Electronic Stability Control (esc)Equipment Adaptive/mobilityVehicle Speed Control
I WAS DRIVING STARAIGHT DOING 40 AND AND I SAW A VECHILE SPEND OUT OF CONTROL I TRIED TO DRIVE FASTER TO GET OUT OF THE WAY BUT DOING IN THE MIDDLE OF DRIVING THE KEY FALLS OUT OF THE IGNITION CAUSING THE THE OTHER CAR TO HIT MINES IN THE REAR RIGHT NO ONE WAS HURT BUT MY CAR WAS SCATCH AND A DENT I NOTICE IT FREQUENTLY THAT WH…
Read full complaint
I WAS DRIVING STARAIGHT DOING 40 AND AND I SAW A VECHILE SPEND OUT OF CONTROL I TRIED TO DRIVE FASTER TO GET OUT OF THE WAY BUT DOING IN THE MIDDLE OF DRIVING THE KEY FALLS OUT OF THE IGNITION CAUSING THE THE OTHER CAR TO HIT MINES IN THE REAR RIGHT NO ONE WAS HURT BUT MY CAR WAS SCATCH AND A DENT I NOTICE IT FREQUENTLY THAT WHEN DRIVING THE KEY COMES OUT BY ITSELF ITS REALLY SCARY AND DANGEROUS. *TR
NHTSA ODI #10593834
109,000 miles · Jul 28, 2013
Electronic Stability Control (esc)Traction Control System
THE SERVICE TRACTION SYSTEM AND ABS LIGHT CAME ON INDICATING THE CAR HAD LOST THE ABS FUNCTION. ACCORDING TO THE DEALER THE HYDRAULIC BRAKE FUNCTION WAS SUPPOSED TO STILL WORK. HOWEVER, IF WHAT I EXPERIENCED RECENTLY USING THE HYDRAULIC FUNCTION IS SUPPOSED TO CONSOLE ME OR OFFER BRAKING SECURITY IT HASN'T LEADING ME TO HAVE M…
Read full complaint
THE SERVICE TRACTION SYSTEM AND ABS LIGHT CAME ON INDICATING THE CAR HAD LOST THE ABS FUNCTION. ACCORDING TO THE DEALER THE HYDRAULIC BRAKE FUNCTION WAS SUPPOSED TO STILL WORK. HOWEVER, IF WHAT I EXPERIENCED RECENTLY USING THE HYDRAULIC FUNCTION IS SUPPOSED TO CONSOLE ME OR OFFER BRAKING SECURITY IT HASN'T LEADING ME TO HAVE MY BRAKES WORKED ON AT MIDAS. WHAT LED ME TO MIDAS WAS THE UNNERVING FEELING OF MY RIGHT FRONT BRAKE SHUDDERING AND GRABBING. THEY SAID THE FRONT BRAKES AND PADS WERE FINE BUT THEY DID DO THE REARS. I CALLED GM AND WAS TOLD THERE WAS NO RECALL ON THIS. I THEN WENT TO THE DEALER AND THEY STATED THEY HAD NO SERVICE BULLETIN ON THIS. SINCE THIS IS PART OF THE BRAKING SYSTEM I AM ASTONISHED THAT THIS PROBLEM HAS NOT BEEN RECALLED. I AM NOT THE ONLY CUSTOMER WITH THIS PROBLEM ACCORDING TO MY OWN INTERNET INVESTIGATING. ACCORDING TO CHEVY THIS PROBLEM COULD COST THOUSANDS. THE PROBLEM DOES NOT APPEAR MECHANICAL BUT ELECTRICAL INVOLVING THE ABS SENSORS AND/OR ECB MODULE. *TR
NHTSA ODI #10532242
130,000 miles · May 6, 2013
Electrical SystemElectronic Stability Control (esc)Fuel/propulsion System
I PUT A NEW FUEL PRESSURE SENSOR IN AND NOW MY 02 IMPALA WONT START AND NOT GETTING ANY POWER TO FUEL PUMP NOW, WE ARE A CAR LOT AND THIS CAR HAS BEEN SITTING UNABLE TO START NOW FOR OVER 2 WEEKS, HAD MANY CERTIFIED MECHANICS FROM OUR AREA OBSERVE THE PROBLEM, INCLUDING 2 CERTIFIED CHEVROLET MECHANICS, AND NONE HAVE COME UP WITH…
Read full complaint
I PUT A NEW FUEL PRESSURE SENSOR IN AND NOW MY 02 IMPALA WONT START AND NOT GETTING ANY POWER TO FUEL PUMP NOW, WE ARE A CAR LOT AND THIS CAR HAS BEEN SITTING UNABLE TO START NOW FOR OVER 2 WEEKS, HAD MANY CERTIFIED MECHANICS FROM OUR AREA OBSERVE THE PROBLEM, INCLUDING 2 CERTIFIED CHEVROLET MECHANICS, AND NONE HAVE COME UP WITH A SOLUTION. JUST DON'T MAKE SENSE, I AM SURE CHEVROLET IS AWARE OF THE PROBLEM SO PLEASE LET ME KNOW WHAT THE PROBLEM IS SO I CAN HAVE IT REPAIRED SO WE CAN SELL THE CAR. *TR
NHTSA ODI #10510760
83,900 miles · Nov 2, 2012
Electronic Stability Control (esc)Vehicle Speed Control
THE CATALYTIC CONVERTER CAUSED THE CAR ENGINE TO TURN OFF IN THE MIDDLE OF THE ROAD. THE CAR WAS HAVING ACCELERATION PROBLEMS GETTING TO JUST 25-30 MPH AND WHILE DRIVING IT, THE ENGINE TURNED OFF AND TOOK SEVERAL ATTEMPTS TO RESTART IT. AFTER A COUPLE MONTHS, I FOUND ONLINE THAT LETTERS (SPECIAL POLICY NUMBER 05551) WERE SUPPO…
Read full complaint
THE CATALYTIC CONVERTER CAUSED THE CAR ENGINE TO TURN OFF IN THE MIDDLE OF THE ROAD. THE CAR WAS HAVING ACCELERATION PROBLEMS GETTING TO JUST 25-30 MPH AND WHILE DRIVING IT, THE ENGINE TURNED OFF AND TOOK SEVERAL ATTEMPTS TO RESTART IT. AFTER A COUPLE MONTHS, I FOUND ONLINE THAT LETTERS (SPECIAL POLICY NUMBER 05551) WERE SUPPOSEDLY SENT OUT TO IMPALA OWNERS FOR AN EXTENDED WARRANTY FOR THIS FAULTY PART. I'M THE SECOND OWNER OF THIS CAR SO I WASN'T AWARE OF THIS AND JUST GOT IT REPLACED IN OCTOBER. A CHEVY DISTRICT SPECIALIST SAID THE CAR WAS BOUGHT 18 DAYS BEFORE THIS WARRANTY COVERAGE AND I WAS 2 YEARS OUTSIDE OF IT BECAUSE I'M THE SECOND OWNER. THE CAR IS IN GREAT CONDITION AND LESS THAN 84,000 MILES ON IT AS OF TODAY. I'M NOT SURE WHAT WARRANTS A RECALL, BUT SEVERAL SITES HAVE CUSTOMERS SAYING THEY'VE HAD TO REPLACE THIS PART MULTIPLE TIMES ON THEIR CARS BECAUSE GM SOLD A CAR WITH A FAULTY DESIGN. *TR
NHTSA ODI #10483173
129,850 miles · Feb 29, 2012
Electronic Stability Control (esc)Service Brakes, HydraulicSteering
MY ABS AND SERVICE TRACTION CONTROL LIGHT STAYS ON. WHEN I TURN MY STEERING WHEEL, THERE'S A FUNNY NOISE AND A FEELING LIKE MY BRAKES ARE SCRUBBING. *TR
NHTSA ODI #10449762
68,000 miles · Dec 5, 2009
Electrical SystemElectronic Stability Control (esc)Equipment
I HAVE A SAFETY CONCERN INVOLVING UNRESOLVEABLE ISSUES WITH A 2002 IMPALA LS. DUE TO PASSLOCK, MY CAR WILL RANDOMLY NOT START, THINKING THAT I (THE OWNER) AM TRYING TO STEAL THE CAR. THIS IS A SAFETY ISSUE BEING THAT I AM A YOUNG, UNMARRIED WOMAN, WHO HAS TO DRIVE IN AND THROUGH ROUGH NEIGHBORHOODS TO GET TO WORK AND SCHOOL. THI…
Read full complaint
I HAVE A SAFETY CONCERN INVOLVING UNRESOLVEABLE ISSUES WITH A 2002 IMPALA LS. DUE TO PASSLOCK, MY CAR WILL RANDOMLY NOT START, THINKING THAT I (THE OWNER) AM TRYING TO STEAL THE CAR. THIS IS A SAFETY ISSUE BEING THAT I AM A YOUNG, UNMARRIED WOMAN, WHO HAS TO DRIVE IN AND THROUGH ROUGH NEIGHBORHOODS TO GET TO WORK AND SCHOOL. THIS ISSUE COULD LEAVE ME AND OTHERS STRANDED AT LOCATION. AND WHO KNOWS WHAT COULD HAPPEN FROM THERE, VARYING FROM MURDER TO ASSAULT, ETC. AND IF YOU KNOW FLINT, SAGINAW, AND DETROIT MICHIGAN, THIS IS A HUGE ISSUE. THE CAR HAS BEEN EVALUATED BY THREE DIFFERENT MECHANICS, TWO DEALERSHIPS, AND THERE IS NO SOLUTION. ASIDE FROM THAT ISSUE, THE CAR'S TRACTION CONTROL TURNS ON AT RANDOM, THE ABS BRAKES TURN ON, ALMOST CAUSING ACCIDENTS. THIS IS ANOTHER ISSUE THAT CAN'T BE RESOLVED BY ANY OF THE MECHANICS I'VE TALKED TO. THIS IS COSTING TONS OF MONEY AND GM HAS NO SOLUTION. GM NEEDS TO ISSUE A RECALL AND HAVE THESE ISSUES FIXED. *TR
NHTSA ODI #10294570
Mileage unknown · Aug 7, 2008
Air BagsElectrical SystemElectronic Stability Control (esc)
CAR WOULD NOT START CHANGED PASSLOCK AND STILL WILL NOT START. SECURITY LIGHT IS ON, RADIO IS LOCKED AND THE CHEVY DEALERSHIP DOES NOT KNOW WHAT IS WRONG WITH IT, THEY ARE GUESSING THAT IS THE BCM AND THE SDM BUT THEY CANNOT PROMISE THAT IT WILL WORK. *TR
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration