NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
795 reports100,000 miles · Dec 5, 2008
Suspension
I HAVE A 2002 CHEVY IMPALA. I HAVE SO MANY PROBLEMS WITH IS CAR SINCE THE MOMENT I DROVE IT OFF THE LOT. IN MY OPINION, THE WHOLE CAR SHOULD BE RECALLED. BUT, I AM ONLY GOING TO FILE A COMPLAINT ON MY CURRENT ISSUE. THIS IS THE SECOND TIME THIS HAS HAPPENED TO MY CAR. ABOUT A YEAR AGO, I STARTING HEARING A ROARING SOUND COM…
Read full complaint
I HAVE A 2002 CHEVY IMPALA. I HAVE SO MANY PROBLEMS WITH IS CAR SINCE THE MOMENT I DROVE IT OFF THE LOT. IN MY OPINION, THE WHOLE CAR SHOULD BE RECALLED. BUT, I AM ONLY GOING TO FILE A COMPLAINT ON MY CURRENT ISSUE. THIS IS THE SECOND TIME THIS HAS HAPPENED TO MY CAR. ABOUT A YEAR AGO, I STARTING HEARING A ROARING SOUND COMING FROM THE FRONT OF MY CAR WHEN I DROVE DOWN THE ROAD. IT WAS REALLY STRANGE BECAUSE IT SOUNDED LIKE THE ENGINE, BUT THE NOISE WAS NOT CAUSE FROM PUSHING THE GAS, JUST THE TIRES DRIVING DOWN THE ROAD. I TOOK IT TO A LOCAL AUTOMOTIVE CENTER. THEY INFORMED ME THAT IT WAS THE HUB BEARING LOCATED NEAR MY TIRE. THEY TOLD ME IT WAS SO BAD THAT MY TIRE WOULD HAVE FALLEN OFF WHILE DRIVING, WHICH COULD HAVE A CAUSED AN ACCIDENT. THEY FIXED IT, CHARGING ME $350. NOW, LAST MONTH (NOV 08), I STARTED HEARING THAT SAME NOISE. I ALREADY KNOW THAT IT'S THE SAME PROBLEM, BUT UNSURE IF ITS COMING FROM THE SAME SIDE OR NOT. IT IS SO BAD THAT WHEN I AM GOING AROUND A CURVE WHILE DRIVING, THE WHOLE CAR SHAKES AND RATTLES. I CANNOT AFFORD TO GET THIS FIXED AGAIN. I HAVE CHILDREN AND AM VERY CONCERNED FOR OUR SAFETY. I JUST THINK THAT THIS IS A VERY SERIOUS PROBLEM AND COULD BE DANGEROUS. I DO THINK THAT CHEVY SHOULD RECALL THIS. *TR
NHTSA ODI #10250842
189,000 miles · Nov 24, 2008
Air Bags
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE APPROACHING A STOP LIGHT AT 5 MPH, THE AIR BAGS DEPLOYED. THE WINDSHIELD WAS DAMAGED, BUT THE VEHICLE WAS STILL ABLE TO BE DRIVEN. GENERAL MOTORS INSPECTED THE VEHICLE, BUT WOULD NOT PROVIDE AN EXPLANATION OF WHAT CAUSED THE FAILURE. THE VEHICLE HAS NOT YET BEEN REPAIRED. T…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE APPROACHING A STOP LIGHT AT 5 MPH, THE AIR BAGS DEPLOYED. THE WINDSHIELD WAS DAMAGED, BUT THE VEHICLE WAS STILL ABLE TO BE DRIVEN. GENERAL MOTORS INSPECTED THE VEHICLE, BUT WOULD NOT PROVIDE AN EXPLANATION OF WHAT CAUSED THE FAILURE. THE VEHICLE HAS NOT YET BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 189,000.
NHTSA ODI #10249680
25,000 miles · Nov 18, 2008
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKE PEDAL WOULD PULSATE AND THE STEERING COLUMN TURNED SLIGHTLY TO THE LEFT AND RIGHT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE ROTORS WERE WARPED AND NEEDED TO BE TURNED. THE VEHICLE …
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 25 MPH, THE BRAKE PEDAL WOULD PULSATE AND THE STEERING COLUMN TURNED SLIGHTLY TO THE LEFT AND RIGHT WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE ROTORS WERE WARPED AND NEEDED TO BE TURNED. THE VEHICLE WAS REPAIRED. APPROXIMATELY SEVEN MONTHS LATER, THE ROTORS HAD TO BE TURNED AGAIN. THE FAILURE HAS PERSISTED FOR THE PAST THREE YEARS. THE VEHICLE HAS NOT BEEN REPAIRED SINCE AUGUST OF 2008. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS RELATED TO HIS VIN; THEREFORE, THEY WERE NOT LIABLE FOR THE REPAIRS. THE CURRENT MILEAGE WAS 97,000 AND FAILURE MILEAGE WAS 25,000.
NHTSA ODI #10249152
5,000 miles · Nov 14, 2008
Steering
HAVE A CLUNKING SOUND WITH STEERING. HAVE READ ON THE INTERNET THAT AT TIMES THIS PROBLEM HAS CAUSED A LOCK UP AND COULD NOT STEER THE CAR. I HAVE NOT RECEIVED A RECALL NOTICE ON THIS PROBLEM AND GM KNOWS ABOUT IT. THERE IS A TSB #01023200 ON THE CAR. DON'T KNOW WHAT TO DO THE CAR HAS 38,000 MILES ON IT AND HAS DONE THIS SI…
Read full complaint
HAVE A CLUNKING SOUND WITH STEERING. HAVE READ ON THE INTERNET THAT AT TIMES THIS PROBLEM HAS CAUSED A LOCK UP AND COULD NOT STEER THE CAR. I HAVE NOT RECEIVED A RECALL NOTICE ON THIS PROBLEM AND GM KNOWS ABOUT IT. THERE IS A TSB #01023200 ON THE CAR. DON'T KNOW WHAT TO DO THE CAR HAS 38,000 MILES ON IT AND HAS DONE THIS SINCE IT WAS NEW. JIMMI
NHTSA ODI #10248805
106,000 miles · Nov 10, 2008
Engine And Engine CoolingService Brakes, Hydraulic
2002 CHEVROLET IMPALA I HAVE A 50 / 50 CHANCE OF GETTING THIS JUNK TO START. I HAVE TALKED TO THE DEALER AND ALL THEY WANT TO DO IS REPLACE THE BCM AND THE IGNITION, BUT JUDGING FROM THE OTHER COMPLAINTS ON THIS MODEL WHY SPEND THE MONEY IF IT IS NOT GOING TO FIX THE PROBLEM. SOME ONE SOME WHERE MUST KNOW HOW TO FIX IT, IT CAN'…
Read full complaint
2002 CHEVROLET IMPALA I HAVE A 50 / 50 CHANCE OF GETTING THIS JUNK TO START. I HAVE TALKED TO THE DEALER AND ALL THEY WANT TO DO IS REPLACE THE BCM AND THE IGNITION, BUT JUDGING FROM THE OTHER COMPLAINTS ON THIS MODEL WHY SPEND THE MONEY IF IT IS NOT GOING TO FIX THE PROBLEM. SOME ONE SOME WHERE MUST KNOW HOW TO FIX IT, IT CAN'T BE THAT DIFFICULT. WHAT I HAVE BEEN DOING TO GET IT STARTED IS LEAVE THE KEY ON THE ON POSITION FOR A FULL TEN MINUTES UNTIL THE SECURITY LIGHT STOPS FLASHING 3 TIMES. IF YOU TRY AND START IT TO SOON YOU HAVE TO WAIT ANOTHER TEN MINUTES, THE GREAT PART ABOUT ALL THIS IS GM WANTS THE GOVERNMENT TO BAIL THEM OUT BECAUSE THEY ARE LOOSING MONEY, I WISH GM WOULD HELP BAIL ME OUT OF THIS PIECE OF JUNK, I'M LOSING MONEY TRYING TO KEEP THIS THING GOING. *TR
NHTSA ODI #10248372
40,281 miles · Oct 30, 2008
Service Brakes, Hydraulic
TRACTION CONTROL PANEL WOULD LIGHT UP WHEN THERE WASN'T ANY SNOW. A FEW MONTHS LATER THE WARNING WOULD BE TO "SERVICE TRACTION CONTROL", WOULD SHUT DOWN THE ABS. CAR WAS SERVICED, BAD WHEEL BEARING. COST $427.00. *TR
NHTSA ODI #10247262
77,000 miles · Oct 30, 2008
Electrical SystemExterior Lighting
WHEN DRIVING AT NIGHT AND USING THE "HIGH BEAMS," THEY GO OUT AFTER AWHILE. NEARLY CRASHED UNTIL I COULD SLOW DOWN ENOUGH TO SAFELY STOP! BY MOVING HIGH/LOW BEAM LEVER, I WAS ABLE TO GET HEADLIGHTS TO COME BACK ON IN THE LOW BEAM POSITION. IN CHECKING NHTSA WEB SITE, FOUND THIS IS A PROBLEM GENERAL MOTORS IS AWARE OF BUT EXPE…
Read full complaint
WHEN DRIVING AT NIGHT AND USING THE "HIGH BEAMS," THEY GO OUT AFTER AWHILE. NEARLY CRASHED UNTIL I COULD SLOW DOWN ENOUGH TO SAFELY STOP! BY MOVING HIGH/LOW BEAM LEVER, I WAS ABLE TO GET HEADLIGHTS TO COME BACK ON IN THE LOW BEAM POSITION. IN CHECKING NHTSA WEB SITE, FOUND THIS IS A PROBLEM GENERAL MOTORS IS AWARE OF BUT EXPECTS OWNERS TO PAY FOR REPAIR OF POORLY DESIGNED PART. *TR
NHTSA ODI #10247208
60,303 miles · Oct 7, 2008
Visibility
MY WINDOW REGULATOR KEEPS SNAPPING. THIS IS THE SECOND ONE THAT I PURCHASE IN ONE YEAR AT THE COST OF $300.00 EACH TIME TO REPAIR. THE REPAIRMAN SAID THAT HE BELIEVE THAT THE WINDOW IS TO HEAVY FOR IT. EACH TIME I GET IT REPAIRED, THEY SAID THAT THEY GET A LOT OF THEM TO FIX. *TR
NHTSA ODI #10244658
87,000 miles · Sep 29, 2008
Structure
I HAVE A 2003 CHEVY IMPALA AND IT IS A MAINTENANCE NIGHTMARE. THE LATEST ISSUE IS I HAVE FOUND A LARGE PUDDLE OF WATER ON THE PASSENGERS SIDE AFTER THE RAIN. A GOOGLE SEARCH SHOWS OTHERS ARE HAVING THE TROUBLE WITH VARIOUS YEARS. I AM TOLD THIS IS A COMMON PROBLEM WITH IMPALA'S AND IS REALLY UNACCEPTABLE. BESIDES HAVING TO R…
Read full complaint
I HAVE A 2003 CHEVY IMPALA AND IT IS A MAINTENANCE NIGHTMARE. THE LATEST ISSUE IS I HAVE FOUND A LARGE PUDDLE OF WATER ON THE PASSENGERS SIDE AFTER THE RAIN. A GOOGLE SEARCH SHOWS OTHERS ARE HAVING THE TROUBLE WITH VARIOUS YEARS. I AM TOLD THIS IS A COMMON PROBLEM WITH IMPALA'S AND IS REALLY UNACCEPTABLE. BESIDES HAVING TO REPLACE ALL THE HUBS, THE CAR LITERALLY ATE TIRES FOR THE FIRST 2 YEARS I OWNED IT BUT HAVE FOUND TIRES THAT LAST MORE THEN 4000 MILES AND LAST THE PAINT IS NOT STAYING ON THE CAR. I CANNOT FIND ANY RECALLS AND I KNOW SEVERAL TRUCKS THAT THE PAINT IS PEALING OFF AND THE OWNERS ARE TOLD TO BAD BY THE DEALER. I HOPE THERE ARE LOTS OF PEOPLE ARE COMPLAINING SO A RECALL CAN BE DONE. I COULD LITERALLY SWIM IN THE WATER FROM THE RAIN THAT CAME IN. OH ALMOST FORGOT THE DRIVERS SIDE POWER WINDOW IS RANDOMLY WORKING AS WELL. *TR
NHTSA ODI #10243935
32,301 miles · Sep 26, 2008
Electrical SystemSteering
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT ATTEMPTED TO EXIT HIS VEHICLE, BUT WAS LOCKED INSIDE THE PASSENGER COMPARTMENT. THE RADIO DISPLAYED "LOCKED" AND HE COULD NOT EXIT THE VEHICLE THROUGH THE DOORS NOR THE WINDOWS BECAUSE THE ELECTRICAL SYSTEM FAILED. THE REPRESENTATIVE AT THE DEALER STATED THAT HE OWNED T…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT ATTEMPTED TO EXIT HIS VEHICLE, BUT WAS LOCKED INSIDE THE PASSENGER COMPARTMENT. THE RADIO DISPLAYED "LOCKED" AND HE COULD NOT EXIT THE VEHICLE THROUGH THE DOORS NOR THE WINDOWS BECAUSE THE ELECTRICAL SYSTEM FAILED. THE REPRESENTATIVE AT THE DEALER STATED THAT HE OWNED THE SAME YEAR, MAKE, AND MODEL VEHICLE AND HAD EXPERIENCED THE SAME FAILURES. THE DEALER DIAGNOSED THE VEHICLE WITH AN ELECTRICAL SYSTEM DEFECT AND REPAIRED IT AT THE ESTIMATED COST OF OVER $1,400. THE FAILURE PERSISTED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER. THEY REPLACED THE KEY SWITCH AT THE COST OF $492.13 THE FAILURE MILEAGE WAS 32,301 AND CURRENT MILEAGE WAS 32,328. UPDATED 020209 *BF THE WINDOWS WOULD NOT ROLL DOWN. UPDATED 02/03/09. *JB SEVERAL COMPONENTS WITHIN THE ELECTRICAL SYSTEM WERE REPLACED AND THE SECURITY LIGHT ILLUMINATED TWICE. UPDATED 02/20/09. *JB THE CONSUMER WAS INFORMED AN INTERMEDIATE SHAFT WAS NEEDED AT A COST OF $300.00. WHEN THE STEERING WHEEL WAS TURNED, IT MADE STRANGE NOISES AS IF IT WERE ABOUT TO BREAK. UPDATED 0423/10.*JB UPDATED 04/29/10.*JB
NHTSA ODI #10243526
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration