Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
590–25K
9725–50K
10950–75K
10775–100K
130100–150K
69150K+
571 reports with mileage · 224 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 305 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports32 fire reports27 injury reports
What owners actually said
795 reports
100,000 miles · Mar 7, 2011
Exterior Lighting
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 60 MPH, THE HEADLIGHTS FAILED WITHOUT WARNING. THE FAILURE OCCURRED INTERMITTENTLY AND WHEN THE TURN SIGNAL MECHANISM WAS SLIGHTLY JOLTED THE HEADLIGHTS WOULD OPERATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY INFORMED THE CONTACT THAT THE U…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 60 MPH, THE HEADLIGHTS FAILED WITHOUT WARNING. THE FAILURE OCCURRED INTERMITTENTLY AND WHEN THE TURN SIGNAL MECHANISM WAS SLIGHTLY JOLTED THE HEADLIGHTS WOULD OPERATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY INFORMED THE CONTACT THAT THE UNIVERSAL LIGHT SWITCH WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. UPDATED 04/15/11*LJ UPDATED 11/21/11
NHTSA ODI #10386673
50,000 miles · Feb 18, 2011
Electrical System
MY 02 CHEVY IMPALA HAS ISSUES WITH THE STARTING SYSTEM. I HAVE NO KNOW ELECTRICAL PROBLEMS WITH THIS CAR EXCEPT SOMETIMES IT WILL NOT START AND HOURS OF TRYING TO START THE CAR IT STARTS. I EVEN TRIED TO SHORT OUT MY STARTER AND THAT DIDN'T WORK. IT WAS IN THE MIDDLE OF THE SUMMER AND MY INFANT CHILD GOT VERY HOT WAITING ON ME T…
Read full complaint
MY 02 CHEVY IMPALA HAS ISSUES WITH THE STARTING SYSTEM. I HAVE NO KNOW ELECTRICAL PROBLEMS WITH THIS CAR EXCEPT SOMETIMES IT WILL NOT START AND HOURS OF TRYING TO START THE CAR IT STARTS. I EVEN TRIED TO SHORT OUT MY STARTER AND THAT DIDN'T WORK. IT WAS IN THE MIDDLE OF THE SUMMER AND MY INFANT CHILD GOT VERY HOT WAITING ON ME TO START THE CAR. *LN
NHTSA ODI #10383284
115,000 miles · Feb 17, 2011
Exterior Lighting
BOTH HEADLIGHTS SHUT OFF AT NIGHT WITH NO WARNING. SOMETIMES LOW LIGHTS TURN OFF AND THEN COME BACK ON AFTER A FEW SECONDS. SOMETIMES HIGH LIGHTS SHUT OFF AND DO NOT COME BACK ON UNLESS THE LIGHTS ARE MANUALLY SWITCHED TO LOW. THIS HAPPENS AS MUCH AS ONCE A MONTH TRAVELING AT 65 MPH EVER SINCE I OWNED THE VEHICLE. THERE IS N…
Read full complaint
BOTH HEADLIGHTS SHUT OFF AT NIGHT WITH NO WARNING. SOMETIMES LOW LIGHTS TURN OFF AND THEN COME BACK ON AFTER A FEW SECONDS. SOMETIMES HIGH LIGHTS SHUT OFF AND DO NOT COME BACK ON UNLESS THE LIGHTS ARE MANUALLY SWITCHED TO LOW. THIS HAPPENS AS MUCH AS ONCE A MONTH TRAVELING AT 65 MPH EVER SINCE I OWNED THE VEHICLE. THERE IS NO INDICATION WHEN AND WHERE THIS WILL HAPPEN. IT IS JUST RANDOM. IF YOU ARE UNAWARE HOW TO GET THE LIGHTS TO COME BACK ON, THEY WILL NOT. DEALERSHIP IS AWARE OF SEVERAL OWNERS WITH THE SAME PROBLEM, BUT DOES NOT KNOW HOW TO REMEDY! *TR
NHTSA ODI #10383026
70,000 miles · Feb 14, 2011
Exterior Lighting
I OWN A 2002 CHEVROLET IMPALA LS 4D. I WOULD BE DRIVING AT NIGHT WITH THE HEADLIGHTS ON AND FOR NO REASON BOTH HEADLIGHTS WOULD TURN OFF, DRIVING DOWN THE ROAD WITHOUT ABILITY TO SEE. WHEN I THEN I THEN HIT THE HIGH/LOW DIMMER SWITCH SEVERAL TIMES WITH MY HAND THE LIGHTS WOULD RETURN. THIS WOULD OCCUR ONCE EVERY MONTH OR SO, A…
Read full complaint
I OWN A 2002 CHEVROLET IMPALA LS 4D. I WOULD BE DRIVING AT NIGHT WITH THE HEADLIGHTS ON AND FOR NO REASON BOTH HEADLIGHTS WOULD TURN OFF, DRIVING DOWN THE ROAD WITHOUT ABILITY TO SEE. WHEN I THEN I THEN HIT THE HIGH/LOW DIMMER SWITCH SEVERAL TIMES WITH MY HAND THE LIGHTS WOULD RETURN. THIS WOULD OCCUR ONCE EVERY MONTH OR SO, AND OCCURRED AT THIS APPROXIMATE FREQUENCY OF TIME FOR AS OFTEN AS I OWNED MY CAR, SINCE 2007. IT IS QUITE FRIGHTENING TO DRIVE AT NIGHT WHEN YOUR LIGHTS WOULD SUDDENLY GO OFF WITHOUT WARNING. FINALLY, LAST YEAR THE HIGH BEAM WOULD NOT CLICK ON WITH THE SWITCH APPARENTLY BEING BROKEN. MY FATHER OWNED THE SAME YEAR IMPALA, AND HE REPORTED THE SAME EXACT PROBLEM, THE LIGHTS WOULD SUDDENLY GO OUT AND HE WOULD HAVE TO HIT THE SWITCH TO HAVE THE LIGHTS RETURN ON. HE HAD HIS FIXED AND IT COST HIM IN THE NEIGHBORHOOD OF 600 DOLLARS. MY BRIGHTS ARE CURRENTLY NOT FUNCTIONING DUE TO THIS BROKEN SWITCH WITH THE COST TO FIX BEING AROUND 600 DOLLARS. I FIND IT QUITE UNUSUAL WITH THE SAME YEAR IMPALA TO HAVE THIS OCCUR, AND FIND IT EXTREMELY HAZARDOUS WHEN DRIVING AT NIGHT. *TR
NHTSA ODI #10382541
Mileage unknown · Feb 6, 2011
Electrical SystemCrash
MY CAR LEAVES ME STRANDED FOR HOURS BEFORE IT STARTS. PASSLOCK/PASSKEY II IS THE WORST THING CHEVY EVER CREATED. WHILE DRIVING THE GAUGES GO OFF AND ON; AND THE CAR SHUTS THE FUEL OFF. BEING SAID MY SISTER USED MY CAR ONE DAY AND THE FUEL SHUT OFF, THE CAR DIED, AND SHE WAS REAR ENDED. THANKFULLY IT WAS A BUMP AND SHE WASN'T SER…
Read full complaint
MY CAR LEAVES ME STRANDED FOR HOURS BEFORE IT STARTS. PASSLOCK/PASSKEY II IS THE WORST THING CHEVY EVER CREATED. WHILE DRIVING THE GAUGES GO OFF AND ON; AND THE CAR SHUTS THE FUEL OFF. BEING SAID MY SISTER USED MY CAR ONE DAY AND THE FUEL SHUT OFF, THE CAR DIED, AND SHE WAS REAR ENDED. THANKFULLY IT WAS A BUMP AND SHE WASN'T SERIOUSLY INJURED. I'M ALWAYS LATE FOR WORK AND I HAVE REPLACED THE BCM, IGNITION SWITCH, AND TUMBLER. NOTHING IS RESOLVED. I'VE BEEN HOME STRANDED FOR A WEEK, WHICH HAS CAUSED ME TO MISS SCHOOL. DUE TO THE LACK OF MONEY I AM FORCED TO WITHDRAW FROM COLLEGE AND THIS IS MY SENIOR YEAR WHICH THROWS MY OUT OF MY INTERNSHIP. CHEVY NEEDS TO RECALL THIS "PASSLOCK" FEATURE AND REIMBURSE ALL OF THE PEOPLE THEY HAVE SWINDLED. THIS IS THERE FAULT AND WE, THE CONSUMERS, SHOULD NOT HAVE TO PAY FOR IT. THIS FEATURE ALLOWS OWNERS TO NOT BE ABLE TO USE THEIR VEHICLES, AND A PROFESSIONAL THIEF CAN STEAL THE CAR. RESEARCH SHOWS THAT THOUSANDS OF CONSUMERS ARE HAVING THIS PROBLEM AND STILL NOTHING HAS BEEN DONE, AND FRANKLY, I DO NOT THINK ANYTHING EVER WILL BE. I FOR ONE WILL NEVER PURCHASE A CHEVY AGAIN. *TR
NHTSA ODI #10380912
67,000 miles · Jan 7, 2011
Engine And Engine Cooling
HEAD GASKET FAILURE. HEAD GASKETS ARE DEFECTIVE ON THE 3400 SERIES ENGINES. THE COOLANT USED IN THESE VEHICLES CAUSES PREMATURE EROSION IN THE HEAD GASKET. *TR
NHTSA ODI #10375082
72,000 miles · Jan 7, 2011
Electrical System
PASSLOCK 2 SYSTEM FAILED CAUSING THE VEHICLE TO STALL WHILE DRIVING. VEHICLE WOULD NOT START. *TR
NHTSA ODI #10375079
97,566 miles · Jan 3, 2011
Service Brakes, Hydraulic
MY ABS LIGHT STAYS ON AND HAVING AN ISSUE WITH THE BRAKES, MAKING AWFUL GRINDING NOISE WHILE DRIVING ON A STRAIGHT AWAY. DOES IT RATHER ROADS ARE WET OR DRY. THIS IS VERY DANGEROUS . I HAVE READ MANY MANY OWNERS OF THE 2002 CHEVY IMPALAS ARE HAVING THIS ISSUE. THE PROBLEM NEEDS TO BE ADDRESSED BEFORE SOMEONE GETS SERIOUSLY INJUR…
Read full complaint
MY ABS LIGHT STAYS ON AND HAVING AN ISSUE WITH THE BRAKES, MAKING AWFUL GRINDING NOISE WHILE DRIVING ON A STRAIGHT AWAY. DOES IT RATHER ROADS ARE WET OR DRY. THIS IS VERY DANGEROUS . I HAVE READ MANY MANY OWNERS OF THE 2002 CHEVY IMPALAS ARE HAVING THIS ISSUE. THE PROBLEM NEEDS TO BE ADDRESSED BEFORE SOMEONE GETS SERIOUSLY INJURED OR RESULT IN A FATALITY.
NHTSA ODI #10374388
Mileage unknown · Dec 16, 2010
Electrical SystemExterior Lighting
HEADLIGHTS SUDDENLY WENT OUT WHILE IN OPERATION. *TR
NHTSA ODI #10370874
57,000 miles · Dec 2, 2010
Electrical System
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE HAD NO POWER WHEN HE ATTEMPTED TO START IT. THE CONTACT REPLACED THE BATTERY THE FIRST TIME BUT THE REMEDY DID NOT CORRECT THE PROBLEM. THE VEHICLE WAS INSPECTED BY A MECHANIC WHO ADVISED THAT THE VEHICLE WOULD NEED A NEW BODY CONTROL MODULE. THE M…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE HAD NO POWER WHEN HE ATTEMPTED TO START IT. THE CONTACT REPLACED THE BATTERY THE FIRST TIME BUT THE REMEDY DID NOT CORRECT THE PROBLEM. THE VEHICLE WAS INSPECTED BY A MECHANIC WHO ADVISED THAT THE VEHICLE WOULD NEED A NEW BODY CONTROL MODULE. THE MECHANIC ADVISED THAT THE FAILURE WAS CAUSED BY THE MODULE BEING BURNED OUT BY THE IGNITION SWITCH. THE VEHICLE WAS NOT INSPECTED BY AN AUTHORIZED DEALER NOR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 57,000. UPDATED 02/03/11*LJ THE CONSUMER WAS TOLD TO WAIT 15 MINUTES AND THEN START THE VEHICLE. THE CONSUMER STATED HE SHOULD NO HAVE TO WAIT TO START THE VEHICLE. UPDATED 03/22/11
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration