NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
159 reportsClear category filter126,000 miles · Jan 30, 2012
Engine And Engine CoolingFire
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT COOLANT WAS LEAKING OUT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE LOWER PLENTUN WAS MELTING AS A RESULT OF IT BEING TOO CLOSE TO THE MOTOR AND RECOMMENDED HAVING THE COMPONENT REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FA…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT COOLANT WAS LEAKING OUT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE LOWER PLENTUN WAS MELTING AS A RESULT OF IT BEING TOO CLOSE TO THE MOTOR AND RECOMMENDED HAVING THE COMPONENT REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 126,000.
NHTSA ODI #10445849
Mileage unknown · Dec 13, 2011
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
WHILE DRIVING THIS CAR IT WOULD JUST STALL OR DIE AS IF SOMEONE HAD REACHED OVER AND SHUT THE CAR OFF AND WOULD NOT START FOR A FEW DAYS. I HAVE BROUGHT THIS CAR TO TWO MECHANICS AND NEITHER WERE ABLE TO STOP THE PROBLEM BUT TOLD ME THAT DIFFERENT PARTS WERE THE CULPRIT, SO 800 DOLLARS LATER I HAVE REPLACED THE FUEL FILTER, FUEL…
Read full complaint
WHILE DRIVING THIS CAR IT WOULD JUST STALL OR DIE AS IF SOMEONE HAD REACHED OVER AND SHUT THE CAR OFF AND WOULD NOT START FOR A FEW DAYS. I HAVE BROUGHT THIS CAR TO TWO MECHANICS AND NEITHER WERE ABLE TO STOP THE PROBLEM BUT TOLD ME THAT DIFFERENT PARTS WERE THE CULPRIT, SO 800 DOLLARS LATER I HAVE REPLACED THE FUEL FILTER, FUEL PUMP, CRANK SHAFT POSITION SENSOR, MASS AIR FLOW SENSOR,REPLACED THE BATTERY, TESTED THE ALTERNATOR, TESTED THE FUEL INJECTORS BOTH HOT AND COLD, TESTED THE IGNITION MODULE AND STILL THE CAR DIED LEAVING MY CHILD AND I STRANDED ON THE SIDE OF THE FREEWAY IN COLD TEMPERATURES. I THEN CALLED A GM DEALERSHIP WHOM SAID ANOTHER 120.00 JUST TO LOOK AT IT AND SAID THEY COULDN'T FIND THE PROBLEM . THIS IS OUTRAGEOUS! *TR
NHTSA ODI #10439750
248,643 miles · Nov 1, 2011
Engine And Engine Cooling
COOLANT LEAK AT GASKET BETWEEN BLACK FRP (FIBERGLASS REINFORCED PLASTIC) UPPER INTAKE MANIFOLD / PLENUM AND METAL INTAKE MANIFOLD NEAR THROTTLE BODY. NHTSA 10006144. *TR
NHTSA ODI #10433755
57,000 miles · Sep 23, 2011
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STALL WITHOUT WARNING. AFTER WAITING A WHILE SHE WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY ADVISED HER THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STALL WITHOUT WARNING. AFTER WAITING A WHILE SHE WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY ADVISED HER THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 57,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10426950
2,573,302 miles · Mar 29, 2011
Electrical SystemEngine And Engine CoolingEquipment
BOUGHT 2000 CHEVY IMPALA ON FEB 8,2009,AND HAVE HAD MULTIPLE REALLY BAD PROBLEMS. BAD SHAKE IN FRONT END,PULLS TO RIGHT REALLY BAD, HAS SEVEAR COOLING PROBLEMS, TURN SIGNAL FAILURE MORE THEN WORKING, GEAR SHIFT PROBLEMS, AIR BUBBLES BACKING UP IN COOLANT BOTTLE, LOW COOLANT LIGHT ALWAYS ON, CHECK ENGINE IGHT ALWAYS ON MAJOR OIL…
Read full complaint
BOUGHT 2000 CHEVY IMPALA ON FEB 8,2009,AND HAVE HAD MULTIPLE REALLY BAD PROBLEMS. BAD SHAKE IN FRONT END,PULLS TO RIGHT REALLY BAD, HAS SEVEAR COOLING PROBLEMS, TURN SIGNAL FAILURE MORE THEN WORKING, GEAR SHIFT PROBLEMS, AIR BUBBLES BACKING UP IN COOLANT BOTTLE, LOW COOLANT LIGHT ALWAYS ON, CHECK ENGINE IGHT ALWAYS ON MAJOR OIL LEAKAGE UNDER CAR BODY NOT ON GROUND. LOSS OF COOLANT BUT NO IDEA WHERE ITS GOING. SERGING PROBLEM IN ELECTRICAL SYSTEM, AND WIRING CONECTIONS AND PLUGS NOT CONNECTED TO ANYTHING. ICNITION PROBLEMS KEY WONT STAY IN AND CAN BE PULLED OUT WITH CAR RUNNING.HAVE REPLACED RADIATOR,ALL HOSES,ALL GASKETS,THERMISTATE,WATER PUMP,BELTS,DONE TUNEUP,OIL CHANGE, DONE BRAKES,REPLACED SENCERS,BATTERY,AND OTHER THINGS. IM PISSED AND VERY ANGRY WITH CHEVY AND GM FOR ALL THE PROBLEMS THEY HAVE WITH THERE VEHICALS AND NOT FIXING THE PROBLEMS.
NHTSA ODI #10393669
200,000 miles · Jul 3, 2010
Engine And Engine Cooling
MY CAR (A 2000 CHEVROLET IMPALA, 3.8L V6 ENGINE) REPEATEDLY DIED AS I WAS DRIVING OR STALLED. IT BECAME A HUGE SAFETY ISSUE, ESPECIALLY WHEN I WOULD BE DRIVING AT HIGH SPEEDS ON THE FREEWAY WITH NOWHERE TO PULL OVER. I TOOK IT IN, BUT DIAGNOSTICS SHOWED NOTHING. I KEPT REPLACING PARTS, BUT TO NO AVAIL. I FELT UNSAFE DRIVING ANYW…
Read full complaint
MY CAR (A 2000 CHEVROLET IMPALA, 3.8L V6 ENGINE) REPEATEDLY DIED AS I WAS DRIVING OR STALLED. IT BECAME A HUGE SAFETY ISSUE, ESPECIALLY WHEN I WOULD BE DRIVING AT HIGH SPEEDS ON THE FREEWAY WITH NOWHERE TO PULL OVER. I TOOK IT IN, BUT DIAGNOSTICS SHOWED NOTHING. I KEPT REPLACING PARTS, BUT TO NO AVAIL. I FELT UNSAFE DRIVING ANYWHERE AND EVEN GOT A BIKE SO I WOULDN'T BE FACING NEAR-DEATH EXPERIENCES EVERY TIME I DROVE. EVENTUALLY I FOUND A MESSAGE BOARD THAT SUGGESTED REPLACING THE CRANKSHAFT POSITION SENSOR. I JUST DID AND AM HOPING IT WORKS. SOMETHING NEEDS TO BE DONE ABOUT THIS THOUGH, IT'S CRAZY TO HAVE TO GO YEARS WITH A FAULTY CAR AND NO ONE CAN FIND A FIX FOR IT. *TR
NHTSA ODI #10341349
Mileage unknown · Jan 24, 2010
Engine And Engine CoolingFire
AFTER PARKING THE CAR I WAS NOTIFIED BY A NEIGHBOR THAT MY VEHICLE WAS ON FIRE. THE FIRE DEPT. WAS CALL AND EXTINGUISHED THE FIRE.THE ARSON SQUAD WAS CALLED AND DETERMINED THE VEHICLES FIRE WAS DUE TO A MECHANICAL PROBLEM. AFTER I RESEARCHED THE VEHICLES SAFETY RECALLS AND FOUND OUT THERE HAD BEEN A RECALL FOR THIS VEHICLE AN…
Read full complaint
AFTER PARKING THE CAR I WAS NOTIFIED BY A NEIGHBOR THAT MY VEHICLE WAS ON FIRE. THE FIRE DEPT. WAS CALL AND EXTINGUISHED THE FIRE.THE ARSON SQUAD WAS CALLED AND DETERMINED THE VEHICLES FIRE WAS DUE TO A MECHANICAL PROBLEM. AFTER I RESEARCHED THE VEHICLES SAFETY RECALLS AND FOUND OUT THERE HAD BEEN A RECALL FOR THIS VEHICLE AND I WAS UNAWARE OF IT. I PURCHASED IT USED. I DID NOT RECEIVE ANY NOTICE ON THE RECALL. I FOUND THERE WERE MANY OTHER FIRES ASSOCIATED WITH THIS FAILURE. THE VEHICLE WAS TOTALLY BURNED UP VEHICLE WAS NON REPAIRABLE AND TOWED TO THE JUNK YARD AFTER ARSON INVESTIGATION WAS COMPLETE. *TR
NHTSA ODI #10302108
101,000 miles · Sep 10, 2009
Engine And Engine Cooling
TL*- THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED WHEN ATTEMPTING TO START THE VEHICLE, THE INTAKE MANIFOLD EXPLODED INTO PIECES. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP AND IS CURRENTLY WAITING TO BE INSPECTED. SHE CONTACTED THE MANUFACTURER AND FILED A COMPLAINT, BUT WAS ADVISED BY A REPRESENTATIVE THAT TH…
Read full complaint
TL*- THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED WHEN ATTEMPTING TO START THE VEHICLE, THE INTAKE MANIFOLD EXPLODED INTO PIECES. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP AND IS CURRENTLY WAITING TO BE INSPECTED. SHE CONTACTED THE MANUFACTURER AND FILED A COMPLAINT, BUT WAS ADVISED BY A REPRESENTATIVE THAT THE STATUE OF LIMITATIONS IN THE STATE OF MAINE SPECIFIES THAT AFTER FOUR YEARS THEY ARE NOT OBLIGATED TO MAKE REPAIRS. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 101,000.
NHTSA ODI #10283573
Mileage unknown · Jun 22, 2009
Engine And Engine CoolingEquipmentFire
PUT. *TR
NHTSA ODI #10274671
Mileage unknown · Jun 18, 2009
Engine And Engine CoolingFire
2000 CHEVROLET IMPALA CAUGHT A FIRE AND TOTALED. CONSUMER RECEIVED RECALL NOTICE AFTER THE FIRE. *NJ
NHTSA ODI #10274510
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
Illustration