NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
80 reportsClear category filterMileage unknown · Mar 14, 2018
Engine And Engine Cooling
2003 CHEVROLET IMPALA. CONSUMER REQUESTS REIMBURSEMENT FOR FLUID LEAKAGE ONTO EXHAUST MANIFOLD RECALL NOTICE. *SMD THE CONSUMER STATED THE VEHICLE REQUIRED THE MANIFOLD TO BE REPAIRED UNDER RECALL WHICH COULD NOT BE COMPLETED UNTIL ANOTHER FAILURE WAS REPAIRED. THE CONSUMER STATED THE REPAIR WAS A FAILURE CAUSED BY THE FA…
Read full complaint
2003 CHEVROLET IMPALA. CONSUMER REQUESTS REIMBURSEMENT FOR FLUID LEAKAGE ONTO EXHAUST MANIFOLD RECALL NOTICE. *SMD THE CONSUMER STATED THE VEHICLE REQUIRED THE MANIFOLD TO BE REPAIRED UNDER RECALL WHICH COULD NOT BE COMPLETED UNTIL ANOTHER FAILURE WAS REPAIRED. THE CONSUMER STATED THE REPAIR WAS A FAILURE CAUSED BY THE FAILURE OF THE MANIFOLD.*JS
NHTSA ODI #10862867
Mileage unknown · May 4, 2016
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE …
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. ....UPDATED 07/05/16 *BF UPDATED 07/21/16.*JB
NHTSA ODI #10863114
Mileage unknown · Apr 22, 2016
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION FOR THE ENGINE AND ENGINE COOLING. THE PARTS WERE NOT AVAILABLE WITHIN A REASONABLE TIME FRAME SO THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS UNABLE TO DETERMINE WHEN THE PARTS WOULD BE SUPPLIED TO THE…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION FOR THE ENGINE AND ENGINE COOLING. THE PARTS WERE NOT AVAILABLE WITHIN A REASONABLE TIME FRAME SO THE CONTACT WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS UNABLE TO DETERMINE WHEN THE PARTS WOULD BE SUPPLIED TO THE DEALER. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 06/14/16*LJ THE VALVE COVER GASKET AND TRQUE BOLTS WRER REPLACED. UPDATED 06/27/16.*JB
NHTSA ODI #10860918
Mileage unknown · Mar 2, 2016
Engine And Engine Cooling
2003 CHEVROLET IMPALA. CONSUMER WRITES IN REGARDS TO NOT PARTS AVAILABLE TO REPAIR ENGINE OIL LEAK RESULTING IN ENGINE COMPARTMENT FIRE RECALL NOTICE. *SMD
NHTSA ODI #10838372
Mileage unknown · Feb 29, 2016
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE …
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT EXPERIENCED A FAILURE WITH THE EXHAUST MANIFOLD LEAKING FLUID ONTO THE GROUND. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 04/13/16*LJ
NHTSA ODI #10838926
Mileage unknown · Feb 19, 2016
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART FOR THE RECALL WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS N…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING); HOWEVER, THE PART FOR THE RECALL WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. UPDATED 04/14/16*LJ UPDATED 04/19/16
NHTSA ODI #10837163
Mileage unknown · Feb 1, 2016
Engine And Engine CoolingFire
2003 CHEVROLET IMPALA. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE FIRE AFTER OIL SPILLED ONTO ENGINE. CONSUMER STATES RECEIVED ENGINE COMPARTMENT FIRES RECALL NOTICE AFTER INCIDENT. *SMD THE CONSUMER STATED AS A RESULT OF THE FIRE, SHE HAD TO PURCHASE A NEW VEHICLE, BECAUSE HER INSURANCE COMPANY DEEMED THE VEHICLE TOTALED.…
Read full complaint
2003 CHEVROLET IMPALA. CONSUMER WRITES IN REGARDS TO VEHICLE ENGINE FIRE AFTER OIL SPILLED ONTO ENGINE. CONSUMER STATES RECEIVED ENGINE COMPARTMENT FIRES RECALL NOTICE AFTER INCIDENT. *SMD THE CONSUMER STATED AS A RESULT OF THE FIRE, SHE HAD TO PURCHASE A NEW VEHICLE, BECAUSE HER INSURANCE COMPANY DEEMED THE VEHICLE TOTALED. *JB
NHTSA ODI #10838287
Mileage unknown · Jan 19, 2016
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
2003 CHEVROLET IMPALA. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL REPAIRS ISSUES. *SMD THE CONSUMER ALSO STATED THE CHECK ENGINE, ABS AND TIRE PRESSURE LIGHT WAS ON. ALSO, THERE WAS A CLICK IN THE STEERING WHEEL WHEN TURNING IT, THE VEHICLE HAD AN OIL LEAK, FREON WAS LEAKING FROM THE VEHICLE. . *JB
NHTSA ODI #10838275
Mileage unknown · Sep 23, 2015
Engine And Engine Cooling
2003 CHEVROLET IMPALA. CONSUMER WRITES IN REGARDS TO VEHICLE FAULTY ENGINEERING MISTAKE AND REQUESTS REFUND FOR REPLACEMENT ENGINE. *SMD THE REPAIR SHOP FOUND A MISFIRE IN THE #3 CYLINDER. THEY FOUND THE THREAD PULLED OUT OF THE HEAD FOR THE ROCKER ARM. *JB
NHTSA ODI #10682304
Mileage unknown · Apr 15, 2015
Engine And Engine CoolingStructure
I BOUGHT A CAR FROM PROGRESSIVE AUTO AND THEY TOLD ME IT WAS A INSPECT ABLE CAR AND THAT IT SHOULD RUN JUST FINE, I BOUGHT THE CAR FEBRUARY 20TH OF 2015 AND THE INSPECTION WAS DUE ON THE END OF FEBRUARY THAT'S WHEN THEY TOLD ME IT SHOULD INSPECT FINE, BUT WHEN I TOOK IT TO MY MECHANIC HE TOLD ME HE COULDN'T INSPECT IT SO I GOT T…
Read full complaint
I BOUGHT A CAR FROM PROGRESSIVE AUTO AND THEY TOLD ME IT WAS A INSPECT ABLE CAR AND THAT IT SHOULD RUN JUST FINE, I BOUGHT THE CAR FEBRUARY 20TH OF 2015 AND THE INSPECTION WAS DUE ON THE END OF FEBRUARY THAT'S WHEN THEY TOLD ME IT SHOULD INSPECT FINE, BUT WHEN I TOOK IT TO MY MECHANIC HE TOLD ME HE COULDN'T INSPECT IT SO I GOT THE FENDER RUST FIXED. THEN I TOOK IT TO INTEGRITY AUTO TO SEE IF THEY COULD INSPECT IT BUT THEY COULD NOT BECAUSE THE BOTTOM WAS RUSTED OUT THEN I TOOK IT TO TWO MORE MECHANICS WHO ALSO TOOK ME IT WAS WORTH IT BECAUSE ITS ALL ROTTED THE INTAKE GASKET WENT THE CO2 SENSOR WENT AND THE WATER PUMP WENT AND THE PANELS ARE ALL ROTTED... IT WAS A CAR THAT SHOULDN'T HAVE BEEN SOLD AND I ENDED UP PAYING OVER $1,000 DOLLARS FOR IT... NOW I'M OUT OF A CAR I RELY ON FOR WORK... *TR
NHTSA ODI #10705915
Official recalls
5Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 14, 2003
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration