NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
76 reportsClear category filter137,000 miles · Dec 18, 2014
Electrical SystemEngineSteering
THE SECURITY LIGHT CAME ON AND CAR SHUT OFF WHILE I WAS DRIVING THE CAR AT APPROX 30 MPH. THIS HAPPENED SEVERAL TIMES SINCE THEN WHILE TRAVELING AT A HIGHER RATE OF SPEED. LUCKILY I DID NOT HAVE AN ACCIDENT BUT, I AM AFRAID TO DRIVE THE CAR THAT AN ACCIDENT MAY HAPPEN. THIS IS A VERY SERIOUS SAFETY ISSUE. I HAVE RESEARCHED THE I…
Read full complaint
THE SECURITY LIGHT CAME ON AND CAR SHUT OFF WHILE I WAS DRIVING THE CAR AT APPROX 30 MPH. THIS HAPPENED SEVERAL TIMES SINCE THEN WHILE TRAVELING AT A HIGHER RATE OF SPEED. LUCKILY I DID NOT HAVE AN ACCIDENT BUT, I AM AFRAID TO DRIVE THE CAR THAT AN ACCIDENT MAY HAPPEN. THIS IS A VERY SERIOUS SAFETY ISSUE. I HAVE RESEARCHED THE INTERNET AND CAME ACROSS MANY COMPLAINTS THE SAME AS MINE. HOW CAN IT BE THAT NO RECALLS HAVE BEEN MADE ON AN ISSUE SO SERIOUS? *TR
NHTSA ODI #10667193
Mileage unknown · Oct 7, 2014
Electrical SystemService BrakesSteering
THIS CAR HAS HAD MAJOR PROBLEMS WITH THE COOLING SYSTEM AND WHEN THE CAR HEATS UP MY BRAKES DON'T WORK RITE IT IS VERY SCARY AT TIMES WHEN I DON'T KNOW IF MY BRAKES ARE GOING TO STOP ME FROM GOING INTO TRAFFIC OR NOT. I HAVE REPLACED MANY PARTS AND IT HAS NOT BEEN FIXED. MY CAR IS ON THE RECALL FOR THE IGNITION SWITCH BUT I'M NO…
Read full complaint
THIS CAR HAS HAD MAJOR PROBLEMS WITH THE COOLING SYSTEM AND WHEN THE CAR HEATS UP MY BRAKES DON'T WORK RITE IT IS VERY SCARY AT TIMES WHEN I DON'T KNOW IF MY BRAKES ARE GOING TO STOP ME FROM GOING INTO TRAFFIC OR NOT. I HAVE REPLACED MANY PARTS AND IT HAS NOT BEEN FIXED. MY CAR IS ON THE RECALL FOR THE IGNITION SWITCH BUT I'M NOT SURE IS THIS IS A SAFE VEHICLE TO DRIVE AROUND ANYMORE. AND MY QUESTION TO U GUYS IS Y DO THESE MANUFACTURING COMPANY KEEP ON GETTING TO MAKE UNSAFE CARS AND CONTINUE TO BE ABLE TO MAKE MONEY OFF THE CONSUMER. TO ME THAT IS NOT FAIR. I HAVE SPENT A LOT OF MONEY TO GET MY CAR REPAIRED WITH NO OUT COME ITS STILL A P.O.S. *TR
NHTSA ODI #10643077
140,000 miles · Sep 15, 2014
SteeringVehicle Speed ControlCrash
WE WERE DRIVING OFF H-820 N IN FORTWORTH TEXAS..THE CAR COULD NOT SLOW DOWN NOR COULD WE CONTROL IT. WE ENDED UP HITTING THE GUARD RAIL IN ONE CAR ACCIDENT AND IT WAS A TOTAL LOSS. BEFORE THAT, SAME CAR WAS SERVICED BY IGNITION PROBLEM BY CHEVROLET DEALER OFF 1-20 IN ARLINGTON,TX..STILL I WAS EXPERIENCING SAME PROBLEM. *TR
NHTSA ODI #10633422
Mileage unknown · Jul 25, 2014
Air BagsElectronic Stability Control (esc)SteeringCrashInjury
I WAS DRIVING DOWN THE ROAD ON DAY AND LOST TOTAL CONTROL OF MY VEHICLE AND HIT A GUIDE RAIL . I BOUNCED OFF THE GUIDE RAIL AND THE CAR STARTED SPINNING AND ANOTHER GUY HAD HIT ME AND I WENT HEAD ON INTO THE GUIDE RAIL . MY AIRBAGS DIDN'T DEPLOY AND I HAD MINOR INJURY (PAIN IN NECK AND BACK, MY GLASSES BROKE AND IHIT MY HEAD OFF…
Read full complaint
I WAS DRIVING DOWN THE ROAD ON DAY AND LOST TOTAL CONTROL OF MY VEHICLE AND HIT A GUIDE RAIL . I BOUNCED OFF THE GUIDE RAIL AND THE CAR STARTED SPINNING AND ANOTHER GUY HAD HIT ME AND I WENT HEAD ON INTO THE GUIDE RAIL . MY AIRBAGS DIDN'T DEPLOY AND I HAD MINOR INJURY (PAIN IN NECK AND BACK, MY GLASSES BROKE AND IHIT MY HEAD OFF THE STEERING WHEEL) I'M PRETTY SURE MY CARE IS TOTALED BECAUSE THE FRAME IS BENT AND BROKE. *TR
NHTSA ODI #10616173
187,000 miles · Apr 3, 2014
Air BagsEngineSteeringCrashInjury
AIR BAG DID NOT DEPLOY CAUSING STRAIN OF NECK MUSCLES, UPPER BACK INJURY, BILATERAL STRAIN, CONTUSION OF MULTIPLE SITES OF MY LOWER LIMBS BILATERAL. THERE HAVE BEEN SEVERAL RECALLS ON THE IMPALA BUT DUE TO NEGLIGENCE OF GMC I AM IN PAIN MY CAR WAS TOTALED AND I HAVE TO PURCHASE A NEW CAR. I WILL NEED ASSISTANCE IN PRICE, PAYME…
Read full complaint
AIR BAG DID NOT DEPLOY CAUSING STRAIN OF NECK MUSCLES, UPPER BACK INJURY, BILATERAL STRAIN, CONTUSION OF MULTIPLE SITES OF MY LOWER LIMBS BILATERAL. THERE HAVE BEEN SEVERAL RECALLS ON THE IMPALA BUT DUE TO NEGLIGENCE OF GMC I AM IN PAIN MY CAR WAS TOTALED AND I HAVE TO PURCHASE A NEW CAR. I WILL NEED ASSISTANCE IN PRICE, PAYMENTS, EXTENDED MAINTENANCE WARRANTY AT YOUR COST AND DELIVERY OF NEW VEHICLE TO ADDRESS I PROVIDE NO FEE ALSO INCLUDE TAG PAYMENTS. I CONTACTED YOUR COMPLAINT DEPARTMENT LAST NIGHT AND WAS TOLD THAT I WILL BE COMPENSATED IN THIS WILL BE TAKEN CARE OF AS CHEVROLET ALWAYS TAKES CARE OF THEIR BEST CUSTOMERS. *TR
NHTSA ODI #10577267
70,000 miles · Sep 14, 2012
EngineSteering
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT THE TEMPERATURE GAUGED INDICATED THAT THE VEHICLE WAS OVERHEATING BUT THE CONTACT DID NOT NOTICE A COOLANT LEAK OR ANY SMOKE. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC FOR A DIAGNOSTIC. THE MECHANIC REPLACED A SENSOR. AFTER THE REPAIR THE CHECK ENGINE W…
Read full complaint
TL* THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE CONTACT STATED THAT THE TEMPERATURE GAUGED INDICATED THAT THE VEHICLE WAS OVERHEATING BUT THE CONTACT DID NOT NOTICE A COOLANT LEAK OR ANY SMOKE. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC FOR A DIAGNOSTIC. THE MECHANIC REPLACED A SENSOR. AFTER THE REPAIR THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE TEMPERATURE GAUGED STILL INDICATED THAT THE VEHICLE OVERHEATING. THE MECHANIC SUGGESTED THE CONTACT TAKE THE VEHICLE TO THE DEALER. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER. THE CONTACT ALSO STATED THAT THE STEERING WHEEL MADE A STRANGE SOUND WHEN TURNED. IN ADDITION, THE STEERING WHEEL WOULD JERK ABNORMALLY. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC AND THE MECHANIC ADVISED THAT THERE WAS AN ISSUE WITH THE STEERING SHAFT. THE FAILURE MILEAGE WAS 70,000.
NHTSA ODI #10475426
47,600 miles · Feb 14, 2010
SteeringSuspension
STEERING TIE RODS FAILING AT AN ALARMING RATE. $1300 SPENT ON REPLACING TIE RODS AND OTHER STEERING PARTS THAT COULD BE A SAFETY ISSUE IF THE WHEEL OR LOSS OF STEERING OCCURS. *TR
NHTSA ODI #10310319
15,000 miles · Jun 25, 2009
Steering
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. WHENEVER THE CONTACT TURNED THE VEHICLE IN EITHER DIRECTION, HE HEARD A GRINDING AND CLICKING SOUND COMING FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPLACED THE STEERING SHAFT. MONTHS PRIOR TO THE FAILURE, THE STEERING BECAME VERY LOOSE. THE CURRENT MI…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. WHENEVER THE CONTACT TURNED THE VEHICLE IN EITHER DIRECTION, HE HEARD A GRINDING AND CLICKING SOUND COMING FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPLACED THE STEERING SHAFT. MONTHS PRIOR TO THE FAILURE, THE STEERING BECAME VERY LOOSE. THE CURRENT MILEAGE WAS 28,000 AND FAILURE MILEAGE WAS 15,000. UPDATED 07/14/09 *BF UPDATED 07/16/09.*JB
NHTSA ODI #10274965
Mileage unknown · May 22, 2009
Steering
WHILE I WAS DRIVING TO A STORE MY CAR WAS DRIVING JUST FINE BUT, AS I WAS TURNING A CORNER MY STEERING WHEEL LOCKED UP ON ME. THIS ALMOST CAUSED ME TO HIT A CAR THAT WAS AT A STOP SIGN. I HAVEN'T HAD ANY PROBLEMS WITH THIS UNTIL NOW.. IT JUST HAPPENED UNEXPECTEDLY. I CHECKED THE FLUID AND IT WAS FINE THE CAR THEN DROVE OFF JUST …
Read full complaint
WHILE I WAS DRIVING TO A STORE MY CAR WAS DRIVING JUST FINE BUT, AS I WAS TURNING A CORNER MY STEERING WHEEL LOCKED UP ON ME. THIS ALMOST CAUSED ME TO HIT A CAR THAT WAS AT A STOP SIGN. I HAVEN'T HAD ANY PROBLEMS WITH THIS UNTIL NOW.. IT JUST HAPPENED UNEXPECTEDLY. I CHECKED THE FLUID AND IT WAS FINE THE CAR THEN DROVE OFF JUST FINE. *TR
NHTSA ODI #10269760
27,000 miles · Jan 2, 2009
Service Brakes, HydraulicSteeringStructure
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE VEHICLE HAS BEEN IN THE REPAIR SHOP APPROXIMATELY FOUR TIMES AND THEY STATED THAT THE STEERING SHAFT AND THE FRAME IN FRONT OF THE WHEELS FAILED. THE BRAKES ARE CURRENTLY FAILING. THE CONTACT HEARS GRINDING METAL WHEN BRAKING, DRIVING OVER BUMPS, AND WHEN REVERSING. THE DEALER…
Read full complaint
TL*THE CONTACT OWNS A 2001 CHEVROLET IMPALA. THE VEHICLE HAS BEEN IN THE REPAIR SHOP APPROXIMATELY FOUR TIMES AND THEY STATED THAT THE STEERING SHAFT AND THE FRAME IN FRONT OF THE WHEELS FAILED. THE BRAKES ARE CURRENTLY FAILING. THE CONTACT HEARS GRINDING METAL WHEN BRAKING, DRIVING OVER BUMPS, AND WHEN REVERSING. THE DEALER HAS YET TO DETERMINE THE CAUSE OF THE BRAKE FAILURE. THE NOISE HAS INTENSIFIED. THE FAILURE MILEAGE WAS 27,000 AND CURRENT MILEAGE WAS 57,000.
NHTSA ODI #10253583
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration