NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
305 reportsClear category filter102,000 miles · Apr 16, 2012
Electrical SystemExterior Lighting
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE HEADLIGHTS MALFUNCTIONED WHEN SWITCHING FROM LOW BEAMS TO HIGH BEAMS. THE MANUFACTURER WAS NOTIFIED, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOW EXPERIENCING ANOTHER NEW SAFETY CONCERN IN REGARDS TO TH…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE HEADLIGHTS MALFUNCTIONED WHEN SWITCHING FROM LOW BEAMS TO HIGH BEAMS. THE MANUFACTURER WAS NOTIFIED, BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS NOW EXPERIENCING ANOTHER NEW SAFETY CONCERN IN REGARDS TO THE PASS LOCK, WHERE THE COMPONENTS WERE WEARING OUT. THE SECURITY SYSTEM WOULD NOT RECOGNIZE THE KEY WHEN IT WAS INSERTED INTO THE IGNITION. THIS LOCKED THE CONTACT IN THE VEHICLE AND PREVENTED IT FROM STARTING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE HAD NOT BEEN DRIVEN SINCE THIS PASS LOCK FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 102,000.
NHTSA ODI #10455399
35,000 miles · Mar 6, 2012
Electrical SystemExterior Lighting
TURN SIGNALS WORK INTERMEDIATELY. THIS IS A VERY COMMON ISSUE WITH IMPALAS. VERY DANGEROUS WHEN I SIGNAL I DON'T KNOW IF IT IS GOING TO WORK. I HAVE ALMOST CAUSED MULTIPLE ACCIDENTS BECAUSE OF THIS ISSUE. I COMPLAINED MULTIPLE TIMES TO THE DEALER BUT THEY CLAIMED NOTHING WAS WRONG. AS SOON AS I HIT THE 100,000 MILE MARK THEY ALL…
Read full complaint
TURN SIGNALS WORK INTERMEDIATELY. THIS IS A VERY COMMON ISSUE WITH IMPALAS. VERY DANGEROUS WHEN I SIGNAL I DON'T KNOW IF IT IS GOING TO WORK. I HAVE ALMOST CAUSED MULTIPLE ACCIDENTS BECAUSE OF THIS ISSUE. I COMPLAINED MULTIPLE TIMES TO THE DEALER BUT THEY CLAIMED NOTHING WAS WRONG. AS SOON AS I HIT THE 100,000 MILE MARK THEY ALL OF A SUDDEN HAVE A SOLUTION. THIS SHOULD BE FIXED BY THE DEALER BECAUSE OF THE NUMBER OF TIMES IT'S BEEN REPORTED. THERE IS OBVIOUSLY SOMETHING GOING ON WITH THE SWITCH. *TR
NHTSA ODI #10450514
Mileage unknown · Jan 13, 2012
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
CAR CRANKS WHEN IT WANTS TOO IT CRANKS UP AND SOMETIME IS DOES NOT. *TR
NHTSA ODI #10443676
72,554 miles · Jan 2, 2012
Electrical System
AIR BAG LIGHT HAS BEEN DIAGNOSTIC BY, AUTHORIZED CHEVY DEALER, AS NEEDING TO BE REPLACED. ESTIMATED COST OF THE PART $703.00 PLUS TAX AND SHIPPING. THIS IS A PART THAT SHOULD LAST THE LIFE OF THE VEHICLE ,ESPECIALLY AT THAT PRICE. I WAS TOLD, THERE IS RECALLS IN REFERENCE THE SAFETY AIR BAG SYSTEM FOR 2002 CHEVY IMPALA'S .WAS T…
Read full complaint
AIR BAG LIGHT HAS BEEN DIAGNOSTIC BY, AUTHORIZED CHEVY DEALER, AS NEEDING TO BE REPLACED. ESTIMATED COST OF THE PART $703.00 PLUS TAX AND SHIPPING. THIS IS A PART THAT SHOULD LAST THE LIFE OF THE VEHICLE ,ESPECIALLY AT THAT PRICE. I WAS TOLD, THERE IS RECALLS IN REFERENCE THE SAFETY AIR BAG SYSTEM FOR 2002 CHEVY IMPALA'S .WAS THIS PART INCLUDED IN THE RECALL ? IF NOT, THIS PART SHOULD BE, OR AT LEAST MADE AVAILABLE TO THE END CUSTOMER AT THE MANUFACTURERS COST. I AM A CONTINUES GENERAL MOTORS CUSTOMER SINCE 1987. THIS 2002 IMPALA HAS GIVEN ME ELECTRICAL PROBLEMS SINCE I PURCHASED IT. I AM AT THE POINT OF LOOKING AT DIFFERENT PRODUCT LINES. I AM VERY INTERESTED IN GM RESPONSE TO THIS . *TR
NHTSA ODI #10442090
115,000 miles · Dec 23, 2011
Electrical System
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START INTERMITTENTLY AFTER DRIVING A SHORT DISTANCE. WHEN THE FAILURE OCCURRED, THE SECURITY WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER INFORMED THE CONTACT THAT THE PASS LOCK 2 FUNCTION HAD A FAILED PASS LOCK SENSOR.…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START INTERMITTENTLY AFTER DRIVING A SHORT DISTANCE. WHEN THE FAILURE OCCURRED, THE SECURITY WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER INFORMED THE CONTACT THAT THE PASS LOCK 2 FUNCTION HAD A FAILED PASS LOCK SENSOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. NO REPAIRS WERE PERFORMED. THE CURRENT MILEAGE WAS 127,000 AND THE FAILURE MILEAGE WAS 115,000.
NHTSA ODI #10441081
184,000 miles · Nov 14, 2011
Electrical System
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA LS. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ON NUMEROUS OCCASIONS WHILE THEY KEY WAS IN THE IGNITION. THE CONTACT STATED THAT A RED SECURITY FAILURE LIGHT ILLUMINATED DURING THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS CONTACTED WHO ADVISED THA…
Read full complaint
TL* THE CONTACT OWNS A 2002 CHEVROLET IMPALA LS. THE CONTACT STATED THAT THE VEHICLE FAILED TO START ON NUMEROUS OCCASIONS WHILE THEY KEY WAS IN THE IGNITION. THE CONTACT STATED THAT A RED SECURITY FAILURE LIGHT ILLUMINATED DURING THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS CONTACTED WHO ADVISED THAT THE FAILURE MIGHT BE CAUSED BY THE SECURITY PASS LOCK SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 184,000 AND THE CURRENT MILEAGE WAS 191,000.
NHTSA ODI #10435557
Mileage unknown · Nov 7, 2011
Electrical System
I HAVE A 2002 CHEVY IMPALA,DOOR LOCKS,LOCK AN UNLOCK BY THERE SELF DRAINING THE BATTERY,DOME LIGHT STAYS ON BLINKERS DON'T WORK THERE'S A CLICKING SOUND COMING OUT OF FUSE BOX DASH LIGHTS AND HEAD LIGHTS BLINK CAR STARTS BUT RUNS ERRATICALLY,REPLACED TURN SIGNAL SWITCH DID NOT HELP,WIPERS STAY IN THE UP RITE POSITION ALSO,I'VE T…
Read full complaint
I HAVE A 2002 CHEVY IMPALA,DOOR LOCKS,LOCK AN UNLOCK BY THERE SELF DRAINING THE BATTERY,DOME LIGHT STAYS ON BLINKERS DON'T WORK THERE'S A CLICKING SOUND COMING OUT OF FUSE BOX DASH LIGHTS AND HEAD LIGHTS BLINK CAR STARTS BUT RUNS ERRATICALLY,REPLACED TURN SIGNAL SWITCH DID NOT HELP,WIPERS STAY IN THE UP RITE POSITION ALSO,I'VE TRIED CONTACTING GM NO LUCK,DO NOT TRUST DEALERSHIP BEEN RIPPED OFF MORE THAN ONCE. *TR
NHTSA ODI #10434771
100,000 miles · Oct 10, 2011
Electrical SystemEngine And Engine Cooling
AFTER STARTING THE CAR BLOWER MOTOR WONT WORK CRUISE LIGHT STAYS ON MIRROR CLUSTER DON'T WORK UNTIL 15 MIN THEN EVERYTHING WILL WORK BUT WHEN USING THE CRUISE IT WILL STOP WORKING BUT LIGHT STAYS ON AFTER TIME GAUGES CUT OUT AND THEN COME BACK ON AND ALL PROBLEMS SLOWLY BECOME WORSE WITH TIME. HAVE REASON TO BELIEVE ITS THE IGN…
Read full complaint
AFTER STARTING THE CAR BLOWER MOTOR WONT WORK CRUISE LIGHT STAYS ON MIRROR CLUSTER DON'T WORK UNTIL 15 MIN THEN EVERYTHING WILL WORK BUT WHEN USING THE CRUISE IT WILL STOP WORKING BUT LIGHT STAYS ON AFTER TIME GAUGES CUT OUT AND THEN COME BACK ON AND ALL PROBLEMS SLOWLY BECOME WORSE WITH TIME. HAVE REASON TO BELIEVE ITS THE IGNITION SWITCH. *KB
NHTSA ODI #10429374
130,000 miles · Oct 6, 2011
Electrical SystemExterior LightingSeats
I BOUGHT THIS CAR 4 YEARS AGO AND I DID NOT HAVE PROBLEMS TILL THIS HAPPENED, THE CAR DON'T WANT TO STAR IN SEVERAL TIMES, IM ALREADY PISSED OFF AND I DON'T REALLY KNOW WHAT TO DO WITH IT, CUZ I KNOW THAT NOBODY IS GOING TO BUY IT LIKE THAT; I LIKE THE CAR BUT THIS IS INOPERABLE!!!! *TR
NHTSA ODI #10428890
111,440 miles · Aug 24, 2011
Electrical System
SECURITY SYSTEM FAILURE. VEHICLE WOULD NOT START. LUCKILY I WAS IN MY DRIVEWAY WHEN IT REFUSED TO START. HAD TO REPLACE BODY CONTROL MODULE, LOCK CYLINDER WITH PASSLOCK SENSOR BEFORE CAR WOULD START. THIS MAY NOT SEEM LIKE A SAFETY PROBLEM, BUT, WHEN YOU THINK ABOUT ALL THE PLACES YOUR CAR COULD LEAVE YOU STRANDED, IT'S SCARY. I…
Read full complaint
SECURITY SYSTEM FAILURE. VEHICLE WOULD NOT START. LUCKILY I WAS IN MY DRIVEWAY WHEN IT REFUSED TO START. HAD TO REPLACE BODY CONTROL MODULE, LOCK CYLINDER WITH PASSLOCK SENSOR BEFORE CAR WOULD START. THIS MAY NOT SEEM LIKE A SAFETY PROBLEM, BUT, WHEN YOU THINK ABOUT ALL THE PLACES YOUR CAR COULD LEAVE YOU STRANDED, IT'S SCARY. I AM NOT THE ONLY ONE WHO HAS HAD THIS PROBLEM. THERE ARE THOUSANDS OF COMPLAINTS WITH THIS PROBLEM ON SEVERAL WEB SITES.THIS IS A FAULT OF GENERAL MOTORS, THEY KNOW ABOUT THE PROBLEM AND HAVE NOT DONE ANYTHING TO HELP THEIR CUSTOMERS WITH THIS PROBLEM. THEY NEED TO COME UP WITH A PERMANENT FIX FOR THE PASSLOCK SYSTEM AND HAVE A RECALL AND FIX IT ONCE AND FOR ALL. AVERAGE COST FOR THIS REPAIR IS ABOUT $1,000.00 DOLLARS. THE CUSTOMERS WHO HAVE PAID IT DESERVES THEIR MONEY BACK. *TR
NHTSA ODI #10421285
Official recalls
4Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Aug 9, 2002
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence & remedy
Consequence: PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy: DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration