TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE HAD NO POWER WHEN HE ATTEMPTED TO START IT. THE CONTACT REPLACED THE BATTERY THE FIRST TIME BUT THE REMEDY DID NOT CORRECT THE PROBLEM. THE VEHICLE WAS INSPECTED BY A MECHANIC WHO ADVISED THAT THE VEHICLE WOULD NEED A NEW BODY CONTROL MODULE. THE M…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE HAD NO POWER WHEN HE ATTEMPTED TO START IT. THE CONTACT REPLACED THE BATTERY THE FIRST TIME BUT THE REMEDY DID NOT CORRECT THE PROBLEM. THE VEHICLE WAS INSPECTED BY A MECHANIC WHO ADVISED THAT THE VEHICLE WOULD NEED A NEW BODY CONTROL MODULE. THE MECHANIC ADVISED THAT THE FAILURE WAS CAUSED BY THE MODULE BEING BURNED OUT BY THE IGNITION SWITCH. THE VEHICLE WAS NOT INSPECTED BY AN AUTHORIZED DEALER NOR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 57,000. UPDATED 02/03/11*LJ THE CONSUMER WAS TOLD TO WAIT 15 MINUTES AND THEN START THE VEHICLE. THE CONSUMER STATED HE SHOULD NO HAVE TO WAIT TO START THE VEHICLE. UPDATED 03/22/11
NHTSA ODI #10368649
86,000 miles · Nov 14, 2010
Electrical System
2002 IMPALA "PASSKEY" SYSTEM FAILS... NO START CONDITION, LEAVES DRIVER AND PASSENGERS STRANDED.
NHTSA ODI #10365631
Mileage unknown · Nov 12, 2010
Electrical System
INTERMITTENT PASSLOCK FAILURE CAUSED CAR NOT TO START HAVE TO WAIT 20-30 MINUTES TO START MY CAR. *TR
NHTSA ODI #10365414
72,013 miles · Nov 8, 2010
Electrical System
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE SECURITY WARNING LIGHT WAS ILLUMINATED AND THE STARTER FAILED. THE DEALER INSPECTED THE CHARGING SYSTEM AND DETERMINED THAT THE STARTER HAD A DEFECTIVE SOLENOID. THE DEALER REPLACED THE STARTER AND CLEANED THE CABLES. THE CONTACT STATED THAT SHORTLY AFTER …
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE SECURITY WARNING LIGHT WAS ILLUMINATED AND THE STARTER FAILED. THE DEALER INSPECTED THE CHARGING SYSTEM AND DETERMINED THAT THE STARTER HAD A DEFECTIVE SOLENOID. THE DEALER REPLACED THE STARTER AND CLEANED THE CABLES. THE CONTACT STATED THAT SHORTLY AFTER REPAIRS, THE SECURITY WARNING LIGHT WAS ILLUMINATED AGAIN AND THE VEHICLE WOULD NOT START. THE CONTACT BELIEVED THERE WAS A CONNECTION BETWEEN THE SECURITY WARNING LIGHT AND THE VEHICLE FAILURE AND STATED THAT THE FAILURE WAS A RISK TO SAFETY. THE FAILURE MILEAGE WAS 72,013 AND THE CURRENT MILEAGE WAS 72,030.
NHTSA ODI #10365026
85,000 miles · Nov 1, 2010
Electrical SystemEngine And Engine Cooling
AT TIMES THE CAB OF THE 2002 CHEVY IMPALA SEEMS TO OVERHEAT AND WHEN YOU TRY TO START IT ALL OF THE WARNING LIGHTS FLASH, INCLUDING HEADLIGHTS, THEN IT WON'T START. *TR
NHTSA ODI #10363618
106,000 miles · Oct 27, 2010
Electrical SystemService Brakes, Hydraulic
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED WHEN THE SECURITY WARNING LIGHT WAS ILLUMINATED, THE VEHICLE WOULD NOT START. THE CONTACT STATED THAT IF THE VEHICLE WAS BEING DRIVEN WHILE THE WARNING LIGHT WAS ILLUMINATED, THE VEHICLE WOULD CONTINUE TO DRIVE BUT IF TURNED OFF, THE CONTACT WOULD HAVE TO HAVE TO W…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED WHEN THE SECURITY WARNING LIGHT WAS ILLUMINATED, THE VEHICLE WOULD NOT START. THE CONTACT STATED THAT IF THE VEHICLE WAS BEING DRIVEN WHILE THE WARNING LIGHT WAS ILLUMINATED, THE VEHICLE WOULD CONTINUE TO DRIVE BUT IF TURNED OFF, THE CONTACT WOULD HAVE TO HAVE TO WAIT THIRTY MINUTES BEFORE BEING ABLE TO RESTART THE VEHICLE. THE DEALER REPLACED THE STARTER TO NO AVAIL AND ADVISED THE CONTACT THAT HE WAS UNABLE TO DETERMINE WHAT WAS CAUSING THE FAILURE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 106,000 AND THE CURRENT MILEAGE WAS 107,000. UPDATED 03/22/11*LJ THE CONSUMER ALSO STATED THE BRAKES NEEDED TO BE REPLACED EVERY OTHER YEAR. THE CONSUMER HAS SINCE TRADED THE VEHICLE. UPDATED 05/06/11
NHTSA ODI #10362677
140,000 miles · Oct 26, 2010
Electrical SystemEngine And Engine Cooling
2002 IMPALA IN THE CHECK ENGINE LIGHT BOX THE LOW COOLANT LIGHT AND THE SECURITY LIGHTS ALSO SHOWS AND THE BATTERY LIGHT THEN THE ENGINE DIES IN THE MIDDLE OF TRAFFIC I HAVE SEEN SO MANY AND MORE PEOPLE WITH IMPALAS IN DANGEROUS MOMENTS TALKING OF IT ONLINE COULD YOU PLEASE HAVE CHEVY CORRECT THIS DEADLY MESS GOT THE PROBLEM FIX…
Read full complaint
2002 IMPALA IN THE CHECK ENGINE LIGHT BOX THE LOW COOLANT LIGHT AND THE SECURITY LIGHTS ALSO SHOWS AND THE BATTERY LIGHT THEN THE ENGINE DIES IN THE MIDDLE OF TRAFFIC I HAVE SEEN SO MANY AND MORE PEOPLE WITH IMPALAS IN DANGEROUS MOMENTS TALKING OF IT ONLINE COULD YOU PLEASE HAVE CHEVY CORRECT THIS DEADLY MESS GOT THE PROBLEM FIXED THEN IT STARTED BACK I DO HAVE KIDS ACTIVE IN SCHOOL SPORTS NEEDING TRANSPORTATION I CAN NOT DESCRIBE HOW BEING STRANDED IN TRAFFIC MAKES ME FEEL. *TR
NHTSA ODI #10362551
40,000 miles · Oct 14, 2010
Electrical System
2002 CHEVY IMPALA. BOUGHT NEW. THE SPEEDOMETER AND THE FUEL GAGE STARTED TO ACT ERRATICALLY TWO YEARS AGO. THE SPEEDOMETER FAILED COMPLETELY LAST YEAR. IT SHOWS INFINITE SPEED FOR EXAMPLE WHILE IDLING. NO WAY TO KNOW HOW FAST THE CAR IS GOING. THOUSANDS OF PEOPLE REPORTING THE SAME PROBLEM ON VARIOUS INTERNET BLOGS. THE PROBLEM …
Read full complaint
2002 CHEVY IMPALA. BOUGHT NEW. THE SPEEDOMETER AND THE FUEL GAGE STARTED TO ACT ERRATICALLY TWO YEARS AGO. THE SPEEDOMETER FAILED COMPLETELY LAST YEAR. IT SHOWS INFINITE SPEED FOR EXAMPLE WHILE IDLING. NO WAY TO KNOW HOW FAST THE CAR IS GOING. THOUSANDS OF PEOPLE REPORTING THE SAME PROBLEM ON VARIOUS INTERNET BLOGS. THE PROBLEM EXISTS ON ALL IMPALA MODELS, STARTING WITH 2001 AND UNTIL PRESENT. SOME OTHER GM CARS HAVE A SIMILAR PROBLEM. GM DOES NOT CARE. DEALERS CHARGE UP TO $900 TO REPLACE AN INSTRUMENT CLUSTER, AND SOMETIMES A SPEED SENSORS. MANY TIMES THEY ARE GUESSING THE PROBLEM AND OVERCHARGE CUSTOMERS FOR TRAIL AND ERROR DIAGNOSTIC. THE ISSUE IS A SAFETY ISSUE. PEOPLE ARE GETTING SPEEDING TICKETS FOR NO FAULT OF THEIR OWN. CAR CAN OVERTURN ON SHARP TURNS. THE DRIVER HAS ONLY HIS GUT FEELING TO GUESS HOW FAST HE IS GOING. HE CAN BE TO SLOW ON A HIGHWAY AND POSE RISK TO OTHER DRIVERS. GM IS NOT CONCERNED AND WON'T FIX THIS PROBLEM, UNLESS A RECALL IS FORCED ON IT. PLEASE SAFEGUARD THE LIVES OF DRIVERS AND FORCE GM TO DO WHAT IS FAIR AND JUST. THEY SOLD A DEFECTIVE PRODUCT AND SHOULD FIX THE PROBLEM IMMEDIATELY. THANK YOU *TR
NHTSA ODI #10360447
67,000 miles · Oct 12, 2010
Electrical System
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE SECURITY SYSTEM ON THE VEHICLE WOULD LOCK UP AND THE VEHICLE WOULD NOT START AS A RESULT. THE FAILURE OCCURRED AT LEAST ONCE EVERY WEEK AT ANY TIME. THE CONTACT WOULD HAVE TO WAIT AND KEEP ATTEMPTING TO START THE VEHICLE; EVENTUALLY, IT WOULD START. THE BAT…
Read full complaint
TL*THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE SECURITY SYSTEM ON THE VEHICLE WOULD LOCK UP AND THE VEHICLE WOULD NOT START AS A RESULT. THE FAILURE OCCURRED AT LEAST ONCE EVERY WEEK AT ANY TIME. THE CONTACT WOULD HAVE TO WAIT AND KEEP ATTEMPTING TO START THE VEHICLE; EVENTUALLY, IT WOULD START. THE BATTERY, ALTERNATOR AND STARTER WERE REPLACED BUT THE FAILURE CONTINUED TO OCCUR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE WIRING SYSTEM NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 127,000. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000.
NHTSA ODI #10360115
118,000 miles · Aug 24, 2010
Electrical System
UNKNOWN REASON AS TO WHY THE DIRECTIONALS ON MY 02 IMPALA WORK INTERMITTENTLY. THIS FIRST OCCURRED APPROXIMATELY 4 MONTHS AGO WITH AVERAGE OCCURRENCE OF ONCE A WEEK. NOW IT OCCURS APPROXIMATELY ONCE A DAY. MECHANIC CANNOT FIND A SOLID REASON AS TO WHY THIS IS OCCURRING AND CANNOT REPLICATE IT AT THE TIME THE VEHICLE IS IN THE S…
Read full complaint
UNKNOWN REASON AS TO WHY THE DIRECTIONALS ON MY 02 IMPALA WORK INTERMITTENTLY. THIS FIRST OCCURRED APPROXIMATELY 4 MONTHS AGO WITH AVERAGE OCCURRENCE OF ONCE A WEEK. NOW IT OCCURS APPROXIMATELY ONCE A DAY. MECHANIC CANNOT FIND A SOLID REASON AS TO WHY THIS IS OCCURRING AND CANNOT REPLICATE IT AT THE TIME THE VEHICLE IS IN THE SHOP. *TR
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2002 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration