IllustrationNO ACCIDENT HAS OCCURRED AS OF YET. THE CAR STOPS WHEN I AM AT STOP SIGNS AND RED LIGHTS. IT HAS EVEN STOPPED WHEN ON THE INTERSTATE AND I HAVE GONE FROM 70 MPH TO 0 MPH IN LESS THAN 60 SECONDS. *NM
2001 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
470–25K
8825–50K
8350–75K
7375–100K
112100–150K
73150K+
476 reports with mileage · 266 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 225 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 123 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
33 crash reports67 fire reports27 injury reports
What owners actually said
742 reportsTHERE IS A HUGE AMOUNT OF OIL IN THE COOLANT IN MY 2001 CHEVY IMPALA. KNOWING JUST A LITTLE ABOUT INTERNAL COMBUSTION ENGINES PROBABLY AN INTAKE GASKET LEAKING. FOR A CAR WHICH HAS BEEN VERY WELL MAINTAINED WITH UNDER 80,000 MILES ON THE ODOMETER THIS WAS ALARMING. HIGH ENGINE TEMP AND A SLUDGE IN MY MOTOR ARE THE OBVIOUS CONS…
Read full complaint
THERE IS A HUGE AMOUNT OF OIL IN THE COOLANT IN MY 2001 CHEVY IMPALA. KNOWING JUST A LITTLE ABOUT INTERNAL COMBUSTION ENGINES PROBABLY AN INTAKE GASKET LEAKING. FOR A CAR WHICH HAS BEEN VERY WELL MAINTAINED WITH UNDER 80,000 MILES ON THE ODOMETER THIS WAS ALARMING. HIGH ENGINE TEMP AND A SLUDGE IN MY MOTOR ARE THE OBVIOUS CONSEQUENCES. WHO KNOWS WHAT THE LONG TERM AFFECTS WILL BE. THE CAR IS NOW AT THE MECHANICS AND ALREADY I AM LOOKING AT 700 TO 1,000 DOLLARS WHICH I DO NOT HAVE TO REPAIR. *NM
REPEATED BROKEN WINDOW MECHANISM IN TWO SEPARATE CHEVROLET CARS IN THE PAST TWO YEARS. *JB
I HAVE HAD ISSUES WITH MY 2001 CHEVROLET IMPALA REGARDING THE PASSLOCK SENSOR, WHICH IS PART OF THE IGNITION SWITCH. THERE'S A SERVICE BULLETIN OUT ON THE PART. I'VE CONTACTED GM AND THEY OUT RIGHT TOLD ME THAT THEY WEREN'T GOING TO DO ANYTHING ABOUT MY PROBLEM BECAUSE MY CAR HAS TOO MANY MILES ON IT. I HAD THE PART REPLACED …
Read full complaint
I HAVE HAD ISSUES WITH MY 2001 CHEVROLET IMPALA REGARDING THE PASSLOCK SENSOR, WHICH IS PART OF THE IGNITION SWITCH. THERE'S A SERVICE BULLETIN OUT ON THE PART. I'VE CONTACTED GM AND THEY OUT RIGHT TOLD ME THAT THEY WEREN'T GOING TO DO ANYTHING ABOUT MY PROBLEM BECAUSE MY CAR HAS TOO MANY MILES ON IT. I HAD THE PART REPLACED WITHIN THE FIRST 6 MONTHS OF PURCHASING THE CAR BRAND NEW. I HAD IT REPLACED AGAIN ON 11-10-05, WHICH TOOK A YEAR AND A HALF TO DIAGNOSE THE PROBLEM. NOW I AM HAVING THE PROBLEM AGAIN. I CONTACTED CHEVROLET TODAY AND THEY REFUSED TO EVEN HELP...WOULDN'T EVEN OPEN A COMPLAINT FOR ME. THEY'RE SAYING THAT NO ONE ELSE IS HAVING THIS PROBLEM, BUT I'VE RESEARCHED FORUMS AND IT APPEARS THAT SEVERAL PEOPLE ARE HAVING THIS PROBLEM. I DON'T FEEL THAT I SHOULD HAVE TO PAY TO HAVE THIS REPAIR DONE AGAIN SINCE IT WAS DONE 11 MONTHS AGO. I'M IRRITATED AND I WOULD LIKE A RESPONSE FROM SOMEONE AS TO WHAT WILL BE DONE. *NM
I HAVE A 2001 CHEVY IMPALA AND IT HAS BEEN LEAKING ENGINE COOLANT FOR SOMETIME NOW. WE PUT THE REQUIRED DEXCOOL COOLANT TO REPLACE THE LOST, BUT IT JUST KEPT ON LEAKING. WE TOOK IT TO A MECHANIC TO REPAIR IT AND HE INFORMED US THAT IT WAS LEAKING FROM THE INTAKE GASKET DOWN ONTO THE SPARK PLUGS AND IT WAS DAMAGING THE SPARK PLUG…
Read full complaint
I HAVE A 2001 CHEVY IMPALA AND IT HAS BEEN LEAKING ENGINE COOLANT FOR SOMETIME NOW. WE PUT THE REQUIRED DEXCOOL COOLANT TO REPLACE THE LOST, BUT IT JUST KEPT ON LEAKING. WE TOOK IT TO A MECHANIC TO REPAIR IT AND HE INFORMED US THAT IT WAS LEAKING FROM THE INTAKE GASKET DOWN ONTO THE SPARK PLUGS AND IT WAS DAMAGING THE SPARK PLUGS. HE SAID DON'T PUT DEXCOOL COOLANT INTO THE CAR AGAIN BECAUSE IT JUST DAMAGES THE GASKETS. HE SAID I CANT TELL U HOW MANY TIMES I HAVE HAD TO REPAIR THIS SAME THING ON CHEVROLET VEHICLES. TOTAL REPAIRS $749.43 . THERE NEEDS TO BE A RECALL ON THIS. NOT JUST BECAUSE OF THE DEXCOOL COOLANT BUT BECAUSE OF THE GASKETS. *NM
DT*: THE CONTACT STATED WHILE DRIVING ANY SPEED THERE WAS A BANGING NOISE IN THE STEERING COLUMN ACCOMPANIED BY A VIBRATION. THE BANGING AND THE VIBRATION BECAME GRADUALLY WORSE WHEN THE STEERING WHEEL WAS TURNED TO EITHER SIDE. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHO DETERMINED THAT THE INTERMEDIATE STEERING SHAFT NEE…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING ANY SPEED THERE WAS A BANGING NOISE IN THE STEERING COLUMN ACCOMPANIED BY A VIBRATION. THE BANGING AND THE VIBRATION BECAME GRADUALLY WORSE WHEN THE STEERING WHEEL WAS TURNED TO EITHER SIDE. THE VEHICLE WAS TAKEN TO A SERVICE DEALER WHO DETERMINED THAT THE INTERMEDIATE STEERING SHAFT NEEDED TO BE REPACKED. THE SHAFT WAS SUBSEQUENTLY REPLACED, BUT THE PROBLEM RECURRED. UPDATED 9/22/2006 - THE FUEL TANK SENDING UNIT WAS REPLACED. THE FUEL INJECTOR UNIT WAS REPLACED INTAKE GASKET LEAKED. *NM
TRANSMISSION FAILURE. *NM
POWER TRAIN FAILURE: FIRST SIGN OF PROBLEM WAS HARSH SHIFTING, HAD THE TRANSMISSION FLUID AND FILTER CHANGED, STILL HAD SAME PROBLEM. BEFORE I FOUND THE SERVICE BULLETINS ON THIS PROBLEM THE PLANETARY GEARS GOT CHEWED UP BY A BROKEN PIECE OF METAL, HAD TO REBUILD THE TRANSMISSION $1800. FILED COMPLAINT WITH GM, SINCE I DID NOT H…
Read full complaint
POWER TRAIN FAILURE: FIRST SIGN OF PROBLEM WAS HARSH SHIFTING, HAD THE TRANSMISSION FLUID AND FILTER CHANGED, STILL HAD SAME PROBLEM. BEFORE I FOUND THE SERVICE BULLETINS ON THIS PROBLEM THE PLANETARY GEARS GOT CHEWED UP BY A BROKEN PIECE OF METAL, HAD TO REBUILD THE TRANSMISSION $1800. FILED COMPLAINT WITH GM, SINCE I DID NOT HAVE IT REPAIRED AT A DEALER (FOR TWICE THE PRICE) THEY WOULD NOT HELP. NOW I HAVE A 2001 MONTE CARLO SHOWING THE SAME HARSH SHIFTING. THE TRANSMISSION HAS BE FLUSHED BY THE DEALER AND THEY PUT AN ADDITIVE INTO THE TRANSMISSION FLUID TO HELP THE STICKY VALUE PROBLEM, DID NOT WORK. THERE IS A PATTERN HERE AND GM WILL NOT STAND BEHIND THEIR PRODUCT. *NM
(1) I WAS DRIVING ON 2 LANE UNDIVIDED STATE HIGHWAY ON A CLEAR DAY WITH THE CRUISE CONTROL AND FELL ASLEEP WHILE DRIVING. MY WIFE AND I WERE THE ONLY OCCUPANTS. I WOKE ON THE SIDE OF THE HIGHWAY GOING ABOUT 65 MPH. I STARTED BRAKING (ABS BRAKES) I THINK WE SLOWED TO ABOUT 50 MPH BEFORE HITTING THE BLUNT END OF A GUARD RAIL. …
Read full complaint
(1) I WAS DRIVING ON 2 LANE UNDIVIDED STATE HIGHWAY ON A CLEAR DAY WITH THE CRUISE CONTROL AND FELL ASLEEP WHILE DRIVING. MY WIFE AND I WERE THE ONLY OCCUPANTS. I WOKE ON THE SIDE OF THE HIGHWAY GOING ABOUT 65 MPH. I STARTED BRAKING (ABS BRAKES) I THINK WE SLOWED TO ABOUT 50 MPH BEFORE HITTING THE BLUNT END OF A GUARD RAIL. THE CAR IMPACTED ABOUT 6 INCHES RIGHT(DRIVERS SIDE) OF CENTER ON THE FRONT. SEAT BELTS WERE IN USE. THE CAR HAD SPUN 170 DEGREES CLOCKWISE AND COME TO A COMPLETE STOP AND THEN I LOOKED AT MY WIFE FOR AN INSTANT WHEN HER AIRBAG WENT OFF CLOSELY FOLLOWED BY MY AIR BAG. (2) THE FAILURE OF THE AIRBAGS RESULTED IN SEAT BELT RELATED STRAINS AND SOFT TISSUE INJURIES FOR MY WIFE. I RECEIVED A BRUISE ON THE CHEST. (3) SO FAR NOTHING HAS BEEN DONE. THE INSURANCE COMPANY SOLD THE CAR TO A USED AUTO PARTS YARD. I WAS ABLE TO TRACK IT DOWN AND I BOUGHT THE COMPUTER MODULE THAT WAS UNDER THE PASSENGER SIDE SEAT. I WITNESSED THE REMOVAL. I WAS UNSUCCESSFUL AT CONTACTING CHEVROLET. *JB
THE ANTI-LOCK BRAKING SYSTEM WOULD ENGAGE WHEN THE BRAKE PEDAL WAS DEPRESSED AT LOW TO MODERATE SPEEDS. THIS OCCURRED ON DRY PAVEMENT AND SEEMED TO EXTEND THE LENGTH OF TIME NEEDED TO COME TO A COMPLETE STOP. THE DEALERSHIP REPLACED THE HUB AND SENSOR. THE PROBLEM RECURRED. THE HUB AND SENSOR WERE ADJUSTED. THE PROBLEM RECURRED…
Read full complaint
THE ANTI-LOCK BRAKING SYSTEM WOULD ENGAGE WHEN THE BRAKE PEDAL WAS DEPRESSED AT LOW TO MODERATE SPEEDS. THIS OCCURRED ON DRY PAVEMENT AND SEEMED TO EXTEND THE LENGTH OF TIME NEEDED TO COME TO A COMPLETE STOP. THE DEALERSHIP REPLACED THE HUB AND SENSOR. THE PROBLEM RECURRED. THE HUB AND SENSOR WERE ADJUSTED. THE PROBLEM RECURRED. THE DEALERSHIP HAD TO REPLACE THE WIRING HARNESS TO CORRECT THE PROBLEM. OLD PARTS WERE NEVER OFFERED IN RETURN. THE REPAIR WAS NOT COVERED BY WARRANTY. *JB
Official recalls
715V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
01V136000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
00V371000 · Air Bags:side/window
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
00V244000 · Air Bags
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.