NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
124 reportsClear category filter32,000 miles · Jan 18, 2005
Steering
I BOUGHT THE CAR NEW AND WITHIN 32000 MILES YOU COULD FEEL A CLUNK IN THE STEERING COLUMN. THE IMPALA WAS DRIVEN UNDER NORMAL DAY TO DAY USAGE AND WAS PROPERLY MAINTAINED. TOOK THE CAR IN FOR WARRANTY WORK AND WAS TOLD THEY HAD TO LUBE AND REPLACE A PIECE ON THE INTERMEDIATE SHAFT OF THE STEERING. NOW AT 81000 MILES THE SAME …
Read full complaint
I BOUGHT THE CAR NEW AND WITHIN 32000 MILES YOU COULD FEEL A CLUNK IN THE STEERING COLUMN. THE IMPALA WAS DRIVEN UNDER NORMAL DAY TO DAY USAGE AND WAS PROPERLY MAINTAINED. TOOK THE CAR IN FOR WARRANTY WORK AND WAS TOLD THEY HAD TO LUBE AND REPLACE A PIECE ON THE INTERMEDIATE SHAFT OF THE STEERING. NOW AT 81000 MILES THE SAME CHARACTERISTICS SHOW UP AGAIN! INTERMEDIATE SHAFT ON STEERING COLUMN STARTS WITH A CLICKING NOISE AND THROUGH USAGE AND TIME GETS WORSE. YOU START FEELING THE CLICK THROUGH THE STEERING COLUMN AND WHEEL AT LOW SPEEDS AND WHEN THE BRAKE IS DEPRESSED WHILE DRIVING! I FEEL AS AN AIRCRAFT MECHANIC AND IN MY PROFESSIONAL OPINION GM NEEDS TO BE MADE TO HAVE A RECALL ON ALL IMPALA'S PRODUCED FROM 2000 THRU 2004. THIS CLICKING IS A FAILURE OF THE INTERMEDIATE SHAFT AND OTHER STEERING COMPONENTS ASSOCIATED IT AND WILL LEAD TO SUBSEQUENT FAILURE AND ACCIDENT IN THIS VEHICLE. *NM
NHTSA ODI #10106585
Mileage unknown · Jan 11, 2005
Steering
THE STEERING WHEEL LOCKS UP WHEN THE VEHICLE IS MAKING TURNS WHICH INCREASES THE RISK OF A CRASH. TAKEN TO DEALER FOR CHECK UP, AND RESULTS SHOWED THAT A GEAR IN THE STEERING BOX NEEDED TO BE REPLACED.*AK. THE POWER STEERING STOPS WORKING DURING TURNS. SOMETIMES IT DIDN'T WORK AT ALL, OTHER TIMES, IT WORKED WHEN STARTING A TURN …
Read full complaint
THE STEERING WHEEL LOCKS UP WHEN THE VEHICLE IS MAKING TURNS WHICH INCREASES THE RISK OF A CRASH. TAKEN TO DEALER FOR CHECK UP, AND RESULTS SHOWED THAT A GEAR IN THE STEERING BOX NEEDED TO BE REPLACED.*AK. THE POWER STEERING STOPS WORKING DURING TURNS. SOMETIMES IT DIDN'T WORK AT ALL, OTHER TIMES, IT WORKED WHEN STARTING A TURN THE STOPPED PART WAY THROUGH THE TURN. A SMALL PERSON WOULD HAVE A PROBLEM TURNING THE VEHICLE. TOOK VEHICLE TO USED CAR DEALER, AND MECHANIC ADVISED HIM THAT A GEAR IN THE STEERING BOX WENT BAD, AND PUT A NEW STEERING BOX IN. *AK
NHTSA ODI #10107169
Mileage unknown · Jan 7, 2005
Electrical SystemSteeringWheels
THE RACK AND PINION STEERING ASSEMBLY FAILURE. RACK AND PINION LEAKED AND HAS BEEN SERVICED AND STILL HAS PROBLEMS. *BF THE LOW TIRE PRESSURE LIGHT HAD COME ON AND THERE WAS A RATTLING NOISE COMING FROM THE RIGHT FRONT WHEEL WHILE THE VEHICLE WAS IN MOTION. *SC *JB
NHTSA ODI #10109454
70,000 miles · Dec 15, 2004
Steering
A 'CLUNK' WITH ASSOCIATE 'LOOSENESS' IN THE STEERING OF OUR 2000 IMPALA IS NOTED. OUR RESEARCH INDICATES THAT MANY OWNERS OF SIMILAR MODELS WHO EXPERIENCED THIS OCCURRENCE AND, BY SOME DEALERS, WAS CORRECTED BY REPLACEMENT OF THE INTERMEDIATE STEERING SHAFT. WE ARE CONCERNED THAT WE HAVE A PROBLEMATIC STEERING ASSEMBLY AND DO …
Read full complaint
A 'CLUNK' WITH ASSOCIATE 'LOOSENESS' IN THE STEERING OF OUR 2000 IMPALA IS NOTED. OUR RESEARCH INDICATES THAT MANY OWNERS OF SIMILAR MODELS WHO EXPERIENCED THIS OCCURRENCE AND, BY SOME DEALERS, WAS CORRECTED BY REPLACEMENT OF THE INTERMEDIATE STEERING SHAFT. WE ARE CONCERNED THAT WE HAVE A PROBLEMATIC STEERING ASSEMBLY AND DO NOT KNOW IF THIS CAN LEAD TO FAILURE OR NOT.*AK
NHTSA ODI #10103031
11,000 miles · Nov 22, 2004
Steering
THE CONSUMER WAS HAVING A PROBLEM WITH THE INTERMEDIATE STEERING SHAFT. THE CONSUMER RECEIVED A RECALL NOTICE ON THE MANIFOLD. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AND HAD THE FUEL SYSTEM CHECKED AND WAS CHARGED 124.85. PROVIDE FURTHER DETAILS. *JB
NHTSA ODI #10101517
Mileage unknown · Nov 19, 2004
Steering
STEERING WHEEL LOCKED UP WHILE DRIVING. CONSUMER PULLED OVER, TURNED OFF THE VEHICLE AND RESTARTED. CONSUMER DROVE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10101406
35,000 miles · Nov 19, 2004
Steering
AT ANY SPEED MY POWER STEERING STARTED TO FAIL INTERMITTENTLY, WITH ANY SPECIFIC WARNING. THIS HAS OCCURRED 4 TIMES IN THE LAST 7 DAYS, LUCKILY NO ONE WAS HURT BUT THE LAST TIME I DID GO OFF THE ROAD AND IMMEDIATELY BROUGHT IT TO MY DEALERSHIP. THEY CONTEND THEY HAVE NOT FOUND ANY PROBLEM, AND THAT THE DIAGNOSTICS DO NOT SHOW …
Read full complaint
AT ANY SPEED MY POWER STEERING STARTED TO FAIL INTERMITTENTLY, WITH ANY SPECIFIC WARNING. THIS HAS OCCURRED 4 TIMES IN THE LAST 7 DAYS, LUCKILY NO ONE WAS HURT BUT THE LAST TIME I DID GO OFF THE ROAD AND IMMEDIATELY BROUGHT IT TO MY DEALERSHIP. THEY CONTEND THEY HAVE NOT FOUND ANY PROBLEM, AND THAT THE DIAGNOSTICS DO NOT SHOW ANY ISSUE.
NHTSA ODI #10100204
Mileage unknown · Aug 4, 2004
SteeringStructure
DEALERSHIP ON 08/13/2001 REPLACED THE CRADLE. VEHICLE WAS UNDER WARRANTY IN NOVEMBER 2001, AND DEALER REPLACED SHAFT. CRADLE FAILED 2 YEARS LATER, AND NEEDED TO BE REPLACED AGAIN, ALSO, HAD A STEERING PROBLEM.*AK
NHTSA ODI #10087198
34,560 miles · Jun 4, 2004
Steering
ON JULY 4, 2003 MY 2000 CHEVROLET IMPALA WAS LUBED AT THE CHEVROLET DEALERSHIP BECAUSE OF STEERING ISSUES. THE CAR WOULD VIBRATE, POP, AND JERK WHEN ACCELERATING, SLOWING DOWN OR MAKING TURNS AND STEERING BECOMES VERY TIGHT AND DIFFICULT TO TURN. IT TOOK 3 SEPARATE VISITS TO THE DEALERSHIP BEFORE THEY DISCOVERED WHAT THEY THOU…
Read full complaint
ON JULY 4, 2003 MY 2000 CHEVROLET IMPALA WAS LUBED AT THE CHEVROLET DEALERSHIP BECAUSE OF STEERING ISSUES. THE CAR WOULD VIBRATE, POP, AND JERK WHEN ACCELERATING, SLOWING DOWN OR MAKING TURNS AND STEERING BECOMES VERY TIGHT AND DIFFICULT TO TURN. IT TOOK 3 SEPARATE VISITS TO THE DEALERSHIP BEFORE THEY DISCOVERED WHAT THEY THOUGHT WAS THE SOURCE OF THE PROBLEM. I HAVE SEVERAL CHILDREN AND I AM GREATLY CONCERNED ABOUT OUR SAFETY. I DO NOT KNOW WHAT ELSE TO DO BECAUSE THIS SEEMS TO BE A RECURRING PROBLEM WITH MANY 2000 IMPALAS. I DID A LOT OF RESEACH AND FOUND OTHER COMPLAINTS ON YOUR SITE DUE TO THE SAME ISSUE, AS WELL AS COMPLAINTS ON WWW.IMPALAHQ.COM. I'VE ALSO READ ISSUES WHERE SOME POLICE DEPARTMENTS ARE USING THIS SAME MODEL AND THEY HAVE REPORTED ACCIDENTS DUE TO STEERING LOST, WHICH SEEMS TO BE RELATED TO THE INTERMEDIATE STEERING SHAFT ISSUES. THE LAST STEERING SHAFT LUBE WAS 11 MONTHS AGO AND COST ME $140. LOOKS LIKE I WILL HAVE TO HAVE THIS SERVICE DONE EVERY 10-12 MONTHS TO KEEP THIS CAR FROM LOOSING STEERING. I CAN NOT PUT A PRICE ON THE SAFETY OF MY CHILDREN, BUT I CAN INFORM OTHER AND HOPE CHEVY WILL FIND A SOLUTION TO THIS PROBLEM QUICKLY. *AK
NHTSA ODI #10074808
44,000 miles · Apr 21, 2004
Steering
THERE IS A CLUNKING AND CLICKING SOUND WHEN STEERING. THIS IS A KNOWN PROBLEM WHERE A LOT OF CONSUMERS HAVE COMPLAINED ABOUT AND CHEVROLET WILL NOT FIX THE PROBLEM AT NO COST. CHEVROLET SAID THAT THEY CAN EITHER CHANGE THE INTERMEDIATE STEERING SHAFT OR USE THE LUBRICATION KIT TO FIX IT. THEY WILL NOT EVEN USE THE LUBRICATON KIT…
Read full complaint
THERE IS A CLUNKING AND CLICKING SOUND WHEN STEERING. THIS IS A KNOWN PROBLEM WHERE A LOT OF CONSUMERS HAVE COMPLAINED ABOUT AND CHEVROLET WILL NOT FIX THE PROBLEM AT NO COST. CHEVROLET SAID THAT THEY CAN EITHER CHANGE THE INTERMEDIATE STEERING SHAFT OR USE THE LUBRICATION KIT TO FIX IT. THEY WILL NOT EVEN USE THE LUBRICATON KIT TO FIX IT AT LEAST. THIS IS NOT RIGHT THAT THE CONSUMER SHOULD PAY FOR A MISTAKE THAT THE MANUFACTURER CREATED DUE TO A LACK OF LUBRICATION . *AK
NHTSA ODI #10067627
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
Illustration