I HAD TO HAVE THE KEY LOCK CYLINDER REPLACED FOR THE SECOND TIME I TOOK IT IN ABOUT A MONTH AGO AND GM DONE THE RECALL WHICH WAS TO PUT A PLASTIC PLUG IN THE KEYS BUT DID NOT REPLACE THE LOCK AND AT THE TIME I TOLD THEM I NEEDED A NEW LOCK. I HAVE NOT TAKEN MY CAR OUT OF THE AREA BECAUSE OF WARNING LIGHTS COMING ON AND NOT START…
Read full complaint
I HAD TO HAVE THE KEY LOCK CYLINDER REPLACED FOR THE SECOND TIME I TOOK IT IN ABOUT A MONTH AGO AND GM DONE THE RECALL WHICH WAS TO PUT A PLASTIC PLUG IN THE KEYS BUT DID NOT REPLACE THE LOCK AND AT THE TIME I TOLD THEM I NEEDED A NEW LOCK. I HAVE NOT TAKEN MY CAR OUT OF THE AREA BECAUSE OF WARNING LIGHTS COMING ON AND NOT STARTING PROBLEMS. I HAVE REPLACED THE BATTERY MANY TIMES AND GM REPLACED SENSORS A FEW TIMES. GM KNOWS THEY HAVE A PROBLEM BUT HAVE NOT BEEN HELD ACCOUNTABLE FOR THE REPAIRS.
NHTSA ODI #10716153
Mileage unknown · May 11, 2015
Electrical SystemEngineSteering
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE IGNITION FAILED TO TURN TO THE ON POSITION AND THE STEERING WHEEL DID NOT LOCK WHILE THE VEHICLE WAS TURNED OFF. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE IGNITION SWITCH FAILED A…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE IGNITION FAILED TO TURN TO THE ON POSITION AND THE STEERING WHEEL DID NOT LOCK WHILE THE VEHICLE WAS TURNED OFF. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE IGNITION SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10715594
145,000 miles · Apr 27, 2015
Electrical SystemUnknown Or Other
CAR WILL ONLY START RANDOMLY. ENGINE WILL NOT TURN. ALL LIGHTS ON DASH WILL GO OUT WHEN TURNING THE IGNITION. STARTER HAS BEEN REPLACED AND ELECTRICAL SHOP ADVISED TO GO TO DEALER. TOOK TO DEALER FOR IGNITION RECALL WHICH DID NOT FIX THE PROBLEM. DEALER ADVISED THIS ISSUE IS NOT COVERED BY RECALL. SECURITY LIGHT TURNS ON. …
Read full complaint
CAR WILL ONLY START RANDOMLY. ENGINE WILL NOT TURN. ALL LIGHTS ON DASH WILL GO OUT WHEN TURNING THE IGNITION. STARTER HAS BEEN REPLACED AND ELECTRICAL SHOP ADVISED TO GO TO DEALER. TOOK TO DEALER FOR IGNITION RECALL WHICH DID NOT FIX THE PROBLEM. DEALER ADVISED THIS ISSUE IS NOT COVERED BY RECALL. SECURITY LIGHT TURNS ON. *TR
NHTSA ODI #10713010
Mileage unknown · Mar 24, 2015
Electrical System
MY DAUGHTER WAS DRIVING THE CAR AND IT STALLED, SO SHE PULLED OVER TO TRY AND RESTART IT BUT IT WOULDN'T START. WE HAD IT TOWED TO A SHOP AND THEY THOUGHT IT WAS THE CRANK SHAFT CENSOR. WE DROVE FOR 3 DAYS AND THE SECURITY LIGHT CAME ON AGAIN AND THE CAR WOULDN'T START. SO WE HAD TO HAVE IT TOWED HOME. I'VE READ SEVERAL COMPLAI…
Read full complaint
MY DAUGHTER WAS DRIVING THE CAR AND IT STALLED, SO SHE PULLED OVER TO TRY AND RESTART IT BUT IT WOULDN'T START. WE HAD IT TOWED TO A SHOP AND THEY THOUGHT IT WAS THE CRANK SHAFT CENSOR. WE DROVE FOR 3 DAYS AND THE SECURITY LIGHT CAME ON AGAIN AND THE CAR WOULDN'T START. SO WE HAD TO HAVE IT TOWED HOME. I'VE READ SEVERAL COMPLAINTS ABOUT THIS SAME PROBLEM WITH THIS MAKE AND MODEL. I FIND IT HARD TO BELIEVE THAT GM HAVEN'T HAD A RECALL ON THIS PART. THIS IS VERY FRUSTRATING AND SOMETHING NEEDS TO BE DONE ABOUT IT. THIS PART HAS TO BE DEFECTED. *TR
NHTSA ODI #10701293
19,900 miles · Mar 5, 2015
Electrical SystemFuel/propulsion System
MY VEHICLE HAS A FAULTY ELECTRICAL START UP SYSTEM AND FUEL PUMP SYSTEM THE BATTERY ON THIS VEHICLE WAS REPLACED AND THE STARTER WAS REPLACED AS WELL AND THE VEHICLE STILL IS EXPERIENCING THE SAME PROBLEMS. I TOOK THE VEHICLE TO BE SERVICED AT A MECHANIC SHOP AND THE VEHICLE WORKED PERFECTLY FINE FOR THE MECHANIC AT THE TIME AND…
Read full complaint
MY VEHICLE HAS A FAULTY ELECTRICAL START UP SYSTEM AND FUEL PUMP SYSTEM THE BATTERY ON THIS VEHICLE WAS REPLACED AND THE STARTER WAS REPLACED AS WELL AND THE VEHICLE STILL IS EXPERIENCING THE SAME PROBLEMS. I TOOK THE VEHICLE TO BE SERVICED AT A MECHANIC SHOP AND THE VEHICLE WORKED PERFECTLY FINE FOR THE MECHANIC AT THE TIME AND THEY WERE UNABLE TO MAKE ANY REPAIRS BECAUSE THE VEHICLE DIDN'T PERFORM THE ISSUE IN FRONT OF THE MECHANIC. THE ISSUE HAS BEEN GOING ON SINCE JUNE OF 2014 AND IT RANDOMLY WONT START AT ALL AND THEN ITS STARTS HOURS AND HOURS LATER. I HAVE SPENT HUNDREDS OF DOLLARS REPLACING PARTS ON THIS CAR THAT DEAL WITH STARTING ISSUES AND STILL THIS CAR IS EXPERIENCING THE SAME DIFFICULTIES. I HAVE BEEN STRANDED NUMEROUS PLACES WITH THIS VEHICLE REFUSING TO START. I AM AWARE THAT THIS VEHICLE HAS A RECALL OUT FOR KEY IGNITION ELECTRICAL SWITCH AND FUEL PUMP PRESSURE ALL OF WHICH FIT THE PROBLEMS MY VEHICLE IS EXPERIENCING THE RECALL THAT IS AVAILABLE TO MY VEHICLE DOESN'T INCLUDE EITHER ONE OF THESE AND I PERSONALLY FEEL IT SHOULD INCLUDE THESE BECAUSE MULTIPLE MECHANICS WHO HAVE INSPECTED THE CAR HAVE CONFIRMED THESE ARE THE ISSUES THIS CAR IS EXPERIENCING I DON'T HAVE HUNDREDS OF DOLLARS TO KEEP INSTALLING AND MAKING REPAIRS ON THIS CAR ONLY TO HAVE IT KEEP BREAKING DOWN I AM IN NEED OF ASSISTANCE TO FIGURE OUT IF I CAN GET THIS VEHICLE UNDER THE OTHER RECALLS AS WELL PLEASE AND THANK YOU. *TR
NHTSA ODI #10692277
Mileage unknown · Feb 26, 2015
Electrical System
2002 CHEVROLET IMPALA. CONSUMER WRITES IN REGARDS TO RECALL NOTICE ISSUES. *SMD THE CONSUMER STATED BECAUSE GM DID NOT ADDRESS THE ISSUE IN A TIMELY MANNER, THE WORK ON HIS VEHICLE HAD TO BE PERFORMED PRIOR TO THE RECALL ANNOUNCEMENT. RECALL # 14V40000 *JB
NHTSA ODI #10669034
20,000 miles · Feb 19, 2015
Electrical System
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING 35 MPH, THE KEY DISLODGED FROM THE IGNITION WITHOUT CAUSE AND THE VEHICLE CONTINUED TO OPERATE. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THERE WAS NO KNOWN DIAGNOSIS. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER:…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING 35 MPH, THE KEY DISLODGED FROM THE IGNITION WITHOUT CAUSE AND THE VEHICLE CONTINUED TO OPERATE. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT THERE WAS NO KNOWN DIAGNOSIS. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM) AND THE KEYS WERE REPLACED. THE CONTACT STATED THAT THE REPLACEMENT KEYS WERE DIFFICULT TO OPERATE. THE VEHICLE WAS RETURNED TO THE DEALER, BUT THE CONTACT WAS NOT ABLE TO PROVIDE THE DETAILS OF THE DIAGNOSIS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 20,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10689408
34,600 miles · Jan 30, 2015
Electrical SystemEngineService Brakes
THE CAR IGNITION SUDDENLY SHUT OFF AND THE POWER STEERING AND BRAKES FAILED ON A STEEP GRADE. (THE IGNITION RECALL HAD PREVIOUSLY BEEN PERFORMED ON THE VEHICLE, AND THE KEY FOB HAD BEEN REWORKED SO IT SHOULDN'T HAVE BEEN A IGNITION ISSUE). THE TRANSMISSION WAS SHIFTED INTO NEUTRAL AND THE CAR RESTARTED (WHILE STILL COASTING DOWN…
Read full complaint
THE CAR IGNITION SUDDENLY SHUT OFF AND THE POWER STEERING AND BRAKES FAILED ON A STEEP GRADE. (THE IGNITION RECALL HAD PREVIOUSLY BEEN PERFORMED ON THE VEHICLE, AND THE KEY FOB HAD BEEN REWORKED SO IT SHOULDN'T HAVE BEEN A IGNITION ISSUE). THE TRANSMISSION WAS SHIFTED INTO NEUTRAL AND THE CAR RESTARTED (WHILE STILL COASTING DOWN THE HILL) TO REGAIN CONTROL,THIS WAS REPEATED NUMEROUS TIMES UNTIL A SAFE PLACE TO PULL OFF WAS REACHED. THIS GRADE WAS EXTREMELY STEEP, THE ROAD HAD SWITCHBACKS , CLIFFS,AND NO GUARDRAIL, IT WAS A MIRACLE NO ONE WAS INJURED OR KILLED. THIS SAME VEHICLE HAD JUST HAD A DUPLICATE PROBLEM AND WAS REPAIRED AT THE DEALERSHIP IN JULY, LESS THAT 1000 MILES PRIOR TO THIS CURRENT EVENT. THE DEALER IN JULY REPLACED THE MAS SENSOR AND THE BATTERY AS THEY SAID THE MAS WAS CORRODED AND NEEDED TO BE REPLACED. THIS CURRENT EVENT WAS CAUSED BY THE MAP SENSOR AND THE MAIN COMPUTER ACCORDING TO THE DEALER. *TR
NHTSA ODI #10679863
184,471 miles · Jan 16, 2015
Electrical SystemEngine
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 184,471.
NHTSA ODI #10673050
Mileage unknown · Jan 6, 2015
Electrical System
2002 CHEVROLET IMPALA. CONSUMER STATES CAR WAS TOTALED IN AN ACCIDENT AND NO LONGER OWNS THE CAR. REQUESTS NO MORE RECALL NOTICES. *TA
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration