NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
76 reportsClear category filter64,000 miles · Jan 8, 2005
Steering
1) THERE'S A KNOWN PROBLEM WITH THE INTERMEDIATE STEERING SHAFT ON MOST W,J, AND G PLATFORM GENERAL MOTORS VEHICLES. IN AS LITTLE AS 15-20K MILES, THE STEERING WILL GET SLOPPY AND WILL "KLUNK" ON LOW SPEED STEERING MANEUVERS, AND WILL ALSO "KLUNK" ON ACCELERATION AND BRAKING. ) IN SOME CASES, THE STEERING SHAFT WILL BIND UP O…
Read full complaint
1) THERE'S A KNOWN PROBLEM WITH THE INTERMEDIATE STEERING SHAFT ON MOST W,J, AND G PLATFORM GENERAL MOTORS VEHICLES. IN AS LITTLE AS 15-20K MILES, THE STEERING WILL GET SLOPPY AND WILL "KLUNK" ON LOW SPEED STEERING MANEUVERS, AND WILL ALSO "KLUNK" ON ACCELERATION AND BRAKING. ) IN SOME CASES, THE STEERING SHAFT WILL BIND UP OR BREAK, RESULTING IN STEERING FAILURE. THERE ARE DOCUMENTED CASES OF THIS HAPPENING IN POLICE EQUIPPED IMPALA VEHICLES. 3) IN MY CASE, THE DEALERSHIP "LUBED" THE STEERING SHAFT. RATHER THAN REPLACE THE FAULTY PART, GM ADVICES TO INJECT A SYRINGE OF GREASE INTO THE YOKE OF THE SHAFT, AND PLACE THE PART BACK INTO THE VEHICLE. 10-15K MILES LATER, THE PROBLEM RETURNS. I'VE TWICE HAD MY STEERING SHAFT LUBED FOR THIS PROBLEM. GM HAS JUST RECENTLY DEVELOPED A REDESIGNED PART, BUT AVAILABILITY IS SEVERELY LIMITED, AND THE COST OF REPLACEMENT IS PLACED ON THE VEHICLE OWNER IF OUTSIDE THE WARRANTY PERIOD (3YEAR/36000 MILES. *AK
NHTSA ODI #10105962
40,483 miles · Jan 5, 2005
Electrical SystemSteering
A CLANKING/GROWLING NOISE WAS HEATD WHILE DRIVING AND MAKING TURNS. VEHICLE WAS TAKEN TO THE DEALER WHO INFORMED THE CONSUMER THAT THE STEERING SHAFT NEEDED TO BE REPLACED. CONSUMER HAD A CONCERN THAT THE VEHICLE HAD LESS THEN 41,000 MILES OF WEAR. *NM THE BATTERY WAS REPLACED. *JB
NHTSA ODI #10101649
32,000 miles · Jan 5, 2005
Steering
THE CONSUMER WAS HAVING A PROBLEM WITH THE STEERING. THE CONSUMER CONTACTED THE DEALER AND WAS TOLD THAT THE MANUFACTURER WAS AWARE OF THE STEERING PROBLEM BUT WAS NOT DOING ANYTHING ABOUT IT. PROVIDE FURTHER DETAILS. *JB THE STEERING SHAFT WAS TAKEN OUT AN GREASED. TIE RODS WENT BAD ON THE RIGHT SIDE.
NHTSA ODI #10101520
60,754 miles · Dec 8, 2004
Steering
CLUNKING FROM FRONT STEERING AND THROUGH STEERING WHEEL. GM HAS SERVICE BULLETIN ID#1539408 (#04-02-35-004B (JUL 27,2004)) THAT DESCRIBES FAILURE. GM HAS REFUSED REPLACEMENT OR REPAIR UNDER WARRANTY. *JB
NHTSA ODI #10102359
33,000 miles · Nov 16, 2004
Steering
CAR WAS PURCHASED USED IN 2002 WITH 33000 ON IT. ONE MONTH LATER, A POPPING/CLICKING SOUND BEGAN IN THE STEERING WHEEL COLUMN, AND THE STEERING WHEEL DID NOT MOVE SMOOTHLY WHEN IN TURNING MOTIONS. TAKEN TO DEALERSHIP, TOLD THE INTERMEDIATE STEERING SHAFT NEEDED LUBRICATION. REPLACEMENT NOT RECOMMENDED. WARRANTY COVERED. TWO YEAR…
Read full complaint
CAR WAS PURCHASED USED IN 2002 WITH 33000 ON IT. ONE MONTH LATER, A POPPING/CLICKING SOUND BEGAN IN THE STEERING WHEEL COLUMN, AND THE STEERING WHEEL DID NOT MOVE SMOOTHLY WHEN IN TURNING MOTIONS. TAKEN TO DEALERSHIP, TOLD THE INTERMEDIATE STEERING SHAFT NEEDED LUBRICATION. REPLACEMENT NOT RECOMMENDED. WARRANTY COVERED. TWO YEARS LATER, PROBLEM CAME BACK, ALBEIT FAR MORE SEVERE THIS TIME. IMMEDIATELY TOOK TO DEALERSHIP AND WAS TOLD THE INTERMEDIATE STEERING SHAFT WAS COMING APART AND NEEDED IMMEDIATE REPLACEMENT. WARRANTY HAD EXPIRED AND CHEVROLET WOULD NOT COVER. WENT AHEAD WITH REPAIR ANYWAY BECAUSE WAS EXTREMELY SCARED BY THE PROBLEM! HAVE SUBMITTED FORMAL COMPLAINT TO CHEVROLET OF THIS PROBLEM AND FOUND MANY OTHER COMPLAINTS OF THE SAME PROBLEM. AM HOPING CHEVROLET WILL CORRECT THIS DESIGN FLAW.*AK
NHTSA ODI #10100018
38,000 miles · Oct 15, 2004
SteeringSuspension
A POPPING CAN BE HEARD AND FELT IN THE STEERING WHEEL WHEN TURNING TO THE LEFT OR RIGHT, APPLYING AND RELEASING BRAKES, AND WHEN ACCELERATING AND DECELERATING THE ENGINE. CONDITION STARTED AT APPROXIMATELY 38,000 MILES, VEHICLE NOW HAS 51,500 MILES AND CONDITION HAS CONTINUED TO WORSEN.*AK
NHTSA ODI #10095850
36,572 miles · Sep 15, 2004
Steering
WANT TO ADD MY COMPLAINT TO THE LIST OF COMPLAINTS ABOUT NOISEY, POORLY LUBRICATED STEERING COUPLING SHAFT, ON MY 2001 CHEVROLET IMPALA. I HAVE READ THE GM BULLITTEN, BUT FEEL THIS IS GOING TO BE A POTENTIAL SAFEY CONCERN. MANY OWNERS WILL NOT PAY TO HAVE THIS REPAIR PERFORMED, AND AS THE STEERING SHAFT WEARS FROM THE LACK OF LU…
Read full complaint
WANT TO ADD MY COMPLAINT TO THE LIST OF COMPLAINTS ABOUT NOISEY, POORLY LUBRICATED STEERING COUPLING SHAFT, ON MY 2001 CHEVROLET IMPALA. I HAVE READ THE GM BULLITTEN, BUT FEEL THIS IS GOING TO BE A POTENTIAL SAFEY CONCERN. MANY OWNERS WILL NOT PAY TO HAVE THIS REPAIR PERFORMED, AND AS THE STEERING SHAFT WEARS FROM THE LACK OF LUBE, IT IS VERY LIKELY THAT THE SHAFTS WILL BEGIN TO BIND, AS ALL OTHER ROTATING SHAFTS WITH LACK OF LUBRICATION, EVENTUALLY DO. THIS LUBRICATION IS NOT LISTED AS A RECOMMENDED MAINTENANCE. I, AS WELL AS MANY OTHERS, FEEL THIS CONCERN SHOULD BE CORRECTED AT NO CHARGE, EITHER THROUGH A RECALL, OR GOODWILL POLICY ADJUSTMENT. WHY WOULD GM WANT TO WAIT UNTILL THESE SHAFTS BIND, OR BREAK, BEFORE DOING SOMETHING?*AK
NHTSA ODI #10091044
44,007 miles · Aug 20, 2004
Steering
POWER STEERING RACK HAD TO BE REPLACED ON VEHICLE.*MR THE CONSUMER FEELS THE VEHICLE RACK SHOULD NOT HAVE FAILED SINCE THE VEHICLE ONLY HAS 43000 MILES ON IT. *NM
NHTSA ODI #10089555
18,000 miles · Aug 11, 2004
Steering
REFERENCE # 10086513 THE DEALER TODAY OFFERED TO REPLACE THE STEERING COLUMN AT NO COST TO ME. I GUESS I SHOULD HAVE GIVEN HIM MORE OF A CHANCE. I MUST HAVE MISUNDERSTOOD HIS INTENTIONS. I AM SATISFIED AND AM EXTREMELY HAPPY WITH THE DEALER'S ATTITUDE. *JB
NHTSA ODI #10086658
18,000 miles · Aug 10, 2004
Steering
I HAVE A 2001 CHEVROLET IMPALA LS SEDAN WITH ONLY 18K MILES ON IT. IT IS NOW EXPERIENCING A 'CLUNKING' IN THE STEERING. WHEN I CALLED THE DEALER YESTERDAY, HE SAID (1) IT IS A KNOWN PROBLEM, AND (2) SINCE I AM 6 MONTHS OUT OF WARRANTY, REPAIR WOULD BE AT MY COST! HE SAID THE PROBLEM WAS A MINOR ONE, SOME $200.00 TO FIX (WIT…
Read full complaint
I HAVE A 2001 CHEVROLET IMPALA LS SEDAN WITH ONLY 18K MILES ON IT. IT IS NOW EXPERIENCING A 'CLUNKING' IN THE STEERING. WHEN I CALLED THE DEALER YESTERDAY, HE SAID (1) IT IS A KNOWN PROBLEM, AND (2) SINCE I AM 6 MONTHS OUT OF WARRANTY, REPAIR WOULD BE AT MY COST! HE SAID THE PROBLEM WAS A MINOR ONE, SOME $200.00 TO FIX (WITH GREASE?) , NOT TO WORRY ABOUT ANY DANGER, ETC. SINCE I WANT THE PROBLEM FIXED, I MADE AN APPOINTMENT FOR SAME. SINCE YESTERDAY, I HAVE LEARNED THAT THIS PROBLEM INDEED IS VERY SERIOUS, BUT THAT GM IS IGNORING IT, AND HAS NOT ISSUED ANY RECALL(S) FOR THE PROBLEM. I FEEL VERY STRONGLY (1) THAT THIS IS A DANGEROUS SITUATION SINCE THERE ARE MANY CASES OF 'LOCKED' STEERING RESULTING IN CRASHES, (2) AND THAT GM SHOULD FIX THIS KNOWN PROBLEM UNDER AN 'IMPLIED WARRANTY' SCENARION. OTHERWISE, MY IMPALA MIGHT INDEED CRASH HURTING OR KIILLING US. I INTEND TO DEMAND THAT AN GM AREA REPRESENTATIVE CONTACT ME SOONEST TO TELL ME WHAT TO DO AND WHAT GM WILL DO FOR ME. I HAVE DOCUMENTED MY SITUATION AND AM GOING TO TURN IT OVER TO MY LAWYER FOR LEGAL ACTIONS IN CASE SOMETHINGS BAD DEVELOP FROM THIS DOCUMENTED DEFECT. I DON'T KNOW WHAT ELSE TO DO, SINCE MY DEALER IS TREATING THIS PROBLEM SO LIGHTLY. THANK YOU JOHN WILLIAMS
NHTSA ODI #10086513
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration