NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
305 reportsClear category filterMileage unknown · Dec 5, 2007
Electrical System
WAS STRANDED FOR ABOUT 30 MINUTES BECAUSE CAR WOULDN'T START ON MY 2002 CHEVY IMPALA THE ORIGINAL SECURITY SYSTEM PASSLOCK DOESN'T LET THE VEHICLE START. HAS HAPPENED SEVERAL TIMES ABOUT 10 AND I HAVE ONLY HAD THIS VEHICLE FOR 4 MONTHS I HAVE READ SOME FORUMS IN THE INTERNET AND IT'S A KNOWN PROBLEM WITH GM AND A LOT OF PEOPLE H…
Read full complaint
WAS STRANDED FOR ABOUT 30 MINUTES BECAUSE CAR WOULDN'T START ON MY 2002 CHEVY IMPALA THE ORIGINAL SECURITY SYSTEM PASSLOCK DOESN'T LET THE VEHICLE START. HAS HAPPENED SEVERAL TIMES ABOUT 10 AND I HAVE ONLY HAD THIS VEHICLE FOR 4 MONTHS I HAVE READ SOME FORUMS IN THE INTERNET AND IT'S A KNOWN PROBLEM WITH GM AND A LOT OF PEOPLE HAVE THIS PROBLEM AND A RISK SINCE THEY ARE TRYING TO FIX IT BY WORKING BY THE STEERING WHEEL AND TRIGGER THE AIR BAG. SOME PEOPLE SAY IT COULD BE THE BCM I DON'T KNOW BUT GM DOES. *TR
NHTSA ODI #10210905
100,000 miles · Dec 4, 2007
Electrical SystemEngine And Engine CoolingExterior Lighting
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE TURN SIGNAL LIGHTS WORK SPORADICALLY AND THE VEHICLE SHUTS OFF AND ON INTERMITTENTLY. HE STATED THAT THE FAILURE WAS DUE TO AN ELECTRICAL FAILURE. THE DEALER STATED THAT NOTHING COULD BE DONE BECAUSE THE VEHICLE WAS OUT OF WARRANTY. THE MANUFACTURER HAS…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE TURN SIGNAL LIGHTS WORK SPORADICALLY AND THE VEHICLE SHUTS OFF AND ON INTERMITTENTLY. HE STATED THAT THE FAILURE WAS DUE TO AN ELECTRICAL FAILURE. THE DEALER STATED THAT NOTHING COULD BE DONE BECAUSE THE VEHICLE WAS OUT OF WARRANTY. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE FAILURE MILEAGE WAS 100,000 AND CURRENT MILEAGE WAS 102,000.
NHTSA ODI #10210821
Mileage unknown · Nov 16, 2007
Electrical System
KEY START DELAY START ISSUE, DUMMY LIGHTS, NO CRANK. *TR
NHTSA ODI #10209143
63,000 miles · Sep 18, 2007
Electrical System
MY IGNITION COIL (?) BECAME STUCK/FROZEN AND WOULD NOT TURN - THUS THE CAR WOULD NOT START. $700 LATER, I GOT A NEW IGNITION, BUT NOW MY LIGHTER DOESN'T WORK, HALF THE LIGHTS ON THE DASH NO LONGER WORK, EQUIPMENT WAS NOT BOLTED DOWN UNDER THE HOOD AND FOR THE COST OF THIS REPAIR, AT LEAST THE WORKMANSHIP COULD HAVE BEEN A LITTL…
Read full complaint
MY IGNITION COIL (?) BECAME STUCK/FROZEN AND WOULD NOT TURN - THUS THE CAR WOULD NOT START. $700 LATER, I GOT A NEW IGNITION, BUT NOW MY LIGHTER DOESN'T WORK, HALF THE LIGHTS ON THE DASH NO LONGER WORK, EQUIPMENT WAS NOT BOLTED DOWN UNDER THE HOOD AND FOR THE COST OF THIS REPAIR, AT LEAST THE WORKMANSHIP COULD HAVE BEEN A LITTLE BETTER. THIS SAME PROBLEM HAS BEEN REPORTED ON MANY CHEVY PRODUCTS THAT I HAVE FOUND ON LINE AND STILL NO RECALL ... I GUESS IT WILL TAKE A FEW PEOPLE DYING BEFORE THIS TURNS INTO ANYTHING LIKE THAT. *TR
NHTSA ODI #10203390
70,000 miles · Aug 31, 2007
Electrical System
SECURITY LIGHT COMING ON AND PASSLOCK FAILURE. I WOULD LIKE TO KNOW WHY GM IS NOT FIXING THIS PROBLEM WHEN SO MANY PEOPLE ARE HAVING THEM. MY SECURITY LIGHT WILL ONLY GO OFF IF I SHUT THE CAR OFF AND RESTART IT. THE LIGHTS BLINK, AND FROM WHAT I AM HEARING, SOON I WILL NOT BE ABLE TO START MY CAR. *TR
NHTSA ODI #10201593
127,000 miles · Aug 26, 2007
Electrical System
CAR WOULD NOT START THERE WAS NO CLICKING SOUNDS OR ANYTHING PASSLOCK SECURITY LIGHT AND BATTERY LIGHT COMES ON FIDDLED AROUND WITH LOCK AND UNLOCK ON REMOTE WAITED 10 MINUTES AND CAR STARTED NO PROBLEM. THIS HAS HAPPENED TWICE SINCE I PURCHASED THIS CAR 2 WEEKS AGO. I AM NOT IMPRESSED WITH THIS CAR. GOOD THING I WASN'T STRANDE…
Read full complaint
CAR WOULD NOT START THERE WAS NO CLICKING SOUNDS OR ANYTHING PASSLOCK SECURITY LIGHT AND BATTERY LIGHT COMES ON FIDDLED AROUND WITH LOCK AND UNLOCK ON REMOTE WAITED 10 MINUTES AND CAR STARTED NO PROBLEM. THIS HAS HAPPENED TWICE SINCE I PURCHASED THIS CAR 2 WEEKS AGO. I AM NOT IMPRESSED WITH THIS CAR. GOOD THING I WASN'T STRANDED SOMEWHERE ESPECIALLY WITH MY 5 WEEK ON SON IN THE CAR. *TR
NHTSA ODI #10200810
55,000 miles · Aug 6, 2007
Electrical System
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE IGNITION SWITCH, ALARM, AND SECURITY LIGHTS HAVE STOPPED WORKING. THE VEHICLE IS DISABLED AND FAILS TO START. THE DEALER STATED THAT SHE NEEDED AN IGNITION SWITCH AND THE MODULE REPLACED. THE MANUFACTURER NOTIFIED THE DEALER WHERE THE VEHICLE WAS PURCHA…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE IGNITION SWITCH, ALARM, AND SECURITY LIGHTS HAVE STOPPED WORKING. THE VEHICLE IS DISABLED AND FAILS TO START. THE DEALER STATED THAT SHE NEEDED AN IGNITION SWITCH AND THE MODULE REPLACED. THE MANUFACTURER NOTIFIED THE DEALER WHERE THE VEHICLE WAS PURCHASED. THE DEALER OFFERED 10% OFF OF THE REPAIR COST. THE CURRENT MILEAGE WAS 90,000 AND FAILURE MILEAGE WAS 55,000.
NHTSA ODI #10198621
40,000 miles · Aug 1, 2007
Electrical SystemExterior LightingVisibility
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT SHE WAS UNABLE TO START THE VEHICLE AND THE TRUNK AND DOOR LOCKS FAILED TO WORK. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF FAILURE. THE CONTACT BELIEVED THAT THE FAILURE WAS CAUSED BY THE ANTI-THEFT SYSTEM. SHE HAS REPROGRAMMED THE ANTI-THEFT SYSTEM. …
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT SHE WAS UNABLE TO START THE VEHICLE AND THE TRUNK AND DOOR LOCKS FAILED TO WORK. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF FAILURE. THE CONTACT BELIEVED THAT THE FAILURE WAS CAUSED BY THE ANTI-THEFT SYSTEM. SHE HAS REPROGRAMMED THE ANTI-THEFT SYSTEM. THE FAILURE HAS OCCURRED APPROXIMATELY SIX TIMES. THE WINDSHIELD ON A CLEAR DAY CAUSED BLURRED VISION. THE DEALER REPLACED THE WINDSHIELD, THE FAILURE DID NOT CONTINUE. WHILE DRIVING 70 MPH THE HEADLIGHTS BEGAN TO BLINK. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE CURRENT MILEAGE WAS 60,000 AND FAILURE MILEAGE WAS 40,000.
NHTSA ODI #10198149
40,000 miles · Jul 31, 2007
Electrical SystemExterior Lighting
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING AT ANY RATE OF SPEED, THE HEAD LIGHTS WOULD SHUT OFF WITHOUT WARNING. THE CONTACT STATED HE WOULD HAVE TO TURN HEADLIGHTS FROM HIGH TO LOW, TO GET THEM TO ILLUMINATE. THE DEALER STATED THAT THEY HAVE NEVER HEARD OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND THE …
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. WHILE DRIVING AT ANY RATE OF SPEED, THE HEAD LIGHTS WOULD SHUT OFF WITHOUT WARNING. THE CONTACT STATED HE WOULD HAVE TO TURN HEADLIGHTS FROM HIGH TO LOW, TO GET THEM TO ILLUMINATE. THE DEALER STATED THAT THEY HAVE NEVER HEARD OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 46,000.
NHTSA ODI #10197976
78,000 miles · Jul 16, 2007
Electrical SystemLatches/locks/linkages
SEVERAL TIMES I WOULD GO TO START MY CAR AND THE SECURITY LIGHT WOULD BE ON IN THE MESSAGE CENTER. THE CAR WOULD NOT START. IT DID NOTHING LIKE A DEAD BATTERY. I WOULD WAIT ABOUT 15 MINUTES AND TRY AGAIN. SOMETIMES IT WOULD START SOMETIMES IT WOULDN'T. IT WAS DOING THIS 2 OR 3 TIMES A WEEK. ON SEPT. 9, 2006 I CAME OUT FROM SHOPP…
Read full complaint
SEVERAL TIMES I WOULD GO TO START MY CAR AND THE SECURITY LIGHT WOULD BE ON IN THE MESSAGE CENTER. THE CAR WOULD NOT START. IT DID NOTHING LIKE A DEAD BATTERY. I WOULD WAIT ABOUT 15 MINUTES AND TRY AGAIN. SOMETIMES IT WOULD START SOMETIMES IT WOULDN'T. IT WAS DOING THIS 2 OR 3 TIMES A WEEK. ON SEPT. 9, 2006 I CAME OUT FROM SHOPPING AND IT WOULDN'T START. I WAITED FOR 15 MINUTES AND STILL NOTHING. I DID THIS FOR AN HOUR. THEN I CALLED A FRIEND TO COME AND GET ME. I WENT BACK TO MY CAR WHICH IS A 2002 IMPALA, THE NEXT DAY, STILL NOTHING. THE NEXT DAY, STILL NOTHING. I CALLED A TOW TRUCK TO THE DEALER TO GET IT FIXED. ALSO MY POWER DOOR LOCKS HAD QUIT AT THE SAME TIME. I WAS TOLD I HAD TO GIVE THEM $100.00 JUST TO LOOK AT IT. 3 HOURS LATER THEY CALLED AND SAID THAT I COULD PICK UP MY CAR. TOTAL COST TOWING $59.00, DEALER $496.95. I AM DISABLED AND ONLY GET $600.00 A MONTH FROM DISABILITY. NOW I HAVE NO MONEY FOR MY LIVING EXPENSES FOR THE MONTH BUT THE CAR IS STILL DOING THE SAME THING. ON THE 1ST OF OCT. I WENT OUT TO START MY CAR AND GUESS WHAT IT WON'T START. SINCE THIS WAS A SUNDAY I CALLED THE DEALER ON MONDAY MORNING TO TELL THEM THAT IT WAS NOT FIXED . IT WAS STILL DOING THE EXACT SAME THING THAT IT WAS BEFORE THEY SUPPOSEDLY FIXED IT. BY THE WAY WHEN THEY SUPPOSEDLY FIX IT THEY REPLACED THE BMC. NOW THEY WANT ANOTHER $100.00 TO LOOK AT IT AGAIN. THE PART WAS GUARANTEED BUT NOT LABOR, I COULD NOT AFFORD ANOTHER BILL LIKE THE LAST ONE, I JUST HOPE IT STARTS WHEN I GO TO THE DR. IT STARTS ONLY WHEN IT WANTS TO. MY HUSBAND JUST HAD BRAIN SURGERY, I HAVE HAD 5 SURGERIES ON MY SPINE, I NEED A CAR THAT I CAN DEPEND ON TO START. NEVER HAD A PROBLEM WITH IT. I WILL HOLD CHEVROLET RESPONSIBLE IF ANY THING HAPPENS TO MY HUSBAND OR MY SELF BECAUSE THE CAR WON'T START. AFTER I TOOK THE CAR TO THE DEALER I CAME HOME, LOOKED ON THE INTERNET UNDER CHEVROLET IMPALA 2002 AND FOUND 100'S OF SERVICE BULLETINS ON THE VERY SAME PROBLEM. WHY ISN'T ANY THING BEING DONE ABOUT THIS. *TR
NHTSA ODI #10196517
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration