NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
73 reportsClear category filter245,000 miles · Sep 8, 2020
Exterior Lighting
BOTH HEADLIGHTS UNEXPECTEDLY TURN OFF WHILE DRIVING. FLICKER ON AND OFF AND THEN GO OFF. USED TO BE ABLE TO LET THE CAR SIT A FEW HOURS AND THEY WOULD WORK AGAIN. NOW 2 NIGHTS AGO THEY WENT OFF WHILE DRIVING AT NIGHT....WON'T COME BACK ON AT ALL. PARKING LIGHTS STAY ON, TURN SIGNALS, AND 4 WAY FLASHERS STILL WORK, PULL SWITCH LE…
Read full complaint
BOTH HEADLIGHTS UNEXPECTEDLY TURN OFF WHILE DRIVING. FLICKER ON AND OFF AND THEN GO OFF. USED TO BE ABLE TO LET THE CAR SIT A FEW HOURS AND THEY WOULD WORK AGAIN. NOW 2 NIGHTS AGO THEY WENT OFF WHILE DRIVING AT NIGHT....WON'T COME BACK ON AT ALL. PARKING LIGHTS STAY ON, TURN SIGNALS, AND 4 WAY FLASHERS STILL WORK, PULL SWITCH LEVER BACK FOR BRIGHT LIGHTS AND BOTH HEADLIGHTS WORK IN BRIGHT MODE AS LONG AS YOU KEEP HOLDING BACK ON THE LEVER. THIS WAS AN INTERMITTENT PROBLEM THAT NO ONE HAS BEEN ABLE TO FIGURE OUT. HAVE HAD IT LOOKED AT SEVERAL TIMES AND PROBLEM STILL EXISTS. REPLACED HAZARD FLASHERS SWITHC, REPLACED MUTLIFUNCTION SWITCH, REPLACED HEADLIGHTS SWITCH. PROBLEM STILL EXISTS. NOW LIGHTS ARE OFF AND WON'T COME BACK ON NO MATTER WHAT WE TRY.....LOOKING ON THE INTERNET THIS IS HUGE PROBLEM FOR IMPALA'S COVERING ALOT OF YEARS, THIS IS A VERY DANGEROUS ISSUE WHEN YOU LOOSE YOUR HEADLIGHTS TOTALLY AT NIGHT WHILE DRIVING.......ONCE THEY GO OUT/OFF IT DOESN'T MATTER IF YOU STOP, PARK, MOVE, BANG ON THEM, WIGGLE WIRES AND CONNECTORS, THEY MAY OR MAY NOT COME BACK ON. SO FAR, THIS TIME, OURS ARE NOT COMING BACK ON......CAN'T KEEP THROWING MONEY AWAY TO A DEALER WHEN THEY CAN'T FIX THE PROBLEM EITHER. THEY JUST WANT TO START THROWING PARTS AT IT AND HOPEFULLY THEY FINALLY FIX IT....THAT HASN'T WORKED SO FAR EITHER.....
NHTSA ODI #11353772
343,232 miles · Apr 18, 2019
Exterior LightingSeat BeltsSteering
TAKATA RECALL WHEN GOING TO FASTEN SEAT BELT IT WILL NOT FASTEN YOU HAVE TO MESS WITH IT A COUPLE TIMES BEFORE IT WILL LATCH AND SOMETIMES WILL UNLATCH WHILE DRIVING. TAKATA RECALL THE DRIVER FRONT BLINKER BULB HAS BEEN REPLACED MULTIPLE TIMES BUT AFTER BUYING NUMEROUS BULBS IT STILL WILL NOT WORK. TAKATA RECALL WHEN TURNING T…
Read full complaint
TAKATA RECALL WHEN GOING TO FASTEN SEAT BELT IT WILL NOT FASTEN YOU HAVE TO MESS WITH IT A COUPLE TIMES BEFORE IT WILL LATCH AND SOMETIMES WILL UNLATCH WHILE DRIVING. TAKATA RECALL THE DRIVER FRONT BLINKER BULB HAS BEEN REPLACED MULTIPLE TIMES BUT AFTER BUYING NUMEROUS BULBS IT STILL WILL NOT WORK. TAKATA RECALL WHEN TURNING THE WHEEL LEFT WHEN I SLOW DOWN TO GO AROUND A CURVE IT TIGHTENS UP LIKE THE STEERING PUMP IS GOING OUT BUT IT ONLY DOES IT WHILE SLOWING DOWN TO TURN, ALSO WHILE DRIVING ITS LIKE THE VEHICLE IS ALL OVER THE ROAD SWAYING AROUND.
NHTSA ODI #11197093
150,000 miles · Nov 23, 2016
Electrical SystemExterior LightingService Brakes
DASH LIGHTS WENT OUT,REPLACED LIGHT SWITCH,BLOWS FUSE IF DASH LIGHTS ARE TURNED ON,HORN WILL COME ON WHEN CAR IS OFF.EARLIER BRAKE PEDDLE WORE WIRES BEHIND IT DOWN, CAUSED SHORT,CAR WOULD DIE WHILE DRIVING.LOW TIRE PRESSURE LIGHT ON,TIRES ARE FINE.
NHTSA ODI #10927741
100,000 miles · Nov 6, 2015
Exterior Lighting
ON TWO SEPARATE OCCASIONS I'VE BEEN DRIVING ON THE HIGHWAY AT HIGHWAY SPEEDS AND WHEN I GO FROM BRIGHT TO DIM MY HEADLIGHTS SHUT OFF. THEY COME BACK ON SHORTLY AFTER, IT'S ONLY MY HEADLIGHTS AS I CAN SEE MY SIDE LAMPS ILLUMINATED. QUICKLY GOING BACK TO BRIGHT SEEMED TO BRING THEM ON QUICKER THE SECOND TIME THEY WENT OUT. THE…
Read full complaint
ON TWO SEPARATE OCCASIONS I'VE BEEN DRIVING ON THE HIGHWAY AT HIGHWAY SPEEDS AND WHEN I GO FROM BRIGHT TO DIM MY HEADLIGHTS SHUT OFF. THEY COME BACK ON SHORTLY AFTER, IT'S ONLY MY HEADLIGHTS AS I CAN SEE MY SIDE LAMPS ILLUMINATED. QUICKLY GOING BACK TO BRIGHT SEEMED TO BRING THEM ON QUICKER THE SECOND TIME THEY WENT OUT. THESE TWO ISSUES BOTH OCCURRED AS I WAS MEETING ANOTHER VEHICLE AND WENT FROM BRIGHT TO DIM. THEY OCCURRED OVER THE TIME PERIOD OF TWO MONTHS.
NHTSA ODI #10788863
Mileage unknown · Oct 20, 2015
Exterior Lighting
THE TURN SIGNALS STOP WORKING AND COULD POSE A SAFETY HAZARD AS TO NOT BEING ABLE TO SIGNAL WHICH DIRECTION YOU TRAVELING TO. SO OTHER DRIVERS WOULD NOT BE ABLE TO KNOW THAT YOUR ARE MAKING A TURN AND COULD RESULT IN A CRASH. THIS IS A VERY COMMON PROBLEM ON MANY GM VEHICLES NOT JUST THE IMPALA, SUCH AS GRAND AM, MONTE CARLO, …
Read full complaint
THE TURN SIGNALS STOP WORKING AND COULD POSE A SAFETY HAZARD AS TO NOT BEING ABLE TO SIGNAL WHICH DIRECTION YOU TRAVELING TO. SO OTHER DRIVERS WOULD NOT BE ABLE TO KNOW THAT YOUR ARE MAKING A TURN AND COULD RESULT IN A CRASH. THIS IS A VERY COMMON PROBLEM ON MANY GM VEHICLES NOT JUST THE IMPALA, SUCH AS GRAND AM, MONTE CARLO, OLDSMOBILE ALERO, AND MORE. THE PROBLEM IS IN THE HAZARD SWITCH RELAY WHICH ALSO CONTROLS THE TURN SIGNALS WHICH IS A DEFECTIVE PART AND PREMATURELY FAILS. GENERAL MOTORS SHOULD MAKE A RECALL WITH HOW MANY VEHICLES HAVE THIS PROBLEM AND IS A KNOW ISSUE ON MANY OF THERE CARS.
NHTSA ODI #10783548
Mileage unknown · Sep 29, 2014
Electrical SystemExterior Lighting
I BEGAN EXPERIENCING PROBLEMS WITH MY TURNING SIGNALS. APPROXIMATELY IN APRIL THEY BEGAN TO NOT WORK AUTOMATICALLY WHEN INSTRUCTED TO USE. IN RECENT MONTHS THEY MAKE NOISE AS THEY ARE INSTRUCTED TO BE USED AND WELL NOT FUNCTION PROPERLY. ALSO, THE EMERGENCY LIGHTS ARE INOPERABLE AT THIS TIME. *TR
NHTSA ODI #10639740
180,000 miles · Sep 25, 2014
Electrical SystemEngineExterior Lighting
ALL AT ONCE THE CAR WOULD NOT START DEPENDING ON HOW KEY WAS IN IGNITION. COULD WIGGLE THEN START, SOMETIMES HAD TO WAIT A PERIOD OF TIME BEFORE YOU COULD WIGGLE IT AND IT STARTED. UNRELIABLE. AT THE EXACT SAME TIME THE FRONT END ELECTRICAL SEEMED TO ALL GO HAYWIRE. HEADLIGHTS NOT WORKING PROPERLY. HIGH BEAMS WITH NO LOW. WIPERS…
Read full complaint
ALL AT ONCE THE CAR WOULD NOT START DEPENDING ON HOW KEY WAS IN IGNITION. COULD WIGGLE THEN START, SOMETIMES HAD TO WAIT A PERIOD OF TIME BEFORE YOU COULD WIGGLE IT AND IT STARTED. UNRELIABLE. AT THE EXACT SAME TIME THE FRONT END ELECTRICAL SEEMED TO ALL GO HAYWIRE. HEADLIGHTS NOT WORKING PROPERLY. HIGH BEAMS WITH NO LOW. WIPERS WENT INTO UPRIGHT POSITION WHEN CAR STARTED AND WON'T GO DOWN. ALL ROUTINE MAINTENANCE AND TUNEUPS WERE ON SCHEDULE. *TR
NHTSA ODI #10639032
107,000 miles · Sep 21, 2014
Electrical SystemExterior Lighting
THE VEHICLE WILL NOT START IF THE SECURITY LIGHT IS FLASHING... I HAVE TO WAIT ATLEAST 15-20 MINUTES WITH THE KEY POSITIONED IN THE ON POSITION UNTIL THE SECURITY LIGHT STOPS FLASHING.. THEN IT STARTS. ANOTHER PROBLEM IS THE BRAKE LIGHT AND THE BATTERY LIGHT COMES ON AT THE SAME TIME AND THE CAR FEELS LIKE IT WANTS TO STALL. FI…
Read full complaint
THE VEHICLE WILL NOT START IF THE SECURITY LIGHT IS FLASHING... I HAVE TO WAIT ATLEAST 15-20 MINUTES WITH THE KEY POSITIONED IN THE ON POSITION UNTIL THE SECURITY LIGHT STOPS FLASHING.. THEN IT STARTS. ANOTHER PROBLEM IS THE BRAKE LIGHT AND THE BATTERY LIGHT COMES ON AT THE SAME TIME AND THE CAR FEELS LIKE IT WANTS TO STALL. FINALLY, IF THE CAR IS RUNNING IN PARK.....ALL OF THE EXTERIOR AND INTERIOR LIGHTS STARTS TO FLASH. *TR
NHTSA ODI #10637841
89,124 miles · Jan 20, 2014
Electrical SystemExterior Lighting
THE LIGHT WENT OUT ON THE SPEEDOMETER. THE INSTRUMENT LIGHTING CLUSTER WAS REPLACED AT THE DEALER FOR $614.00 AND IT WENT OUT AGAIN IN ABOUT ONE YEAR. IT IS OUT NOW. THE SPEEDOMETER SPEED CANNOT BE READ AT NIGHT. *TR
NHTSA ODI #10560636
126,000 miles · Dec 7, 2011
Electrical SystemExterior Lighting
MY TURN SIGNALS WORKED INTERMITTENTLY. PRESSING THE HAZARD SWITCH A COUPLE TIMES FIXED PROBLEM. ONLINE FORUM SAID REPLACE THE HAZARD SWITCH. FIXED THE PROBLEM FOR ABOUT A MONTH. NOW, MY CAR NEEDS TO BE RUNNING AND WARMED UP BEFORE THE TURN SIGNALS WORK CORRECTLY. PROBLEM SEEMS TO BE WORSENING HAS THE TEMPERATURE DROPS. *TR
NHTSA ODI #10438914
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 29, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE AIR BAG SENSING AND DIAGNOSTIC MODULES (SDM) COULD EXPERIENCE A MEMORY ERROR RESULTING IN THE AIR BAGS NOT DEPLOYING IN A CRASH SITUATION.
Consequence & remedy
Consequence: IN A CRASH, A FRONT SEAT OCCUPANT MAY RECEIVE MORE SERIOUS INJURIES.
Remedy: DEALERS WILL REPLACE THE SENSING AND DIAGNOSTIC MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06017 · Alleged Headlight Failure
Opened May 15, 2006 · Closed Oct 25, 2006
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:headlights; Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Exterior Lighting
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:headlights:switch
A TOTAL OF 646,038 SUBJECT VEHICLES WERE SOLD DURING MY 2001-2003, AND THE COMPLAINT AND WARRANTY DATA TABULATED ABOVE APPLY TO THE TOTAL VEHICLE POPULATION.COMPLAINT REPORTS ALLEGING HEADLIGHT OUTAGE REPRESENT SLIGHTLY MORE THAT ONE-HALF OF THE TOTAL NUMBER OF COMPLAINTS AND THE BALANCE ARE ALLEGATIONS OF FLICKERING AND DIMMING.INVESTIGATION DISCLOSED THE ROOT CAUSE OF THE MALFUNCTION TO BE WEAR OF A CONTACT PLUNGER IN THE MULTIFUNCTION SWITCH THAT MAY RESULT IN A TEMPORARY OPEN CIRCUIT, WITH THE PLUNGER IN A NEUTRAL POSITION BETWEEN HIGH- AND LOW-BEAM CONTACT POINTS.CONSUMERS CONSISTENTLY REPORTED THAT MANIPULATION OF THE SWITCH HANDLE ON THE STEERING COLUMN RESTORES EITHER HIGH OR LOW BEAM HEADLIGHT FUNCTION.NO OTHER POTENTIAL SAFETY RELATED ISSUES, E.G., FIRES OR WINDSHIELD WIPER FAILURE, WERE FOUND TO BE RELATED TO THIS ISSUE.THE MANUFACTURER RECOGNIZED THE SUBJECT HEADLIGHT ISSUES FROM FAILURE AND WARRANTY REPORTS, AND ISSUED A REDESIGNED PLUNGER IN 2003. THE MANUFACTURER DID NOT IDENTIFY A DEFECT REQUIRING RECALL AND REMEDY.ODI HAS DETERMINED THAT THE RATES OF OCCURRENCE, THE FAILURE MODE AND THE REAL-WORLD CONSEQUENCE OF THE ALLEGED DEFECT AS COMPARED TO OTHER SIMILAR INVESTIGATIONS FAIL TO IDENTIFY A SAFETY-RELATED DEFECT TREND.THIS PRELIMINARY EVALUATION HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY MAY TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Illustration