IllustrationTURNING SIGNAL DID NOT COME ON. THIS OCCURS RANDOMLY PUTTING MY LIFE IN DANGER IN MANY OCCASIONS. *TR
2002 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
590–25K
9725–50K
10950–75K
10775–100K
130100–150K
69150K+
571 reports with mileage · 224 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 305 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports32 fire reports27 injury reports
What owners actually said
795 reportsTL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE SECURITY LIGHT ILLUMINATED WHICH INDICATED THAT THE ANTI-THEFT DEVICE WAS DEFECTIVE. AS A RESULT, SHE WAS UNABLE TO START HER VEHICLE. THE DEALER INSPECTED THE VEHICLE AND STATED THAT THE PATH LOCK SENSOR CAUSED THE FAILURE. THEY MADE THE REPLACEMENT HO…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE SECURITY LIGHT ILLUMINATED WHICH INDICATED THAT THE ANTI-THEFT DEVICE WAS DEFECTIVE. AS A RESULT, SHE WAS UNABLE TO START HER VEHICLE. THE DEALER INSPECTED THE VEHICLE AND STATED THAT THE PATH LOCK SENSOR CAUSED THE FAILURE. THEY MADE THE REPLACEMENT HOWEVER APPROXIMATELY TEN MONTHS LATE THE FAILURE OCCURRED AGAIN. THE MECHANIC STATED THAT THE PATH LOCK SENSOR CAUSED THE FAILURE AND THEY MADE THE REPLACEMENT. APPROXIMATE SIX MONTHS LATER THE FAILURE OCCURRED AGAIN. THE MECHANIC STATED THAT THE PATH LOCK SENSOR CAUSED THE FAILURE. AS OF APRIL 21, 2008, THE MECHANIC HAD NOT REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 65,000 AND CURRENT MILEAGE WAS 88,000.
I HAVE A 2002 CHEVROLET IMPALA WITH THE ABS/TRACTION CONTROL WARNING LAMP ON PROBLEM. THIS PROBLEM CAN BE INTERMITTENT. THE CAR HAS APPROXIMATELY 98,764 MILES ON IT. THE PROBLEM WAS FIRST NOTICED AT ABOUT 89000 MILES. THERE IS AN ASSORTED AMOUNT OF SYMPTOMS THAT GO ALONG WITH THIS ISSUE. THIS PROBLEM IS DANGEROUS AND COULD POSSI…
Read full complaint
I HAVE A 2002 CHEVROLET IMPALA WITH THE ABS/TRACTION CONTROL WARNING LAMP ON PROBLEM. THIS PROBLEM CAN BE INTERMITTENT. THE CAR HAS APPROXIMATELY 98,764 MILES ON IT. THE PROBLEM WAS FIRST NOTICED AT ABOUT 89000 MILES. THERE IS AN ASSORTED AMOUNT OF SYMPTOMS THAT GO ALONG WITH THIS ISSUE. THIS PROBLEM IS DANGEROUS AND COULD POSSIBLY RESULT IN AN ACCIDENT. HERE ARE THE SYMPTOMS YOU MAY EXPERIENCE YOU MAY HAVE ONE OR MORE OF THE FOLLOWING SYMPTOMS: 1. AFTER START UP (WITHOUT THE BRAKE PEDAL DEPRESSED) THE ABS/TRACTION LAMP MAY OR MAY NOT COME ON. THIS IS TEMPERATURE DEPENDENT COLD START OR HOT RESTART (IT SEEMS TO OCCUR MORE FREQUENTLY AT THE BOTH EXTREMES). 2. THE ABS BRAKES MAY CYCLE ON JUST DURING NORMAL BRAKING. THIS MAY CAUSE THE VEHICLE TO UNEXPECTEDLY PULL TO THE RIGHT. 3. THE ABS BRAKES MAY CYCLE ON WHILE MAKING A SLOW RIGHT HAND TURN WITH THE BRAKES APPLIED LIGHTLY. 4. THE ABS BRAKES MAY CYCLE ON WHEN TRAVELING ON A STRAIGHT ROADWAY AT ABOUT 40 MPH AND THEN COMING TO A SLOW STOP WITH THE BRAKE PEDAL LIGHTLY APPLIED. 5. THE ABS/TRACTION CONTROL LAMP MAY COME ON WHILE TRAVELING IN LIGHT AND HEAVY RAIN. THIS MAY ALSO OCCUR AFTER RUNNING THE CAR THOUGH AN AUTOMATIC CAR WASH. IT SHOULD BE NOTED THAT YOU MAY HEAR THE ABS PUMP MOTOR CYCLE A NUMBER OF TIMES (USUALLY 3) BEFORE THE INDICATOR LAMPS COME ON. TECHNICAL INFORMATION: THE FOLLOWING FAILURE CODES MAY BE STORED IN THE EBCM SEE BELOW: C1216 ELECTRONIC BRAKE CONTROL MODULE COMMANDED PRESSURE RELEASE IS TO LONG. C1221 LF WHEEL SPEED SENSOR INPUT SIGNAL IS 0. C1222 RF WHEEL SPEED SENSOR INPUT SIGNAL IS 0. C1223 LR WHEEL SPEED SENSOR INPUT SIGNAL IS 0. C1224 RIGHT REAR WHEEL SPEED SENSOR INPUT SIGNAL = 0. C1225 LEFT FRONT EXCESSIVE WHEEL SPEED SENSOR VARIATION. C1226 RIGHT FRONT EXCESSIVE WHEEL SPEED SENSOR VARIATION. C1232 LEFT FRONT WHEEL SPEED SENSOR CIRCUIT IS OPEN OR SHORTED. C1233 RIGHT FRONT WHEEL SPEED SENSOR CIRCUIT IS OPEN OR SHORTED. *TR
I HAVE A 2002 CHEVROLET IMPALA WITH THE ABS/TRACTION CONTROL WARNING LAMP ON PROBLEM. THIS PROBLEM CAN BE INTERMITTENT. THE CAR HAS APPROXIMATELY 98,764 MILES ON IT. THE PROBLEM WAS FIRST NOTICED AT ABOUT 89,000 MILES. THERE IS AN ASSORTED AMOUNT OF SYMPTOMS THAT GO ALONG WITH THIS ISSUE. THIS PROBLEM IS DANGEROUS AND COULD…
Read full complaint
I HAVE A 2002 CHEVROLET IMPALA WITH THE ABS/TRACTION CONTROL WARNING LAMP ON PROBLEM. THIS PROBLEM CAN BE INTERMITTENT. THE CAR HAS APPROXIMATELY 98,764 MILES ON IT. THE PROBLEM WAS FIRST NOTICED AT ABOUT 89,000 MILES. THERE IS AN ASSORTED AMOUNT OF SYMPTOMS THAT GO ALONG WITH THIS ISSUE. THIS PROBLEM IS DANGEROUS AND COULD POSSIBLY RESULT IN AN ACCIDENT. HERE ARE THE SYMPTOMS YOU MAY EXPERIENCE YOU MAY HAVE ONE OR MORE OF THE FOLLOWING SYMPTOMS: 1. AFTER START UP (WITHOUT THE BRAKE PEDAL DEPRESSED) THE ABS/TRACTION LAMP MAY OR MAY NOT COME ON. THIS IS TEMPERATURE DEPENDENT COLD START OR HOT RESTART (IT SEEMS TO OCCUR MORE FREQUENTLY AT THE BOTH EXTREMES). 2. THE ABS BRAKES MAY CYCLE ON JUST DURING NORMAL BRAKING. THIS MAY CAUSE THE VEHICLE TO UNEXPECTEDLY PULL TO THE RIGHT. 3. THE ABS BRAKES MAY CYCLE ON WHILE MAKING A SLOW RIGHT HAND TURN WITH THE BRAKES APPLIED LIGHTLY. 4. THE ABS BRAKES MAY CYCLE ON WHEN TRAVELING ON A STRAIGHT ROADWAY AT ABOUT 40 MPH AND THEN COMING TO A SLOW STOP WITH THE BRAKE PEDAL LIGHTLY APPLIED. 5. THE ABS/TRACTION CONTROL LAMP MAY COME ON WHILE TRAVELING IN LIGHT AND HEAVY RAIN. THIS MAY ALSO OCCUR AFTER RUNNING THE CAR THOUGH AN AUTOMATIC CAR WASH. IT SHOULD BE NOTED THAT YOU MAY HEAR THE ABS PUMP MOTOR CYCLE A NUMBER OF TIMES (USUALLY 3) BEFORE THE INDICATOR LAMPS COME ON. TECHNICAL INFORMATION: THE FOLLOWING FAILURE CODES MAY BE STORED IN THE EBCM SEE BELOW: C1216 ELECTRONIC BRAKE CONTROL MODULE COMMANDED PRESSURE RELEASE IS TO LONG. C1221 LF WHEEL SPEED SENSOR INPUT SIGNAL IS 0. C1222 RF WHEEL SPEED SENSOR INPUT SIGNAL IS 0. C1223 LR WHEEL SPEED SENSOR INPUT SIGNAL IS 0. C1224 RIGHT REAR WHEEL SPEED SENSOR INPUT SIGNAL = 0. C1225 LEFT FRONT EXCESSIVE WHEEL SPEED SENSOR VARIATION. C1226 RIGHT FRONT EXCESSIVE WHEEL SPEED SENSOR VARIATION. C1232 LEFT FRONT WHEEL SPEED SENSOR CIRCUIT IS OPEN OR SHORTED. C1233 RIGHT FRONT WHEEL SPEED SENSOR CIRCUIT IS OPEN OR SHORTED. *TR
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE DEALER CHANGED THE BCM MODULE; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE DEALER THEN REPLACED THE BCM MODULE AGAIN. APPROXIMATELY SIX MONTHS LATER THE FAILURE OCCURRED AGAIN. AS A RESULT, THE POWER WINDOWS WERE INOPERABL…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE DEALER CHANGED THE BCM MODULE; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE DEALER THEN REPLACED THE BCM MODULE AGAIN. APPROXIMATELY SIX MONTHS LATER THE FAILURE OCCURRED AGAIN. AS A RESULT, THE POWER WINDOWS WERE INOPERABLE. THE MECHANIC STATED THAT AN ELECTRICAL SHORT CAUSED THE FAILURE. THEY REPLACED THE WIRES HOWEVER APPROXIMATELY ONE MONTH LATER THE FAILURE OCCURRED AGAIN. AS OF APRIL 14, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 10,000 AND CURRENT MILEAGE WAS 121,000.
CAR HAS APPROXIMATELY 50,000 MILES. THE STEERING SHAFT WAS SERVICED UNDER WARRANTY. THE STEERING BEGAN TO SQUEAL WHEN TURNING AND NOW THERE IS A CLUNKING NOISE. THERE IS NO SLACK IN THE STEERING. A TIE ROD END WAS REPLACED ALSO WHEN THE STEERING SHAFT WAS SERVICE. THE SERVICE MANAGER STATED THAT THERE WAS A TECH BULLETIN ON THE …
Read full complaint
CAR HAS APPROXIMATELY 50,000 MILES. THE STEERING SHAFT WAS SERVICED UNDER WARRANTY. THE STEERING BEGAN TO SQUEAL WHEN TURNING AND NOW THERE IS A CLUNKING NOISE. THERE IS NO SLACK IN THE STEERING. A TIE ROD END WAS REPLACED ALSO WHEN THE STEERING SHAFT WAS SERVICE. THE SERVICE MANAGER STATED THAT THERE WAS A TECH BULLETIN ON THE SHAFT BUT NO RECALL. THIS PROBLEM DEFINITELY SHOULD BE RECALLED. STEERING FAILURE IS A POSSIBILITY. *TR
WE HIT A HORSE WITH OUR CAR AND THE AIR BAGS DID NOT DEPLOY. WE RECEIVED CUTS ON OUR HEAD, FACE, HANDS, AND LEGS. I RECEIVED A BLOW TO MY HEAD CAUSING SWELLING AND BRUISING TO MY FOREHEAD, EYES, NOSE, CHEEKS. EXPERIENCING HEADACHES AND DIZZINESS SINCE THEN. LARGE BRUISES AND SWELLING ON MY THIGHS FROM THE STEERING WHEEL. *T…
Read full complaint
WE HIT A HORSE WITH OUR CAR AND THE AIR BAGS DID NOT DEPLOY. WE RECEIVED CUTS ON OUR HEAD, FACE, HANDS, AND LEGS. I RECEIVED A BLOW TO MY HEAD CAUSING SWELLING AND BRUISING TO MY FOREHEAD, EYES, NOSE, CHEEKS. EXPERIENCING HEADACHES AND DIZZINESS SINCE THEN. LARGE BRUISES AND SWELLING ON MY THIGHS FROM THE STEERING WHEEL. *TR
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE STEERING MAKES A CLUNKING NOISE. THE VEHICLE WAS TAKEN TO A MECHANIC AND THE DIAGNOSIS WAS THAT THE STEERING COLUMN ROD NEEDED TO BE REPLACED. ON APRIL 2, 2008, THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION PRIOR TO A ROAD TRIP. AT THAT TIME, THE CONTACT WAS INFORMED THAT…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE STEERING MAKES A CLUNKING NOISE. THE VEHICLE WAS TAKEN TO A MECHANIC AND THE DIAGNOSIS WAS THAT THE STEERING COLUMN ROD NEEDED TO BE REPLACED. ON APRIL 2, 2008, THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION PRIOR TO A ROAD TRIP. AT THAT TIME, THE CONTACT WAS INFORMED THAT THE STEERING COLUMN ROD WAS GOING TO NEED REPLACING AGAIN SOON. HE BELIEVES THAT THIS IS A MANUFACTURER DEFECT, IN WHICH THEY SHOULD REPAIR. THE CURRENT MILEAGE WAS 71,000 AND FAILURE MILEAGE WAS 59,926. UPDATED 04/22/08. *LJ THE STEERING SHAFT WAS LUBRICATED. UPDATED
INTAKE/HEAD GASKET FAILURE. LEAKING COOLANT IS DUE TO A KNOWN DEFECTIVE GASKET. IN FACT A CLASS ACTION LAWSUIT HAS BEEN FILED BUT IS INSUFFICIENT TO REPAY COST OF REPAIR. THIS SHOULD BE CONSIDERED A RECALL ITEM. IT IS WELL DOCUMENTED AMONG WEB-BASED AUTOMOTIVE COMPLAINT FORUMS THAT THIS IS A PROBLEM MOST IF NOT ALL OWNERS EXPERI…
Read full complaint
INTAKE/HEAD GASKET FAILURE. LEAKING COOLANT IS DUE TO A KNOWN DEFECTIVE GASKET. IN FACT A CLASS ACTION LAWSUIT HAS BEEN FILED BUT IS INSUFFICIENT TO REPAY COST OF REPAIR. THIS SHOULD BE CONSIDERED A RECALL ITEM. IT IS WELL DOCUMENTED AMONG WEB-BASED AUTOMOTIVE COMPLAINT FORUMS THAT THIS IS A PROBLEM MOST IF NOT ALL OWNERS EXPERIENCE....2002 CHEVROLET IMPALA..... *TR
VARIOUS ENGINE FAILURES DUE TO DEX COOL COOLANT SYSTEM. ENGINE REBUILT. GASKETS. ETC NEW PARTS INSTALLED IN EACH INSTANCE. *TR
Official recalls
415V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
02V222000 · Air Bags:frontal
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.