NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
742 reports50,000 miles · Jun 8, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNED A 2001 CHEVROLET IMPALA. WHILE DRIVING LESS THAN 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT EXITED THE VEHICLE AND NOTICED FLAMES UNDER THE HOOD. THE VEHICLE EXPLODED. THE FIRE AND POLICE DEPARTMENTS ARRIVED AT THE SCENE AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE FAILURE AND C…
Read full complaint
TL*THE CONTACT OWNED A 2001 CHEVROLET IMPALA. WHILE DRIVING LESS THAN 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT EXITED THE VEHICLE AND NOTICED FLAMES UNDER THE HOOD. THE VEHICLE EXPLODED. THE FIRE AND POLICE DEPARTMENTS ARRIVED AT THE SCENE AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 50,000.
NHTSA ODI #10273117
100,000 miles · Jun 8, 2009
Power Train
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WAS NOT RECEIVING ENOUGH POWER. THE DEALER REPLACED THE SPARK PLUGS AND THE STARTER, BUT THE FAILURE CONTINUED. WHILE DRIVING MORE THAN 60 MPH, THE VEHICLE WOULD SHAKE VIOLENTLY. THE DEALER WAS UNABLE TO CORRECT THE FAILURES. THE VIN WAS UNKNOW…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE WAS NOT RECEIVING ENOUGH POWER. THE DEALER REPLACED THE SPARK PLUGS AND THE STARTER, BUT THE FAILURE CONTINUED. WHILE DRIVING MORE THAN 60 MPH, THE VEHICLE WOULD SHAKE VIOLENTLY. THE DEALER WAS UNABLE TO CORRECT THE FAILURES. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 100,000.
NHTSA ODI #10273112
100,000 miles · Jun 8, 2009
Engine And Engine CoolingFire
TL*THE CONTACT OWNED A 2001 CHEVROLET IMPALA. THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD OF HER VEHICLE. SHE LIFTED THE HOOD AND NOTICED A SMALL FIRE BETWEEN THE ALTERNATOR AND SEVERAL WIRES. THE DRIVER WAS ABLE TO EXTINGUISH THE FIRE AFTER A FEW MINUTES WITH A FIRE EXTINGUISHER. THE FIRE DEPARTMENT ARRIVED AFTER THE FIRE…
Read full complaint
TL*THE CONTACT OWNED A 2001 CHEVROLET IMPALA. THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD OF HER VEHICLE. SHE LIFTED THE HOOD AND NOTICED A SMALL FIRE BETWEEN THE ALTERNATOR AND SEVERAL WIRES. THE DRIVER WAS ABLE TO EXTINGUISH THE FIRE AFTER A FEW MINUTES WITH A FIRE EXTINGUISHER. THE FIRE DEPARTMENT ARRIVED AFTER THE FIRE WAS EXTINGUISHED. THE LOCAL GM DEALER COULD NOT DETERMINE THE CAUSE OF THE FIRE; HOWEVER, THEY CONFIRMED THAT THE MANIFOLD GASKET WAS LEAKING AND MAY HAVE STARTED THE FIRE. ONE WEEK LATER, THE CONTACT RECEIVED A RECALL NOTICE THAT STATED "IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND, INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE". NHTSA CAMPAIGN ID NUMBER 09V116000 WAS REFERENCED. NO REPAIRS HAVE BEEN MADE TO THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE LESS THAN 100,000. UPDATED 8/10/09 *CN UPDATED 08/13/09.*JB
NHTSA ODI #10273092
90,000 miles · Jun 8, 2009
Unknown Or Other
SAFETY RECALL RECEIVED FROM GM ON 6/5/09 REGARDING RECALL #09047. CONTACTED DEALER ON 6/8/09 FOR NEEDED REPAIRS AND WAS TOLD THAT PARTS ARE NOT AVAILABLE AND NO ETA FOR AVAILABILITY AND/OR REPAIRS. *TR
NHTSA ODI #10273071
158,000 miles · Jun 5, 2009
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT THE REMEDY REFERENCED IN NHTSA CAMPAIGN ID NUMBER 09V116000 (ENGINE AND ENGINE COOLING) WOULD NOT SUFFICIENTLY CORRECT THE FAILURE. HE STATED THAT BY INSTALLING TWO NEW SPARK PLUG WIRE RETAINERS FOR FREE WILL NOT STOP DROPS OF ENGINE OIL FROM BEING DEPOSITED …
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT THE REMEDY REFERENCED IN NHTSA CAMPAIGN ID NUMBER 09V116000 (ENGINE AND ENGINE COOLING) WOULD NOT SUFFICIENTLY CORRECT THE FAILURE. HE STATED THAT BY INSTALLING TWO NEW SPARK PLUG WIRE RETAINERS FOR FREE WILL NOT STOP DROPS OF ENGINE OIL FROM BEING DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING. THE DEALER DID NOT ASSIST. THE FAILURE AND CURRENT MILEAGES WERE 158,000.
NHTSA ODI #10272975
125,000 miles · Jun 2, 2009
Electrical System
I HAVE 2001 CHEVY IMPALA AND IT HAS STARTING ISSUES. IT DOESN'T START AT TIMES AND IT'S GETTING TO BE MORE OFTEN AND NOTHING WILL GET IT TO START. I JUST LEAVE IT SIT, SOMETIIMES FOR 2 HOURS AND IT MAY OR MAY NOT START. IT QUIT WHILE GETTING READY TO STOP AT A RED LIGHT AND ALMOST CAUSED AN ACCIDENT, AS I COULDN'T STEER MY CAR …
Read full complaint
I HAVE 2001 CHEVY IMPALA AND IT HAS STARTING ISSUES. IT DOESN'T START AT TIMES AND IT'S GETTING TO BE MORE OFTEN AND NOTHING WILL GET IT TO START. I JUST LEAVE IT SIT, SOMETIIMES FOR 2 HOURS AND IT MAY OR MAY NOT START. IT QUIT WHILE GETTING READY TO STOP AT A RED LIGHT AND ALMOST CAUSED AN ACCIDENT, AS I COULDN'T STEER MY CAR AND IT SMELLED HOT. ALSO THE BLINKERS WON'T WORK AT TIMES AND I HAVE TO PRESS MY EMERGENCY FLASHER SWITCH TO GET THEM TO WORK. I HAVE REPLACED THE STARTER AND THE STARTING ISSUE HASN'T IMPROVED AT ALL. IT IS VERY MADDENING AS I NEVER KNOW WHEN IT WILL NOT START WHEN I GO TO LEAVE SOMEWHERE AND IT'S VERY UNDEPENDABLE TO TAKE ANYWHERE. PLEASE CAN YOU HELP WITH THIS PROBLEM? IT HAS BEEN HAPPENING FOR THE LAST YEAR AND IS HAPPENING MORE OFTEN LATELY. *TR
NHTSA ODI #10272613
Mileage unknown · May 22, 2009
Steering
WHILE I WAS DRIVING TO A STORE MY CAR WAS DRIVING JUST FINE BUT, AS I WAS TURNING A CORNER MY STEERING WHEEL LOCKED UP ON ME. THIS ALMOST CAUSED ME TO HIT A CAR THAT WAS AT A STOP SIGN. I HAVEN'T HAD ANY PROBLEMS WITH THIS UNTIL NOW.. IT JUST HAPPENED UNEXPECTEDLY. I CHECKED THE FLUID AND IT WAS FINE THE CAR THEN DROVE OFF JUST …
Read full complaint
WHILE I WAS DRIVING TO A STORE MY CAR WAS DRIVING JUST FINE BUT, AS I WAS TURNING A CORNER MY STEERING WHEEL LOCKED UP ON ME. THIS ALMOST CAUSED ME TO HIT A CAR THAT WAS AT A STOP SIGN. I HAVEN'T HAD ANY PROBLEMS WITH THIS UNTIL NOW.. IT JUST HAPPENED UNEXPECTEDLY. I CHECKED THE FLUID AND IT WAS FINE THE CAR THEN DROVE OFF JUST FINE. *TR
NHTSA ODI #10269760
53,542 miles · Apr 30, 2009
Service Brakes, HydraulicVehicle Speed Control
MY DAUGHTER WAS IN THE FAST LANE ON I71 HEADING FROM COLUMBUS, OHIO TO CLEVELAND, OHIO. SHE SET THE CRUISE CONTROL AT 75 MPH AND WENT TO BRAKE BECAUSE TRAFFIC WAS SLOWING DOWN. WHEN SHE HIT THE BRAKE THEY DID NOTHING! SHE IMMEDIATELY PANICKED AND MOVED OVER 4 LANES OF TRAFFIC TO THE BERM NEARLY CAUSING AN ACCIDENT. SHE QUICK…
Read full complaint
MY DAUGHTER WAS IN THE FAST LANE ON I71 HEADING FROM COLUMBUS, OHIO TO CLEVELAND, OHIO. SHE SET THE CRUISE CONTROL AT 75 MPH AND WENT TO BRAKE BECAUSE TRAFFIC WAS SLOWING DOWN. WHEN SHE HIT THE BRAKE THEY DID NOTHING! SHE IMMEDIATELY PANICKED AND MOVED OVER 4 LANES OF TRAFFIC TO THE BERM NEARLY CAUSING AN ACCIDENT. SHE QUICKLY THREW THE CAR IN NEUTRAL AND IT STOPPED. I CALLED A CHEVROLET DEALER AFTER SHE CALLED ME FRIGHTENED TO DRIVE THE CAR. THEY ASKED IF THE CAR MATS POSSIBLY BLOCKED THE BRAKE AND MY DAUGHTER SAID NO, SHE REACHED DOWN AND PULLED IT OUT AND THE CAR WOULD STILL NOT SLOW DOWN. SHE EVEN STATED BOTH FEET WERE PUSHING DOWN ON THE BREAK PEDAL AND NOTHING WAS SLOWING DOWN THE CAR. I JUST HAD A FRONT HUB REPLACED AT AUTO PLUS (WHERE I TAKE MY CARS FOR SERVICE) IN ORIENT, OHIO. MY DAUGHTER AND HER FRIEND COULD HAVE BEEN KILLED BECAUSE OF THE CRUISE CONTROL. *TR
NHTSA ODI #10267339
Mileage unknown · Apr 17, 2009
Service Brakes, Hydraulic
I HAVE ROTATED MY FRONT ROTORS AND CHANGED BRAKE PADS 2. I ALSO HAVE REPLACED THEM AND 6 MONTHS LATER I HAVE TO TURN THE NEW ONES. THEY HAVE WARPED AND MY CAR VIBRATES VERY BAD. *TR
NHTSA ODI #10265906
38,000 miles · Apr 17, 2009
Engine And Engine Cooling
I PURCHASED THIS CAR WITH 28,000 MILES ON IT. AROUND 38,000 MILES IS WHEN THE PROBLEMS STARTED. THE CHECK ENGINE LIGHT CAME ON AND IT WOULD NOT PASS SMOG BECAUSE OF THAT. THE THERMOSTAT GETS STUCK, THE FAN CONTINUES TO RUN AFTER CAR IS SHUT OFF, THE LOW COOLANT LIGHT COMES ON EVEN WHEN IT IS NOT LOW. THE CAR SMELLS LIKE IT IS BU…
Read full complaint
I PURCHASED THIS CAR WITH 28,000 MILES ON IT. AROUND 38,000 MILES IS WHEN THE PROBLEMS STARTED. THE CHECK ENGINE LIGHT CAME ON AND IT WOULD NOT PASS SMOG BECAUSE OF THAT. THE THERMOSTAT GETS STUCK, THE FAN CONTINUES TO RUN AFTER CAR IS SHUT OFF, THE LOW COOLANT LIGHT COMES ON EVEN WHEN IT IS NOT LOW. THE CAR SMELLS LIKE IT IS BURNING OR RUNNING HOT. THE CAR NOW HAS 53,000 MILES ON IT AND I CANT AFFORD TO GET IT FIXED. IT HAS EXPIRED TAGS ON IT BECAUSE I CANT GET IT TO PASS SMOG. I AM REALLY UPSET TO FIND OUT THIS IS A DEFECT IN THE MAKE OF THE CAR. IT WAS HARD ENOUGH TO COME UP WITH THE MONEY TO BUY THIS CAR AND NOW I CANT DRIVE IT MORE THEN TO WORK AND BACK. I AM HOPING THEY WILL RECALL THIS CAR AND I COULD FINALLY GET IT FIXED. *TR
NHTSA ODI #10265703
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration