NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
795 reports24,000 miles · Jun 10, 2009
Electrical System
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE HAS A PASS LOCK FAILURE, WHICH IS A SECURITY ISSUE. AS A RESULT, THE VEHICLE THINKS IT IS BEING STOLEN AND WILL NOT START. THE VEHICLE WAS REPAIRED TWICE BY THE DEALER. THERE ARE NO RECALLS FOR THIS FAILURE. THE FAILURE MILEAGE WAS 24,000 AND …
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE HAS A PASS LOCK FAILURE, WHICH IS A SECURITY ISSUE. AS A RESULT, THE VEHICLE THINKS IT IS BEING STOLEN AND WILL NOT START. THE VEHICLE WAS REPAIRED TWICE BY THE DEALER. THERE ARE NO RECALLS FOR THIS FAILURE. THE FAILURE MILEAGE WAS 24,000 AND CURRENT MILEAGE WAS 64,000. UPDATED 06/24/09. *LJ THE CONSUMER STATED THE LEAST CHEVROLET COULD IS FIX THE PROBLEM IF THEY ARE NOT GOING TO ISSUE A RECALL. UPDATED 06/26/09. *JB
NHTSA ODI #10273486
Mileage unknown · Jun 10, 2009
Electrical SystemFire
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING BETWEEN 65-70 MPH WITH THE RADIO AND AIR CONDITIONING ACTIVATED, THE FRONT PASSENGER FLOOR PANEL AREA IGNITED INTO FLAMES WITHOUT WARNING. THERE WERE NO INJURIES. THE PASSENGER EXTINGUISHED THE FLAMES AND THE FIRE DEPARTMENT WAS NOT CALLED TO THE SCENE. THE DASHBOARD…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING BETWEEN 65-70 MPH WITH THE RADIO AND AIR CONDITIONING ACTIVATED, THE FRONT PASSENGER FLOOR PANEL AREA IGNITED INTO FLAMES WITHOUT WARNING. THERE WERE NO INJURIES. THE PASSENGER EXTINGUISHED THE FLAMES AND THE FIRE DEPARTMENT WAS NOT CALLED TO THE SCENE. THE DASHBOARD AND CARPET SUSTAINED MINOR FIRE DAMAGE. THE VEHICLE WAS ABLE TO BE DRIVEN. THE FOLLOWING DAY, THE VEHICLE FAILED TO START. THE VEHICLE IS CURRENTLY INOPERABLE AND HAS NOT BEEN REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 09V116000 (ENGINE AND ENGINE COOLING). THE FAILURE AND CURRENT MILEAGES WERE UNAVAILABLE.
NHTSA ODI #10273480
47,000 miles · Jun 10, 2009
Fuel System, Gasoline
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHEN THE VEHICLE IS TRAVELING OR ACCELERATING FROM A STOP, THE VEHICLE JERKS. THE JERKING STOPS WHEN THE ACCELERATOR PEDAL IS RELEASED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND THEY FOUND NO FAILURES. A MECHANIC STATED THAT THERE WAS A LOW FUEL SURGE AND ADVI…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHEN THE VEHICLE IS TRAVELING OR ACCELERATING FROM A STOP, THE VEHICLE JERKS. THE JERKING STOPS WHEN THE ACCELERATOR PEDAL IS RELEASED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND THEY FOUND NO FAILURES. A MECHANIC STATED THAT THERE WAS A LOW FUEL SURGE AND ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER. THE DEALER STATED THAT THE DIAGNOSTIC WOULD COST $90 AND THERE WERE NO RECALLS AVAILABLE. THE FAILURE MILEAGE WAS 47,000 AND CURRENT MILEAGE WAS 58,000. UPDATED 062909 *BF UPDATED 07/01/09.*JB
NHTSA ODI #10273457
115,000 miles · Jun 8, 2009
Electrical SystemExterior LightingFuel System, Gasoline
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT WHEN SHE TURNS THE IGNITION, IT DOES NOT RECOGNIZE THE KEY. SHE HAS TO WAIT 10-15 MINUTES TO TURN THE IGNITION AGAIN BEFORE THE VEHICLE STARTS NORMALLY. THE FAILURE HAS BEEN OCCURRING FOR APPROXIMATELY SEVEN MONTHS. IN ADDITION, THE HEADLIGHTS AND INSTRUMEN…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT WHEN SHE TURNS THE IGNITION, IT DOES NOT RECOGNIZE THE KEY. SHE HAS TO WAIT 10-15 MINUTES TO TURN THE IGNITION AGAIN BEFORE THE VEHICLE STARTS NORMALLY. THE FAILURE HAS BEEN OCCURRING FOR APPROXIMATELY SEVEN MONTHS. IN ADDITION, THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTS FLICKER WHILE THE VEHICLE IS IN MOTION. THE SECURITY LIGHT ALSO ILLUMINATES IN THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO STATED THAT THE FUEL PUMP NEEDED TO BE REPAIRED. THE RELAY SWITCHES RUN THROUGH THE FUEL PUMP. TWO NEW RELAY SWITCHES WERE INSTALLED AT THE CONTACT'S EXPENSE. THE DEALER STATED THAT THERE WERE NOT ENOUGH COMPLAINTS TO ISSUE A RECALL FOR THIS ISSUE. THE FAILURE MILEAGE WAS 115,000 AND CURRENT MILEAGE WAS 126,651.
NHTSA ODI #10273151
140,000 miles · Jun 8, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNED A 2002 CHEVROLET IMPALA. ON MARCH 10, 2009, THE VEHICLE CAUGHT FIRE AND WAS DESTROYED. A POLICE REPORT WAS FILED. GM ADVISED THE CONTACT TO CALL HIS INSURANCE COMPANY BECAUSE THE MANUFACTURER WOULD NOT BE RESPONSIBLE FOR THE DAMAGES. RECENTLY, THE CONTACT RECEIVED A RECALL NOTICE FOR GM RECALL NUMBER 900…
Read full complaint
TL*THE CONTACT OWNED A 2002 CHEVROLET IMPALA. ON MARCH 10, 2009, THE VEHICLE CAUGHT FIRE AND WAS DESTROYED. A POLICE REPORT WAS FILED. GM ADVISED THE CONTACT TO CALL HIS INSURANCE COMPANY BECAUSE THE MANUFACTURER WOULD NOT BE RESPONSIBLE FOR THE DAMAGES. RECENTLY, THE CONTACT RECEIVED A RECALL NOTICE FOR GM RECALL NUMBER 90047, WHICH STATED THAT THE VEHICLE COULD CATCH FIRE. THE MANUFACTURER STATED THAT THEY COULD NOT ASSIST. THERE WERE NO INJURIES. THE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10273134
Mileage unknown · Jun 8, 2009
Exterior Lighting
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE HEADLIGHTS FOG UP. THE DEALER CHARGED $300 TO REMEDY THE ISSUE, BUT THE FAILURE RECURRED. THERE WERE WARNING LIGHTS ON THE INSTRUMENT PANEL THAT REMAINED ILLUMINATED FOR A YEAR; HOWEVER, THE WARNING LIGHT FOR THE HEADLIGHTS REMAINED DIM. THE CURRENT MIL…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE HEADLIGHTS FOG UP. THE DEALER CHARGED $300 TO REMEDY THE ISSUE, BUT THE FAILURE RECURRED. THERE WERE WARNING LIGHTS ON THE INSTRUMENT PANEL THAT REMAINED ILLUMINATED FOR A YEAR; HOWEVER, THE WARNING LIGHT FOR THE HEADLIGHTS REMAINED DIM. THE CURRENT MILEAGE WAS 45,000 AND THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10273120
35,000 miles · Jun 4, 2009
Electrical SystemFire
2002 CHEVROLET IMPALA LS/ 3.8-V6 THE PROBLEM STARTED WITH THE IGNITION SWITCH. IT CAUGHT ON FIRE. TOOK IN TO DEALER, AFTER IT WAS REPLACED, ANOTHER PROBLEM SURFACED.. WE KEEP GETTING THE RUN AROUND AT THE DEALER..THE CAR INTERMITTENTLY STARTS. WHEN IT WANTS TO. THE DEALER THAT I BROUGHT IT TO SAID HE WAS 80% SURE THAT IT WAS MY …
Read full complaint
2002 CHEVROLET IMPALA LS/ 3.8-V6 THE PROBLEM STARTED WITH THE IGNITION SWITCH. IT CAUGHT ON FIRE. TOOK IN TO DEALER, AFTER IT WAS REPLACED, ANOTHER PROBLEM SURFACED.. WE KEEP GETTING THE RUN AROUND AT THE DEALER..THE CAR INTERMITTENTLY STARTS. WHEN IT WANTS TO. THE DEALER THAT I BROUGHT IT TO SAID HE WAS 80% SURE THAT IT WAS MY BCM (BODY CONTROL MODULES) AND HE WOULD HAVE TO RESET MY RADIO. THE TWO REPAIRS WOULD RUN ME ABOUT $1,200 AND THAT ISN'T EVEN 100% GUARANTEED THAT IT WOULD REMEDY THE PROBLEM. WHAT A WAY TO CONDUCT BUSINESS. I CAN'T BELIEVE THERE ARE NO SERVICE BULLETINS ON THIS.. IN DOING SOME RESEARCH I SEE THE PROBLEM IS QUITE FAMILIAR ON MODELS OF THE SAME PLATFORM.. I'M AT MY WITS END WITH THIS PROBLEM.. THE CAR DOES FINALLY START AFTER SITTING THERE FOR 10 MIN OR SO.. MY ISSUE WITH THIS IS! I'M HAPPY TO PAY IF THE PROBLEM WENT AWAY BUT NON OF THE G.M DEALERS I'VE CONTACTED SEEM TO BE UPFRONT REGARDING THE MATTER, AND I QUOTE "BRING IT IN WE'LL TAKE A LOOK AT IT" THAT'S IT! HOW ABOUT FIXING IT? I REPLY.. "WELL WE DON'T KNOW WHAT'S WRONG WITH IT".. THE CAR DOES NOT DO IT ALL THE TIME, BUT A LOT OF THE TIME.. USUALLY AT THE MOST INOPPORTUNE TIME. THE PROBLEM DOES NOT SEEM TO BE A NEW ONE IT'S HAPPENING A LOT.. I'M SURE A DESIGN FLAW. I'M JUST SCARED OF ANOTHER FIRE. *TR
NHTSA ODI #10272827
104,000 miles · May 28, 2009
Electrical System
PASSLOCK SYSTEM FAILURE ON 2002 CHEVROLET IMPALA LS. MY WIFE BECAME STRANDED LATE AT NIGHT DUE TO THE PASSLOCK SYSTEM FAILURE, VEHICLE WOULD NOT START. IT TOOK ALMOST 30 MINUTES TO EVENTUALLY GET THE CAR TO START AND IT IS NOW HAPPENING MORE FREQUENTLY. AN INTERNET SEARCH TURNED OUT LITERALLY HUNDREDS OF COMPLAINTS ABOUT THE …
Read full complaint
PASSLOCK SYSTEM FAILURE ON 2002 CHEVROLET IMPALA LS. MY WIFE BECAME STRANDED LATE AT NIGHT DUE TO THE PASSLOCK SYSTEM FAILURE, VEHICLE WOULD NOT START. IT TOOK ALMOST 30 MINUTES TO EVENTUALLY GET THE CAR TO START AND IT IS NOW HAPPENING MORE FREQUENTLY. AN INTERNET SEARCH TURNED OUT LITERALLY HUNDREDS OF COMPLAINTS ABOUT THE PROBLEM. *TR
NHTSA ODI #10270210
122,000 miles · May 26, 2009
Air BagsCrashInjury
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING 35 MPH, THE CONTACT REAR-ENDED THE PRECEDING VEHICLE. NONE OF THE AIR BAGS DEPLOYED IN HER VEHICLE. SHE BELIEVES THAT THE IMPACT WAS SEVERE ENOUGH THAT THE AIR BAGS SHOULD HAVE DEPLOYED. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE DRIVER SUSTAINED SEVERE BACK PAIN A…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING 35 MPH, THE CONTACT REAR-ENDED THE PRECEDING VEHICLE. NONE OF THE AIR BAGS DEPLOYED IN HER VEHICLE. SHE BELIEVES THAT THE IMPACT WAS SEVERE ENOUGH THAT THE AIR BAGS SHOULD HAVE DEPLOYED. THE VEHICLE WAS TOWED TO A REPAIR SHOP. THE DRIVER SUSTAINED SEVERE BACK PAIN AND A HEADACHE. SHE WAS TRANSPORTED TO THE HOSPITAL AND RELEASED THREE HOURS LATER. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 122,000.
NHTSA ODI #10269958
Mileage unknown · May 22, 2009
Electrical System
I HAVE A 2002 IMPALA. THE PROBLEM IS WITH THE ELECTRICAL SYSTEM. SPECIFICALLY, THE SECURITY LIGHT COMES ON, THE DOOR LOCK FUSE BLOWS, CLICKING NOISES FROM THE PASSENGER SIDE FUSE PANEL, AND ON MULTIPLE OCCASIONS THE STARTER WILL NOT TURN WHEN THE KEY IS PLACED IN THE "START" POSITION. THIS ISSUE CAN EASILY BE FOUND ELSEWHERE …
Read full complaint
I HAVE A 2002 IMPALA. THE PROBLEM IS WITH THE ELECTRICAL SYSTEM. SPECIFICALLY, THE SECURITY LIGHT COMES ON, THE DOOR LOCK FUSE BLOWS, CLICKING NOISES FROM THE PASSENGER SIDE FUSE PANEL, AND ON MULTIPLE OCCASIONS THE STARTER WILL NOT TURN WHEN THE KEY IS PLACED IN THE "START" POSITION. THIS ISSUE CAN EASILY BE FOUND ELSEWHERE ON THE INTERNET. WE HAVE HAD THIS CAR SINCE SEPT 2003. NO ISSUES UNTIL THE LAST 7 MONTHS. THE PROBLEM HAS BECOME MORE FREQUENT AND SOMETIMES DISCONNECTING AND RECONNECTING THE BATTERY SEVERAL TIMES FIXES THE PROBLEM. IT IS A VERY FRUSTRATING EXPERIENCE HAVING TO "REBOOT" THE BCM BY DISCONNECTING AND RECONNECTING THE BATTERY ALL OF THE TIME. MY CONCERN IS EVENTUALLY THE ELECTRICAL SYSTEM WILL COMPLETELY FAIL OR WORSE CAUSE AN ELECTRICAL FIRE. OTHERS WHO ARE DEALING WITH THE SAME ISSUE ARE SPENDING HUNDREDS OF DOLLARS IN PARTS REPLACEMENTS ONLY TO HAVE THE PROBLEM RETURN A COUPLE OF WEEKS LATER. THIS "SECURITY" PROBLEM HAS TO SOMEHOW QUALIFY AS A RECALL WITH CHEVROLET/GM. CURRENTLY, I AM STILL ABLE TO MANIPULATE THE ELECTRICAL SYSTEM IN ORDER TO GET THE CAR TO START. I'M REALLY NOT LOOKING FORWARD TO TAKING THE CAR TO THE DEALERSHIP AND BE CHARGED ENORMOUS FEES FOR PARTS AND LABOR KNOWING THAT THIS PROBLEM WILL RETURN LATER ON LIKE OTHERS HAVE EXPERIENCED. PLEASE FIND A WAY TO FORCE GM TO DO A RECALL ON THIS PROBLEM. *TR
NHTSA ODI #10269670
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration