IllustrationCONSUMER SMELLED ANTIFREEZE FOR SOME TIME. THEN, WHILE HAVING AN OIL CHANGE, IT WAS DISCOVERED THERE WAS A LEAK IN THE INTAKE MANIFOLD SEAL.*AK
2001 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
470–25K
8825–50K
8350–75K
7375–100K
112100–150K
73150K+
476 reports with mileage · 266 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 225 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports67 fire reports27 injury reports
What owners actually said
742 reportsCONSUMER STATED THAT SHE KEPT SEEING PUDDLES OF ANTI-FREEZE UNDER HER VEHICLE. SHE SAID SHE TOOK HER VEHICLE TO THE MECHANIC AND AFTER AN EXAMINATION OF THE AUTOMOBILE, SHE WAS TOLD THAT HER VEHICLE WAS LEAKING COOLANT AROUND THE MANIFOLD. SHE STATES THIS VEHICLE IS MUCH TOO NEW FOR THIS TYPE OF PROBLEM. *JB
CLUNKING FROM FRONT STEERING AND THROUGH STEERING WHEEL. GM HAS SERVICE BULLETIN ID#1539408 (#04-02-35-004B (JUL 27,2004)) THAT DESCRIBES FAILURE. GM HAS REFUSED REPLACEMENT OR REPAIR UNDER WARRANTY. *JB
VEHICLE WOULD INTERMITTENTLY NOT START. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK THE CONSUMER STATED THAT WHEN THE SECURITY LIGHT COMES ON THE VEHICLE WILL NOT START. THE VEHICLE HAS TO SIT FOR 15 MINUTES BEFORE IT WILL START. *TC
WHILE DRIVING AT ANY SPEED THE CONSUMER COULD HEAR NOISE COMING FROM THE FRONT WHEEL. FRONT PASSENGER SIDE WHEEL BEARING FAILED. THE REAR DRIVER'S SIDE WHEEL BEARING ALSO FAILED AT 38,600. *AK
CAR WAS PURCHASED USED IN 2002 WITH 33000 ON IT. ONE MONTH LATER, A POPPING/CLICKING SOUND BEGAN IN THE STEERING WHEEL COLUMN, AND THE STEERING WHEEL DID NOT MOVE SMOOTHLY WHEN IN TURNING MOTIONS. TAKEN TO DEALERSHIP, TOLD THE INTERMEDIATE STEERING SHAFT NEEDED LUBRICATION. REPLACEMENT NOT RECOMMENDED. WARRANTY COVERED. TWO YEAR…
Read full complaint
CAR WAS PURCHASED USED IN 2002 WITH 33000 ON IT. ONE MONTH LATER, A POPPING/CLICKING SOUND BEGAN IN THE STEERING WHEEL COLUMN, AND THE STEERING WHEEL DID NOT MOVE SMOOTHLY WHEN IN TURNING MOTIONS. TAKEN TO DEALERSHIP, TOLD THE INTERMEDIATE STEERING SHAFT NEEDED LUBRICATION. REPLACEMENT NOT RECOMMENDED. WARRANTY COVERED. TWO YEARS LATER, PROBLEM CAME BACK, ALBEIT FAR MORE SEVERE THIS TIME. IMMEDIATELY TOOK TO DEALERSHIP AND WAS TOLD THE INTERMEDIATE STEERING SHAFT WAS COMING APART AND NEEDED IMMEDIATE REPLACEMENT. WARRANTY HAD EXPIRED AND CHEVROLET WOULD NOT COVER. WENT AHEAD WITH REPAIR ANYWAY BECAUSE WAS EXTREMELY SCARED BY THE PROBLEM! HAVE SUBMITTED FORMAL COMPLAINT TO CHEVROLET OF THIS PROBLEM AND FOUND MANY OTHER COMPLAINTS OF THE SAME PROBLEM. AM HOPING CHEVROLET WILL CORRECT THIS DESIGN FLAW.*AK
ON MY 2001 CHEVROLET IMPALA, AN AIR BAG LIGHT WAS ON. THE GM DEALERSHIP IN NEW RICHMOND WI, REPLACED AN AIRBAG MODULE IN OCTOBER. A FEW WEEKS LATER I NOTICED ONLINE THAT THERE WAS A RECALL FOR MY CAR, THAT BEING THE AIRBAG MODULE THAT WAS CHANGED. SO I BROUGHT IN THE RECALL INFORMATION TO THE GM DEALERSHIP AND THEY SAID MY V…
Read full complaint
ON MY 2001 CHEVROLET IMPALA, AN AIR BAG LIGHT WAS ON. THE GM DEALERSHIP IN NEW RICHMOND WI, REPLACED AN AIRBAG MODULE IN OCTOBER. A FEW WEEKS LATER I NOTICED ONLINE THAT THERE WAS A RECALL FOR MY CAR, THAT BEING THE AIRBAG MODULE THAT WAS CHANGED. SO I BROUGHT IN THE RECALL INFORMATION TO THE GM DEALERSHIP AND THEY SAID MY VIN DOESN'T SHOW UP AS BEING PART OF THE RECALL, SO THEY COULDN'T HELP. BUT THEY SAID I COULD CALL UP GM. SO I CALLED THE CHEVROLET CUSTOMER ASSISTANCE CENTER AT 1-800-222-1020. THEY ALSO SAID THAT MY CAR WASN'T PART OF THE RECALL. *AK WITH HAVING THE RIGHT YEAR, MAKE, MODEL, AND REPLACING THE EXACT PART THAT WAS RECALLED, I BELIEVE MY CAR SHOULD HAVE BEEN APART OF THE RECALL. CAN YOU HELP? JOEL HETZEL
COMPLAINT RECEIVED VIA E-MAIL."I WOULD LIKE TO REPORT WHAT I CONSIDER TO BE A DEFECTIVE AND POTENTIAL FIRE HAZARD ON MY TRUCK. THE CATALYTIC CONVERTER FAILED AND THE EGR VALVE RETURNED HOT GASES INTO THE INTAKE MANIFOLD. THE HOT GASES BURNED A HOLE IN THE PLASTIC INTAKE MANIFOLD AND MELTED THE WIRING HARNESS. THIS COULD OF CAUS…
Read full complaint
COMPLAINT RECEIVED VIA E-MAIL."I WOULD LIKE TO REPORT WHAT I CONSIDER TO BE A DEFECTIVE AND POTENTIAL FIRE HAZARD ON MY TRUCK. THE CATALYTIC CONVERTER FAILED AND THE EGR VALVE RETURNED HOT GASES INTO THE INTAKE MANIFOLD. THE HOT GASES BURNED A HOLE IN THE PLASTIC INTAKE MANIFOLD AND MELTED THE WIRING HARNESS. THIS COULD OF CAUSED A FIRE IN THE ENGINE COMPARTMENT. THE ENGINE STOPPED WORKING PROPERLY AND THE VEHICLE HAD TO BE TOWED TO THE GARAGE. MY LOCAL GARAGE REPLACED THE INTAKE MANIFOLD. THE ENGINE WAS STILL NOT RUNNING PROPERLY. I HAD MY LOCAL GARAGE TAKE THE CAR TO OUR CHEVROLET GARAGE. THEY FOUND THE PROBLEM WITH THE CONVERTER AND REPLACED IT UNDER FEDERAL WARRANTY. I REPORTED THIS TO GM. BOTH GARAGE AGREED THAT THIS WAS CAUSED DUE TO THE FAILURE OF THE MANIFOLD. I BELIEVE THE PLASTIC MANIFOLD SHOULD BE RECALLED AS A SAFETY FACTOR." *JB *SC
MANIFOLD AND PUMP GASKET LEAKED. *NM THE LOW COOLANT LIGHT CAME ON. *TC *JB
WHEN PARKING AIR BAG WARNING LIGHT ILLUMINATED UNTIL THE VEHICLE WAS TURNED OFF. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
Official recalls
715V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
01V136000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
00V371000 · Air Bags:side/window
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
00V244000 · Air Bags
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.