NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
795 reports279,303 miles · Aug 6, 2020
Electrical System
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT SEVERAL ATTEMPTS WERE NEEDED TO START THE VEHICLE. THE CONTACT STATED THAT THE FAILURE WAS DUE TO THE IGNITION SWITCH. THE VEHICLE WAS TAKEN TO DENNY MENHOLT CHEVROLET (3000 KING AVE W, BILLINGS, MT 59102) ON SEVERAL OCCASIONS HOWEVER, THE VEHICLE WAS NOT REPA…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT SEVERAL ATTEMPTS WERE NEEDED TO START THE VEHICLE. THE CONTACT STATED THAT THE FAILURE WAS DUE TO THE IGNITION SWITCH. THE VEHICLE WAS TAKEN TO DENNY MENHOLT CHEVROLET (3000 KING AVE W, BILLINGS, MT 59102) ON SEVERAL OCCASIONS HOWEVER, THE VEHICLE WAS NOT REPAIRED DUE TO THE COST. THE CONTACT STATED THAT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 279,303.
NHTSA ODI #11343691
Mileage unknown · Jul 18, 2020
Exterior Lighting
HIGH BEAM SWITCH HAS BEEN BROKEN, VERY COMMON PROBLEM WHEN GOOGLE SEARCHING. NO ONE FIXES IT AS IT IS PROHIBITIVELY EXPENSIVE. CANNOT USE HIGH BEAMS AND MANY PEOPLE ADJUST THE LOW BEAMS HIGHER AS A SOLUTION, WHICH IS BAD FOR EVERYONE. SHOULD BE A RECALL?
NHTSA ODI #11340188
135,000 miles · Mar 31, 2020
EnginePower Train
SUPPOSEDLY THE COOLING SYSTEM WAS FIXED IN 2003 BUT IT STILL TELLS ME THAT MY COOLANT IS LOW AND IT LEAKS. I AM THE SECOND OWNER OF THIS CAR AND HAVE ONLY HAD IT SINCE SEPTEMBER OF 2019. ALSO THE TRANSMISSION HAS A DELAYED SHIFT FROM 1ST TO SECOND.
NHTSA ODI #11319827
Mileage unknown · Dec 16, 2019
Electrical SystemEngineFuel/propulsion System
I BOUGHT A 2002 CHEVY IMPALA AND GOT IT LOOKED AT BEFORE PURCHASE THE ONLY THING THAT POPPED UP ON THE CODE READER WAS THERE IS AN ELECTRICAL PROBLEM, SOMETIMES MY SIGNAL LIGHTS WORK SOMETIMES THEY DON'T, MY SPEEDOMETER DOESN'T LIGHT UP OR ANYTHING. I THEN START TO SMELL GAS WHEN I TURN ON THE HEAT OR AIR IT'S UNBEARABLE. I THEN…
Read full complaint
I BOUGHT A 2002 CHEVY IMPALA AND GOT IT LOOKED AT BEFORE PURCHASE THE ONLY THING THAT POPPED UP ON THE CODE READER WAS THERE IS AN ELECTRICAL PROBLEM, SOMETIMES MY SIGNAL LIGHTS WORK SOMETIMES THEY DON'T, MY SPEEDOMETER DOESN'T LIGHT UP OR ANYTHING. I THEN START TO SMELL GAS WHEN I TURN ON THE HEAT OR AIR IT'S UNBEARABLE. I THEN PROCEEDED TO CHECK FOR ANY RECALLS AND THERE ARE A FEW DEALING WITH THE ENGINE COOLING AND EXHAUST/GAS LEAK ALONG WITH ELECTRICAL ISSUES. THEY SAID THE CAR COULD CATCH ON FIRE AT ANY TIME. I HAVE TWO TODDLERS SO THERE IS NO WAY THAT THIS IS A SAFE CAR.
NHTSA ODI #11289264
19,500 miles · Aug 3, 2019
Electrical SystemEngine
TAKARA RECALL
NHTSA ODI #11241426
186,000 miles · Jul 29, 2019
EngineFire
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL ODOR OF BURNING OIL EMERGING FROM THE VEHICLE. ADDITIONALLY, THERE WAS OIL ON THE ENGINE COMPARTMENT. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO MODERN CHEVROLET (5955 UNIVERSITY P…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL ODOR OF BURNING OIL EMERGING FROM THE VEHICLE. ADDITIONALLY, THERE WAS OIL ON THE ENGINE COMPARTMENT. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO MODERN CHEVROLET (5955 UNIVERSITY PKWY, WINSTON-SALEM, NC 27105 (336) 793-5943) BUT, WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 186,000.
NHTSA ODI #11240441
Mileage unknown · Apr 13, 2019
Engine
ON APRIL 9TH OF 2017, OUR 2002 IMPALA LS WAS BROUGHT IN TO HAVE THE VEHICLE SERVICED DUE TO THIS RECALL: THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING, WHICH MAY RESULT IN AN UNDER HOOD FIRE. THIS WORK WAS DONE IN APRIL 2017: DEALERS WILL REPLACE THE EN…
Read full complaint
ON APRIL 9TH OF 2017, OUR 2002 IMPALA LS WAS BROUGHT IN TO HAVE THE VEHICLE SERVICED DUE TO THIS RECALL: THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING, WHICH MAY RESULT IN AN UNDER HOOD FIRE. THIS WORK WAS DONE IN APRIL 2017: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION. SUMMER OF 2017 WE HAD THE OIL AND FILTER REPLACED, AND AFTERWARDS LOTS OF SMOKE CAME FROM ENGINE. WE THOUGHT THE MECHANIC HAD SIMPLY SPILLED SOME OIL ON THE ENGINE. SUMMER OF 2018 OIL AND FILTER WAS CHANGED AND SMOKE FROM THE ENGINE COMPARTMENT, WE AGAIN THOUGHT THE MECHANIC HAD SPILLED SOME OIL ON THE ENGINE. IN MARCH OF 2019 THE VEHICLE WAS PARKED, FACING DOWNHILL AT AN ABOVE AVERAGE ANGLE, AND OIL BEGAN TO SEEP OUT OF THE ENGINE AND BURN OF ON THE HOT EXHAUST MANIFOLD LOTS OF SMOKE AND POTENTIAL FIRE HAZARD. THE VEHICLE WAS RETURNED TO BOB MCCOSH, WHO HAD PERFORMED THE ORIGINAL GASKET REPLACEMENT IN 2017, TO HAVE THE ORIGINAL RECALL WORK INSPECTED. UPON INSPECTION A PIECE OF GASKET, ABOUT 2 TO 3 INCHES LONG, WAS FOUND TO BE PROTRUDING FROM BETWEEN THE VALVE COVER AND THE ENGINE. UPON FURTHER INSPECTION OF THIS GASKET, THE EDGE OF THE GASKET VISUALLY APPEARED TO HAVE BEEN CAUGHT BY THE BOLT AS IT WAS TIGHTENED AND THIS EITHER TORE THE GASKET OR WEAKENED IT SUFFICIENTLY SO THAT THE GASKET FAILED. SAID GASKET IS CURRENTLY IN MY POSSESSION. WE KNOW IT FAILED BEFORE THE OIL/FILTER CHANGE IN THE SUMMER OF 2017, BECAUSE OF THE AMOUNT OF SMOKE THAT ISSUED FROM THE ENGINE COMPARTMENT AFTERWARDS. THIS RECALL REPAIR LASTED FAR LESS THAN THE 12MONTH/12,000 MILE WARRANTY. THE VEHICLE, TODAY APRIL 2019, STILL HAS LESS THAN 10,000 MILES SINCE THE ORIGINAL RECALL WORK WAS DONE IN MARCH 2017.
NHTSA ODI #11196031
196,000 miles · Apr 5, 2019
Engine
LAST YEAR I BOUGHT MY CAR FROM A PRIVATE DEALER. SINCE PURCHASING IT, MY CAR ALWAYS SEEMS TO BE RUNNING HOT. MY "CHECK ENGINE COOLANT" LIGHT USE TO COME ON SO OFTEN, I WENT OUT AND PURCHASED ANOTHER RADIATOR HOSE AND CLAMPS AND GOT THE LIGHT TO TURN OFF. HOWEVER THE ISSUE WITH MY CAR RUNNING HOT HAS NOT GONE AWAY. I'M SCARED THA…
Read full complaint
LAST YEAR I BOUGHT MY CAR FROM A PRIVATE DEALER. SINCE PURCHASING IT, MY CAR ALWAYS SEEMS TO BE RUNNING HOT. MY "CHECK ENGINE COOLANT" LIGHT USE TO COME ON SO OFTEN, I WENT OUT AND PURCHASED ANOTHER RADIATOR HOSE AND CLAMPS AND GOT THE LIGHT TO TURN OFF. HOWEVER THE ISSUE WITH MY CAR RUNNING HOT HAS NOT GONE AWAY. I'M SCARED THAT THIS IS A BIGGER ISSUE THAN COOLANT AND IT COULD CREATE A FIRE AND AFTER READING THE RECALL, I AM AFRAID TO DRIVE UNTIL THIS PROBLEM IS FIXED.
NHTSA ODI #11194205
118,000 miles · Feb 1, 2019
Electrical SystemEngineSteering
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING OIL, FUEL, AND POWER STEERING FLUID. IN ADDITION, THE VEHICLE FAILED TO START AND THE ENGINE, TRACTION CONTROL, AND POWER STEERING WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAG…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING OIL, FUEL, AND POWER STEERING FLUID. IN ADDITION, THE VEHICLE FAILED TO START AND THE ENGINE, TRACTION CONTROL, AND POWER STEERING WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V400000 (ELECTRICAL SYSTEM) AND 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL AND PROVIDED A CASE NUMBER. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.
NHTSA ODI #11173601
89,000 miles · Sep 12, 2018
SeatsStructure
THE SPRING ON THE DRIVER SEAT BROKE NOT VERY HEAVE PEAPLE DRIVING THE CAR. BODY OF THE CAR I HAVE 2 IMPALAS 2002 AND 2004 BOTH ARE RUSTING UNDER THE DOORS AND AT THE QUARTER PANELS I LOOK AT ALL IMPALAS AROUND THE AGE OF BOTH OF MINE AND 90% OF THE ARE RUSTING IN THE SAME SPOTS. MY CARS WERE RUSTPROOFED AND UNDERNEITH IT IS A …
Read full complaint
THE SPRING ON THE DRIVER SEAT BROKE NOT VERY HEAVE PEAPLE DRIVING THE CAR. BODY OF THE CAR I HAVE 2 IMPALAS 2002 AND 2004 BOTH ARE RUSTING UNDER THE DOORS AND AT THE QUARTER PANELS I LOOK AT ALL IMPALAS AROUND THE AGE OF BOTH OF MINE AND 90% OF THE ARE RUSTING IN THE SAME SPOTS. MY CARS WERE RUSTPROOFED AND UNDERNEITH IT IS A MESS YOU CANT HARDLY GET A JACK UNDER BOTH OF THEM. I KEEP THEM GARAGE KEPT SINCE WE GOT BOTH OF THE I WILL NEVER OWN A IMPALA AGAIN.
NHTSA ODI #11129184
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration