IllustrationMy car sometimes cuts off while driving. Was on highway 301 running about 60 mph in the middle lane and just lost power no warning. No code no nothing. Sacred me, I truly feel that's a safety issue, for me and the cars behind me. It's bad not knowing when or where this will happen again.
2003 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
670–25K
6625–50K
9150–75K
8175–100K
121100–150K
87150K+
513 reports with mileage · 181 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 264 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 103 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 88 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
32 crash reports32 fire reports23 injury reports
Electrical System complaints
264 reportsI have a 2003 Chevrolet Impala! Look it up on the internet, and you will see that the failure rate of the GM passlock system is huge, and massively expensive to repair! In fact from a inside relative, says GM makes more money in parts, and repairs than on selling a new vehicle! This is without doubt a premeditated flow to rip o…
Read full complaint
I have a 2003 Chevrolet Impala! Look it up on the internet, and you will see that the failure rate of the GM passlock system is huge, and massively expensive to repair! In fact from a inside relative, says GM makes more money in parts, and repairs than on selling a new vehicle! This is without doubt a premeditated flow to rip off the public! This is in fact insensitive for GM to engineer a constant, and ongoing failure of the of its vehicles! This passlock defect can not be fixed by accessing the cars computer! It should be that easy but it is not a option. Being stranded by this defect is life threatening. The problem is the Passlock system that has failed for me, and hundreds of thousands owners of GM vehicles, and tens of millions of dollars in repairs that GM should be forced to repair, at no costs, past, and present to the owners, and including towing, and a rental car! The passlock defect, and failure completely locks up the cars entire electrical system, so the owner can not start, or even open the trunk of their car in a emergency! After it happens you can’t even access the car radio to reset back to the original factory functions! Even if you disconnect the battery, to get this accomplished, it will be a short while before it happens again! It is crazy expensive just to diagnose this problem! Please note that this is not just a Impala problem! This passlock defect falling involves dozens of Models of all types, old, and new. These vehicles number in the many hundreds of thousands over decades! Many tens of millions of dollars in repairs, and hundreds of thousands waiting to happen! This needs to be addressed at a government level! We won’t to see some consumer protection, and Justice! Thank you for your time, and consideration! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
VEHICLE FIRE. VEHICLE CAUGHT FIRE WHILE CRUISING AT HIGHWAY SPEEDS. VERY DANGEROUS. VEHICLE IS A TOTAL LOSS.
VEHICLE DIDN'T START, SECURITY LIGHT WAS FLASHING, WAS TOLD TO TURN THE KEY INTO THE 'ON' POSITION AND WAIT EXACTLY 10 MINUTES BEFORE TRYING TO START IT. IT WORKED, BUT THE ISSUE BECAME WORSE AND WORSE UNTIL IT NO LONGER STARTED. WAS THEN TOLD TO REPLACE KEYS, DID THAT, SAME ISSUE. WHEN BLINKERS WERE USED, A LOUD BUZZING NOISE O…
Read full complaint
VEHICLE DIDN'T START, SECURITY LIGHT WAS FLASHING, WAS TOLD TO TURN THE KEY INTO THE 'ON' POSITION AND WAIT EXACTLY 10 MINUTES BEFORE TRYING TO START IT. IT WORKED, BUT THE ISSUE BECAME WORSE AND WORSE UNTIL IT NO LONGER STARTED. WAS THEN TOLD TO REPLACE KEYS, DID THAT, SAME ISSUE. WHEN BLINKERS WERE USED, A LOUD BUZZING NOISE OCCURRED AND EVERY LIGHT ON THE DASH LIT UP, THE GEAR SHIFT LABELS BEGAN FLICKERING AND THE STEREO DID AS WELL. THE DEALERSHIP HAS REPLACED THE BCM AND THE IGNITION SWITCH, AND IT HAD FINALLY STARTED, UNTIL I WENT TO TRY TO GO SOMEWHERE. NO ONE KNOWS WHAT IS GOING ON AND MULTIPLE PEOPLE HAVE SAID THAT THIS ISSUE IS VERY COMMON IN THIS TYPE OF VEHICLE.
2003 CHEVROLET IMPALA 3.4L IS DIFFICULT TO START, REPLACED MANY PARTS TO TRY AND FIX: FUEL FILTER, FUEL PUMP, SPARK PLUGS AND WIRES, OXYGEN SENSORS, FUEL EVAP VALVE, AND THROTTLE CONTROL. VEHICLE CURRENTLY HAS 52,XXX MILES. SECURITY LIGHT FLASHES, WAS ABLE TO PULL ERROR CODE P1626: THEFT DETERRENT FUEL ENABLE SIGNAL NOT RECEIV…
Read full complaint
2003 CHEVROLET IMPALA 3.4L IS DIFFICULT TO START, REPLACED MANY PARTS TO TRY AND FIX: FUEL FILTER, FUEL PUMP, SPARK PLUGS AND WIRES, OXYGEN SENSORS, FUEL EVAP VALVE, AND THROTTLE CONTROL. VEHICLE CURRENTLY HAS 52,XXX MILES. SECURITY LIGHT FLASHES, WAS ABLE TO PULL ERROR CODE P1626: THEFT DETERRENT FUEL ENABLE SIGNAL NOT RECEIVED. KEYS ARE ORIGINAL TO CAR, I HAVE TRIED TO RE-LEARN KEYS TO VEHICLE WITH NO SUCCESS. NUMEROUS REPAIRS ARE LISTED UNDER THIS ERROR CODE, INCLUDING THE REPLACEMENT OF THE BCM, AND THIS DOESN'T ALWAYS FIX THE PROBLEM. THIS ISSUE NEEDS TO BE RESEARCHED FURTHER.
MY AIR BAG LIGHTS ARE ON ALL THE TIME, I HAVE TO CHANGE MY BRAKES EVER 2 MONTHS BC THEY START TO LOCK UP AND GO THROUGH BRAKE PADS LIKE NOTHING. I ALSO HAVE ELECTRONICAL PROBLEMS MY BLINKERS WORK WHEN THEY WANT TO AN WHEN IT STARTS TO NOT WORK MY LIGHTS DIM IF THE RADIO IS ON IT TURNS DOWN IT'S HAPPENING MORE AN MORE
VEHICLE WILL NOT START SOMETIMES AFTER DRIVING WILL USUALLY HAVE TO GIGGLE THE KEY IN THE IGNITION TO GET THE VEHICLE STARTED BACK UP..NHTSA RECALL #14V400
I RECENTLY RECEIVED A ALERT FROM MY CREDIT KARMA STATING THAT I HAD A RECALL ON MY 2003 CHEVY IMPALA FOR A ELECTRICAL SYSTEM: IGNITION RECALL #213545. I PAID OUT OF POCKET TO GET THIS RECALL FIXED BACK IN FEB OF THIS YEAR AND WOULD LIKE TO KNOW HOW CAN I GET A REINBURSMENT FOR THAT RECALL.
UNDER THE HOOD FIRE AND UNINTENDED KEY ROTATION. MAYBE 5 DAYS AFTER I TOOK MY VEHICLE INTO TC CHEVY (IN ASHLAND OREGON) TO HAVE THE 2 RECALLS REPAIRED ON IT. I TRIED TO START MY CAR AND IT CAUGHT ON FIRE DOWN BY THE FRONT BUMPER AND THE FLAMES MADE IT TO THE BACK SIDE OF THE MOTOR AND IGNITED THE FUEL LINES CAUSING A MINI EXPLOS…
Read full complaint
UNDER THE HOOD FIRE AND UNINTENDED KEY ROTATION. MAYBE 5 DAYS AFTER I TOOK MY VEHICLE INTO TC CHEVY (IN ASHLAND OREGON) TO HAVE THE 2 RECALLS REPAIRED ON IT. I TRIED TO START MY CAR AND IT CAUGHT ON FIRE DOWN BY THE FRONT BUMPER AND THE FLAMES MADE IT TO THE BACK SIDE OF THE MOTOR AND IGNITED THE FUEL LINES CAUSING A MINI EXPLOSION UNDER THE HOOD, MEAN WHILE I'M SITTING IN THE DRIVER'S SEAT. I JUMPED OUT OF THE CAR NEARLY HAVING THE LIFE SCARED OUT OF ME, I POPPED THE HOOD AND GRABBED MY HOUSE GARDEN HOUSE AND STARTED TO TRY AND PUT THE FIRE OUT AND MINIMIZE THE DAMAGE TO MY VEHICLE WHILE I WAITED FOR THE FIRE DEPARTMENT TO REACH MY HOUSE. THE FIRE DEPARTMENT SHOWED UP AND WAS ABLE TO GET THE FIRE PUT OUT ALMOST TORCHING ONE OF THE FIREFIGHTERS HEAD WHEN THE FUEL PUMP KICKED ON WITHOUT THE KEYS IN THE IGNITION AND STARTED SHOOTING GASOLINE REIGNITING THE FIRE. I'M LUCKY THE FIRE DIDN'T BURN DOWN MY HOUSE AND MY NEIGHBOR'S HOUSE THAT DAY SEEING HOW THE FIRE CAUGHT THE BUSH NEXT DOOR ON FIRE AND THERE WAS FLAMES 14 FT IN THE AIR. SEE CHEVY AND GM HAVE BEEN TRYING TO ACT LIKE THE FIRE AND THE DAMAGE TO THE VEHICLE IS MY OWN FAULT AND NONE OF THEIR OWN EVEN THOUGH THE TECHNICIAN SAYS NONE OF THE REPAIRS WERE ACTUALLY DONE. I'VE BEEN TRYING TO GET AN INVESTIGATION DONE AND THEY'RE TRYING TO PUSH MY CLAIM ASIDE AND SWEEP IT UNDER THE RUG. MY VEHICLE WAS PARKED IN MY DRIVEWAY AT MY HOME RIGHT NEXT TO A BUSH NOT MY NEIGHBOR'S HOUSE IS RIGHT UP AGAINST. PLEASE LOOK INTO THIS SO THAT IT DOESN'T GET SWEPT UNDER THE RUG. PLEASE HELP ME. I ALSO HAVE THE FIREFIGHTERS REPORT.
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 45 MPH, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT WAS CONCERNED THAT THE AIR BAG WOULD DEPLOY. THE VEHICLE WAS TAKEN TO COAD CHEVROLET IN CAPE GIRARDEAU, MISSOURI, 573-335-5581 TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SY…
Read full complaint
TL* THE CONTACT OWNS A 2003 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 45 MPH, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE CONTACT WAS CONCERNED THAT THE AIR BAG WOULD DEPLOY. THE VEHICLE WAS TAKEN TO COAD CHEVROLET IN CAPE GIRARDEAU, MISSOURI, 573-335-5581 TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) IN APPROXIMATELY APRIL OF 2017. THE DEALER PROVIDED THE CONTACT WITH A TWO KEY RING HOLDER. THE VEHICLE WAS NOT REPAIRED FOR THE RECENT FAILURE ACCORDING TO SPECIFICATIONS ON THE LETTER ORIGINALLY RECEIVED, WHICH SPECIFIED THAT AN INSERT IN THE KEY SLOT WAS SUPPOSED TO BE PROVIDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. *TT UPDATED 8/28/18*JB *TT *JB
Official recalls
515V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
03V051000 · Air Bags:frontal:driver Side:inflator Module
Feb 14, 2003
ON CERTAIN MINI VANS, PASSENGER AND SPORT UTILITY VEHICLES, SOME OF THESE VEHICLES HAVE A DRIVER'S SIDE AIR BAG THAT MAY NOT DEPLOY AS DESIGNED. IN ADDITION, THE AIR BAG INFLATOR COULD RUPTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED CAPABILITY OF THE AIR BAG TO PROTECT THE DRIVER. ALSO IF THE AIR BAG INFLATOR RUPTURED, PIECES OF THE INFLATOR COULD STRIKE AND INJURE THE VEHICLE OCCUPANTS.
Remedy: DEALERS WILL INSPECT, AND IF NECESSARY, INSTALL A NEW DRIVER'S AIR BAG. OWNER NOTIFICATION BEGAN ON MARCH 11, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR PONTIAC AT 1-800-762-2737.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.