NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
795 reportsMileage unknown · Feb 19, 2008
Electrical System
ON A 2002 CHEVROLET IMPALA, THE SECURITY LIGHT COMES ON WHILE DRIVING. FOLLOWING THIS EVENT VARIOUS ELECTRICAL ABNORMALITIES OCCUR. DASHBOARD WARNING LIGHTS ALL FLASH TOGETHER, DASH GOES DARK. SOMETIMES WHEN YOU START THE CAR THE SECURITY LIGHT COMES ON AND THE HEADLIGHTS FLASH AS IF THEY WERE ICC FLASHERS. THERE ARE NUMEROUS CO…
Read full complaint
ON A 2002 CHEVROLET IMPALA, THE SECURITY LIGHT COMES ON WHILE DRIVING. FOLLOWING THIS EVENT VARIOUS ELECTRICAL ABNORMALITIES OCCUR. DASHBOARD WARNING LIGHTS ALL FLASH TOGETHER, DASH GOES DARK. SOMETIMES WHEN YOU START THE CAR THE SECURITY LIGHT COMES ON AND THE HEADLIGHTS FLASH AS IF THEY WERE ICC FLASHERS. THERE ARE NUMEROUS COMPLAINTS ABOUT THIS ON THE INTERNET. CHEVROLET DOESN'T SEEM TO HAVE ANY FINITE FIX FOR THIS AND RANDOMLY REPLACES THE BCM AND IGNITION SWITCH AS POSSIBLE CAUSES. MOST PEOPLE REPORT HAVING THE EXACT SAME PROBLEM OVER AGAIN SEVERAL DAYS LATER??? DUE TO THIS ERRONEOUS REPORTING I THOUGHT I HAD A BATTERY PROBLEM AND THE GARAGE CHANGED MY ALTERNATOR. AT A COST OF $306 DOLLARS. WHICH I NOW BELIEVE WAS TOTALLY UN-NECESSARY. *TR
NHTSA ODI #10218483
75,000 miles · Feb 11, 2008
Electrical System
INTERMITTENT FLASHING OF ALL VEHICLE EXTERNAL LIGHTS. IT HAPPENS EVERYDAY. DEALER DIAGNOSED THE FOLLOWING ELECTRICAL PROBLEMS: CONNECTION AT THE BODY CONTROL MODULE MUST BE REPAIRED. THE PASSOLCK SENSOR AND IGNITION SWITCH MUST BE REPLACED. *TR
NHTSA ODI #10217658
30,000 miles · Feb 6, 2008
Exterior LightingStructure
THE HEAD LIGHTS ON MY 2002 IMPALA ARE GETTING WATER IN THEM CAUSING ELECTRICAL AND SAFETY PROBLEMS. STEAM - MOISTURE GATHER IN THE LIGHTS AND WE ARE NOT ABLE TO SEE THE ROAD. THIS IA A DEFECT THAT IS ON EVERY 2002-2003 IMPALA I HAVE SEEN, GM REFUSES TO REPLACE OR EVEN RECOGNIZE THE PROBLEM, THEY AND THE DEALER I PURCHASED FROM S…
Read full complaint
THE HEAD LIGHTS ON MY 2002 IMPALA ARE GETTING WATER IN THEM CAUSING ELECTRICAL AND SAFETY PROBLEMS. STEAM - MOISTURE GATHER IN THE LIGHTS AND WE ARE NOT ABLE TO SEE THE ROAD. THIS IA A DEFECT THAT IS ON EVERY 2002-2003 IMPALA I HAVE SEEN, GM REFUSES TO REPLACE OR EVEN RECOGNIZE THE PROBLEM, THEY AND THE DEALER I PURCHASED FROM SAID ITS NOT CONSIDERED A DEFECT UNLESS IT IS A RECALL, I WAS TOLD UNTIL A MAJOR ACCIDENT HAPPENS THAT THEY WILL NOT CONSIDER IT A SAFETY ISSUE. I TOLD THEM WHEN THE LIGHTS GET HOT THE WATER IN THE HEAD LIGHTS TURN TO STEAM FOGGING UP THE LIGHTS PREVENTING ME FROM SEEING THE ROAD WHEN DRIVING AT NIGHT, THEY (THE DEALERSHIP) SAID WELL YOU SHOULD DRIVE ONLY DURING THE DAY. THIS IS ALSO CAUSING OTHER ELECTRICAL PROBLEMS WITH TURN SIGNALS NOT WORKING SOMETIMES AND HAZARDS NOT WORKING NOT TO MENTION HAVING TO REPLACE A BULB EVERYTIME IT GETS WET. THIS HAPPENS ALL THE TIME WHEN WE WASH OUR CAR OR GET INTO BAD WEATHER. I BELIEVE THIS SHOULD BE A RECALL... GM REFUSES TO HANDLE THIS PROBLEM UNTIL WE HAVE MULTIPLE FATAL ACCIDENTS AROUND THE COUNTRY? NOT SMART THERE ARE ALOT OF PEOPLE ON OUR STREETS AND HIGHWAYS THAT ARE BEING PUT AT RISK. *TR
NHTSA ODI #10217095
51,000 miles · Jan 31, 2008
Electrical System
VEHICLE IGNITION IS LOCKED UP, NO WARNING, THIS IS A PROBLEM WITH MOST OF THESE VEHICLES PRODUCED WITH IN DASH IGNITIONS. AT 51,000 MILES GM WANTS CUSTOMERS TO PAY FOR REPAIRS OF THESE AT THE CUSTOMER COST BEING AROUND $900.00 AND IN MOST INSTANCES WITHIN 18MONTHS THE FAILURE OCCURS AGAIN. I FEEL THAT THIS IS CRIMINAL OF GM TO B…
Read full complaint
VEHICLE IGNITION IS LOCKED UP, NO WARNING, THIS IS A PROBLEM WITH MOST OF THESE VEHICLES PRODUCED WITH IN DASH IGNITIONS. AT 51,000 MILES GM WANTS CUSTOMERS TO PAY FOR REPAIRS OF THESE AT THE CUSTOMER COST BEING AROUND $900.00 AND IN MOST INSTANCES WITHIN 18MONTHS THE FAILURE OCCURS AGAIN. I FEEL THAT THIS IS CRIMINAL OF GM TO BE AWARE OF THIS PROBLEM AND NOT RECALL EVERY VEHICLE TO COVER REPAIRS. TOWING BILL 75.00 TO DATE AS WELL 900.00 FOR REPAIRS. *TR
NHTSA ODI #10216616
126,750 miles · Jan 28, 2008
Electrical System
ON 01/22/08 WHILE DRIVING, THE "SECURITY" LIGHT APPEARED IN THE MESSAGE CENTER ON THE INSTRUMENT PANEL. WHEN I STOPPED THE CAR, TURNED IT OFF, AND RESTARTED, ALL WAS FINE AND THE LIGHT REMAINED OFF. THE FOLLOWING DAY, AFTER DRIVING APPROXIMATELY 10 MILES, THE "SECURITY" LIGHT APPEARED. THIS HAS HAPPENED A TOTAL OF FOUR TIMES,…
Read full complaint
ON 01/22/08 WHILE DRIVING, THE "SECURITY" LIGHT APPEARED IN THE MESSAGE CENTER ON THE INSTRUMENT PANEL. WHEN I STOPPED THE CAR, TURNED IT OFF, AND RESTARTED, ALL WAS FINE AND THE LIGHT REMAINED OFF. THE FOLLOWING DAY, AFTER DRIVING APPROXIMATELY 10 MILES, THE "SECURITY" LIGHT APPEARED. THIS HAS HAPPENED A TOTAL OF FOUR TIMES, MOST RECENTLY ON 01/27/08. WHEN THE LIGHT APPEARED, THE HEADLIGHTS DIMMED FOR A MOMENT. WHEN I STOPPED THE CAR, THE LIGHTS ON THE RADIO WERE EXTREMELY DIM. ON 01/28/08, I WENT TO START THE CAR AND THE BATTERY APPEARED TO BE DEAD. AN ATTEMPT TO JUMP OFF THE CAR WAS UNSUCCESSFUL. THIS SEEMS TO BE RELATED TO THE VERY COMMON "PASSLOCK" PROBLEMS ON OTHER GM PRODUCTS. *TR
NHTSA ODI #10216309
97,500 miles · Jan 22, 2008
Exterior Lighting
ABOUT 9 MONTHS AGO HIGH BEAMS WOULD GO OUT COMPLETELY (NO LIGHTS AT ALL) UNTIL HIT LEVER. GOT WORSE UNTIL NO HEADLIGHTS AT ALL. TOOK TO DEALER AND CHARGED ME $629.66 FOR A MULTI FUNCTION SWITCH. ADVISED GM OF NHTSA PEO6017 BUT THEIR RESPONSE WAS THAT GM WOULD NOT COVER DUE TO AGE (2002) AND MILEAGE (107,200). *TR
NHTSA ODI #10215678
60,000 miles · Jan 16, 2008
Electrical System
TL*THE CONTACT OWNS A 2002 CHEVY IMPALA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START WHEN THE SECURITY LIGHT ILLUMINATED. IN ADDITION, THE FAILURE OCCURRED INTERMITTENTLY THE LAST THREE YEARS. THE DEALER REPLACED THE IGNITION AND PASS SENSOR; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE CURRENT MILEAGE WAS 96,000 AND …
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVY IMPALA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START WHEN THE SECURITY LIGHT ILLUMINATED. IN ADDITION, THE FAILURE OCCURRED INTERMITTENTLY THE LAST THREE YEARS. THE DEALER REPLACED THE IGNITION AND PASS SENSOR; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE CURRENT MILEAGE WAS 96,000 AND FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10215157
75,000 miles · Jan 14, 2008
Engine And Engine Cooling
I TOO AM HAVING PROBLEMS WITH THE COOLANT SYSTEM AND THE LEAKING ANTIFREEZE. THE MANIFOLD GASKET ISSUE HAS TURNED INTO A CLASS ACTION LAWSUIT AGAINST GM. RECENTLY A DECISION WAS MADE IN FAVOR OF CAR OWNERS WITH THIS PROBLEM. DETAILS SHOULD BE RELEASED IN FEB 08 ABOUT THIS BUT I'VE HEARD THAT GM WILL HAVE TO PAY CAR OWNERS WHO…
Read full complaint
I TOO AM HAVING PROBLEMS WITH THE COOLANT SYSTEM AND THE LEAKING ANTIFREEZE. THE MANIFOLD GASKET ISSUE HAS TURNED INTO A CLASS ACTION LAWSUIT AGAINST GM. RECENTLY A DECISION WAS MADE IN FAVOR OF CAR OWNERS WITH THIS PROBLEM. DETAILS SHOULD BE RELEASED IN FEB 08 ABOUT THIS BUT I'VE HEARD THAT GM WILL HAVE TO PAY CAR OWNERS WHO HAVE HAD THIS PROBLEM FIXED A PORTION OR ALL OF THE REPAIR COST. FOR MORE INFO GOOGLE CLASS ACTION LAWSUIT, GM, AND GIBBS(THIS IS THE ATTORNEY). *TR
NHTSA ODI #10214681
40,000 miles · Jan 8, 2008
Electrical System
DEALER SAYS I NEED A NEW ELECTRONIC BODY CONTROL MODULE.( $1,100.) ABS LIGHT ON AND OFF, TRACTION LIGHT ON AND OFF, SECURITY LIGHT ON AND OFF, CAR WOULD NOT START 4 TIMES. TRUNK OPENS ON AND OFF. SERVICE WRITER TOLD ME IT IS NOT COMMON. WHILE PICKING UP MY CAR,I REFUSED TO HAVE THE EBCM REPLACED, ANOTHER CUSTOMER CALLED IN WITH …
Read full complaint
DEALER SAYS I NEED A NEW ELECTRONIC BODY CONTROL MODULE.( $1,100.) ABS LIGHT ON AND OFF, TRACTION LIGHT ON AND OFF, SECURITY LIGHT ON AND OFF, CAR WOULD NOT START 4 TIMES. TRUNK OPENS ON AND OFF. SERVICE WRITER TOLD ME IT IS NOT COMMON. WHILE PICKING UP MY CAR,I REFUSED TO HAVE THE EBCM REPLACED, ANOTHER CUSTOMER CALLED IN WITH THE SAME PROBLEM. MECHANICS WHO WORK INDEPENDENT HAVE TOLD ME THE MAINTENANCE PROGRAMS GM REQUIRES ARE A MAJOR RIP OFF. A CLASS ACTION SUIT NEEDS TO BE STARTED AGAINST GM FOR DESTROYING THE MORAL OF THE AUTO CONSUMER. I HAVE SEEN OTHERS POST THAT THEY HAD THE MODULE REPROGRAMMED. OTHERS HAVE HAD IT REPLACED FOR $400-500. SERVICE WRITERS SHOULD NOT BE ON COMMISSION THIS GIVES THEM A RIP YOU OFF MENTALITY! GM DEALERS ARE SCUM CHEVY IS SCUM. *TR
NHTSA ODI #10214157
47,000 miles · Jan 5, 2008
Power Train
TRANSMISSION FAILED WITH ONLY 47,000 MILES ON VEHICLE. *CN
NHTSA ODI #10213806
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration