Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
330–25K
6825–50K
7150–75K
7275–100K
105100–150K
69150K+
418 reports with mileage · 400 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 187 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 159 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 124 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
49 crash reports73 fire reports41 injury reports
What owners actually said
818 reports
10,000 miles · Dec 22, 2015
SteeringCrash
TL* THE CONTACT RENTED A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH DURING INCLEMENT WEATHER, THE VEHICLE SKIDDED OUT OF CONTROL TO THE LEFT, THE CONTACT APPLIED FORCE TO THE STEERING WHEEL BUT IT DID NOT RESPOND CAUSING THE CONTACTS VEHICLE TO BE SCRAPED ON THE LEFT SIDE FROM A GUARD RA…
Read full complaint
TL* THE CONTACT RENTED A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH DURING INCLEMENT WEATHER, THE VEHICLE SKIDDED OUT OF CONTROL TO THE LEFT, THE CONTACT APPLIED FORCE TO THE STEERING WHEEL BUT IT DID NOT RESPOND CAUSING THE CONTACTS VEHICLE TO BE SCRAPED ON THE LEFT SIDE FROM A GUARD RAIL. THE CONTACT STATED THAT THE VEHICLE THEN VEERED TO THE RIGHT AND SLIGHTLY WENT OVER A CURB. THE POWER STEERING WARNING LIGHT FLASHED WHEN THE FAILURE OCCURRED. THE CONTACT WAS ABLE TO PULL THE VEHICLE OFF TO THE SIDE OF THE ROAD, TURNED OFF THE VEHICLE AND WAS ABLE TO RESTART. THE DRIVER DID NOT SUSTAIN ANY INJURIES AND NO MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. THE RENTAL COMPANY WAS NOTIFIED OF THE POWER STEERING FAILURE. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 10,000.
NHTSA ODI #10811757
Mileage unknown · Dec 18, 2015
EngineFire
TL* THE CONTACT OWNED A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE, WHILE PARKED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THE VEHICLE WAS TOWED. THE VEHICLE WAS DESTROYED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER …
Read full complaint
TL* THE CONTACT OWNED A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE, WHILE PARKED. THE FIRE WAS EXTINGUISHED BY THE FIRE DEPARTMENT. THE VEHICLE WAS TOWED. THE VEHICLE WAS DESTROYED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT DUE TO THE AGE OF THE VEHICLE; THE REPAIR COULD NOT BE PERFORMED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10811205
198,000 miles · Dec 18, 2015
Engine
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND WARMING UP, THE CONTACT HEARD A LOUD NOISE. THE CONTACT DISCOVERED THAT THE PLASTIC COVER DETACHED FROM THE ENGINE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC HOWEVER, THE DIAGNOSIS WAS UNKNOWN. THE VEHICLE…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED AND WARMING UP, THE CONTACT HEARD A LOUD NOISE. THE CONTACT DISCOVERED THAT THE PLASTIC COVER DETACHED FROM THE ENGINE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC HOWEVER, THE DIAGNOSIS WAS UNKNOWN. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT THE VEHICLE BEGAN TO LEAK FLUID FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE AN UNKNOWN REPAIR WAS PERFORMED BUT THE FAILURE RECURRED. THE CONTACT RECENTLY RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 198,000.
NHTSA ODI #10811128
Mileage unknown · Dec 17, 2015
EngineFire
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT SMELLED A BURNING ODOR AND NOTICED SMOKE UNDER THE HOOD WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE OVERHEATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HEAD GASKET NEEDED TO…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT SMELLED A BURNING ODOR AND NOTICED SMOKE UNDER THE HOOD WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE OVERHEATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HEAD GASKET NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #10810967
120,000 miles · Dec 17, 2015
Electrical SystemEngineFire
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT THERE WAS A PROGRESSING FAILURE IN WHICH THE PRESSURE WAS LOW ON THE READER AND THE VEHICLE HESITATED NUMEROUS TIMES BEFORE IT STALLED WITHOUT WARNING. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS TO GET THE VEHICLE TO RESTART. THE VEHICLE WAS TAKEN TO A REPAIR SH…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT THERE WAS A PROGRESSING FAILURE IN WHICH THE PRESSURE WAS LOW ON THE READER AND THE VEHICLE HESITATED NUMEROUS TIMES BEFORE IT STALLED WITHOUT WARNING. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS TO GET THE VEHICLE TO RESTART. THE VEHICLE WAS TAKEN TO A REPAIR SHOP MECHANIC WHO REPLACED THE IGNITION SWITCH AND THE OIL PRESSURE GAUGE, BUT THE FAILURE RECURRED. THE VEHICLE CONTINUED TO STALL. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM), BUT THE CONTACT DID NOT RECEIVE A NOTIFICATION. WHILE AT A STOP LIGHT AND UPON ACCELERATION, THE RPMS AND PRESSURE WENT LOW, THE VEHICLE STALLED, AND AN ENGINE FIRE ERUPTED. THE CONTACT WAS ABLE TO EXIT THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND THEN TOWED TO A SALVAGE YARD. THE VEHICLE WAS DESTROYED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND WAS UNABLE TO RECEIVE THE RECALL REPAIR DUE TO THE FAILURE HAPPENING BEFORE BEING NOTIFIED OF THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. PARTS DISTRIBUTION DISCONNECT. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10810904
Mileage unknown · Dec 16, 2015
EngineFire
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT DISCOVERED THAT THE IGNITION KEY HAD MOVED INTO THE ACCESSORY POSITION. THE CONTACT PULLED OVER AND NOTICED SMOKE EMITTING FROM …
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT DISCOVERED THAT THE IGNITION KEY HAD MOVED INTO THE ACCESSORY POSITION. THE CONTACT PULLED OVER AND NOTICED SMOKE EMITTING FROM THE HOOD OF THE VEHICLE. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS AN INTERMIX OF COOLANT AND OIL IN THE ENGINE, AND THE HEAD GASKET AND RADIATOR NEEDED TO BE REPLACED. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART FOR THE RECALL WAS NOT AVAILABLE. THE DEALER TOLD THE CONTACT THAT THE RECALL REMEDY WOULD NOT FIX THE SPECIFIC FAILURE OF THE HEAD GASKET. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10810757
Mileage unknown · Dec 16, 2015
Engine
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCE A FAILURE. VIN TOO…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCE A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10810690
Mileage unknown · Dec 16, 2015
Electrical SystemEngine
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V400000 (ELECTRICAL SYSTEM) AND 15V701000 (ENGINE AND ENGINE COOLING). HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURE EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPA…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V400000 (ELECTRICAL SYSTEM) AND 15V701000 (ENGINE AND ENGINE COOLING). HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURE EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10810653
150,000 miles · Dec 15, 2015
EngineFire
TL* THE CONTACT OWNED A 2000 CHEVROLET IMPALA. WHILE ATTEMPTING TO START THE VEHICLE BY PLACING THE KEY IN THE IGNITION, THE ENGINE CAUGHT FIRE. A FIRE REPORT WAS FILED. THE FIRE WAS EXTINGUISHED BY THE CONTACT. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DEEMED DESTROYED. THE CONTACT RE…
Read full complaint
TL* THE CONTACT OWNED A 2000 CHEVROLET IMPALA. WHILE ATTEMPTING TO START THE VEHICLE BY PLACING THE KEY IN THE IGNITION, THE ENGINE CAUGHT FIRE. A FIRE REPORT WAS FILED. THE FIRE WAS EXTINGUISHED BY THE CONTACT. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DEEMED DESTROYED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) AFTER THE INCIDENT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.
NHTSA ODI #10810480
154,000 miles · Nov 12, 2015
EngineUnknown Or Other
THE INTAKE MANIFOLD INSIDE OF MY VEHICLE, BLEW UP ON DAY OUT OF NO WHERE. I TURNED ON MY VEHICLE, AND A HUGE POP NOISE CAME FROM MY ENGINE AND IT SMOKED.
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
2000 Chevrolet Impala Problems, Complaints & Recalls | Skip That Year
Illustration