NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
23 reportsClear category filter41,000 miles · Jan 25, 2017
Unknown Or Other
I HAVE MULTIPLE PROBLEMS AND PARTS REPLACED ON MY 2001 CHEVY IMPALA 3.8. WITHIN 2 WEEKS OF PURCHASING I'VE BEEN BATTLING ABS, TRAC OFF, AND SERVICE TRACTION SYSTEM CODES FOR 10 YEARS NOW AND I'VE REPLACED PARTS OVER AND OVER ONLY FOR THE LIGHTS TO GO OUT FOR MAYBE 30 DAYS THEN COME BACK ON AND STAY ON. I'M IN THE MILITARY AND …
Read full complaint
I HAVE MULTIPLE PROBLEMS AND PARTS REPLACED ON MY 2001 CHEVY IMPALA 3.8. WITHIN 2 WEEKS OF PURCHASING I'VE BEEN BATTLING ABS, TRAC OFF, AND SERVICE TRACTION SYSTEM CODES FOR 10 YEARS NOW AND I'VE REPLACED PARTS OVER AND OVER ONLY FOR THE LIGHTS TO GO OUT FOR MAYBE 30 DAYS THEN COME BACK ON AND STAY ON. I'M IN THE MILITARY AND DEPLOYED FOR A YEAR RIGHT AFTER PURCHASING THE CAR WITHOUT EXTENDED WARRANTY BUT 30 DAY WARRANTY. I WAS TOLD WHEN I GOT BACK TO BRING IT IN BECAUSE I HAD THE ISSUE 2 WEEKS AFTER I BOUGHT IT AND THEY FIXED IT THEN IT REPEATED IN 3 MONTHS. 1 YEAR LATER THEY SAID THEY WOULDN'T FIX IT AND THEY WOULD JUST FIND ANOTHER BROKEN PART DIFFERENT FROM BEFORE AND POINT IT TO THAT AND NOT COVER FIXING THE ISSUE I BOUGHT THE CAR WITH. SO MULTIPLESHOPS AND PARTS LATER I'M STILL REPLACING PARTS. LR WHEEL SENSOR READS 0 AND I JUST REPLACED THE SENSOR AGAIN.... NOW ABOUT TO BUY THE WIRING HARNESS AND TRY THAT AGAIN.
NHTSA ODI #10947532
Mileage unknown · Jan 7, 2016
Unknown Or OtherFire
WHILE STARTING 2001 IMPALA 3.8 INTAKE MANIFOLD EXPLODED CAUSING FIRE. HAVE READ OF MANY OTHER CASES ONLINE SINCE THIS HAPPENED THIS MORNING. 1/7/2016..IF CAR HAD BEEN IN GARAGE IT COULD HAVE BEEN REALLY BAD...THIS SHOULD BE A RECALL FROM GM....
NHTSA ODI #10818739
60,000 miles · Dec 5, 2015
Electrical SystemUnknown Or Other
THE IGNITION KEEPS LOCKING OUT THE CARS ABILITY TO START. ON NUMEROUS OCCASIONS THIS VEHICLE WOULD NOT START AFTER ENTERING THE VEHICLE. THE LIGHTS WOULD COME ON AND WHEN THE KEY IS ROTATED TO THE START POSITION NOTHING WOULD HAPPEN. UPON WAITING FOR 10 TO 20 MINUTES THIS VEHICLE WILL THEN RESTART. WHEN TAKEN TO THE GARAGE T…
Read full complaint
THE IGNITION KEEPS LOCKING OUT THE CARS ABILITY TO START. ON NUMEROUS OCCASIONS THIS VEHICLE WOULD NOT START AFTER ENTERING THE VEHICLE. THE LIGHTS WOULD COME ON AND WHEN THE KEY IS ROTATED TO THE START POSITION NOTHING WOULD HAPPEN. UPON WAITING FOR 10 TO 20 MINUTES THIS VEHICLE WILL THEN RESTART. WHEN TAKEN TO THE GARAGE TO HAVE MAINTENANCE DONE THIS VEHICLE NEVER FAILED FOR THEM ON TWENTY TIMES OF STARTING IN A ROW. TOOK THE CAR HOME AND IT SAT AND NOW IT FAILED AGAIN. MY DAUGHTER IS ABOUT TO BE DISMISSED FROM HER CURRENT JOB BECAUSE OF THIS CONSTANT FAILURE TO START. LATELY, THE TIME HAS GROWN. MY DAUGHTER TOOK A VIDEO OF THE INCIDENT AND HAVE TAKEN IT BACK TO THE DEALER AND THEY ARE NOT ABLE TO DUPLICATE THE PROBLEM. THEY SAID THEY HAD TO JUMP IT TO START IT AND WHEN QUESTIONED ABOUT IT THEY STATED IT TOOK THEM 10 TO 15 MINUTES TO GATHER ALL THE EQUIPMENT TO GET IT TO START. THE PROBLEM WOULD HAVE RESOLVED ITSELF IN THAT TIME. THIS IS NOW BECOMING LIFE THREATING AS THE VEHICLE STALLS IN TRAFFIC AND AN ACCIDENT COULD HAPPEN. NO CODES ARE SHOWING FOR THIS ACCORDING TO THE DEALER. THIS HAS BEEN GOING ON FOR APPROXIMATELY 5 MONTHS NOW AND GETTING WORSE. IN MY OPINION IT IS SOMETHING TO DO WITH THE IGNITION OR SECURITY SYSTEM. I HOPE NOTHING SERIOUS HAPPENS WHILE MY DAUGHTER IS DRIVING. THIS IS THE ONLY VEHICLE SHE HAS FOR TRANSPORTATION. I AM SUBMITTING THIS ON HER BEHALF.
NHTSA ODI #10808569
28,000 miles · Jun 22, 2015
Electrical SystemFuel/propulsion SystemUnknown Or Other
AS ANY SERIOUS CAR OWNER, I TRIED TO ADDRESS THE CHEAPER ITEMS SUCH AS BATTERY REPLACEMENT AND SPARK PLUGS, ALL HAVE BEEN REPLACED TWICE. SLOWLY ALL THE ELECTRICAL APPLICATIONS IN MY CAR BEGAN TO STOP WORKING FROM THE BLINKERS, RADIO, HAZARDS, CRUISE CONTROL, CAR WINDOWS, AND FINALLY THE CAR STOPPED STARTING. I WAS TOO BROKE TO …
Read full complaint
AS ANY SERIOUS CAR OWNER, I TRIED TO ADDRESS THE CHEAPER ITEMS SUCH AS BATTERY REPLACEMENT AND SPARK PLUGS, ALL HAVE BEEN REPLACED TWICE. SLOWLY ALL THE ELECTRICAL APPLICATIONS IN MY CAR BEGAN TO STOP WORKING FROM THE BLINKERS, RADIO, HAZARDS, CRUISE CONTROL, CAR WINDOWS, AND FINALLY THE CAR STOPPED STARTING. I WAS TOO BROKE TO ADDRESS IT THEN, SO EVERY EARLY MORNING MY CAR WOULD REQUIRE A NICE JUMP START TO BEGIN THE DAY. THIS IMPALA WOULD NOT START SO OFTEN THAT I PURCHASED A PORTABLE BATTERY TO JUMP IT EVERYWHERE, EVEN AS SIMPLE AS THE GAS STATION. AT FIRST I THOUGHT THE PARASITIC DRAIN (DRAIN ON THE CAR BATTERY) WAS COMING FROM THE DASH CLUSTER/INSTRUMENT PANEL WHICH WAS IN LINE WITH THE COMPLAINTS I HAVE DISCOVERED ON GOOGLE THAT THE BCM WAS CAUSING NON-STARTER ISSUES FOR OTHER IMPALAS. HOWEVER, ONCE THE INSTRUMENT PANEL WAS REPLACED MY RADIO WAS STILL NOT WORKING AND EVENTUALLY THE CAR BECAME A NON-STARTER AGAIN; THEREFORE, I SUSPECTED THE ROOT OF THE ISSUE STILL HAND NOT BEEN DISCOVERED. I EXPLAINED THIS TO MR. MCGHEE, THE OWNER OF MCGHEES AUTO SHOP, HE DID A THOROUGH JOB OF COMBING ALL THE INTRICATE WIRES TO DETERMINE FINALLY AN INTERMITTENT DRAW OCCURRING FROM THE AMPLIFIER IN THE TRUNK OF THE CAR. THE SOLUTION TO THE PROBLEM, FIXING THE AMPLIFIER, COST A GRAND TOTAL OF 220$ TO HAVE THE ACTUAL PART FIXED; I DID NOT WANT TO RISK PLACING A NON-STOCK AMPLIFIER, MY SPECIFIC AMPLIFIER IS NO LONGER AVAILABLE, IN THE CAR. HOWEVER, I LIKE OTHER CONSUMERS CONTINUALLY PAID TO REPLACE PARTS THAT FAILED AS IT WAS NOT OBVIOUS THERE WAS AN UNDERLYING MALFUNCTIONING IN A PARTICULAR APPLICATION THAT MADE THE ESSENTIAL PRODUCT USELESS.
NHTSA ODI #10726639
193,301 miles · May 16, 2015
Unknown Or Other
AS I WAS DRIVING MY ABS / TRACTION CONTROL LIGHT CAME ON AT 45MPH I WAS BRAKING AND HEARD THIS WEIRD SOUND I WAS SLOWLY BRAKING AND THE CAR WASAT COMPLETE STOP ACELARATING THEN MY CAR POWERED OFF.
NHTSA ODI #10716857
200,000 miles · Jan 31, 2015
Unknown Or Other
WELL I TOOK THE CAR IN T 10AM FOR YEMMS TO PUT THE CHIP IN THE KEY AND THE CAR STILL DOESN'T START. SO I TOOK THE KEY TO GET ANOTHER ONE MADE TESTED AND THERE WAS NO CHIP FOUND IN THE KEY. SO NOW WHAT THE CAR DOESN'T MOVE SO I CAN'T TAKE IT TO YEMMS.
NHTSA ODI #10680151
155,000 miles · Jul 7, 2014
Electrical SystemUnknown Or Other
SECURITY SYSTEM IS ALWAYS LOCKING UP I HAVE TO WAIT 10 MINUTES BEFORE I CAN START CAR... I ALSO KNOW SEVERAL OTHER IMPALA OWNERS AND THIS IS A PROBLEM FOR THEM TOO.. IT'S A VERY BIG INCONVENIENCE ESPECIALLY WHEN YOU SHOW UP TO WORK LATE BECAUSE OF IT... IT IS SO MUCH OF A PROBLEM I WILL NEVER BUY ANOTHER IMPALA AND PROBABLY NEVE…
Read full complaint
SECURITY SYSTEM IS ALWAYS LOCKING UP I HAVE TO WAIT 10 MINUTES BEFORE I CAN START CAR... I ALSO KNOW SEVERAL OTHER IMPALA OWNERS AND THIS IS A PROBLEM FOR THEM TOO.. IT'S A VERY BIG INCONVENIENCE ESPECIALLY WHEN YOU SHOW UP TO WORK LATE BECAUSE OF IT... IT IS SO MUCH OF A PROBLEM I WILL NEVER BUY ANOTHER IMPALA AND PROBABLY NEVER PURCHASE A CHEVY EVER AGAIN! *JS
NHTSA ODI #10608790
Mileage unknown · Apr 17, 2014
Unknown Or Other
WE HAVE A 2001 IMPALA THAT'S BEEN DOWN FOR AWHILE EVERYONE SAID IT WAS THE IGNITION SWITH SO WE CHANGED IT WE ALSO CHANGED THE HAZARD SWITCH BUTTON AND STILL NOTHING AND THE BATTERY WONT HOLD A CHARGE WHEN IT WAS RUNNING BATTERY LIGHT WOULD FLASH ON AND OFF. *TT
NHTSA ODI #10583377
Mileage unknown · Feb 17, 2012
Electrical SystemEngine And Engine CoolingUnknown Or Other
BOUGHT THIS CAR USED AND IT WAS RUNNING FINE FOR ABOUT A YEAR TILL IT GOT TO THE POINT THAT THE CAR WOULD NOT CRANK AND SECURITY LOCK WOULD POP UP FREQUENTLY NOW IT ALMOST TAKES AN HOUR TO CRANK IT EVEN IF U HIT THE STARTER THE STATER MOVES BUT WANT CRANK THE CAR I HAVE SPENT OVER 4 GRAND ON IT TRYING TO FIX IT BUT NOTHING WORKS…
Read full complaint
BOUGHT THIS CAR USED AND IT WAS RUNNING FINE FOR ABOUT A YEAR TILL IT GOT TO THE POINT THAT THE CAR WOULD NOT CRANK AND SECURITY LOCK WOULD POP UP FREQUENTLY NOW IT ALMOST TAKES AN HOUR TO CRANK IT EVEN IF U HIT THE STARTER THE STATER MOVES BUT WANT CRANK THE CAR I HAVE SPENT OVER 4 GRAND ON IT TRYING TO FIX IT BUT NOTHING WORKS EVEN CHECKED FUSES WIRES AND COMPUTER BOX NOTHING LOOKS BAD CRUISE CONTROL STOPPED WORKING AWHILE BACK TOO. *TR
NHTSA ODI #10448355
90,000 miles · Jun 8, 2009
Unknown Or Other
SAFETY RECALL RECEIVED FROM GM ON 6/5/09 REGARDING RECALL #09047. CONTACTED DEALER ON 6/8/09 FOR NEEDED REPAIRS AND WAS TOLD THAT PARTS ARE NOT AVAILABLE AND NO ETA FOR AVAILABILITY AND/OR REPAIRS. *TR
NHTSA ODI #10273071
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration