NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
75 reportsClear category filter100,000 miles · Jul 18, 2014
Electrical SystemEngineEquipment
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE INTERMITTENTLY FAILED. IN ADDITION, THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WHEN THE SERVICE ENGINE SOON WARNING LIGHT ILLUMINATED AND THE A/C SYSTEM FAILED TO ACTIVATE. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO …
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE INTERMITTENTLY FAILED. IN ADDITION, THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH WHEN THE SERVICE ENGINE SOON WARNING LIGHT ILLUMINATED AND THE A/C SYSTEM FAILED TO ACTIVATE. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CAUSE OF THE FAILURE WAS UNABLE TO BE DETERMINED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 08/27/14*LJ UPDATED 09/18/2014 *JS
NHTSA ODI #10614591
Mileage unknown · Jul 9, 2014
Engine
MODEL YEARS AFFECTED: 2000, 2001, 2002, 2003, 2004, 2005 ENGINES AFFECTED: 3.4L V6, 3.8L V6 AVERAGE MILEAGE: 108,315 MI (13,756 MI - 198,000 MI) VERIFIED THE INTAKE MANIFOLD GASKET CAN DEVELOP EXTERNAL ENGINE OIL OR COOLANT LEAKS. IN SOME CASES THE FAILED GASKET WILL LEAK COOLANT INTERNALLY. THE MANIFOLD GASKET …
Read full complaint
MODEL YEARS AFFECTED: 2000, 2001, 2002, 2003, 2004, 2005 ENGINES AFFECTED: 3.4L V6, 3.8L V6 AVERAGE MILEAGE: 108,315 MI (13,756 MI - 198,000 MI) VERIFIED THE INTAKE MANIFOLD GASKET CAN DEVELOP EXTERNAL ENGINE OIL OR COOLANT LEAKS. IN SOME CASES THE FAILED GASKET WILL LEAK COOLANT INTERNALLY. THE MANIFOLD GASKET WILL NEED TO BE REPLACED TO CORRECT THIS ISSUE. THOUSANDS OF CARS ARE AFFECTED. THESE VEHICLES NEED TO BE RECALLED AND FIXED. *TR
NHTSA ODI #10609453
235,325 miles · Jun 5, 2014
EnginePower Train
I WAS DRIVING THE VEHICLE AND WHEN I CAME TO A STOP TO PUMP GAS I LEFT THE KEYS IN THE IGNITION I PLACED THE CAR IN PARK. I TURNED AROUND TO PLACE THE PUMP INTO THE GAS GAUGE AND MY CAR WAS ROLLING DOWN THE HILL AND I HAD TO CHASE THE CAR OPEN THE DOOR AND STOP THE CAR. WHEN I GOT THE CAR TO A HALT POSITION. I TRIED TO TAKE THE …
Read full complaint
I WAS DRIVING THE VEHICLE AND WHEN I CAME TO A STOP TO PUMP GAS I LEFT THE KEYS IN THE IGNITION I PLACED THE CAR IN PARK. I TURNED AROUND TO PLACE THE PUMP INTO THE GAS GAUGE AND MY CAR WAS ROLLING DOWN THE HILL AND I HAD TO CHASE THE CAR OPEN THE DOOR AND STOP THE CAR. WHEN I GOT THE CAR TO A HALT POSITION. I TRIED TO TAKE THE KEY OUT THE IGNITION AND COULDN'T GET THE KEY OUT THE IGNITION. ONCE I WAS ABLE TO GET THE KEY, THE KEY SLOT WAS TURNED AT 3:00 POSITION AND NOT A 12:00 POSITION WHEN A KEY IS REMOVED FROM A IGNITION. AFTER THE KEY WAS REMOVED THE CAR STARTED TO ROLL AGAIN AND I HAD TO PLACE THE "EMERGENCY BRAKE" ON TO KEEP THE CAR FROM ROLLING. ONCE I TRIED TO TURN THE CAR BACK ON AFTER PUMPING THE CAR STARTED UP AND I PLACED IT IN DRIVE PRESSED THE GAS PEDAL AND CAR STALLED, I PLACED THE CAR IN REVERSE AND PRESSED THE GAS PEDAL AND THE CAR STALLED. MY CAR HAS NOT WORKED SINCE. *TR
NHTSA ODI #10596511
229,325 miles · Jun 5, 2014
EngineFuel System, Gasoline
MY GAS GAUGE STOP WORKING AND I WAS NOT ABLE TO TELL HOW MUCH GAS WAS IN THE VEHICLE. FUEL GAUGE READ INACCURATELY. I WOULD PUT GAS IN THE CAR AND FILL UP TANK AND BARELY DRIVE MORE THAN 20 MILES AND THE FUEL GAUGE WOULD INDICATE "EMPTY". I WAS TOLD BY PENSKE THAT THEY WERE UNSURE AS TO WHAT WOULD CAUSE THIS ISSUE AND THAT I WO…
Read full complaint
MY GAS GAUGE STOP WORKING AND I WAS NOT ABLE TO TELL HOW MUCH GAS WAS IN THE VEHICLE. FUEL GAUGE READ INACCURATELY. I WOULD PUT GAS IN THE CAR AND FILL UP TANK AND BARELY DRIVE MORE THAN 20 MILES AND THE FUEL GAUGE WOULD INDICATE "EMPTY". I WAS TOLD BY PENSKE THAT THEY WERE UNSURE AS TO WHAT WOULD CAUSE THIS ISSUE AND THAT I WOULDN'T BE ABLE TO GET THE ISSUED REPAIRED. I HAVE RAN OUT GAS SEVERAL TIMES SINCE THE FIRST INCIDENT. *TR
NHTSA ODI #10596510
59,000 miles · Apr 2, 2014
Engine
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, SEVERAL LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AS THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE TECHNICIAN DIAGNOSED THE PASS LOCK ASSEMBLY SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MA…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, SEVERAL LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AS THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE TECHNICIAN DIAGNOSED THE PASS LOCK ASSEMBLY SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000 AND THE CURRENT MILEAGE WAS 60,400.
NHTSA ODI #10576954
230,000 miles · Nov 18, 2013
EngineService BrakesSteering
PROBLEM WITH STARTING HAS PROGRESS TO A PROBLEM WITH THE CAR SHUTTING OFF DURING OPERATION. SEVERAL TIMES NOW THE CAR HAS SHUT DOWN WITH NO WARNING AND AT DIFFERENT SPEEDS. THIS CAUSES A LOSS OF CONTROL WITH THE POWER STEERING AND POWER BRAKES. I HAVE BEEN ABLE TO PLACE THE TRANSMISSION IN NEUTRAL AND RESTART THE CAR WHILE MOVIN…
Read full complaint
PROBLEM WITH STARTING HAS PROGRESS TO A PROBLEM WITH THE CAR SHUTTING OFF DURING OPERATION. SEVERAL TIMES NOW THE CAR HAS SHUT DOWN WITH NO WARNING AND AT DIFFERENT SPEEDS. THIS CAUSES A LOSS OF CONTROL WITH THE POWER STEERING AND POWER BRAKES. I HAVE BEEN ABLE TO PLACE THE TRANSMISSION IN NEUTRAL AND RESTART THE CAR WHILE MOVING. THE LAST TIME IT HAPPENED, I WAS MAKING A RIGHT TURN AND MERGING INTO THE FLOW OF TRAFFIC. I HAD PRESSURE ON THE STEERING WHEEL WHILE TRYING TO MAKE THE CURVE WHEN I RESTARTED THE CAR. AT THIS POINT, THE POWER STEERING KICKED IN AND I FOUND MYSELF SWERVING FROM THE SUDDEN SNATCH ON THE STEERING. WE WERE LUCKY THAT WE DIDN'T CAUSE AN ACCIDENT. IF MY WIFE HAD BEEN AT THE CONTROLS I KNOW IT WOULD HAVE TURN OUT BAD! I SEE UNLIMITED COMPLAINS AROUND THIS ITEM. DO WE HAVE TO WAIT ON PEOPLE TO GET INJURED OR KILLED BEFORE THE COMPANY IS FORCE TO BE RESPONSIBLE? IF THIS WAS A FOREIGN CAR COMPANY, THE GOVERNMENT WOULD HAVE ALREADY FORCED A RECALL. *TR
NHTSA ODI #10552694
37,207 miles · Nov 7, 2013
Electrical SystemEngine
PASSLOCK SYSTEM WOULD DISABLE THE CAR FROM STARTING DOZENS OF TIMES FOR MONTHS. I WOULD GET STUCK ANYWHERE WITHOUT WARNING FOR HALF AN HOUR OR MORE WITH MY CHILDREN. IT WAS TAKEN IN FOR A COOLANT LEAK ISSUE. THE DEXCOOL ( A HORRIBLE PRODUCT WITH LAWSUITS DUE TO ENGINE DAMAGE) HAD EATEN THE HOSES AND WAS SPRAYING AROUND THE ENGIN…
Read full complaint
PASSLOCK SYSTEM WOULD DISABLE THE CAR FROM STARTING DOZENS OF TIMES FOR MONTHS. I WOULD GET STUCK ANYWHERE WITHOUT WARNING FOR HALF AN HOUR OR MORE WITH MY CHILDREN. IT WAS TAKEN IN FOR A COOLANT LEAK ISSUE. THE DEXCOOL ( A HORRIBLE PRODUCT WITH LAWSUITS DUE TO ENGINE DAMAGE) HAD EATEN THE HOSES AND WAS SPRAYING AROUND THE ENGINE. IT CREATED A SLUDGE THAT THANKFULLY DID NOT DESTROY MY RADIATOR. THE CAR FINALLY OUTRIGHT FAILED BECAUSE OF THE SECURITY SYSTEM. THE PASSLOCK SYSTEM IS A KNOWN ISSUE WITH GM. I HAVE READ ENDLESS COMPLAINTS ABOUT THIS PROBLEM. THERE WAS NOTHING WRONG WITH THE CAR, BUT THE SYSTEM WOULD NOT READ THE KEY. IT WAS IN THE SHOP FOR WEEKS. HAD TO GET NEW BCM AND HAVE THE SYSTEM REPROGRAMMED. MY CAR ONLY HAS 37,000 MILES AND FOR IT TO FAIL AND NEED SUCH EXPENSIVE REPAIRS FOR A FAULTY SYSTEM WITH NOTHING WRONG WITH THE MECHANICS OF THE CAR IS UNREAL. ANOTHER KNOWN ISSUE IS WITH THE SIGNALS GOING OUT WITHOUT WARNING. I NEVER KNOW IF THE TURN SIGNALS WILL WORK AND THIS IS VERY DANGEROUS. I AM FEARFUL THAT OTHER ISSUES WITH THE ELECTRICAL SYSTEM MIGHT HAPPEN. BUT KNOWING THAT THE BCM MIGHT FAIL AGAIN IN ANOTHER YEAR OR SO IS THE BIGGEST RUB. HOW MANY TIMES DO PEOPLE HAVE TO REPROGRAM THEIR CAR AND REPLACE PARTS ON A FAULTY PASSLOCK SYSTEM THAT WILL FAIL AGAIN? *TR
NHTSA ODI #10551362
175,632 miles · Oct 31, 2013
Electrical SystemEngine
FACTORY INSTALLED SECURITY SYSTEM WON'T LET ME START THE CAR, I HAVE TO WAIT ANYWHERE FROM 15-45 MINUTES BEFORE IT STARTS, AND THAT IS NOT SAFE TO BE STRANDED WITH THE FAMILY. I'M NOT THE FIRST PERSON WITH THIS PROBLEM, AND I HOPE YOU CAN DO SOMETHING TO HELP ME SOLVE IT. THANK YOU. *TR
NHTSA ODI #10550426
160,000 miles · Sep 11, 2013
EngineFire
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE CAUGHT ON FIRE WITHOUT WARNING. THE CONTACT WAS ABLE TO MOVE OFF THE ROADWAY AND CALLED THE FIRE DEPARTMENT TO EXTINGUISH THE FIRE. NO ONE WAS INJURED. THE FIRE DEPARTMENT DID NOT STATE WHAT CAUSED THE FIRE. AFTER THE FAILURE,…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE CAUGHT ON FIRE WITHOUT WARNING. THE CONTACT WAS ABLE TO MOVE OFF THE ROADWAY AND CALLED THE FIRE DEPARTMENT TO EXTINGUISH THE FIRE. NO ONE WAS INJURED. THE FIRE DEPARTMENT DID NOT STATE WHAT CAUSED THE FIRE. AFTER THE FAILURE, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN I.D. NUMBER 09V116000 (ENGINE AND ENGINE COOLING) AND CALLED THE MANUFACTURER. THE MANUFACTURER STATED THAT BY LAW, THEY WERE NOT RESPONSIBLE TO REMEDY THE VEHICLE DUE TO THE AGE OF THE VEHICLE. THE FAILURE MILEAGE WAS 160,000.
NHTSA ODI #10543083
115,000 miles · Jul 26, 2013
EngineFire
THE VEHICLE STARTED SMOKING WHILE DRIVING DOWN THE HIGHWAY AT 65 MILES PER HOUR, IT LOST POWER. I PULLED OVER AND HAD THE VEHICLE TOWED TO A MECHANIC. THE MECHANIC SAID THAT THE PISTON BROKE, AND A PORTION OF THE PISTON FLEW THROUGH THE OIL PAN. THIS VEHICLE HAS BEEN VERY WELL MAINTAINED. THIS SHOULD NOT HAVE HAPPENED. *TR
NHTSA ODI #10531973
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration