IllustrationTHE CAR MAKES A POPPING (IN THE STRUCTURE) SOUND UPON STOPPING, STARTING AND TURNING CORNERS VERY LOAD, ANNOYING, AND FREQUENT. *AK
2000 Chevrolet Impala
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Impala years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
330–25K
6825–50K
7150–75K
7275–100K
105100–150K
69150K+
418 reports with mileage · 400 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 187 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 159 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 124 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
49 crash reports73 fire reports41 injury reports
What owners actually said
818 reportsABLE TO HEAR FUEL SLOSHING IN THE FUEL TANK WHEN COMING TO A STOP. DEALER NOTIFED, AND INFORMED CONSUMER THAT NOTHING CAN BE DONE. *AK
PE 00005; WHILE DRIVING VEHICLE STALLED UNEXPECTEDLY, AND WOULD NOT START FOR 15 MINUTES, WHICH MAY HAVE CAUSED A CRASH. DEALER COULD NOT DETERMINE CAUSE OF THE PROBLEM. *AK THE VEHICLE WAS LEAKING OIL EXCESSIVELY. THE DEALER WAS UNABLE TO LOCATE THE PROBLEM. *YH
THE VEHICLE WILL FREELY ROLL BACKWARDS OR FORWARD WHEN FOOT IS REMOVED FROM BRAKE AND THE TRANSMISSION IS IN A DRIVE GEAR. EVEN SLIGHT INCLINES WILL CAUSE THE VEHICLE TO ROLL, BUT A STEEP INCLINE CAN BECOME A SERIOUS SAFETY ISSUE, SINCE THE CAR WILL FREELY ROLL, EXACTLY THE SAME WAY A VEHICLE WITH A MANUAL TRANSMISSION WOULD ROL…
Read full complaint
THE VEHICLE WILL FREELY ROLL BACKWARDS OR FORWARD WHEN FOOT IS REMOVED FROM BRAKE AND THE TRANSMISSION IS IN A DRIVE GEAR. EVEN SLIGHT INCLINES WILL CAUSE THE VEHICLE TO ROLL, BUT A STEEP INCLINE CAN BECOME A SERIOUS SAFETY ISSUE, SINCE THE CAR WILL FREELY ROLL, EXACTLY THE SAME WAY A VEHICLE WITH A MANUAL TRANSMISSION WOULD ROLL WHEN TAKEN OUT OF GEAR. UNFORTUNATELY, DRIVERS WHO USE AUTOMATICS EXPECT THE TRANSMISSION TO HOLD THE VEHICLE, AT LEAST PARTIALLY, WHEN ON AN INCLINE. IT IS TYPICAL TO USE ONE FOOT TO MOVE FROM THE BRAKE TO THE THROTTLE, BUT ON STEEP INCLINES, THE VEHICLE WILL ROLL SO QUICKLY THAT USING TWO FEET IS OFTEN NECESSARY (ONE FOR BRAKE, ONE FOR THROTTLE) WHEN MOVING OFF A STOP. OBVIOUS SAFETY ISSUES ARE: VEHICLE ROLLING INTO SOMEONE, VEHICLE ROLLING INTO AN OBJECT OR ANOTHER VEHICLE, UNNECESSARY AIRBAG DEPLOYMENT, AND DRIVER DISORIENTATION RESULTING FROM THE EQUIPMENT NOT WORKING AS EXPECTED, WITH POSSIBLE RESULTING ACCIDENT. DEALER SAYS THIS CONDITION IS CONSIDERED NORMAL, BUT I HAVE DRIVEN MANY VEHICLES WITH AUTOMATIC TRANSMISSIONS AND HAVE NEVER HAD ONE RESPOND IN THIS MANNER, AT LEAST TO THIS DEGREE. THIS LEADS ME TO BELIEVE THAT THERE IS ACTUALLY A DESIGN DEFECT, AND AT THE VERY LEAST, GENERAL MOTORS SHOULD INFORM BUYERS THAT THESE VEHICLES RESPOND DIFFERENTLY THAN OTHERS. ONE REASON WHY I PURCHASED THIS VEHICLE IS FOR ITS SAFETY TEST RESULTS, BUT THIS PROBLEM MAKES ME CONCERNED THAT THE VEHICLE IS ACTUALLY UNSAFE FOR MY WIFE TO DRIVE UNDER CERTAIN CIRCUMSTANCES--SHE HAS ALREADY TOLD ME THAT SHE WILL NOT DRIVE IN DOWNTOWN SEATTLE (STEEP STREETS) WITH THE VEHICLE. SHE IS NOT A HIGHLY SKILLED DRIVER, AND OPERATING THE CAR ON INCLINES WITHOUT EXERCISING EXTRA CAUTION, OR USING TWO FEET (WHICH REQUIRES ADDITIONAL SKILL) COULD EASILY CAUSE AN ACCIDENT. ADDITIONAL COMMENTS FOR NHTSA: PLEASE PLEASE PLEASE GIVE US A WINDOW LONGER THAN 70 CHARACTERS TO TYPE IN. PLEASE ALSO INCREASE THE FIELD SIZE ON THE "SUMMARY"WHENVIEWINGCOMPLAINTDATABASE
THE ALUMINUM SUBFRAME HAS TWO BRACKETS THAT NEED TO BE WELDED ACCORDING TO CHEVROLET. THE ALUMINUM SUBFRAME "FLEXES" CAUSING A CLICKING SOUND WHEN THE STEERING WHEEL IS TURNED TO THE LEFT AND THE RIGHT. CHEVROLET ADVISED THE DEALER TO WELD THE TWO BRACKETS AND THAT SHOULD QUIET THE NOISE. CHEVROLET SAID THAT THERE ARE NO SAFET…
Read full complaint
THE ALUMINUM SUBFRAME HAS TWO BRACKETS THAT NEED TO BE WELDED ACCORDING TO CHEVROLET. THE ALUMINUM SUBFRAME "FLEXES" CAUSING A CLICKING SOUND WHEN THE STEERING WHEEL IS TURNED TO THE LEFT AND THE RIGHT. CHEVROLET ADVISED THE DEALER TO WELD THE TWO BRACKETS AND THAT SHOULD QUIET THE NOISE. CHEVROLET SAID THAT THERE ARE NO SAFETY BULLETINS ON THIS ISSUE. *AK
RE: YOUR ODI#550849 AND ODI#856909 - I TOO EXPERIENCE GAS SLOSHING IN FUEL TANK AND THE FEELING OF BEING TAPPED ON THE REAR BUMPER , OR PERHAPS A BOWLING BALL ROLLING AROUND IN THE TRUNK, WHEN STOPPING. -DEALER ADVISED US THAT THE "BELLOWS" ??? IN THE GAS TANK MAY HAVE SEPARATED AND ADVISED US TO RETURN VEHICLE WITH EMPTY FUEL T…
Read full complaint
RE: YOUR ODI#550849 AND ODI#856909 - I TOO EXPERIENCE GAS SLOSHING IN FUEL TANK AND THE FEELING OF BEING TAPPED ON THE REAR BUMPER , OR PERHAPS A BOWLING BALL ROLLING AROUND IN THE TRUNK, WHEN STOPPING. -DEALER ADVISED US THAT THE "BELLOWS" ??? IN THE GAS TANK MAY HAVE SEPARATED AND ADVISED US TO RETURN VEHICLE WITH EMPTY FUEL TANK SO THAT IT COULD BE REMOVED AND EXAMINED. *AK
ON JAN.16 I WAS DRIVING ON INTERSTATE 95 WHEN DRIVER'S SEAT CUSHION CAME OUT OF ADJUSTMENT. I WAS IN THE FAST LANE AND LOST CONTROL OF THE CAR SEVERAL TIMES BEFORE GETTING IT TO THE SHOULDER OF THE ROAD. 2ND INCIDENT ON JAN. 18. 3RD INCIDENT ON JAN 24. RETURNED THE CAR TO BOB BEL FOR REPAIRS. 4TH INCIDENT ON FEB 2ND. CAR WAS TOW…
Read full complaint
ON JAN.16 I WAS DRIVING ON INTERSTATE 95 WHEN DRIVER'S SEAT CUSHION CAME OUT OF ADJUSTMENT. I WAS IN THE FAST LANE AND LOST CONTROL OF THE CAR SEVERAL TIMES BEFORE GETTING IT TO THE SHOULDER OF THE ROAD. 2ND INCIDENT ON JAN. 18. 3RD INCIDENT ON JAN 24. RETURNED THE CAR TO BOB BEL FOR REPAIRS. 4TH INCIDENT ON FEB 2ND. CAR WAS TOWED TO JP CHEVROLET IN ABERDEEN. THE WAY THE CAR WAS REPAIRED VIOLATES ALL SAFETY STANDARDS! I HAVE BEEN HOSPITALIZED BECAUSE OF INJURIES SUFFERED. I AM NOW BEING TREATED FOR WHIPLASH, SEVERE VERTIGO, HEARING AND VISUAL IMPAIREMENT AND BALANCE PROBLEMS. THE CAR IS STILL NOT FIXED ACCORDING TO NATIONAL SAFETY STANDARDS. BAILING WIRE HAS BEEN USED BY JP CHEVROLET TO CORRECT THE PROBLEM. PLEASE HELP US IF YOU CAN!! *AK
ENGINE/TRANS PARTIAL FAILURE, ALMOST STALLING IN INTERSECTION. INSTRUMENT CLUSTER HAD SYSTEM MANAGMENT LIGHTING IN DASH FLASHING FOR NO REASON. REPLACMENT OF INSTRUMENT CLUSTER ACTUALLY WORSENED UNCOMMANDED LIGHT FLASHING. INITIAL REPAIR OF ENGINE PROBLEMS DIMINISHED SEVERITY OF STALLING, HOWEVER DID NOT COMPLETELY CORRECT TH…
Read full complaint
ENGINE/TRANS PARTIAL FAILURE, ALMOST STALLING IN INTERSECTION. INSTRUMENT CLUSTER HAD SYSTEM MANAGMENT LIGHTING IN DASH FLASHING FOR NO REASON. REPLACMENT OF INSTRUMENT CLUSTER ACTUALLY WORSENED UNCOMMANDED LIGHT FLASHING. INITIAL REPAIR OF ENGINE PROBLEMS DIMINISHED SEVERITY OF STALLING, HOWEVER DID NOT COMPLETELY CORRECT THE PROBLEM. UNABLE TO DUPLICATE STALLING ON A CONSISTANT BASIS. *AK
ON ANY INCLINE VEHICLE WILL ROLL BACK WHEN TAKING FOOT OFF BRAKE TO THROTTLE. CONSUMER SPOKE TO DEALER WHO SAID THAT FRONT WHEEL DRIVE VEHICLES DO THAT. CONSUMER CONTACTED MANUFACTURER, AND REPRESENTATIVE CHECKED OUT THE COMPLAINT, AND STATED THAT IT SEEMED TO BE A COMMON COMPLAINT. *AK *ML
THIS HAS HAPPENED THREE TIMES. STOPPED AT A STOP SIGN T AND ENGINE JUST CUT OFF. STARTED IT UP AND MOVED TO PARK. IT WAS FINE UNTIL 10-MAR-200O WHEN AGAIN AT A STOP LIGHT ENGINE CUT OFF. CONTACTED THE DEALER, WAS NOT ABLE TO DUPLICATE THE PROBLEM. *AK
Official recalls
715V701000 · Engine And Engine Cooling:engine; Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
14V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
09V116000 · Engine And Engine Cooling
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
04V090000 · Fuel System, Gasoline:delivery
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
01V136000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
00V371000 · Air Bags:side/window
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available