NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
305 reportsClear category filter81,555 miles · Dec 19, 2006
Electrical System
THE FOLLOWING MATTER IS A POTENTIAL DISASTER WAITING TO OCCUR. I HAVE INFORMED GM BY MAIL AND TELEPHONE. I HAVE WENT TO THE CHEVY DEALER ONLY TO COME OUT WITH MY KEY FIVE HAND HELD TRANSMITTER TO STOP WORKING. I HAVE SENT LETTERS TO THE DEALERSHIP THAT SOLD ME THE CAR. T THE SECURITY SYSTEM SHUTS DOWN THE VEHICLE AT RANDOM TIM…
Read full complaint
THE FOLLOWING MATTER IS A POTENTIAL DISASTER WAITING TO OCCUR. I HAVE INFORMED GM BY MAIL AND TELEPHONE. I HAVE WENT TO THE CHEVY DEALER ONLY TO COME OUT WITH MY KEY FIVE HAND HELD TRANSMITTER TO STOP WORKING. I HAVE SENT LETTERS TO THE DEALERSHIP THAT SOLD ME THE CAR. T THE SECURITY SYSTEM SHUTS DOWN THE VEHICLE AT RANDOM TIMES AUTOMATICALLY. CONTINUOUS PROBLEMS: SECURITY LIGHT ON MESSAGE CENTER CONTINUES TO FLASH SECURITY SERVICE VEHICLE SOON, - BATTERY THE SECURITY SYSTEM AUTOMATICALLY, CONTINUOUSLY ATTEMPTS TO SHUT DOWN MY CAR THIS SECURITY SYSTEM ALSO UNLOCKS MY TRUNK THE HANDHELD TRANSMITTER DOES NOT WORK AFTER REPLACING THE BATTERY AFTER THE CHEVY DEALER CHECKED THE PROBLEM I HAVE TO UNLOCK THE DOORS MANUALLY THE LIGHTS FLASH AND THE MESSAGE ON THE RADIO PANEL SAYS LOCKED I CANNOT USE MY CAR, IT WILL NOT START - ENGINE LIGHT COMES ON - ALL LIGHTS GO OUT WHILE DRIVING , THIS FAULTY "PASS LOCK THEFT DETERRENT" SYSTEM, AUTOMATICALLY COMES ON AND SHUTS MY CAR DOWN WHEN I PULL OVER TO THE SIDE OF THE ROAD AND TURN THE ENGINE OFF. IT WILL NOT TURN ON AGAIN, ONLY THE CHECK ENGINE LIGHT COMES ON. I HAD THE CAR INSPECTED TODAY AT A CHEVY DEALERSHIP AND THE RESULTS WAS," REPLACE THE CONTROL MODULE AT $325.00, FIRST, THEN I CAN PROGRAM THE KEY FIVE TRANSMITTER." REPLACED TRANSMITTER BATTERY AND CAR BATTERY I CONCLUDE THAT GM HAS THE MONOPOLY ON VEHICLE PARTS AND SERVICE ALL IN THE NAME OF TECHNOLOGY AND COST THE CONSUMER A TREMENDOUS AMOUNT OF REPAIRS ON TOP OF THE COST FOR THE VEHICLE. CONSUMERS SHOULD NOT HAVE TO PAY FOR A SERVICE THAT THEY CANNOT REPAIR AT ANY SHOP IN TOWN. FOR INSTANCE, I CAN TAKE MY TRANSMISSION ISSUES TO ALMOST ANY TRANSMISSION SHOP, HOWEVER, I CANNOT TAKE MY MANUFACTURER BUILT- IN SECURITY SYSTEM TO ANY SHOP. THEY WILL NOT TOUCH IT JUST BECAUSE IT IS MANUFACTURER BUILT. I WANT THE LAWS CHANGED. *JB
NHTSA ODI #10176619
40,080 miles · Nov 1, 2006
Electrical System
DRIVING WHEN ALL WARNING LIGHTS CAME ON, THEN THE BATTERY LIGHT STAYED ON FOR A SHORT PERIOD. IT DID NOT EFFECT THE CAR PERFORMANCE BUT IT DID RESET THE CLOCK ON THE RADIO AS IF THE BATTERY HAD BEEN DISCONNECTED. ANOTHER TIME THE TRACTION CONTROL AND ABS BRAKE LIGHTS FLASHED AND THE RADIO PULSED. THE SECURITY LIGHT REMAINED ON A…
Read full complaint
DRIVING WHEN ALL WARNING LIGHTS CAME ON, THEN THE BATTERY LIGHT STAYED ON FOR A SHORT PERIOD. IT DID NOT EFFECT THE CAR PERFORMANCE BUT IT DID RESET THE CLOCK ON THE RADIO AS IF THE BATTERY HAD BEEN DISCONNECTED. ANOTHER TIME THE TRACTION CONTROL AND ABS BRAKE LIGHTS FLASHED AND THE RADIO PULSED. THE SECURITY LIGHT REMAINED ON AS I WAS MOVING FORWARD OUT OF A DRIVEWAY THE VEHICLE STALLED BUT IMMEDIATELY RESTARTED AND ALL THE LIGHTS CLEARED. *NM
NHTSA ODI #10172369
127,500 miles · Oct 11, 2006
Electrical System
2002 IMPALA LS WITH SERIOUS ELECTRICAL PROBLEMS. THE FIRST PROBLEM STARTED WITH THE TURN SIGNALS GOING OUT. THEN THE RADIO WOULD NOT GO OFF EVEN WHEN THE KEYS WERE OUT AND DOORS LOCKED, AND SOMETIMES DOES NOT WORK AT ALL. AUTOMATIC DOOR LOCK NO LONGER WORKS. WHEN TRYING TO START THE CAR, I HAVE TO TURN THE KEY SEVERAL TIMES …
Read full complaint
2002 IMPALA LS WITH SERIOUS ELECTRICAL PROBLEMS. THE FIRST PROBLEM STARTED WITH THE TURN SIGNALS GOING OUT. THEN THE RADIO WOULD NOT GO OFF EVEN WHEN THE KEYS WERE OUT AND DOORS LOCKED, AND SOMETIMES DOES NOT WORK AT ALL. AUTOMATIC DOOR LOCK NO LONGER WORKS. WHEN TRYING TO START THE CAR, I HAVE TO TURN THE KEY SEVERAL TIMES AND THEN WAIT FOR IT TO FINALLY START. THE INTERIOR LIGHTS FLICKER. THE HEADLIGHTS DON'T ALWAYS WORK - I TRY NOT TO DRIVE AT NIGHT BECAUSE I NEVER KNOW WHEN THEY'LL GO OUT. THE INSTRUMENT PANEL WORKS ABOUT HALF THE TIME, SO I DON'T KNOW HOW MUCH FUEL I HAVE OR HOW FAST I AM GOING. THE MESSAGE DISPLAY GOES BETWEEN "SECURITY", "HIGH BEAM OUT", "SERVICE ENGINE SOON", WHEN IT'S WORKING. THERE SEEMS TO BE A NEW ELECTRICAL COMPONENT THAT GOES OUT EACH DAY. *JB
NHTSA ODI #10170479
46,000 miles · Aug 30, 2006
Electrical System
CAR WOULD NOT START. THOUGHT IT WAS THE BATTERY OR POSSIBLY THE ALTERNATOR, BUT IT TURNED OUT TO BE A FAILED BODY CONTROL MODULE (BCM). OUR CAR HAD ONLY 46,000 MILES WHEN THIS OCCURRED. THERE SHOULD BE AN OFFICIAL RECALL ON THE BCM GIVEN THE NUMEROUS BULLETINS AND COMPLAINTS CONCERNING THE BCM BEFORE SOMEONE'S LOSES HIS OR HER L…
Read full complaint
CAR WOULD NOT START. THOUGHT IT WAS THE BATTERY OR POSSIBLY THE ALTERNATOR, BUT IT TURNED OUT TO BE A FAILED BODY CONTROL MODULE (BCM). OUR CAR HAD ONLY 46,000 MILES WHEN THIS OCCURRED. THERE SHOULD BE AN OFFICIAL RECALL ON THE BCM GIVEN THE NUMEROUS BULLETINS AND COMPLAINTS CONCERNING THE BCM BEFORE SOMEONE'S LOSES HIS OR HER LIFE AS A DIRECT OR INDIRECT RESULT OF ITS FAILURE. *JB
NHTSA ODI #10167066
65,000 miles · Aug 24, 2006
Electrical System
SEVERAL ELECTRICAL / SECURITY PROBLEMS - LIGHTS GO OFF WHILE DRIVING. ALSO AT TIMES WHEN APPROACHING CAR, IT WON'T START DUE TO SECURITY SYSTEM SHUTTING DOWN STARTER CIRCUIT. ALTHOUGH THESE THINGS CORRECT THE PROBLEM AFTER WAITING, THE DEALER DOESN'T FIND THE PROBLEM. IT HAS BEEN SUGGESTED THAT I PAY FOR REPLACEMENT PARTS TH…
Read full complaint
SEVERAL ELECTRICAL / SECURITY PROBLEMS - LIGHTS GO OFF WHILE DRIVING. ALSO AT TIMES WHEN APPROACHING CAR, IT WON'T START DUE TO SECURITY SYSTEM SHUTTING DOWN STARTER CIRCUIT. ALTHOUGH THESE THINGS CORRECT THE PROBLEM AFTER WAITING, THE DEALER DOESN'T FIND THE PROBLEM. IT HAS BEEN SUGGESTED THAT I PAY FOR REPLACEMENT PARTS THAT MIGHT FIX THIS PROBLEM. I DON'T WANT TO SPEND MORE MONEY ON THIS VEHICLE. *JB
NHTSA ODI #10166429
30,215 miles · Jul 14, 2006
Electrical System
WHEN GETTING INTO MY CAR I GO TO START MY CAR AND NOTHING HAPPENS. I HAVE TO WAIT FOR 10 MINUTES BEFORE IT WILL START. THE SECURITY LIGHTS COMES ON WHEN DRIVING DOWN THE ROAD. IT COULD CAUSE A SERIOUS ACCIDENT IF SOMEONE DID NOT KNOW WHAT TO DO. NO ONE CAN FIGURE OUT WHAT THE PROBLEM IS WHEN THE CAR WILL NOT START AND THE SECUR…
Read full complaint
WHEN GETTING INTO MY CAR I GO TO START MY CAR AND NOTHING HAPPENS. I HAVE TO WAIT FOR 10 MINUTES BEFORE IT WILL START. THE SECURITY LIGHTS COMES ON WHEN DRIVING DOWN THE ROAD. IT COULD CAUSE A SERIOUS ACCIDENT IF SOMEONE DID NOT KNOW WHAT TO DO. NO ONE CAN FIGURE OUT WHAT THE PROBLEM IS WHEN THE CAR WILL NOT START AND THE SECURITY LIGHT IS ON. IT IS A MANUFACTURING DEFECT IN THE SECURITY SYSTEM. THERE ARE SEVERAL PEOPLE THAT HAVE THE SAME ISSUES WITH THIS. SOME PEOPLE HAVE TO WAIT 30 MINUTES BEFORE THEIR CAR WILL START. THIS COULD PUT A WOMAN IN A SERIOUS SITUATION. WE NEED TO FIND OUT WHAT IS THE PROBLEM AND I HOPE SOMEONE CAN HELP. *JB
NHTSA ODI #10162430
47,225 miles · Jun 2, 2006
Electrical System
IS THERE A WAY TO LOOK INTO THE CHEVROLET IMPALA 2002, 2001, AND 2000 MODELS FOR FAILURE OF THE SECURITY SYSTEM. THE LIGHT COMES ON AT TIMES AND WHEN TAKEN IN FOR SERVICE YOU ARE TOLD THAT THE PROBLEM CAN'T BE FOUND. AFTER THE LIGHT COMES ON, YOU DON'T KNOW WHEN OR IF THE CAR WILL START AND YOU HAVE IT TOWED AND NO PROBLEMS ARE …
Read full complaint
IS THERE A WAY TO LOOK INTO THE CHEVROLET IMPALA 2002, 2001, AND 2000 MODELS FOR FAILURE OF THE SECURITY SYSTEM. THE LIGHT COMES ON AT TIMES AND WHEN TAKEN IN FOR SERVICE YOU ARE TOLD THAT THE PROBLEM CAN'T BE FOUND. AFTER THE LIGHT COMES ON, YOU DON'T KNOW WHEN OR IF THE CAR WILL START AND YOU HAVE IT TOWED AND NO PROBLEMS ARE FOUND. I THINK THIS CAN LEAD TO SOME TYPE OF SAFETY PROBLEM IF YOU NEED TO MOVE YOUR CAR IN A HURRY AND IT DON'T START. I'VE TALKED WITH MANY OWNERS OF THE TYPE OF CARS AND THEY ALL HAVE THIS PROBLEM. *NM
NHTSA ODI #10158877
48,000 miles · May 31, 2006
Electrical SystemExterior Lighting
DT*: THE CONTACT STATED THE HEADLIGHTS FAILED WITHOUT WARNING. THE DEALERSHIP WAS UNABLE TO DUPLICATE THE PROBLEM. THE MANUFACTURER HAS BEEN ALERTED. UPDATED 6/16/2006 - WHEN THE HIGH BEAMS WERE USED THE DASH LIGHTS WENT DARK. *NM
NHTSA ODI #10158664
61,350 miles · Jan 27, 2006
Electrical SystemExterior Lighting
I WAS DRIVING HOME FROM WORK AROUND 7:30 PM ON TUESDAY ON JANUARY 24, 2006, DARK OUTSIDE. I HAD MY LIGHTS ON BRIGHT AND ALL OF A SUDDEN THERE WERE NO LIGHTS. I DID HAVE FOG LIGHTS ON AND I COULD STILL SEE THEM, BUT THERE WEREN'T ANY HEADLIGHTS. I QUICK FLICKED THE DIMMER SWITCH AND THEY CAME BACK ON. I'VE NEVER EXPERIENCED …
Read full complaint
I WAS DRIVING HOME FROM WORK AROUND 7:30 PM ON TUESDAY ON JANUARY 24, 2006, DARK OUTSIDE. I HAD MY LIGHTS ON BRIGHT AND ALL OF A SUDDEN THERE WERE NO LIGHTS. I DID HAVE FOG LIGHTS ON AND I COULD STILL SEE THEM, BUT THERE WEREN'T ANY HEADLIGHTS. I QUICK FLICKED THE DIMMER SWITCH AND THEY CAME BACK ON. I'VE NEVER EXPERIENCED THAT BEFORE. HOWEVER, WHEN I TALKED TO MY MECHANIC THE NEXT DAY HE SAID SOMEONE THE WEEK BEFORE EXPERIENCED THE SAME THING TWICE IN ONE DRIVE. THE PIECE TO REPLACE THIS IS QUITE EXPENSIVE. I HAVE NOT HAD IT FIXED YET, BUT I FELT IT SHOULD BE REPORTED. THIS HAPPENED ONCE. ANOTHER ITEM OF CONCERN IS THAT MY SECURITY LIGHT INSIDE MY CAR HAS BEEN ON FOR ABOUT 2 MONTHS. EVERY ONCE IN A WHILE MY CAR WON'T START ON THE FIRST TURN. ONLY ONCE DID I HAVE TO HAVE IT JUMPED. THERE IS PLENTY OF POWER AS THE LIGHTS AND RADIO STILL WORK. MY MECHANIC HAS TRIED REPLACING AN IGNITION SWITCH (I THINK), BUT THE FIRST TIME I STARTED IT DIDN'T TURN OVER AND THEN IT DID, BUT THE SECURITY LIGHT WAS STILL ON. IT'S BACK IN THE SHOP TODAY. THE OTHER PERSON MENTIONED ABOVE HAS EXPERIENCED THIS SAME DEFECT. THEY ALSO OWN AN IMPALA. THIS HAS HAPPENED SEVERAL TIMES ON MY CAR. MY MECHANIC CANNOT FIGURE OUT WHAT IS WRONG.*AK
NHTSA ODI #10148862
57,000 miles · Dec 5, 2005
Electrical System
BODY CONTROL MODULE (BCM) FAILED AFTER 57,000 MILES. THE OTHER COMPUTER THAT RESIDES IN THE SAME HOUSING IS COVERED BY A 80,000 MILE WARRANTY, WHERE AS THE BCM IS NOT. THERE ARE NUMEROUS TSB'S THAT ARE POSTED CONCERNING FAILURE OF THE BCM. THERE ARE MANY PEOPLE WHO HAVE SIMILAR PROBLEMS AND MANY SOURCES ARE AVAILABLE BY RESEA…
Read full complaint
BODY CONTROL MODULE (BCM) FAILED AFTER 57,000 MILES. THE OTHER COMPUTER THAT RESIDES IN THE SAME HOUSING IS COVERED BY A 80,000 MILE WARRANTY, WHERE AS THE BCM IS NOT. THERE ARE NUMEROUS TSB'S THAT ARE POSTED CONCERNING FAILURE OF THE BCM. THERE ARE MANY PEOPLE WHO HAVE SIMILAR PROBLEMS AND MANY SOURCES ARE AVAILABLE BY RESEARCHING THE INTERNET. THE TECHNICIAN AT THE DEALERSHIP EVEN SAID THAT "IMPALAS ARE NOTORIOUS" FOR PROBLEM WITH THE BCM. GENERAL MOTORS SAYS THAT IT IS NOT COVERED AND THEREFORE WILL NOT COVER THE REPLACEMENT COSTS OF THE BCM. IF SO MANY PEOPLE ARE HAVING PROBLEMS WITH THIS YEAR MODEL (2002 IMPALA LS) THEN WHY HASN'T ANYTHING BEEN DONE BY THEM. I AM THANKFUL THAT MY CAR DID NOT SHUT OFF ON THE HIGHWAY AND DID SO IN MY PARKING LOT. *NM
NHTSA ODI #10144439
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration