITE. I HAVE OWNED THIS CAR SINCE 2006, 10,000MILES AND HAVE NEVER RECEIVED ANY RECALL INFORMATION. WHAT DO I HAVE TO DO TO GET ALL RECALL INFO SO I CAN TAKE TO DEALERSHIP AND GET FIXED WHATE…
Read full complaint
AT ANY TIME WHETHER TURNING OR PROCEEDING FORWARD AT VARIOUS SPEEDS TRACTION ACTIVATES AND STAYS ON. I HAVE JUST LEARNED OF THIS RECALL WEBSITE. I HAVE OWNED THIS CAR SINCE 2006, 10,000MILES AND HAVE NEVER RECEIVED ANY RECALL INFORMATION. WHAT DO I HAVE TO DO TO GET ALL RECALL INFO SO I CAN TAKE TO DEALERSHIP AND GET FIXED WHATEVER NEEDS TO BE FIXED? ALSO WHENEVER IT RAINS THE FLOOR ON DRIVERS SIDE FRONT SEAT FILLS WITH WATER. THIS HAS BEEN HAPPENING SINCE 2006. PLEASE EMAIL OR SEND LETTER FOR MY RECALLS. *TR
NHTSA ODI #10533941
112,324 miles · Jun 1, 2013
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
ANTI-LOCKING BRAKING SYSTEM, TRACTION CONTROL, AND VSA LIGHT COMES ON UNDER NORMAL DRIVING CONDITIONS. ANTI-LOCK SYSTEM ENGAGES AND PULSATES WHEN THE BRAKES ARE APPLIED AT VARIOUS SPEEDS AND ALSO THE VEHICLE DOESN'T' ACCELERATE IF DEPRESSING THE ACCELERATOR. THIS COULD OR WILL CAUSE A SERIOUS ACCIDENT IF THE SYSTEM IS NOT FIXE…
Read full complaint
ANTI-LOCKING BRAKING SYSTEM, TRACTION CONTROL, AND VSA LIGHT COMES ON UNDER NORMAL DRIVING CONDITIONS. ANTI-LOCK SYSTEM ENGAGES AND PULSATES WHEN THE BRAKES ARE APPLIED AT VARIOUS SPEEDS AND ALSO THE VEHICLE DOESN'T' ACCELERATE IF DEPRESSING THE ACCELERATOR. THIS COULD OR WILL CAUSE A SERIOUS ACCIDENT IF THE SYSTEM IS NOT FIXED IMMEDIATELY. SUSPECT THE WHEEL SPEED SENSOR WHICH IS BUILT INTO THE WHEEL HUB. I AM REQUESTING THIS ISSUE BE REPAIRED AND THE FACTORY EXPENSE SINCE THIS IS A SAFETY ISSUE AND A VERY WELL KNOW DOCUMENTED CASE. *TR
NHTSA ODI #10514667
19,840 miles · Jan 10, 2013
Service Brakes
BRAKE LINE FROM MASTER CYLINDER BLEW, BRAKE FLUID LEAKED AND BRAKES FAILED. BRAKE WARNING LIGHT DID NOT COME ON UNTIL BRAKES WERE INOPERABLE. LINE WAS FOUND TO BE RUSTED THROUGH. THIS IS A KNOWN PROBLEM AND IS A MAJOR SAFETY ISSUE. BRAKE WARNING LIGHT SHOULD COME ON IMMEDIATELY WHEN A BRAKE LINE RUPTURES TO GIVE THE DRIVER…
Read full complaint
BRAKE LINE FROM MASTER CYLINDER BLEW, BRAKE FLUID LEAKED AND BRAKES FAILED. BRAKE WARNING LIGHT DID NOT COME ON UNTIL BRAKES WERE INOPERABLE. LINE WAS FOUND TO BE RUSTED THROUGH. THIS IS A KNOWN PROBLEM AND IS A MAJOR SAFETY ISSUE. BRAKE WARNING LIGHT SHOULD COME ON IMMEDIATELY WHEN A BRAKE LINE RUPTURES TO GIVE THE DRIVER TIME TO STOP BEFORE BRAKES FAIL COMPLETELY. *TR
NHTSA ODI #10492188
100,000 miles · Aug 30, 2012
Electronic Stability Control (esc)Service BrakesCrashInjury
ABS TRACTION CONTROL LIGHTS ON INTERMITTENTLY FOR 3 YEARS. HAD THIS CHECKED BY DEALER NUMEROUS TIMES AND WAS NOT ABLE TO DIAGNOSE A PROBLEM. THE LIGHTS NOW STAY ON FOR THE LAST 8 MONTHS. *TR
NHTSA ODI #10473041
276,000 miles · Aug 6, 2012
Service Brakes
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE ABS AND THE SERVICE TRACTION SOON LIGHTS ILLUMINATED. THE VEHICLE INDEPENDENTLY TURNED THE TRACTION OFF. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 276,000.
NHTSA ODI #10469396
112,878 miles · Jul 18, 2012
Service BrakesSuspension
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. WHILE PARKED THE CONTACT NOTICED THE ABS, CHECK TRACTION SYSTEM AND TRAC OFF WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THERE WAS ALSO A GRINDING NOISE WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC. THE MECHANIC STATED THE FRONT PASSENGER SIDE…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. WHILE PARKED THE CONTACT NOTICED THE ABS, CHECK TRACTION SYSTEM AND TRAC OFF WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THERE WAS ALSO A GRINDING NOISE WHILE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC. THE MECHANIC STATED THE FRONT PASSENGER SIDE HUB BEARING ASSEMBLY WOULD HAVE TO BE REPLACED. AFTER THE REPAIR THE WARNING LIGHTS CONTINUED TO ILLUMINATE. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC. THE FRONT DRIVERS SIDE HUB ASSEMBLY WAS REPLACED. THE LIGHT CONTINUED TO ILLUMINATE AFTER THE REPAIR. THE VEHICLE WAS TAKEN TO THE MECHANIC A THIRD TIME. THE MECHANIC WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 112,878.
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2003 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration