TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE VEHICLE CAUGHT ON FIRE WITHOUT WARNING. THE CONTACT CALLED THE FIRE DEPARTMENT TO EXTINGUISH THE FIRE. THE FIRE DEPARTMENT COULD NOT DETERMINE WHAT CAUSED THE FIRE. THE CONTACT DID NOT CALL THE MANUFACTURER. THE VEHICLE WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE VEHICLE CAUGHT ON FIRE WITHOUT WARNING. THE CONTACT CALLED THE FIRE DEPARTMENT TO EXTINGUISH THE FIRE. THE FIRE DEPARTMENT COULD NOT DETERMINE WHAT CAUSED THE FIRE. THE CONTACT DID NOT CALL THE MANUFACTURER. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10515367
257 miles · Mar 20, 2013
Electrical SystemEngine
CAR WILL SHUT DOWN WHILE DRIVING AND SECURITY LIGHT WILL FLASH. HAS DONE IT NUMEROUS TIMES, WORRIED IT WILL CAUSE AN ACCIDENT. THERE ARE MULTIPLE CASES OF THIS PROBLEM ON INTERNET. *TR
NHTSA ODI #10503840
67,483 miles · Mar 11, 2013
Electrical SystemEngine
BOUGHT THIS 2003 CHEVROLET IMPALA ON JAN. 2 2012 AND ROCKER ARMS HAVE BEEN REPLACED 6 TIMES SINCE THEN, JUST TODAY MARCH 11,2013 ( MILES ARE 67483) BACK IN FOR SAME THING, CAR WAS JUST IN ON FEB. 13,2013 FOR ROCKER ARMS ( MILES WERE 100396) AND THE DEALER PUT A NEW ENGINE IN AND IN LESS THEN A MONTH BACK IN SAME THING. HEAD LIG…
Read full complaint
BOUGHT THIS 2003 CHEVROLET IMPALA ON JAN. 2 2012 AND ROCKER ARMS HAVE BEEN REPLACED 6 TIMES SINCE THEN, JUST TODAY MARCH 11,2013 ( MILES ARE 67483) BACK IN FOR SAME THING, CAR WAS JUST IN ON FEB. 13,2013 FOR ROCKER ARMS ( MILES WERE 100396) AND THE DEALER PUT A NEW ENGINE IN AND IN LESS THEN A MONTH BACK IN SAME THING. HEAD LIGHTS DON'T WORK RIGHT.THIS CAR IS FAULTY AND SHOULD BE RECALLED AND OFF THE ROAD BEFORE SOMEONE KILLS THEM SELF OR SOMEONE ELSE. WHEN THE ROCKER ARMS WENT DIDN'T HAVE POWER AND ALMOST CRASHED ONTO A WAS WHEN TURNING A BEND.VERY DANGEROUS VEHICLE!!! *TR
NHTSA ODI #10502353
108,000 miles · Feb 18, 2013
Engine
BLOWN HEAD GASKET. DOING SEARCHES ON INTERNET, THERE ARE THOUSANDS OF COMPLAINTS FOR THIS ISSUE WITH THIS ENGINE TYPE! SPARE US ALL THE EXPENSIVE REPAIR COST AND ISSUE A RECALL ALREADY! *TR
NHTSA ODI #10498545
52,000 miles · Feb 9, 2013
Electrical SystemEngineVehicle Speed Control
ENGINE ACCELERATES TO 3,000 RPM DURING WARM UP (SOMETIMES). USUALLY OCCURS ABOUT FIVE MINUTES AFTER COLD START. HAS LASTED 10 TO 15 MINUTES WHILE DRIVING. HAS NOT REPEATED DURING SAME DAY AND NOT HAPPEN AGAIN FOR DAYS OR WEEKS DURING THE PAST FIVE MONTHS. REPLACED ECM (COMPUTER), IAC (IDLE AIR CONTROL), COOLANT TEMP. SENSOR …
Read full complaint
ENGINE ACCELERATES TO 3,000 RPM DURING WARM UP (SOMETIMES). USUALLY OCCURS ABOUT FIVE MINUTES AFTER COLD START. HAS LASTED 10 TO 15 MINUTES WHILE DRIVING. HAS NOT REPEATED DURING SAME DAY AND NOT HAPPEN AGAIN FOR DAYS OR WEEKS DURING THE PAST FIVE MONTHS. REPLACED ECM (COMPUTER), IAC (IDLE AIR CONTROL), COOLANT TEMP. SENSOR AND CLEANED THROTTLE BODY. DEALER CANNOT SUGGEST SOLUTION. UNABLE TO GET CAR TO DEALER WHILE PROBLEM IS HAPPENING. SCANNED FOR DTCS MULTIPLE TIMES, NONE. CONTROLLING SPEED WITH BRAKE IS NOT A GOOD SOLUTION. SAFETY HAZARD! *TR THE CONSUMER STATED WHEN THE BODY CONTROL MODULE FAILED, THE KEY FOB WOULD NOT WORK, THE ENGINE WOULD NOT START, THE INTERIOR LIGHTS WOULD NOT COME ON AND THE HEAD LIGHT WOULD NOT TURN OFF. THE CONSUMER HAD TO DISCONNECT THE BATTERY, IN ORDER TO TURN THE HEAD LIGHTS OFF. AFTER RECONNECTING THE BATTERY, EVERYTHING RETURNED TO NORMAL. THE BCM WAS REPLACED. UPDATED 03/19/13
NHTSA ODI #10496949
119,000 miles · Nov 30, 2012
Electrical SystemEngine
WHEN I ATTEMPT TO START THE VEHICLE, THE SECURITY LIGHT FLASHES, RADIO LOCKS UP AND THE CAR STALLS. AFTER READING THE MANUAL AND CONTACTING A DEALER, I WAS ADVISED TO TURN THE KEY INTO THE ON POSITION AND WAIT FOR THE SECURITY LIGHT TO STOP FLASHING, THEN START THE CAR. THE FIRST TIME THIS HAPPENED IT TOOK OVER AN HOUR FOR THE C…
Read full complaint
WHEN I ATTEMPT TO START THE VEHICLE, THE SECURITY LIGHT FLASHES, RADIO LOCKS UP AND THE CAR STALLS. AFTER READING THE MANUAL AND CONTACTING A DEALER, I WAS ADVISED TO TURN THE KEY INTO THE ON POSITION AND WAIT FOR THE SECURITY LIGHT TO STOP FLASHING, THEN START THE CAR. THE FIRST TIME THIS HAPPENED IT TOOK OVER AN HOUR FOR THE CAR TO START. THE SECOND TIME, IT TOOK OVER AN HOUR AS WELL. THIS IS THE THIRD TIME AND IM ON DAY 2 OF LEAVING THE KEY IN THE ON POSITION AND NOTHING IS HAPPENING. I CONTACTED THE DEALER AGAIN AND AT FIRST I WAS TOLD I NEEDED TO BRING IT IN FOR A SECURITY SYSTEM RESET. THEN I WAS TOLD THAT I NEED TO REPLACE BCM WITHOUT ANYONE ACTUALLY LOOKING AT MY CAR. AFTER RESEARCHING ONLINE, THERE ARE SEVERAL COMPLAINTS REGARDING THIS SAME ISSUE ON MODEL 2000-2005. GM IS CLEARLY AWARE OF THIS DEFECT BUT REFUSE RECALL. THOSE THAT HAVE PAID OVER $500 TO FIX REPLACE THE BCM ARE STILL HAVING THE SAME ISSUE. CAN GM BE HELD ACCOUNTABLE FOR THE FLAW THAT THEY ARE AWARE OF YET CHARGING PEOPLE HUNDREDS OF DOLLARS TO FIX A PART THAT MAY NOT BE BROKEN? *TR
NHTSA ODI #10486544
140,000 miles · Nov 5, 2012
EngineFire
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT STATED THAT SHE WAS PUTTING OIL IN THE VEHICLE WHEN SHE BEGAN TO SMELL PLASTIC BURNING AND THEN SAW SPARKING COMING FROM UNDERNEATH THE ENGINE. THE CONTACT STATED THAT AS SOON AS SHE SAW THE SPARKS, THE ENGINE IGNITED INTO FLAMES. THERE WAS NO INJURIES AND THE VEHICLE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT STATED THAT SHE WAS PUTTING OIL IN THE VEHICLE WHEN SHE BEGAN TO SMELL PLASTIC BURNING AND THEN SAW SPARKING COMING FROM UNDERNEATH THE ENGINE. THE CONTACT STATED THAT AS SOON AS SHE SAW THE SPARKS, THE ENGINE IGNITED INTO FLAMES. THERE WAS NO INJURIES AND THE VEHICLE WAS DESTROYED. THE POLICE AND THE FIRE DEPARTMENT CAME AND FILED REPORTS. THE FIRE DEPARTMENT WAS UNABLE TO DETERMINE THE CAUSE OF FIRE. THE DEALER WAS NOTIFIED BUT PROVIDED NOT ASSISTANCE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10483349
100,000 miles · Jul 23, 2012
Engine
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 45 MPH THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A PERSONAL MECHANIC FOR DIAGNOSIS AND WAS INFORMED THE VEHICLE WOULD NEED A NEW CRANK SHAFT POSITION SENSOR. THE VEHICLE WAS REPAIRED. FIVE MONTHS LATER THE FAILURE RECURRED. THE VEHICLE WAS A…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 45 MPH THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A PERSONAL MECHANIC FOR DIAGNOSIS AND WAS INFORMED THE VEHICLE WOULD NEED A NEW CRANK SHAFT POSITION SENSOR. THE VEHICLE WAS REPAIRED. FIVE MONTHS LATER THE FAILURE RECURRED. THE VEHICLE WAS AGAIN TAKEN TO A PERSONAL MECHANIC AND HAD THE MASS AIR FLOW SENSOR REPLACED. THE FAILURE RECURRED AGAIN AND THE CAM SHAFT SENSOR AND O2 SENSORS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 119,000.
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2003 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration