NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
71 reportsClear category filter120,000 miles · May 31, 2017
Engine
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE THE VEHICLE WAS STATIONARY, THE INTAKE MANIFOLD LEAKED FUEL AND RELEASED VAPORS. THE CONTACT STATED THAT THE INTAKE MANIFOLD WAS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,0…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE THE VEHICLE WAS STATIONARY, THE INTAKE MANIFOLD LEAKED FUEL AND RELEASED VAPORS. THE CONTACT STATED THAT THE INTAKE MANIFOLD WAS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
NHTSA ODI #10992445
16,000 miles · Apr 7, 2017
EngineFuel/propulsion SystemFire
HAVE BEEN NUMEROUS COMPLAINTS ON THE INTAKE MANIFOLD EXPLODING AND CATCHING FIRE. AS THIS SAME THING HAPPEN TO ME, SOUNDS LIKE A LAWSUIT WAITING TO HAPPEN. MINE JUST HAPPEN TO BE IN THE DRIVE WAY, WHEN I WENT TO START IT I SAW SMOKE. SO I TURNED IT OFF, LOOKED UNDER HOOD DIDN'T SEE ANYTHING. WENT TO START IT A FEW DAYS LATER AN…
Read full complaint
HAVE BEEN NUMEROUS COMPLAINTS ON THE INTAKE MANIFOLD EXPLODING AND CATCHING FIRE. AS THIS SAME THING HAPPEN TO ME, SOUNDS LIKE A LAWSUIT WAITING TO HAPPEN. MINE JUST HAPPEN TO BE IN THE DRIVE WAY, WHEN I WENT TO START IT I SAW SMOKE. SO I TURNED IT OFF, LOOKED UNDER HOOD DIDN'T SEE ANYTHING. WENT TO START IT A FEW DAYS LATER AND I HEARD A REALLY LOUD POP, FOLLOWED BY SMOKE. I QUICKLY TURNED TO OFF POSITION. OPENED MY HOOD AND SURE ENOUGH THE MANIFOLD HAD EXPLODED. WHAT IF I WOULD HAVE BEEN DRIVING? COULD HAVE CAUSED DEATHS TO OTHERS OR EVEN MYSELF, IF IT WASN'T CONTAINED. NOT EVERYONE CARRIES A FIRE EXTINGUISHER!!!!
NHTSA ODI #10971178
156,000 miles · Mar 2, 2017
EngineFire
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHEN THE DRIVER ATTEMPTED TO START THE VEHICLE, THE EXHAUST MANIFOLD EXPLODED WITH A VERY LOUD NOISE AND WITHOUT WARNING. THE CONTACT NOTICED A SMOKE ODOR UNDERNEATH THE HOOD. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO A LOCAL DEALER. THE VEHICLE WAS T…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHEN THE DRIVER ATTEMPTED TO START THE VEHICLE, THE EXHAUST MANIFOLD EXPLODED WITH A VERY LOUD NOISE AND WITHOUT WARNING. THE CONTACT NOTICED A SMOKE ODOR UNDERNEATH THE HOOD. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO A LOCAL DEALER. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE FAILURE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE CONTACT STATED THAT THE SHE DID NOT RECEIVE THE RECALL NOTICE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 156,000. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10958284
Mileage unknown · Aug 22, 2016
EngineEngine And Engine CoolingFire
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE DRIVING 25 MPH, SMOKE AND FLAMES EMITTED FROM THE HOOD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THERE WERE NO INJURIES. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) ASSOCIATED WITH THE FAILURE. THE MANUFACTURER WAS N…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE DRIVING 25 MPH, SMOKE AND FLAMES EMITTED FROM THE HOOD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THERE WERE NO INJURIES. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) ASSOCIATED WITH THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE. UPDATED 11/17/16*LJ *TR
NHTSA ODI #10897572
144,703 miles · Aug 3, 2016
Engine
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE TE VEHICLE WAS STATIONARY, THE IGNITION KEY MALFUNCTIONED. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AFTER NUMEROUS ATTEMPTS. THE CONTACT WAS ABLE TO START THE VEHICLE ON THE LAST ATTEMPT. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE TE VEHICLE WAS STATIONARY, THE IGNITION KEY MALFUNCTIONED. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AFTER NUMEROUS ATTEMPTS. THE CONTACT WAS ABLE TO START THE VEHICLE ON THE LAST ATTEMPT. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 144,703.
NHTSA ODI #10892721
Mileage unknown · Apr 26, 2016
Engine
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE PARTS WERE NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE REPAIR APPOINTMENT. THE DEALER AND THE MANUFACTURER WERE CONTACTED FOR MONTHS AND WERE UNABLE TO DETERMINE WH…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE PARTS WERE NOT AVAILABLE WITHIN A REASONABLE TIME FRAME TO SCHEDULE THE REPAIR APPOINTMENT. THE DEALER AND THE MANUFACTURER WERE CONTACTED FOR MONTHS AND WERE UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10861553
184,000 miles · Apr 15, 2016
EngineFire
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE PULLING INTO THE DRIVEWAY, SMOKE APPEARED UNDER THE HOOD. THE CONTACT OPENED THE HOOD AND NOTICED FLAMES COMING FROM THE ENGINE EXHAUST MANIFOLD. THE CONTACT EXTINGUISHED THE FIRE. THE DEALER HAD THE VEHICLE TOWED TO THEIR LOT. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CO…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. WHILE PULLING INTO THE DRIVEWAY, SMOKE APPEARED UNDER THE HOOD. THE CONTACT OPENED THE HOOD AND NOTICED FLAMES COMING FROM THE ENGINE EXHAUST MANIFOLD. THE CONTACT EXTINGUISHED THE FIRE. THE DEALER HAD THE VEHICLE TOWED TO THEIR LOT. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 184,000.
NHTSA ODI #10859836
153,000 miles · Mar 17, 2016
Engine
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS, THE MANIFOLD INTAKE GASKET, THE VALVE COVER …
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO START. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS, THE MANIFOLD INTAKE GASKET, THE VALVE COVER GASKET, THE MAPPING CENTER, AND THE COMBUSTION CHAMBER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 153,000.
NHTSA ODI #10850167
Mileage unknown · Mar 14, 2016
Engine
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT RECEIVED A NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #10846419
152,155 miles · Mar 3, 2016
Engine
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED A NEW MAPPING SENSOR AND THE SPARK PLUGS NEEDED TO BE CLEANED. IN ADDITION, THERE WAS A LEAK FROM THE INTAKE MANIFOLD AND WOULD…
Read full complaint
TL* THE CONTACT OWNS A 2000 CHEVROLET IMPALA. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE NEEDED A NEW MAPPING SENSOR AND THE SPARK PLUGS NEEDED TO BE CLEANED. IN ADDITION, THERE WAS A LEAK FROM THE INTAKE MANIFOLD AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT WAS NOT NOTIFIED OF NHTSA CAMPAIGN NUMBER: 15V701000 (ENGINE AND ENGINE COOLING) UNTIL AFTER THE REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 152,155.
NHTSA ODI #10839685
Official recalls
7Oct 26, 2015
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence & remedy
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Engine And Engine Cooling:engine
General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Apr 8, 2009
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.
Consequence & remedy
Consequence: IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.
Remedy: DEALERS WILL REPLACE THE ENGINES FRONT VALVE COVER AND FRONT-VALVE-COVER GASKET WITH NEW PARTS OF AN IMPROVED DESIGN AND REMOVE THE ENGINES PLASTIC COVER AND PLASTIC OIL-FILL-TUBE EXTENSION, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2016. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.
Feb 24, 2004
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 3800 V6 (L36) ENGINES AND CERTAIN DELPHI FUEL PRESSURE REGULATORS, THE REGULATORS HAVE A MUCH HIGHER THAN USUAL RATE OF FUEL LEAKS. A LEAK CAN ALLOW FUEL TO ENTER THE INTAKE MANIFOLD THROUGH A VACUUM LINE. IF THE ENGINE DOES NOT START WHEN CRANKED, THE FUEL FROM THE LEAKING REGULATOR AND A MISTIMED SPARK CAN CAUSE A BACKFIRE.
Consequence & remedy
Consequence: THE BACKFIRE CAN RUPTURE THE INTAKE MANIFOLD. THE RUPTURE OF THE INTAKE MANIFOLD CAN DISPLACE A FUEL LINE, PULLING AN INJECTOR OUT OF PLACE, AND CAUSING A FUEL LEAK AND POSSIBLE FIRE.
Remedy: DEALERS WILL INSTALL NEW FUEL PRESSURE REGULATORS WITH IMPROVED DIAPHRAGMS. THE RECALL WILL BE CONDUCTED IN PHASED MAILINGS. PHASE 1 BEGAN ON JUNE 30, 2004, AND PHASE 2 BEGAN ON SEPTEMBER 30, 2004. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, OLDSMOBILE AT 1-800-630-6537, OR PONTIAC AT 1-800-620-7668.
Apr 24, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.4L ENGINE AND NON-ANTILOCK BRAKING SYSTEM (ABS). THESE VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." A FUEL RETURN LINE CAN BECOME SEVERED IN A FRONTAL COLLISION, RESULTING IN FUEL SPILLAGE.
Consequence & remedy
Consequence: IF AN IGNITION SOURCE WAS PRESENT, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A BRAKE MASTER CYLINDER BRACKET THAT WILL MAINTAIN POSITIONING OF THE FUEL LINE IN A FRONTAL CRASH. OWNER NOTIFICATION BEGAN JUNE 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020.
Nov 13, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES EXHIBIT A CONDITION IN WHICH THE DRIVER SIDE IMPACT AIR BAG INFLATOR SEPARATES FROM THE AIR BAG MODULE DURING DEPLOYMENT.
Consequence & remedy
Consequence: IF THE INFLATOR SEPARATES, THE AIR BAG WILL NOT DEPLOY PROPERLY DURING A CRASH AND OCCUPANT PROTECTION WOULD BE REDUCED. IF IS ALSO POSSIBLE THAT A SEPARATED INFLATOR COULD BE PROPELLED DOWNWARD AND COULD RESULT IN INJURY TO A REAR SEAT PASSENGER WHOSE FOOT IS POSITIONED APPROXIMATELY UNDER THE INFLATOR MODULE.
Remedy: DEALERS WILL REPLACE THE SIDE IMPACT AIR BAG MODULE.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA02030 · Engine Compartment Fires
Opened Oct 22, 2002 · Closed Mar 9, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Fuel System, Gasoline
EA02-030 IS CLOSED WITH GMEA02-030 IS CLOSED WITH GM?S ACTIONS IN 03V-473 AND 04V-090 RECALLING APPROXIMATELY 529,000 MY 1998-99 C- AND H-BODY VEHICLES EQUIPPED WITH DEFECTIVE FUEL PRESSURE REGULATORS.THESE VEHICLES WERE EQUIPPED WITH PLASTIC INTAKE MANIFOLDS THAT ARE UNABLE TO CONTAIN PRESSURES THAT OCCUR IN SOME BACKFIRE EVENTS AND DEFECTIVE FUEL PRESSURE REGULATORS WITH LEAKING DIAPHRAGMS THAT CAN PROVIDE A SOURCE OF FUEL TO PRODUCE A COMBUSTIBLE AIR-FUEL MIXTURE IN THE MANIFOLD.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY ODI THAT NO SAFETY DEFECT EXISTS IN THE VEHICLES THAT ARE NOT INCLUDED IN GM?S RECALLS.ODI WILL CONTINUE TO MONITOR THE INCIDENCE OF MANIFOLD RUPTURES AND RELATED FIRES IN OTHER MY 1995-2002 GM PASSENGER CARS EQUIPPED WITH THE SUBJECT INTAKE MANIFOLD.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
PE00005 · Inadvertent Engine Stalling
Opened Jan 19, 2000 · Closed Feb 29, 2000
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
Illustration