Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
470–25K
8825–50K
8350–75K
7375–100K
112100–150K
73150K+
476 reports with mileage · 266 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 225 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports67 fire reports27 injury reports
What owners actually said
742 reports
Mileage unknown · May 19, 2005
Electrical SystemEngine And Engine CoolingExterior Lighting
PROBLEMS WITH THE WIRING SYSTEM ON THE 2001 CHEVROLET IMPALA AFTER THE VEHICLE WAS IMPOUNDED. *MR THE TEMPERATURE GAUGE, GAS MILEAGE AND THE TURN SIGNALS WERE INOPERATIVE AND THE RADIATOR HOSE HAD BURNED AGAINST THE BATTERY. THE CONSUMER FOUND THAT THE WIRING SYSTEM WAS CHANGED. THE CONSUMER ALSO FOUND MISSING COMPONENTS S…
Read full complaint
PROBLEMS WITH THE WIRING SYSTEM ON THE 2001 CHEVROLET IMPALA AFTER THE VEHICLE WAS IMPOUNDED. *MR THE TEMPERATURE GAUGE, GAS MILEAGE AND THE TURN SIGNALS WERE INOPERATIVE AND THE RADIATOR HOSE HAD BURNED AGAINST THE BATTERY. THE CONSUMER FOUND THAT THE WIRING SYSTEM WAS CHANGED. THE CONSUMER ALSO FOUND MISSING COMPONENTS SUCH AS A FUSE AND A HUGE HOLLOW AREA DUE TO THE MISSING FANS. *SC *JB
NHTSA ODI #10122610
2,781 miles · May 16, 2005
Service Brakes, Hydraulic
2001 CHEVROLET IMPALA EXPERIENCING PROBLEMS WITH ACCELERATOR PEDAL AS WELL AS THE VEHICLE VIBRATING WHEN THE BRAKES ARE APPLIED. *MR THIS WOULD BECOME MUCH WORSE AT HIGHER SPEEDS. THE ORIGINAL BRAKE LININGS HAD COME OFF OF THE SHOES. ALL OF THE ROTORS WERE REPLACED AT 2781K MILES. THE ROTORS HAD TO BE TURNED 3 TIMES TO GE…
Read full complaint
2001 CHEVROLET IMPALA EXPERIENCING PROBLEMS WITH ACCELERATOR PEDAL AS WELL AS THE VEHICLE VIBRATING WHEN THE BRAKES ARE APPLIED. *MR THIS WOULD BECOME MUCH WORSE AT HIGHER SPEEDS. THE ORIGINAL BRAKE LININGS HAD COME OFF OF THE SHOES. ALL OF THE ROTORS WERE REPLACED AT 2781K MILES. THE ROTORS HAD TO BE TURNED 3 TIMES TO GET THEM FLAT. *SC *JB
NHTSA ODI #10121525
74,881 miles · May 5, 2005
Engine And Engine Cooling
I HAVE JUST PURCHASED A 2001 IMPALA FROM DEALER LESS THAN A WEEK AGO (4/29/2005) AND I TOOK IT TO THE DEALER TODAY FOR SOME MAINTENANCE. THE DEALER TOLD ME THE INTAKE MANIFOLD IS LEAKING ANTIFREEZE INTO THE ENGINE AND IT IS QUITE SERIOUS. I HAVE CHECKED SOME ONLINE DISCUSSION GROUPS AND THERE SEEMS TO BE A LOT OF COMPLAINTS ON T…
Read full complaint
I HAVE JUST PURCHASED A 2001 IMPALA FROM DEALER LESS THAN A WEEK AGO (4/29/2005) AND I TOOK IT TO THE DEALER TODAY FOR SOME MAINTENANCE. THE DEALER TOLD ME THE INTAKE MANIFOLD IS LEAKING ANTIFREEZE INTO THE ENGINE AND IT IS QUITE SERIOUS. I HAVE CHECKED SOME ONLINE DISCUSSION GROUPS AND THERE SEEMS TO BE A LOT OF COMPLAINTS ON THIS ISSUE. IT SEEMS LIKE THIS IS A COMMON PROBLEM ON THE IMPALAS. I THINK GM SHOULD ISSUE A RECALL FOR THIS ISSUE AND REIMBURSE MY COST OF REPAIR.
NHTSA ODI #10120015
Mileage unknown · Apr 27, 2005
Engine And Engine Cooling
THE LOW COOLANT LIGHT STAYS ON INDICATING THAT THE ENGINE COULD OVER HEAT. CONSUMER CHECKED THE ENGINE AND FOUND THAT THERE WAS A FLUID LEAK OUT THE ENGINE. AS A RESULT THE CONSUMER HAS TO PUT IN COOLANT ABOUT ONCE A MONTH TO AVOID OVERHEATING.*AK DEALER PUT NEW GASKET IN AT INTAKE MANIFOLD AND REPAIRED RADIATOR. *BF *NM
NHTSA ODI #10115530
Mileage unknown · Apr 19, 2005
Engine And Engine Cooling
COOLANT SYSYEM:TEMPERATURE GAUGE MOVES TO HOT FOR ABOUT 5 MINUTES THEN BACK TO NORMAL. CLICKING SOUND IN STEERING WHEEL WHEN YOU YOU MAKE A TURN. LOUD POPPING OR CRACKING SOUND IN THE DASH AREA WITH VARIOUS TEMPERATURE CHANGES.*AK
NHTSA ODI #10118089
30,000 miles · Apr 12, 2005
Steering
MY 2001 CHEVROLET IMPALA IS JERKING WHEN APPLYING THE BRAKES, FRONT END SOUNDS LIKE IT IS READY TO FALL APART,FRONT END WOBBLES WHEN DRIVING,KNOCKS WHEN PUT INTO DRIVE OR REVERSE,TRANSMISSION BOGS WHEN SHIFTING BROUGHT TO THE DEALERSHIP THEY DROVE IT AND DECIDED A NEW STEERING SHAFT WOULD SOLVE ALL MY PROBLEMS, AMD GM IS ALSO AW…
Read full complaint
MY 2001 CHEVROLET IMPALA IS JERKING WHEN APPLYING THE BRAKES, FRONT END SOUNDS LIKE IT IS READY TO FALL APART,FRONT END WOBBLES WHEN DRIVING,KNOCKS WHEN PUT INTO DRIVE OR REVERSE,TRANSMISSION BOGS WHEN SHIFTING BROUGHT TO THE DEALERSHIP THEY DROVE IT AND DECIDED A NEW STEERING SHAFT WOULD SOLVE ALL MY PROBLEMS, AMD GM IS ALSO AWARE OF THIS PROBLEM AND USED TO REPACE SHAFT BUT THAT GOT TOO EXPENSIVE SO NOW THEY HAVE A KIT TO LUBRICATE THE BEARING. MY CAR IS UNDER WARRANTY, BUT THIS PROBLEM IS NOT INCLUDED . STEERING IS ESSENTIAL IN A VEHICLE. I FIND THIS PROBLEM A SAFETY ISSUE FOR MYSELF,PASSENGERS, AND OTHERS ON THE ROAD WITH ME. I AM FILING THIS COMPLAINT FOR DOCUMENTATION. IF EVER THERE IS AN ACCIDENT RELATED TO THE STEERING ISSUE OF MY CAR I WANT THE COURTS TO KNOW THAT ALL WERE AWARE OF THIS PROBLEM I WAS HAVING AND NOBODY WANTED TO FIX A DEFECT THAT THEY WERE AWARE OF. I WILL BE FIXING IT AT MY EXPENSE AND WHEN IT IS RECALLE I WOULD LIKE TO BE REIMBURSED.*AK
NHTSA ODI #10116815
Mileage unknown · Apr 6, 2005
Exterior Lighting
INTERMITTENTLY WHILE DRIVING AT NIGHT THE HEADLIGHTS FAILED.THIS CAUSED POOR VISIBILITY TO THE DRIVER. VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, BUT MECHANIC COULD NOT DUPLICATE THE PROBLEM AT THIS TIME. *AK
NHTSA ODI #10117553
45,000 miles · Apr 3, 2005
Exterior Lighting
BLINKER, HAZARDS WOULD NOT WORK AFTER IT RAINED. HAD TO HAVE THE MULTI SWITCHED REPLACED. (GM #88964580). *AK
NHTSA ODI #10116300
50,000 miles · Apr 3, 2005
Exterior Lighting
BLINKERS AND HAZARDS WOULD STOP WORKING AT TIMES.*AK
NHTSA ODI #10116297
27,000 miles · Mar 23, 2005
Steering
STEERING WHEEL SEEMS VERY HARD TO TURN ,AND WHEN TURNING A CORNER IT PULLS VERY HARD. DEALER CAN'T DUPLICATE THE PROBLEM.*AK
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
2001 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration